Repair manual
Wiring diagrams
Mazda CX-7 I facelift Repair Manual
Step-by-step repair and maintenance instructions for the Mazda CX-7 I facelift (2009–2012): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
- Engine Tune-Up [L3 with Tc]
- Engine Tune-Up Preparation
- Ignition Timing Inspection
- Idle Speed Inspection
- Idle Mixture Inspection
- Drive Belt Inspection [L3 with Tc]
- Drive Belt Removal/installation [L3 with Tc]
- Variable Valve Timing Actuator Inspection [L3 with Tc]
- Variable Valve Timing Actuator Removal/installation [L3 with Tc]
- Oil Control Valve (Ocv) Removal/installation [L3 with Tc]
- Compression Inspection [L3 with Tc]
- Oil Pump Driven Sprocket Removal Note
- Timing Chain Installation Note
- Cylinder Head Gasket Replacement [L3 with Tc]
- Camshaft Removal Note
- Front Oil Seal Replacement [L3 with Tc]
- Rear Oil Seal Replacement [L3 with Tc]
- Engine Removal/installation [L3 with Tc]
- Engine Disassembly/assembly [L3 with Tc]
- Automatic Transaxle - Overhaul (AW6A-EL, AW6AX-EL)
- Automatic Transaxle Shift Mechanism
- Automatic Transaxle - Service, Removal & Installation (AW6A-EL, AW6AX-EL)
- On-Board Diagnostic - Automatic Transaxle (AW6A-EL, AW6AX-EL)
- Symptom Troubleshooting - Automatic Transaxle (AW6A-EL, AW6AX-EL)
- Technical Data - Automatic Transmission
- Service Tools - Automatic Transmission
- AUTOMATIC TRANSAXLE FLUID (ATF) REPLACEMENT [AW6A-EL, AW6AX-EL]
- TRANSAXLE FLUID TEMPERATURE (TFT) SENSOR REMOVAL/INSTALLATION [AW6A-EL, AW6AX-EL]
- On-Vehicle Inspection
- Off-Vehicle Inspection
- INPUT/TURBINE SPEED SENSOR REMOVAL/INSTALLATION [AW6A-EL, AW6AX-EL]
- VEHICLE SPEED SENSOR (VSS) REMOVAL/INSTALLATION [AW6A-EL, AW6AX-EL]
- TCM REMOVAL/INSTALLATION [AW6A-EL, AW6AX-EL]
- OIL SEAL (MANUAL SHAFT) REPLACEMENT [AW6A-EL, AW6AX-EL]
- DIFFERENTIAL GEAR O-RING REPLACEMENT [AW6A-EL, AW6AX-EL]
- On-Vehicle Removal
- On-Vehicle Installation
- Radiator (In Tank Oil Cooler) Installation Note
- ENGINE OVERHAUL SERVICE WARNING
- TIMING CHAIN DISASSEMBLY
- Crankshaft Pulley Lock Bolt Disassembly Note
- Front Oil Seal Disassembly Note
- Oil Pump Driven Sprocket Disassembly Note
- CYLINDER HEAD (I) DISASSEMBLY
- Camshaft Sprocket, Variable Valve Timing Actuator Disassembly Note
- Camshaft Cap Disassembly Note
- Tappet Disassembly Note
- Cylinder Head Disassembly Note
- CYLINDER HEAD (II) DISASSEMBLY
- Valve Keeper Disassembly Note
- Valve Seal Disassembly Note
- CYLINDER BLOCK (I) DISASSEMBLY
- Oil Pan Disassembly Note
- Flywheel Disassembly Note
- CYLINDER BLOCK (II) DISASSEMBLY
- Pilot Bearing Disassembly Note
- Connecting Rod Cap Disassembly Note
- Connecting Rod, Piston Disassembly Note
- Piston Pin Disassembly Note
- Main Bearing Cap Disassembly Note
- CYLINDER BLOCK (I) ASSEMBLY
- Main Bearing Cap Assembly Note
- Piston Pin Assembly Note
- Piston Ring Assembly Note
- Connecting Rod Bearing Assembly Note
- Connecting Rod Cap Assembly Note
- Pilot Bearing Assembly Note
- CYLINDER BLOCK (II) ASSEMBLY
- Flywheel Assembly Note
- CYLINDER HEAD (I) ASSEMBLY
- Water Outlet Case Assembly Note
- Valve Seal Assembly Note
- Valve Keeper Assembly Note
- CYLINDER HEAD (II) ASSEMBLY
- Cylinder Head Assembly Note
- Camshaft Assembly Note
- Camshaft Sprocket, Variable Valve Timing Actuator Assembly Note
- TIMING CHAIN ASSEMBLY
- Drive Sprocket Assembly Note
- Oil Pump Driven Sprocket Assembly Note
- Camshaft Sprocket Lock Bolt Assembly Note
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information
- Waveforms - Injector Pattern Tutorial - General Information
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- Entertainment System
- On-Board Diagnostic - Entertainment System - (Audio Amplifier)
- On-Board Diagnostic - Entertainment System - (Standard Audio)
- Symptom Troubleshooting (Entire Audio System)
- Symptom Troubleshooting (Radio)
- Symptom Troubleshooting (CD Player/changer)
- On-Board Diagnostic - Entertainment System - [Hands-Free Telephone System]
- On-Board Diagnostic - Entertainment System - (Touch Panel Tpe Audio)
- Range of Topics
- Advisory Messages
- Upper and lower limits
- UNITS
- Conversion to SI Units (Systeme International d'Unites)
- Rounding Off
- SERVICE CAUTIONS
- Disconnection of the Negative Battery Cable
- Using UV light (black light)
- Dynamometer
- Speedometer tester measurement
- Free roller type
- Brake tester measurement
- SST
- Viewing orientation for Connectors
- Part-side connector
- Other
- Jumper wire
- Ohmmeter
- Precautions Before Welding
- Jacking Positions
- Front
- Front and rear
- Towing a 2WD Vehicle
- Towing an AWD Vehicle
- Towing/Tiedown Hooks
- TIEDOWN HOOK
- SAE STANDARDS
- Exterior
- Under hood-engine off
- Interior
- On hoist
- Schedule 2: CANADA, Puerto Rico and (Unique Driving Conditions) for U.S.A.
- Chart Symbols
- Remarks
- DRIVE CYCLE PROCEDURE
- Drive Cycle-Mode 1
- Drive Cycle-Mode 2
- Drive Cycle-Mode 3
- Drive Cycle-Mode 4
- Preparation
- Drive Mode
- Comprehensive Component Monitor Repair Verification Drive Mode
- EGR Monitor Repair Verification Drive Mode
- Catalyst Monitor Repair Verification Drive Mode
- Fuel Monitor, Oxygen Sensor Monitor or Oxygen Sensor Heater Monitor Repair Verification Drive Mode
- Misfire Monitor Repair Verification Drive Mode
- Vehicle Preparation For OBD-II Or Monitor Repair Verification Drive Cycle
- Comprehensive Component Monitor Repair Verification Drive Cycle
- EGR Monitor Repair Verification Drive Cycle
- EVAP Running Loss System Repair Verification Drive Cycle
- Catalyst Monitor Repair Verification Drive Cycle
- Fuel Monitor Or HO2S Monitor Repair Verification Drive Cycle
- Misfire Monitor Repair Verification Drive Cycle
- Secondary Air Monitor Repair Verification Drive Cycle
- Verification Drive Cycle
- HO2S/TWC Monitor Repair Verification Drive Cycle
- EVAP Monitor Repair Verification Drive Cycle
- 1999: B2500, B3000, B4000
- Vehicle Preparation For Drive Cycles
- EVAP System Monitor Repair Verification Drive Cycle
- HO2S Monitor Repair Verification Drive Cycle
- OBDII DRIVE MODE
- Mode 1 (PCM adaptive memory produce drive mode)
- Mode 2 (EGR system repair verification drive mode)
- Mode 3 HO2S heater, HO2S, and TWC repair verification drive mode)
- Mode 4 (EVAP system repair verification drive mode)
- Drive Cycle Recommendations
- Vehicle Preparation
- OBD II Drive Cycle
- 2000: MPV
- Mode 1 (PCM Adaptive Memory)
- Mode 2 (EGR Verification)
- Mode 3 (HO2S/TWC Verification)
- Mode 4 (EVAP Verification)
- 2000: PROTEGE
- Standard Drive Mode
- HO2S/TWC Monitor Repair Verification Drive Mode
- EVAP Monitor Repair Verification Drive Mode
- 2001: B2300, B2500, B3000, B4000, TRIBUTE
- OBD-II Drive Cycle Vehicle Preparation
- OBD-II Drive Cycle Procedures
- PCM Adaptive Memory Drive Mode
- Mode 1 (PCM Adaptive Memory Drive Mode)
- Mode 2 (EGR Monitor Repair Verification Drive Mode)
- Mode 3 (HO2S/TWC Monitor Repair Verification Drive Mode)
- Mode 4 (EVAP Monitor Repair Verification Drive Mode)
- OBD-II Drive Cycle Procedure
- 2002: MILLENIA
- Mode 1: PCM Adaptive Memory Procedure
- Mode 2: EGR System Repair Verification
- Mode 3: HO2S & TWC Repair Verification
- Mode 4: EVAP System Repair Verification
- Mode 1 - PCM Adaptive Memory Produce Drive Mode
- Mode 2 - EGR System Repair Verification Drive Mode
- Mode 3 - HO2S Heater, HO2S & TWC Repair Verification Drive Mode
- Mode 6 - EVAP System Repair Verification Drive Mode
- Mode 4 - EVAP System Repair Verification Drive Mode
- Drive Mode 1 - PCM Adaptive Memory
- Drive Mode 2 - EGR Monitor Repair Verification
- Drive Mode 3 - HO2S, HO2S Heater & TWC Repair Verification
- Drive Mode 4 - EVAP System Repair Verification
- Drive Mode 5 - EVAP System Very Small Leak Repair Verification
- OBD-II DRIVE MODES
- 2004-06: MAZDA3 & 2006: MAZDA5 & 2007-09: MAZDA3 (W/O TURBO)
- PCM Adaptive Memory Production Drive Mode
- EVAP System Repair Verification Drive Mode
- 2004-05: MAZDA6
- MODE 6 (EVAP SYSTEM REPAIR VERIFICATION DRIVE MODE)
- 2004: MPV
- 2004: MX-5 MIATA
- MODE 1 (PCM ADAPTIVE MEMORY PRODUCTION DRIVE MODE)
- 2004: RX-8
- 2005-06: MPV
- With rear HO2S model
- 2005: MX-5 MIATA
- 2005-08: RX-8
- 2006-08: MAZDA6
- EVAP System Repair Verification Drive Mode (4 Cylinder W/O Turbo & V6)
- EVAP System Repair Verification Drive Mode (4 Cylinder W/Turbo)
- 2006-08: MX-5 MIATA
- 2007-09: MAZDA3 (W/TURBO)
- 2007: MAZDA5
- 2007-08: CX-7
- PCM Adaptive Memory Production, EGR, HO2S heater, HO2S, TWC, and EVAP System Repair Verification Drive Mode
- 2007-10: CX-9
- 2008-09: MAZDA5
- Mode 06 (EVAP System Repair Verification Drive Mode)
- Single Drive Mode
- 2009-10: MAZDA6 (4 CYLINDER)
- Mode 02 (EGR System Repair Verification Drive Mode)
- 2009-10: MAZDA6 (V6)
- 2009: CX-7
- Mode 03 (A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S, and TWC Repair Verification Drive Mode)
- 2009: MX-5 MIATA
- 2009-11: RX-8
- Mode 5 (AIR System Repair Verification Drive Mode)
- 2010-13: MAZDA3 (W/TURBO)
- 2010: MAZDA5
- 2010-12: CX-7 (W/TURBO)
- 2010-12: CX-7 (W/O TURBO)
- 2010-13: MX-5 MIATA
- Mode 03 (PCM Adaptive Memory Production, EGR System, A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S, and TWC Repair Verification Drive Mode)
- 2011-13: CX-9
- 2010-13: MAZDA3 (W/O TURBO)
- 2012-13: MAZDA5
- 2011-13: MAZDA6 (4 CYLINDER)
- Mode 03 (EGR System, A/F Sensor Heater, HO2S Heater, A/F Sensor, HO2S and TWC Repair Verification Drive Mode)
- 2011-13: MAZDA6 (V6)
- 2012-13: MAZDA2
- 2013: CX-5