In "TIS" use of time allowances, group "J", operation number "J792600".
Home/Opel/Signum/Opel Signum I (2002-2008)/Repair manual/Engine and Engine Aggregates/Time Allowance
Contents
Wiring diagrams Section: Engine and Engine Aggregates- Foreword to Exhaust Emissions Test
- Exhaust Emissions Test Guidelines - Petrol Engines
- Additions / Corrections
- Exhaust Emissions Test Guidelines - Diesel Engines
- EU Directives
- Introduction
- Exhaust Emission Regulations for Germany
- Exhaust Emission Regulations for Austria
- Exhaust Emission Regulations for Switzerland
- Abbreviations
- Reprogrammable Electronic Control Units All Petrol Vaariants
- Alternator Test
- Safety Instructions
- Visual and Functional Check (Petrol and Diesel)
- Warning Lamps for Engine Electronics and Exhaust Emissions (Petrol and Diesel)
- Diagnosis Instructions for Vehicles with Petrol Engines
- Check Exhaust Gas Recirculation
- Read Trouble Codes
- Ege Method - Petrol Engine
- Performing the Exhaust Emissions Test - Petrol Engine
- Diagnostic Instructions for Vehicles with Diesel Engines
- Ege Method - Diesel Engine
- Performing the Exhaust Emissions Test - Diesel Engine
- Engine Speed Measurement and Test Time
- How to Test Certificate the Speed Measurement
- Determination of Opacity Value (Smoke Density) in Measurement Mode 'B'
- Determination of Opacity Value (Smoke Density) in Measurement Mode B
- Fuels for Motor Vehicles
- Time Allowance
- Elimination of the Purge Line in Front of the Turbocharger - Z 20 NET DOHC Turbocharged Petrol Engine - Vectra-C
- Adjustment Data for Vectra-C / Vectra Gts Z 16 XE (1.6 16V Ecotec) 74 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 18 XE (1.8 16V Ecotec) 90 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 22 SE (2.2 16V Ecotec) 108 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 32 SE (3.2 V6 Ecotec) 155 kW
- Adjustment Data for Vectra-C Y 20 DTH (2.0 DTI Ecotec) 74 kW
- Adjustment Data for Vectra-C / Vectra Gts Y 22 DTR (2.2 DTI Ecotec) 86 kW
- Engine Data - Vectra-C
- Performance Data - Vectra-C
- Consumption Data - Vectra-C
- Engine Data - Signum
- Performance Data - Signum
- Consumption Data - Signum
- Adjustment Data for Vectra-C Z 18 XEL (1.8 16V Ecotec) 81 kW
- Ignition, Primary
- Adjustment Data for Vectra-C / Vectra Gts Z 20 NET (2.0 Turbo Ecotec) 129 kW
- Adjustment Data for Vectra-C Z 22 YH (2.2 Direct Ecotec) 114 kW
- Engine Classification
- Adjustment Data for Vectra-C Z 19 DT OHC (1.9 CDTI Ecotec) 88 kW
- Adjustment Data for Vectra-C Z 19 DTH DOHC (1.9 CDTI 16V Ecotec) 110 kW
- Adjustment Data for Vectra-C / Vectra Gts Y 22 DTR (2.2 DTI Ecotec) 92 kW
- Adjustment Data Vectra-C Z 18 XEL (1.8 16V Ecotec) 81 kW
- Adjustment Data for Vectra-C / Vectra Gts Y 30 DT (3.0 CDTI Ecotec) 130 kW
- Adjustment Data for Signum Z 18 XE (1.8 16V Ecotec) 90 kW
- Adjustment Data for Signum Z 20 NET (2.0 Turbo Ecotec) 129 kW
- Adjustment Data for Signum Z 22 YH (2.2 Direct Ecotec) 114 kW
- Adjustment Data for Signum Z 32 SE (3.2 V6 Ecotec) 155 kW
- Adjustment Data for Signum Y 19 DT OHC (1.9 CDTI Ecotec) 88 kW
- Adjustment Data for Signum Z 19 DT OHC (1.9 CDTI Ecotec) 88 kW
- Adjustment Data for Signum Y 19 DTH DOHC (1.9 CDTI 16V Ecotec) 110 kW
- Adjustment Data for Signum Z 19 DTH DOHC (1.9 CDTI 16V Ecotec) 110 kW
- Adjustment Data for Signum Y 20 DTH (2.0 DTI Ecotec) 74 kW
- Engine Values - Vectra C Model Year 2003.5
- Adjustment Data for Signum Y 22 DTR (2.2 DTI Ecotec) 86 kW
- Engine Identification
- Driving Values - Vectra C Model Year 2003.5
- Adjustment Data for Signum Y 22 DTR (2.2 DTI Ecotec) 92 kW
- Consumption Values - Vectra-C Model Year 2003.5
- Adjustment Data for Signum Y 30 DT (3.0 V6 CDTI Ecotec) 130 kW
- Engine Values - Signum Model Year 2003.5
- Driving Values - Signum Model Year 2003.5
- Consumption Values - Signum Model Year 2003.5
- Specified Time Allowance
- Engine Specification - Vectra C
- Performance - Vectra C
- Consumption Figures - Vectra-C
- Adjustment Data for Vectra-C / Vectra Gts Z 28 NEL (2.8 V6 Turbo Ecotec) 169 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 28 NET (2.8 V6 Turbo Ecotec) 184 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 28 NET (2.8 V6 Turbo 'Opc') 188 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 19 DTL OHC (1.9 CDTI Ecotec) 74 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 30 DT (3.0 V6 CDTI Ecotec) 135 kW
- Adjustment Data for Signum Z 28 NEL (2.8 V6 Turbo Ecotec) 169 kW
- Adjustment Data for Signum Z 28 NET (2.8 V6 Ecotec) 184 kW
- Adjustment Data for Signum Z 19 DTL OHC (1.9 CDTI Ecotec) 74 kW
- Adjustment Data for Signum Z 30 DT (3.0 V6 Dcti Ecotec) 135 kW
- Exhaust Gas Recirculation Valve Without Feedback, Z13DT
- Adjustment Data Vectra-C Z 19 DT OHC (1.9) 88 kW
- Adjustment Data Vectra-C Z 19 DTH DOHC (1.9 16 V) 110 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 16 XEP (1.6 16V Twinport Ecotec) 77 kW
- Adjustment Data Signum Y 19 DT OHC (1.9) 88 kW
- Adjustment Data for Vectra-C / Vectra Gts Z 18 XEP (1.8 16V Ecotec) 103 kW
- Adjustment Data Signum Z 19 DT OHC (1.9) 88 kW
- Adjustment Data for Signum Z 18 XER (1.8 16V Ecotec) 103 kW
- Injector, Common Rail Diesel, Z19DT(H)
- Adjustment Data Signum Y 19 DTH DOHC (1.9 16V) 110 kW
- Performing the Exhaust Emissions Test (Petrol and Diesel Engines)
- Adjustment Data Signum Z 19 DTH DOHC (1.9 16V) 110 kW
- Special Features Guidelines 3 & 4
- Oxygen Sensor, Motronic 7.6.1 and Z18XE MY2004
- Oxygen Sensor Behind Catalic Converter, Motronic 7.6.1 and Z18XE MY2004
- Pedal Position Double Signal with Kick Down Switch
- Engines - Overview
- Fuel Rail Pressure Sensor, Z13DT
- Engine Codes
- Exhaust Pressure Sensor, Diesel Particle Filter
- Overview of Engine Data and Engine Management Systems
- Adjustment Data for Vectra-C / Vectra Gts Z 28 NET (2.8 V6 Turbo 'Opc') 206 kW
- Engine Code
- Engine Data - Vectra C MY 2004
- Performance Data - Vectra C MY 2004
- Fuel Consumption Figures - Vectra-C MY 2004
- Engine Data - Signum MY 2004
- Performance Data - Signum MY 2004
- Fuel Consumption Figures - Signum MY 2004
- Engine/transmission Combinations MY 2004
- Performing the Exhaust Emissions Test with the On-Board Diagnosis System (OBD)
- Oil Level - Incorrect
- Engine or Drivetrain - Damaged Due to Tuning
- All Z Engines - Overrun Fuel Cutoff Device Temporarily Not Active
- Engine Z18XE(L) - Noise Between 2000 and 4500 RPM
- Petrol Engines - Refuelled with Diesel Fuel
- New P&a Engines with ECU - TC P0602 (44)
- Diesel Fuel - Contains Up to 7% Bio Diesel (Fame)
- Engine Z22SE - Bad Cold Start at Low Temperatures
- Engine Z22SE-EGR Valve - Defective EGR Valve to Be Omit
- Engines (All) - Usage of Engine Oil Additives
- Engine Z19DTH, Z19DT (Fuel Return Line Detaches from the Fuel Damper Box)
- Engine Y/Z17DT/L/H - Water Pump - Leakages Visible
- Z19DT/H, Z17DTL/H Engine (Service Interval Modification)
- Z20NET Engine Poly-V-Belt - Rattling Noise at Drive-Off or Acceleration at Low RPM
- Diesel Engines - Usage of Gasoline Instead of Diesel Fuel
- Engine Y30DT - Oil Level Warning Lamp Lights Up Too Early
- Engine Z19DT/H - Jerking During Warming Up Phase
- Engine Z19DT/H, Poly V Belt (Squeaking Noise)
- Engine Z19DTH - Grinding Noise During Let off at Around 1500 RPM
- Engine Z17DT/H, Z19DT/H, Management System CR-EDC16 (Svs Does Not Switch off During Ignition on Cycle, No DTC Stored in ECU)
- Engine Y30DT, Oil Pressure Switch (Trouble Code P0520 (00) in ECU Set)
- Engine Z30DT, ECU (Wrong Indication of Dtc's)
- Engine Z30DT, DPF Sensor (Wrong Indication of DPF Differential Pressure Values in Tech 2)
- All Diesel and Petrol Engines - Turbocharger Hose Loose
- Engine Z19DT/L/J/H, Coolant Cirquit (Leakage from Thermostat Housing)
- Engine Z18XE/L - Alternator Lamp Illuminates Sporadically
- Engine Z16XE - MIL Illuminates, Troube Code P0172(52) in ECU Set
- Engine Z18XER, Oil Dipstick (Wrong Oil Level Indication)
- Engine Z19DT/H - Jerking, Somtimes Trouble Code P0201-P0204 Set
- Engine Z19DT/L/H/J and Z13DTJ/H - Diesel Particulate Filter Clogged, Trouble Code P1901(75) Set
- Engine Z19DT/L/H/J - Rough Idle After Cold Start
- Engine Y20/22DTH/R - Lack of Power, P0638 (5B) Set
- Engine Z19DT/L/H, Poly-V Belt Drive (Noise from Poly-V Belt Area)
- Engine Z19DTH/ J - Intake Manifold, Swirl Flaps, Actuator Out of Order, DTC: P1109, P2075 Set
- Engine Z28NEL/T - Jerking, Stalling, Somtimes Together with Trouble Code P0100
- Engine Z18XER, Coolant Temperature Sensor (Svs Illuminates, Trouble Code P2182 Is Set)
- Engine Y30DT, Ems System (Emission Test Failed)
- Engine Z16XEP - Rattling Noise After Cold Start
- Engine Y30DT, Cylinder Head Gasket (Internal Coolant Consumption, No Traces of Coolant Liquid Detectable from Outside the Engine)
- Engine Z28NEL/Z28NET - Jerking Under Part Load Condition
- Engine Z16XEP - Engine Jerks
- Engine Z30DT - Leak at Lower Coolant Expansion Tank Pipe
- Engine Z18XER - Knocking Noise After Cold Start
- Engine Z19DTH - Piston Molten
- Engine Z16XE/P/18XE - Oil Leakages on the Crankshaft Rear Side
- Engine Z30DT - Rough Idle<s> DTC P030* Set
- Engine Z19DT/H/J/L, DPF (Flashing Glow Indicator After Battery Disconnection)
- Engine Z16XE1/LET/LER/XEP/XER/Z18XER - Whistling Noise
- Engine Z18XER - Bad Throttle Response After Cold Start
- Engine Z18XER - Knocking Noise as of 2500 1/min
- Engine Oil - Oil Level to High
- Engine Z19DT/L - Failure Code P0340(28), Wrong Camshaft Signal
- Engine Z19DTX, Oil Level Sensor ("Check Oil Level" Message Shows Up Too Early)
- Two-Mass Flywheel - Diagnosis
- Engine Z28NEL/T, Coolant Expansions Tank (Neck Leaky)
- Engine A/Z16/18XER - Booming Noise Between 2500 - 3500 RPM
- Engine A/Z/18/16XER - Low Torque Between 2000 RPM and 4000 RPM
- Engine Z30DT, Oil Service (Prevention of Engine Damages)
- ABS
- ABS 430
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS Mk20i
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- CAN Bus
- Car Level Control
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Continuously Variable Transmission (Cvt) Front Drive
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Socket Front/ Rear
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Module
- Electronic Ride Control
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Manual Transmission Rear Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Power Steering
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Sac Semi Automatic Climate Control
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)