Home/Mitsubishi/Lancer Evolution/Mitsubishi Lancer Evolution IX (2005-2007)/Repair manual/Supplemental Restraint System - Lancer Evolution/<< A >> NEGATIVE (-) BATTERY CABLE DISCONNECTION

Contents

Section: Supplemental Restraint System - Lancer Evolution

GENERAL DESCRIPTION

ON-BOARD DIAGNOSTIC/SRS WARNING LIGHT FUNCTION

WARNING/CAUTION LABELS

SRS AIR BAG SPECIAL CONNECTOR

SQUIB CIRCUIT CONNECTOR LOCK SWITCH

WARNING LIGHT CIRCUIT CONNECTOR LOCK SWITCH

CIRCUIT DIAGRAM

INTRODUCTION TO DIAGNOSIS

TROUBLESHOOTING STRATEGY

HOW TO CONNECT THE SCAN TOOL

HOW TO READ AND ERASE DIAGNOSTIC TROUBLE CODES

DIAGNOSTIC TROUBLE CODE CHART

TROUBLE SYMPTOM CHART

CIRCUIT OPERATION

DTC SET CONDITIONS

TROUBLESHOOTING HINTS

DIAGNOSIS

TROUBLESHOOTING HITS — Part 1

TROUBLESHOOTING HITS — Part 2

TECHNICAL DESCRIPTION (COMMENT)

SPECIAL TOOLS

TEST EQUIPMENT

POST-COLLISION DIAGNOSIS

SRS-ECU MEMORY CHECK

WHEN FRONT AIR BAGS DEPLOY IN A COLLISION.

WHEN AIR BAGS DO NOT DEPLOY IN LOW-SPEED COLLISION.

STEERING WHEEL, STEERING COLUMN AND SHAFT ASSEMBLY

SEAT BELT WITH PRE-TENSIONER

HARNESS CONNECTOR (FLOOR WIRING HARNESS)

INDIVIDUAL COMPONENT SERVICE

<< A >> NEGATIVE (-) BATTERY CABLE DISCONNECTION

>> A << PRE-INSTALLATION INSPECTION

>> B << FRONT IMPACT SENSOR INSTALLATION

INSPECTION

>> A << SRS-ECU INSTALLATION

REMOVAL AND INSTALLATION

<< B >> COVER REMOVAL

<< C >> STEERING WHEEL-DRIVER'S AIR BAG MODULE ASSEMBLY REMOVAL

<< D >> CLOCK SPRING REMOVAL

<< E >> PASSENGER'S (FRONT) AIR BAG MODULE REMOVAL

>> B << CLOCK SPRING INSTALLATION

>> C << STEERING WHEEL-DRIVER'S AIR BAG MODULE ASSEMBLY INSTALLATION

AIR BAG MODULE CHECK

CLOCK SPRING CHECK

>> B << PRE-TENSIONER CONNECTOR CONNECTION

SEAT BELT WITH PRE-TENSIONER CHECK

AIR BAG MODULE AND SEAT BELT PRE-TENSIONER DISPOSAL PROCEDURES

UNDEPLOYED AIR BAG MODULE DISPOSAL

DEPLOYMENT OUTSIDE THE VEHICLE < DRIVER'S AIR BAG MODULE >

DEPLOYMENT OUTSIDE THE VEHICLE < PASSENGER'S (FRONT) AIR BAG MODULE >

DEPLOYMENT OUTSIDE THE VEHICLE < SEAT BELT PRE-TENSIONER >

DEPLOYED AIR BAG MODULE AND OPERATED SEAT BELT PRE-TENSIONER DISPOSAL

FASTENER TIGHTENING SPECIFICATIONS

All sections

<< A >> NEGATIVE (-) BATTERY CABLE DISCONNECTION Mitsubishi Lancer Evolution IX

Supplemental Restraint System - Lancer Evolution

<< A >> NEGATIVE (-) BATTERY CABLE DISCONNECTION

WARNING

Wait at least 60 seconds after disconnecting the battery cable before doing any further work (Refer to SERVICE PRECAUTIONS ).

WARNING

Battery posts, terminals and related accessories contain lead and lead compounds. WASH HANDS AFTER HANDLING.

Disconnect the negative (-) battery cable from the battery and tape the terminal to prevent accidental connection and air bag(s) deployment.