Fog Lamps, Service Install
With nudge bar installed - see corresponding operation.
Lamps must be installed in pairs.
| .D. ICON01.tif | 0,75 | 0,75 | tiff;; Remove, Disconnect |
Ground cable from battery.
| .D. ICON02.tif | 0,75 | 0,75 | tiff;; Install, Connect |
|---|---|---|---|
| Fog lamp to nudge bar - do not fully tighten retaining / pivot nut. | |||
| .P. U1071.tif | 9 | 7,5 | tiff;; |
| .D. ICON02.tif | 0,75 | 0,75 | tiff;; Install, Connect |
| Wiring plugs from lamps to white multiplugs on front wiring harness, located either side of the radiator. | |||
| .D. ICON01.tif | 0,75 | 0,75 | tiff;; Remove, Disconnect |
Up to MY 97:
Radio speaker covers and speakers from driver's side of instrument panel - for access to wiring harness.
Blanking plate from inner position of switch housing on outboard side of steering column - using a thin bladed screwdriver.
| Locate multiplug for front fog lamp switch - part of instrument wiring harness. | |||
|---|---|---|---|
| .P. U1068.tif | 9 | 7,5 | tiff;; |
| .D. ICON01.tif | 0,75 | 0,75 | tiff;; Remove, Disconnect |
As of MY 97:
Bezel at driving lamp switch assembly from instrument panel - lever out using thin bladed screwdriver.
| Locate multiplug for front fog lamp switch - part of instrument harness. | |||
|---|---|---|---|
| .P. U9153.tif | 9 | 7,5 | tiff;; |
| .D. ICON02.tif | 0,75 | 0,75 | tiff;; Install, Connect |
Multiplug to switch.
Switch - press - in until retaining lugs on switch engage in housing.
| Illustration shows up to MY 97. Switch and connector as of MY 97 is similar. | |||
|---|---|---|---|
| .P. U1073.tif | 9 | 7,5 | tiff;; |
| .D. ICON02.tif | 0,75 | 0,75 | tiff;; Install, Connect |
Fog lamp relay - see "Survey of Fuses, Relays and Control Units" in group N.
Battery ground cable.
| .D. ICON06.tif | 0,75 | 0,75 | tiff;; Inspect |
Operation of fog lamps - they should illuminate in conjunction with parking lamps and headlamps on main / dip beams.
| The rear fog lamps should also illuminate with the parking lamps when the front fog lamps are switched on. | |||
|---|---|---|---|
| .P. U9611.tif | 9 | 7,5 | tiff;; |
| .D. ICON08.tif | 0,75 | 0,75 | tiff;; Adjust |
Fog lamps:
Position vehicle on even surface. Check / correct tyre pressure, load rear seat with approx. 70 kg / 154 lbs.
Pivot lamps to give a light beam inclination of 20 cm / 8 in. per 10 m / 11 yds.
| .D. ICON09.tif | 0,75 | 0,75 | tiff;; Tighten (Torque) |
Lamp pivot nut:
Bosch lamps - 23 Nm / 17 lbf ft.
| Hella lamps - 17 Nm / 13 lbf ft. | |||
|---|---|---|---|
| .P. U1079.tif | 9 | 7,5 | tiff;; |
| .D. ICON02.tif | 0,75 | 0,75 | tiff;; Install, Connect |
| Up to MY 97; radio speaker and cover. | |||
| .P. U1068.tif | 9 | 7,5 | tiff;; |