Repair manual
Wiring diagrams
Mazda CX-9 I Repair Manual
Step-by-step repair and maintenance instructions for the Mazda CX-9 I (2006–2012): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
74sections
725articles
ENManual language
- Automatic Transaxle - Overhaul (AW6A-EL, AW6AX-EL) 2
- Automatic Transaxle Shift Mechanism 2
- Automatic Transaxle - Service, Removal & Installation (AW6A-EL, AW6AX-EL) 3
- Symptom Troubleshooting - Automatic Transaxle (AW6A-EL, AW6AX-EL) 5
- On-Board Diagnostic - Automatic Transaxle (AW6A-EL, AW6AX-EL) 58
- Technical Data (Transmission)
- Service Tools (Transmission)
Automatic Transaxle - Service, Removal & Installation (AW6A-EL, AW6AX-EL): Removal & Installation
14 subsections- Automatic Transaxle Fluid (ATF) Replacement [AW6A-El, AW6AX-El]
- Transaxle Fluid Temperature (TFT) Sensor Removal/Installation [AW6A-El, AW6AX-El]
- On-Vehicle Inspection
- Off-Vehicle Inspection
- Input/Turbine Speed Sensor Removal/Installation [AW6A-El, AW6AX-El]
- Vehicle Speed Sensor (VSS) Removal/Installation [AW6A-El, AW6AX-El]
- TCM Removal/Installation [AW6A-El, AW6AX-El]
- Oil Seal (Manual Shaft) Replacement [AW6A-El, AW6AX-El]
- Automatic Transaxle Removal/Installation [AW6A-El, AW6AX-El]
- Differential Gear O-Ring Replacement [AW6A-El, AW6AX-El]
- On-Vehicle Removal
- On-Vehicle Installation
- Oil Cooler Removal/Installation [AW6A-El, AW6AX-El]
- Radiator (In Tank Oil Cooler) Installation Note
- Security System and Locks System 5
- On-Board Diagnostic (Advanced Keyless Entry and Start System) 18
- Symptom Troubleshooting (Keyless Entry System) 3
- On-Board Diagnostic [Immobilizer System (Advanced Keyless and Start System)] 4
- On-Board Diagnostic [Immobilizer System (Keyless Entry System)] 4
- On-Board Diagnostic (Power Liftgate (Plg) System) 13
- Symptom Troubleshooting (Power Liftgate (Plg) System) 3
- Symptom Troubleshooting (Advanced Keyless System and Start System) 3
- VARIABLE VALVE TIMING ACTUATOR REMOVAL/INSTALLATION [MZI-3.7]
- Variable Valve Timing Actuator Component Removal Note
- TIMING CHAIN REMOVAL/INSTALLATION [MZI-3.7]
- Cylinder Head Cover Oil Seal Removal Note
- Timing Chain Component Removal Note
- Front Oil Seal Installation Note
- Crankshaft Pulley Installation Note
- CYLINDER HEAD GASKET REPLACEMENT [MZI-3.7]
- Camshaft Component Removal Note
- Cylinder Head Installation Note
- Rear Oil Seal Installation Note
- ENGINE REMOVAL/INSTALLATION [MZI-3.7]
- Engine & Transaxle Removal Note
- Water Inlet Pipe Installation Note
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- On-Board Diagnostic - Entertainment System - [Audio (Touch Panel Type Audio)] 2
- Entertainment System 5
- On-Board Diagnostic - Entertainment System - (Audio Amplifier) 3
- On-Board Diagnostic - Entertainment System - [Hands Free Telephone (Hf/tel) System] 3
- On-Board Diagnostic - Entertainment System - [Audio (Standard Audio)] 3
- Symptom Troubleshooting (Entire Audio System) 3
- Symptom Troubleshooting (Radio) 3
- Symptom Troubleshooting (Cassete Tape Player) 3
- Symptom Troubleshooting (CD Player/changer) 2
- Symptom Troubleshooting [Rear Entertainment System (Res)] 4
- Symptom Troubleshooting (Hands-Free Telephone (Hf/tel) System) 3
- Range Of Topics
- Symbols
- Advisory Messages
- Upper And Lower Limits
- UNITS
- Conversion To SI Units (Systeme International d'Unites)
- Rounding Off
- Injury/Damage Prevention Precautions
- Disconnection Of The Negative Battery Cable
- Using UV Light (Black Light)
- Dynamometer
- Speedometer Tester Measurement
- Free Roller Type
- SST
- Viewing orientation for Connectors
- Part-Side Connector
- Other
- Jumper Wire
- Ohmmeter
- Precautions Before Welding
- Jacking Positions
- Front And Rear
- TOWING
- Tiedown Hooks
- Install The Spare Tire
- TIEDOWN HOOK
- SAE STANDARDS
- Exterior
- Under Hood-Engine Off
- Interior
- Under Hood-Engine Running At Operating Temperature
- On Hoist
- Schedule 1: (Normal Driving Conditions) For U.S.A.
- Schedule 2: CANADA, Puerto Rico, And (Unique Driving Conditions) For U.S.A.
- Schedule 1: (Normal Driving Conditions) For Mexico
- Schedule 2: (Unique Driving Conditions) For Mexico
- DRIVE CYCLE PROCEDURE
- Drive Cycle-Mode 1
- Drive Cycle-Mode 2
- Drive Cycle-Mode 3
- Drive Cycle-Mode 4
- Preparation
- Drive Mode
- Comprehensive Component Monitor Repair Verification Drive Mode
- EGR Monitor Repair Verification Drive Mode
- Catalyst Monitor Repair Verification Drive Mode
- Fuel Monitor, Oxygen Sensor Monitor or Oxygen Sensor Heater Monitor Repair Verification Drive Mode
- Misfire Monitor Repair Verification Drive Mode
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Verification Drive Cycle
- HO2S/TWC Monitor Repair Verification Drive Cycle
- EVAP Monitor Repair Verification Drive Cycle
- 1999: B2500, B3000, B4000
- Vehicle Preparation For Drive Cycles
- EVAP System Monitor Repair Verification Drive Cycle
- HO2S Monitor Repair Verification Drive Cycle
- OBDII DRIVE MODE
- Mode 1 (PCM adaptive memory produce drive mode)
- Mode 2 (EGR system repair verification drive mode)
- Mode 3 HO2S heater, HO2S, and TWC repair verification drive mode)
- Mode 4 (EVAP system repair verification drive mode)
- Drive Cycle Recommendations
- Vehicle Preparation
- OBD II Drive Cycle
- 2000: MPV
- Mode 1 (PCM Adaptive Memory)
- Mode 2 (EGR Verification)
- Mode 3 (HO2S/TWC Verification)
- Mode 4 (EVAP Verification)
- 2000: PROTEGE
- Standard Drive Mode
- HO2S/TWC Monitor Repair Verification Drive Mode
- EVAP Monitor Repair Verification Drive Mode
- 2001: B2300, B2500, B3000, B4000, TRIBUTE
- OBD-II Drive Cycle Vehicle Preparation
- OBD-II Drive Cycle Procedures
- PCM Adaptive Memory Drive Mode
- Mode 1 (PCM Adaptive Memory Drive Mode)
- Mode 2 (EGR Monitor Repair Verification Drive Mode)
- Mode 3 (HO2S/TWC Monitor Repair Verification Drive Mode)
- Mode 4 (EVAP Monitor Repair Verification Drive Mode)
- OBD-II Drive Cycle Procedure
- 2002: MILLENIA
- Mode 1: PCM Adaptive Memory Procedure
- Mode 2: EGR System Repair Verification
- Mode 3: HO2S & TWC Repair Verification
- Mode 4: EVAP System Repair Verification
- Mode 1 - PCM Adaptive Memory Produce Drive Mode
- Mode 2 - EGR System Repair Verification Drive Mode
- Mode 3 - HO2S Heater, HO2S & TWC Repair Verification Drive Mode
- Mode 6 - EVAP System Repair Verification Drive Mode
- Mode 4 - EVAP System Repair Verification Drive Mode
- Drive Mode 1 - PCM Adaptive Memory
- Drive Mode 2 - EGR Monitor Repair Verification
- Drive Mode 3 - HO2S, HO2S Heater & TWC Repair Verification
- Drive Mode 4 - EVAP System Repair Verification
- Drive Mode 5 - EVAP System Very Small Leak Repair Verification
- OBD-II DRIVE MODES
- 2004-06: MAZDA3 & 2006: MAZDA5 & 2007-09: MAZDA3 (W/O TURBO)
- PCM Adaptive Memory Production Drive Mode
- EVAP System Repair Verification Drive Mode
- 2004-05: MAZDA6
- MODE 6 (EVAP SYSTEM REPAIR VERIFICATION DRIVE MODE)
- 2004: MPV
- 2004: MX-5 MIATA
- MODE 1 (PCM ADAPTIVE MEMORY PRODUCTION DRIVE MODE)
- 2004: RX-8
- 2005-06: MPV
- With rear HO2S model
- 2005: MX-5 MIATA
- 2005-08: RX-8
- 2006-08: MAZDA6
- EVAP System Repair Verification Drive Mode (4 Cylinder W/O Turbo & V6)
- EVAP System Repair Verification Drive Mode (4 Cylinder W/Turbo)
- 2006-08: MX-5 MIATA
- 2007-09: MAZDA3 (W/TURBO)
- 2007: MAZDA5
- 2007-08: CX-7
- PCM Adaptive Memory Production, EGR, HO2S heater, HO2S, TWC, and EVAP System Repair Verification Drive Mode
- 2007-10: CX-9
- 2008-09: MAZDA5
- Mode 06 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode
- 2009-10: MAZDA6 (4 CYLINDER)
- Mode 02 (EGR System Repair Verification Drive Mode)
- 2009-10: MAZDA6 (V6)
- 2009: CX-7
- Mode 03 (A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S, and TWC Repair Verification Drive Mode)
- 2009: MX-5 MIATA
- 2009-11: RX-8
- Mode 5 (AIR System Repair Verification Drive Mode)
- 2010-13: MAZDA3 (W/TURBO)
- 2010: MAZDA5
- 2010-12: CX-7 (W/TURBO)
- 2010-12: CX-7 (W/O TURBO)
- 2010-13: MX-5 MIATA
- Mode 03 (PCM Adaptive Memory Production, EGR System, A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S, and TWC Repair Verification Drive Mode)
- 2011-13: CX-9
- 2010-13: MAZDA3 (W/O TURBO)
- 2012-13: MAZDA5
- 2011-13: MAZDA6 (4 CYLINDER)
- Mode 03 (EGR System, A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S and TWC Repair Verification Drive Mode)
- 2011-13: MAZDA6 (V6)
- 2012-13: MAZDA2
- 2013: CX-5