The Tigra-B is filled with "red" coolant (part no. 93 170 402 / catalogue no. 19 40 663) in the factory.
Only this coolant must be used to correct the coolant level or for refilling.
Contents
Wiring diagrams Section: DOHC Petrol Engine- How to Check and Measure the Cylinder Head and Attaching Parts (Survey)
- How to Check the Cylinder Head Height
- How to Check for Plane Surface the Cylinder Head
- Air Mass Meter, 4 Cylinder Petrol
- How to Measure the Valve
- How to Check the Inner Diameter of Valve Guide
- Valve Stem Play, Determine
- Air Mass Meter, Z18XE, Z20LEL, Y22XE, Z22XE
- How to Check the Installation Height of Valves
- How to Check the Installation Height of Valve Guide
- Battery / Starter (Voltage Measurement)
- How to Overhaul the Cylinder Head
- Cylinder Head, Attach to Assembly Tool Set KM-6215
- Cylinder Head, Disassemble
- Flexible Maintenance Intervals - Corsa-C, Meriva, Tigra-B
- How to Remove the Valves
- Compression 4-cylinder, Unsynchronised
- Valve Seat, Cut (In Cylinder Head)
- Valve Guide, Ream
- Crankshaft Impulse Sensor, Petrol and Z19DT
- Valve, Grind
- Valve, Grind In
- How to Replace the Valve Stem Seals
- How to Assemble the Cylinder Head
- Cylinder Head Machining Special Tools
- Measuring Oil Consumption
- Injector (Multi-Point Fuel Injection), All Except Z22YH
- Knock Sensor
- Exhaust Manifold for the Z 14 XEP - Corsa-C, Combo-C, Tigra-B, Astra-H
- Lubrication of Radial Shaft Seal Rings No Longer Applicable
- Engine Overview
- Coolant
- On-Board Diagnosis (OBD)
- Engine Identification
- Engine Parameters
- Performance and Consumption Values
- Z 14 XEP Torque and Performance Curve
- Z 18 XE Torque and Performance Curve
- Engine Aggregates
- Engine/transmission Combination
- Camshaft Sensor, Simtec 70/71/81
- Damage Diagnosis, Dual Mass Flywheel
- Pedal Position Double Signal, All Petrol (MY 2002, MY 2003 and MY 2004)
- New Camshaft Sensor - Z 10 XEP, Z 12 XEP, Z 14 XEP Petrol Engines
- Elimination of Twinport Sensor - Z 10 XEP, Z 12 XEP and Z 14 XEP Petrol Engines
- DOHC-0 Engine Z 14 XEP - Corsa-C Combo, Meriva and Tigra-B
- Throttle Valve Potentiometer (Double Signal), Simtec (MY 2003), Simtecand Multec-F (MY 2004)
- Specific Characteristics of the Z 14 XEP Engine
- View of the Engine, Z 12 XEP, Z 14 XEP
- Torque and Power Diagram, Z 14 XEP
- Exhaust Manifold, Z 12 XEP, Z 14 XEP
- Camshaft Control, Z 10 XEP, Z 12 XE, Z 14 XEP (From End MY 2004 to MY 2005)
- Camshaft Sensor
- Wheel Speed Sensor, Except Vectra-C/signum and Astra-H
- Timing Case
- Timing Chain Tensioner
- Bosch Motronic 7.6.2 Engine Control Unit
- Twinport Sensor
- Remove and Install Exhaust Gas Recirculation Valve
- How to Remove and Install the Exhaust Gas Recirculation Pipe
- Toothed Belt Diagnosis - Possible Causes and Remedys
- DOHC O Petrol Engine (Z 12 XE, Z 12 XEP, Z 14 XEP) Engine Number
- Check Compression (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Check Oil Temperature (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Check Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Adjust Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Illustration Z 12 XE, Z 12 XEP, Z 14 XEP
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Cylinder Head Cover (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Both Camshafts (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Intake Manifold Gasket (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Valve Stem Seal (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Engine Oil with Filter Change (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Oil Pressure Switch (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Removing and Installing Oil Pump Pressure Control Valve (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pan (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Oil Intake Pipe (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- How to Remove and Install (Z 12 XE the Oil Baffle Plate (Z 14 XEP))
- Check for Engine Leaks (CO Content in Coolant) (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Mta)
- Sealants, Lubricants and Locking Compounds
- Specifications
- Adjustment Value, Checking Values
- Ribbed V-Belt
- Engine Control Unit
- Cooling System
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, Without Air Conditioning, Lhd)
- Remove and Install Flywheel (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Rear Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Crankshaft (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Engine Damping Block (Right Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Rear Reaction Member (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Engine Damping Block (Left Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Removing and Installing Manual Transmission (Mta) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Special Service Tools
- Torque Guide Values (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Spark Plug Damages - Possible Causes and Failure Modes
- Dohc-I Petrol Engine (Z 18 XE)
- How to Check (Z 18 XE the Compression (With Air Conditioning, Lhd))
- How to Measure (Z 18 XE) the Oil Temperature
- Engine Z18XE - DTC P1372(2) Crankshaft Segment Failure
- How to Check (Z 18 XE the Engine Oil Pressure (With Air Conditioning, Lhd))
- How to Check (Z 18 XE the Timing (With Air Conditioning, Lhd))
- How to Check and Correct (Z 18 XE the Toothed Belt Tension (With Air Conditioning, Lhd))
- Air Cleaner Housing, Air Ducts
- How to Replace (Z 18 XE the Ribbed V-Belt (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Upper Section (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Lower Section (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Tension Roller (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Guide Roller (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Rear (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Cylinder Head Cover (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Camshaft Sprockets (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Camshaft Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Both Camshafts (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Exhaust Manifold Gasket (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Intake Manifold Gasket (With Air Conditioning, Lhd))
- Engine Oil with Filter Change (Z 18 XE, with Air Conditioning, Lhd)
- How to Remove and Install (Z 18 XE the Oil Filter Housing (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Crankshaft Front Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pan (With Air Conditioning, Lhd))
- 020 Additional Work When Replacing the Oil Pan (Z 18 XE, with Air Conditioning, Lhd) (Oil Pan Removed)
- How to Remove and Install (Z 18 XE the Oil Pump (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pump Pressure Regulating Valve (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the 009 Oil Intake Pipe (With Air Conditioning, Lhd) (Oil Sump Removed))
- How to Remove and Install (Z 18 XE the Oil Dipstick Guide Tube (With Air Conditioning, Lhd))
- How to Top Up and Bleed (Z 18 XE) the Cooling System
- How to Check for Leaks (Z 18 XE) the Cooling System
- How to Check for Leaks the Engine ((CO Content in Coolant) (Z 18 XE))
- How to Remove and Install (Z 18 XE the Fan Motor (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Radiator (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Thermostat with Coolant Connection (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Coolant Pump (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Coolant Pipe (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Engine Damping Blocks (Both Sides) (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Front Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Rear Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Right Engine Damping Block (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Left Engine Damping Block (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Engine (With Air Conditioning, Lhd))
- Manual Transmission From/to Engine, Detach and Attach (Z 18 XE, with Air Conditioning, Lhd)
- How to Check (Z 18 XE the Fuel Pressure (With Air Conditioning, Lhd))
- Technical Data Sealants, Lubricants and Locking Compounds
- Torque Guide Values (Z 18 XE)
- Remove and Install Adapter, Exhaust Gas Recirculation Valve
- Check Engine Oil Pressure (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Mt)
- Removing and Installing Manual Transmission (Mt) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Repair Engine Using a Short Block (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning)
- How to Remove and Install (Z 18 XE the Coolant Connection (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the J 312315 Valve Stem Seals (With Air Conditioning, Lhd))
- Engine Z10/12/14XEP - Loss of Oil Between Oil Filter Modul and Engine Block
- Check Engine Pressure Loss (Z 12 XE, Z12 XEP, Z 14 XEP)
- How to Replace the Piston Rings
- Replace One Con-Rod Bearing (Z 12 XE, Z 12 XEP, Z 14 XEP, Lhd)
- Check Crankshaft Alignment (Z 12 XE, Z 12 XEP, Z 14 XEP)
- How to Check (Z 18 XE) the Engine Pressure Loss
- Replace Piston Rings
- How to Replace (Z 18 XE the One Con-Rod Bearing (With Air Conditioning, Lhd))
- How to Check Alignment (Z 18 XE) the Crankshaft
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Housing))
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Cartridge))
- Check Oil Pump
- Flexible Maintenance Intervals
- How to Remove and Install (Z 14 XEP) the Front Reaction Member
- Chemical Products
- How to Remove and Install (Z 18 XE the Spark Plugs (With Air Conditioning, Lhd))
- Engine A/Z10/12/14XEP/L - Crankcase Ventilation Hoses Cracked
- Replace Exhaust Manifold (Z 12 XEP, Z 14 XEP-Combo)
- Remove and Install Exhaust Gas Recirculation Valve (Z 12 XE, Z 12 XEP, Z 14 XEP)
- How to Remove and Install the Attaching Parts to Cylinder Head
- Remove and Install Oil Filter Housing (Z 12 XEP, Z 14 XEP from MY 2005)
- Replace Oil Dipstick Guide Tube (Z 12 XEP, Z 14 XEP from MY 2005)
- How to Replace (From MY 05) the Crankshaft Rear Seal Ring
- ABS
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Adhesive Foiles
- Air Conditioning
- Airbag
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Paint
- Painted Body
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Vehicle Side
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses