| Nm | |
|---|---|
| Refrigerant lines to: | |
| - Condenser | 10 |
| - Expansion valve (TXV) | 9 |
| - Compressor | 25 |
| - ABS bracket (LHD) | 9 |
| - Upper front bracket (RHD) | 9 |
| Receiver-dryer to condenser (lower) | 5.5 |
| Retaining clamp for receiver-dryer to condenser | 5.5 |
| Pressure sensor to refrigerant line | 11 |
| Condenser bracket to upper front | 5.5 |
| Expansion valve (TXV) to evaporator | 3 |
| Compressor to engine main bracket | 20 |
Contents
Wiring diagrams Section: Air Conditioning- Air Conditioning Compressor Diagnosis
- Arrangement of Components in Passenger Compartment
- Arrangement of Components in Engine Compartment
- Evaporator
- Compressor
- Expansion Valve (Txv)
- Technical Data
- Leak Detection in Refrigerant Circuit
- Techline Diagnostic Software
- Arrangement of Diagnostic Plugs
- Diagram of Refrigerant Circuit
- Service Connection Locations (Lhd)
- How to Drain the Air Conditioning
- Air Conditioning, Evacuate and Charge
- How to Top Up the Compressor Lubricant
- How to Remove and Install (Lhd) the Refrigerant Lines
- How to Remove and Install (Rhd the Refrigerant Lines (Except Closed Cooling System))
- How to Remove and Install the Condenser
- How to Remove and Install (Lhd) the Evaporator
- How to Remove and Install (Rhd) the Evaporator
- How to Remove and Install the Receiver-Dryer
- How to Remove and Install the Thermostatically Controlled Expansion Valve (Txv)
- How to Remove and Install the Frost Protection Sensor
- How to Remove and Install (Lhd) the Pressure Sensor - Air Conditioning
- How to Remove and Install (Rhd the Air Conditioning Pressure Sensor (Except Closed Cooling System))
- Compressor - Survey
- How to Remove and Install the Compressor
- How to Remove and Install the Compressor Clutch
- How to Remove and Install the Compressor Pulley
- How to Remove and Install the Compressor Solenoid Coil
- How to Remove and Install the Compressor Control Valve
- How to Remove and Install the Compressor Safety Valve
- How to Remove and Install (Lhd) the Condensation Drain
- How to Remove and Install (Rhd) the Condensation Drain
- How to Remove and Install the Switch - Mixed Air / Air Conditioning Controls
- How to Replace the Bulb - Mixed Air / Air Conditioning Control Switch
- Recommended Torque Values - Compressor
- Recommended Torque Values
- How to Remove and Install the Compressor Seal Ring
- How to Replace the Service Connection Valve (Charged AC)
- How to Replace the Condenser
- How to Remove and Install (Z 13 DT) the Thermostatically Controlled Expansion Valve (Txv)
- How to Remove and Install (Z 13 DT) the Air Conditioning Pressure Sensor
- How to Remove and Install the Main Bracket for Compressor
- ABS
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Other Accessories
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seats, Upholstery, Inner Trim Panels
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses