BUZZERS, RELAYS & TIMERS
| Component | Component Location |
|---|---|
| Accessory Power Socket Relay | On dash fuse box. |
| A/C Compressor Relay | In fuse/relay box. |
| Condenser Fan Hi Relay (2.2L) | In option fuse box. |
| Condenser Fan Hi Relay 2 (2.2L) | In option fuse box. |
| Condenser Fan Lo Relay (2.2L) | In fuse/relay box. |
| Condenser Fan Relay (3.2L) | In fuse/relay box. |
| Dome Light Relay | In fuse/relay box. |
| ECM Main Relay (M/T) | In fuse/relay box. |
| Flasher Unit | Above left kick panel. |
| Foglight Relay | In fuse/relay box. |
| Fuel Pump Relay | In fuse/relay box. |
| Headlight Relay | In fuse/relay box. |
| Heater-A/C Relay | In fuse/relay box. |
| Horn Relay | Integral to alarm & relay control unit. |
| Intake Actuator Relay | Behind glove box. |
| Map Light Timer | Above right kick panel. |
| PCM Main Relay (A/T) | In fuse/relay box. |
| Power Window Relay | On dash fuse box. |
| Rear Window Defogger Relay | On dash fuse box. |
| Shift Lock Relay | Below shift lever. |
| Starter Relay | In fuse/relay box. |
| Taillight Relay | On dash fuse box. |
| Thermo Switch Relay | In fuse/relay box. |
BUZZERS, RELAYS & TIMERS LOCATION
CIRCUIT PROTECTION DEVICES
| Component | Component Location |
|---|---|
| Dash Fuse Box | Behind dash, left of steering column. |
| Diode Box "B" | In fuse/relay box. |
| Diode Box No. 5 | In dash fuse box. |
| Diode Box No. 6 | In dash fuse box. |
| Fuse/Relay Box (2.2L) | On right side of engine compartment. (Схема №1) |
| Fuse/Relay Box (3.2L) | On right side of engine compartment. (Схема №4) |
| Option Fuse Box | At right rear of engine compartment. |
CIRCUIT PROTECTION DEVICES LOCATION
CONTROL UNITS
| Component | Component Location |
|---|---|
| Alarm & Relay Control Unit | Above right kick panel. |
| Cruise Control Unit | Under rear of center console. |
| Electronic Brake Control Module (EBCM) | On right rear corner of engine compartment. |
| Engine Control Module (ECM) (M/T) (2.2L) | Below center of dash. (Схема №8) |
| Engine Control Module (ECM) (M/T) (3.2L) | Left rear of engine compartment. |
| Ignition Control Module (ICM) (2.2L) | On right rear of engine. |
| Intelligent Suspension Control Unit | Below center of dash. |
| Ion Sensing Module (3.2L) | On top of intake manifold. |
| Keyless Entry & Security Control Unit | Above right kick panel. |
| Multi-Plexed Indicator Control Unit | Under rear of center console. |
| Powertrain Control Module (PCM) (A/T) (2.2L) | Below center of dash. (Схема №8) |
| Powertrain Control Module (PCM) (A/T) (3.2L) | Left rear of engine compartment. |
| Sensing & Diagnostic Module (2.2L) | Below center of dash. (Схема №8) |
| Sensing & Diagnostic Module (3.2L) | Below center of dash. |
| Shift-On-The-Fly Controller | On lower left center of dash. |
| Sun Roof Control Unit | Center front of roof. |
| 4WD Control Unit | Under center console. |
CONTROL UNITS LOCATION
MOTORS
| Component | Component Location |
|---|---|
| Blower Motor | Below right side of dash. |
| Condenser Fan | Behind right side of radiator grille. |
| Cruise Control Actuator | On right side of engine compartment, on inner fender panel. |
| Fuel Pump | Beneath rear of vehicle, in top of fuel tank. |
| Intake Actuator | On heater case. |
| Rear Washer Motor | On right front of engine compartment, in washer fluid reservoir. |
| Rear Wiper Motor | Inside right side of tailgate, behind trim panel. |
| Sun Roof Motor | Center front of roof. |
| Windshield Washer Motor | On right front of engine compartment, in washer fluid reservoir. |
| Windshield Wiper Motor | On right rear corner of engine compartment, on firewall. |
| 4WD Transfer Motor Actuator | On rear of transfer case. |
MOTORS LOCATION
SENDING UNITS & SENSORS
| Component | Component Location |
|---|---|
| Acceleration Position Sensor | Above accelerator pedal. |
| Camshaft Position (CMP) Sensor (2.2L) | On top center front of cylinder head. (Схема №1) |
| Camshaft Position (CMP) Sensor (3.2L) | On top rear of left cylinder head. (Схема №5) |
| Crankshaft Position (CKP) Sensor (2.2L) | On lower left front of engine. |
| Crankshaft Position (CKP) Sensor (3.2L) | On lower right side of engine. (Схема №7) |
| Engine Coolant Temperature (ECT) Gauge Sender (2.2L) | On right rear of engine, below intake manifold. |
| Engine Coolant Temperature (ECT) Gauge Sender (3.2L) | On left front of engine. (Схема №6) |
| Engine Coolant Temperature (ECT) Sensor (2.2L) | On rear of engine, in coolant manifold. (Схема №3) |
| Engine Coolant Temperature (ECT) Sensor (3.2L) | On right front of engine. (Схема №4) |
| Front Speed Sensors (ABS) | On inside of front wheels. |
| Fuel Vapor Pressure Sensor | On top of fuel tank. |
| Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 1) (3.2L) | On right exhaust downpipe. |
| Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 2) (3.2L) | On underside of vehicle, rear of right TWC converter. |
| Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 1) (3.2L) | On left exhaust downpipe. |
| Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 2) (3.2L) | On underside of vehicle, rear of left TWC converter. |
| Heated Oxygen Sensor (HO2S-POST) (2.2L) | Beneath center of vehicle, rear of TWC converter. |
| Heated Oxygen Sensor (HO2S-PRE) (2.2L) | On lower left side of engine, in exhaust downpipe. |
| Intake Air Temperature (IAT) Sensor (2.2L) | On left front of engine, on air duct assembly. (Схема №1) |
| Intake Air Temperature (IAT) Sensor (3.2L) | In air duct assembly. (Схема №4) |
| Knock Sensor (KS) (2.2L) | On lower right side of engine. (Схема №2) |
| Knock Sensor (KS) (3.2L) | Below upper intake manifold. (Схема №5) |
| Manifold Absolute Pressure (MAP) Sensor (2.2L) | On right side of engine, on intake manifold. (Схема №1) |
| Manifold Absolute Pressure (MAP) Sensor (3.2L) | On top rear of intake manifold. (Схема №4) |
| Mass Airflow (MAF) Sensor (3.2L) | In air duct assembly. (Схема №4) |
| Rear Speed Sensor (ABS) | Beneath rear of vehicle, on top of differential. |
| Throttle Position (TP) Sensor (2.2L) | On right side of engine, on throttle body. (Схема №1) |
| Throttle Position (TP) Sensor (3.2L) | On throttle body assembly. (Схема №6) |
| Transmission Speed Sensor (A/T) | Beneath center of vehicle, on top of transmission. |
| Vehicle Speed Sensor (VSS) (2.2L) | On right side of transmission. |
| Vehicle Speed Sensor (VSS) (3.2L) | Beneath center of vehicle, rear of transmission. |
SENDING UNITS & SENSORS LOCATION
SOLENOIDS & SOLENOID VALVES
| Component | Component Location |
|---|---|
| Evaporative Emission (EVAP) Canister Cut Valve | On underside of vehicle, above right side of rear axle. |
| Evaporative Emission (EVAP) Canister Purge Valve (2.2L) | On right rear of engine. |
| Evaporative Emission (EVAP) Canister Purge Valve (3.2L) | On front of engine. (Схема №6) |
| Exhaust Gas Recirculation (EGR) Solenoid Valve (2.2L) | On top center rear of engine. (Схема №3) |
| Exhaust Gas Recirculation (EGR) Solenoid Valve (3.2L) | On top right rear of engine. (Схема №4) |
| Front Actuator (Left) | On top of left front shock. |
| Front Actuator (Right) | On top of right front shock. |
| Front Axle Vacuum Solenoid Valve (Blue) | In left rear corner of engine compartment. |
| Front Axle Vacuum Solenoid Valve (Gray) | In left rear corner of engine compartment. |
| Idle Air Control (IAC) Valve (2.2L) | On throttle body. (Схема №1) |
| Idle Air Control (IAC) Valve (3.2L) | On top of throttle body. (Схема №4) |
| Rear Actuator (Left) | On top of left rear shock. |
| Rear Actuator (Right) | On top of right rear shock. |
| Shift Lock Solenoid | Below shift lever cover. |
| Variable Intake Manifold Vacuum Switching Valve (3.2L) | On left rear of engine. |
SOLENOIDS & SOLENOID VALVES LOCATION
SWITCHES
| Component | Component Location |
|---|---|
| A/C Dual Pressure Switch (M/T) (3.2L) | Behind left side of radiator grille. |
| A/C Pressure Switch (2.2L) | Behind left side of radiator grille. |
| A/C Thermo Switch | On A/C compressor. |
| A/C Triple Pressure Switch (A/T) (3.2L) | Behind left side of radiator grille. |
| A/T Gear Position Switch | Beneath center of vehicle, on left side of transmission. |
| A/T Mode Switch | Beneath center of vehicle, on left side of transmission. |
| Back-Up Light Switch (M/T) (2.2L) | Beneath vehicle, on left side of transmission. |
| Back-Up Light Switch (M/T) (3.2L) | Beneath vehicle, on top of transmission. |
| Brake Fluid Level Switch | On left rear of engine compartment, in brake fluid reservoir. |
| Brake Switch | Behind dash, on brake pedal support. |
| Clutch Start Switch | Behind dash, on clutch pedal support. |
| Clutch Switch | Behind dash, on clutch pedal support. |
| Driver's Seat Belt Switch | In driver's seat belt buckle. |
| Engine Hood Switch | At right rear corner of engine compartment. |
| Front Axle Switch | On center of front axle. |
| Hatch Gate Open Switch | Inside top center of tailgate, on latch assembly. |
| Kickdown Switch | Behind left side of dash, on accelerator pedal bracket. |
| Oil Pressure Switch (2.2L) | On lower right side of engine, near oil filter. (Схема №2) |
| Oil Pressure Switch (3.2L) | On lower front of engine, near oil filter. |
| Parking Brake Switch | Beneath center console, on parking brake lever. |
| Park Position Detect Switch | Below shift lever cover. |
| Power Steering Pressure (PSP) Switch | On power steering pump. |
| Tailgate Open Switch | On tailgate. |
| Transmission Switch No. 1 & No. 2 (M/T) | On left front of transmission. |
| Transmission Switch No. 3 & No. 4 (M/T) | On right front of transmission. |
| 4WD Transfer Switch | Beneath vehicle, on right side of transfer case. |
SWITCHES LOCATION
MISCELLANEOUS
| Component | Component Location |
|---|---|
| Anti-Theft Horn | On right side of engine compartment. |
| Blower Resistor | Behind glove box, on plenum. |
| Condenser (Ignition) | On right front of engine. |
| Data Link Connector (DLC) | On lower left side of dash, near engine hood release lever. |
| Electronic Thermostat | Behind glove box, on plenum. |
| Fuel Tank Unit | Beneath rear of vehicle, in top of fuel tank. |
| High Note Horn | Behind right side of radiator grille. |
| Ignition Coils (2) (2.2L) | On right rear of engine. |
| Ignition Coils (6) (3.2L) | On both valve covers, at top of respective cylinder. (Схема №7) |
| Inverter | Underside of vehicle, behind left rear wheel. |
| J/C "A" | In fuse/relay box. |
| J/C "B" | In fuse/relay box. |
| Low Note Horn | Behind right side of radiator grille. |
| Trailer Lighting Connector | In left rear cargo compartment, taped to harness. |
MISCELLANEOUS LOCATION
CONNECTORS
| Component | Component Location |
|---|---|
| B9 (Black, 6 Pin) | In right taillight assembly. |
| B13 (Black, 6 Pin) | In left taillight assembly. |
| B22 (White, 2 Pin) | Under left front seat. |
| B38 (White/Gray, 2 Pin) | Under driver's seat. |
| B39 (White/Gray, 2 Pin) | Under passenger's seat. |
| C13 (Brown, 2 Pin) | Behind left front wheel. |
| C17 (Gray, 2 Pin) | Behind left side of front bumper. |
| C22 (Gray, 2 Pin) | Behind right side of front bumper. |
| C24 (Gray, 2 Pin) | At left front of engine compartment, behind grille. |
| C27 (White, 6 Pin) | At right rear of engine compartment, on wiper motor assembly. |
| C33 (Brown, 3 Pin) | Behind right front wheel. |
| C35 (Gray, 4 Pin) | On left side of fan shroud. |
| C37 (White, 22 Pin) | Below center of dash, below engine control module. |
| C43 (Gray, 6 Pin) | At right side of engine compartment. |
| C44 (Black, 4 Pin) | At right side of engine compartment. |
| C45 (Black, 4 Pin) | At left side of engine compartment. |
| C46 (Gray, 6 Pin) | At left side of engine compartment. |
| C47 (Gray, 4 Pin) | At lower left side of engine. |
| C71 (2.2L) | At center front of engine compartment. |
| C72 (2.2L) | At center front of engine compartment. |
| D2 (White, 2 Pin) | Behind trim, inside front of left front door. |
| D3 (White, 8 Pin) | At top front of left front door. |
| D9 (White, 3 Pin) | Inside rear of left front door. |
| D11 (White, 2 Pin) | Inside front of right front door. |
| D12 (White, 8 Pin) | Top front of right front door. |
| D15 (White, 3 Pin) | Inside rear of right front door. |
| D20 (White, 2 Pin) | Inside front of left rear door. |
| D25 (White, 2 Pin) | Inside front of right rear door. |
| E4 (Gray, 1 Pin) | At left side of engine compartment. |
| E9 (Gray, 5 Pin) | At left side of engine compartment, near air cleaner. |
| E14 (Black, 2 Pin) | At right side of engine compartment, near generator. |
| E27 (Gray, 3 Pin) | At right front of engine, beside generator. |
| E45 (Black, 1 Pin) | At front of engine, near throttle body. |
| E50 (3.2L) (Black, 4 Pin) | At left front of transmission. |
| E51 (3.2L) (Black, 4 Pin) | At right front of transmission. |
| E52 (Gray, 4 Pin) | At left side of transmission. |
| E53 (3.2L) (Black, 8 Pin) | At left side of transmission. |
| E54 (Gray, 7 Pin) | At left side of transmission. |
| E56 (White, 1 Pin) | On right side of transfer case. |
| E57 (White, 1 Pin) | On right side of transfer case. |
| E58 (3.2L) (Black, 4 Pin) | At left rear of transmission. |
| E59 (3.2L) (Black, 4 Pin) | At right rear of transmission. |
| E60 (Gray, 6 Pin) | Underneath center of vehicle, rear of transfer case. |
| E62 (3.2L) (1 Pin) | On top of transmission. |
| E63 (1 Pin) | On top of transmission. |
| F1 (Black, 4 Pin) | Under vehicle, on top of fuel tank. |
| F4 (Gray, 2 Pin) | Under center rear of vehicle. |
| F5 (Black, 4 Pin) | Underneath vehicle, near left rear shock absorber. |
| F6 (Gray, 8 Pin) | Underneath vehicle, near right rear shock absorber. |
| F7 (Gray, 8 Pin) | Underneath vehicle, near right rear shock absorber. |
| G1 (White, 2 Pin) | Behind trim, on tailgate. |
| G4 (Black, 2 Pin) | At rear of hardtop. |
| G5 (Black, 3 Pin) | Behind trim, on tailgate. |
| G6 (White, 6 Pin) | Behind trim, on tailgate. |
| G8 (Gray, 2 Pin) | Under right side of rear bumper. |
| H1 (White, 1 Pin) | In fuse/relay box, at right side of engine compartment. |
| H2 (Gray, 2 Pin) | At right side of engine compartment, on fuse/relay box. |
| H4 (Black, 16 Pin) | At left side of engine compartment, below brake fluid reservoir. |
| H5 (2.2L) (Green, 16 Pin) | At left side of engine compartment, below brake fluid reservoir. |
| H5 (3.2L) (Green, 16 Pin) | At left side of engine compartment. |
| H6 (Blue, 16 Pin) | At left side of engine compartment, below brake fluid reservoir. |
| H7 (White, 16 Pin) | At left side of engine compartment. |
| H8 (Blue, 16 Pin) | At lower right rear of engine compartment. |
| H11 (Gray, 6 Pin) | Behind right kick panel. |
| H12 (Blue, 20 Pin) | Below right side of dash, behind kick panel. |
| H13 (White, 19 Pin) | Below right side of dash, behind kick panel. |
| H14 (Black, 19 Pin) | Below right side of dash, behind kick panel. |
| H15 (Blue, 20 Pin) | Behind left kick panel. |
| H16 (Black, 22 Pin) | Behind left kick panel. |
| H17 (Black, 19 Pin) | Behind left kick panel. |
| H18 (White, 22 Pin) | Behind right kick panel. |
| H19 (White, 22 Pin) | Below right side of dash, behind kick panel. |
| H20 (White, 1 Pin) | Behind trim, at right side of rear roof panel. |
| H21 (White, 2 Pin) | Behind trim, at left side of rear roof panel. |
| H21 (Rodeo Sport) (White, 4 Pin) | At left rear of cargo compartment. |
| H22 (White, 8 Pin) | Behind trim, at lower left "D" pillar. |
| H24 (White, 10 Pin) | At left "B" pillar, behind trim. |
| H25 (W/ Intelligent Suspension System) (White, 10 Pin) | Below carpet, under driver's seat. |
| H25 (W/O Intelligent Suspension System) (White, 13 Pin) | Below carpet, under driver's seat. |
| H27 (Gray, 2 Pin) | Underneath left rear of vehicle. |
| H28 (W/ Keyless Security & Anti-Theft) (White, 22 Pin) | Above left kick panel, in door grommet. |
| H28 (W/O Keyless Security & Anti-Theft) (White, 4 Pin) | Above left kick panel, in door grommet. |
| H29 (White, 10 Pin) | Behind trim, on right "B" pillar. |
| H30 (Rodeo) (White, 6 Pin) | Behind left side of dash, above kick panel. |
| H31 (White, 22 Pin) | Behind left kick panel. |
| H32 (White, 16 Pin) | Behind left kick panel. |
| H33 (W/ Keyless Security & Anti-Theft) (White, 22 Pin) | Above right kick panel, in door grommet. |
| H33 (W/O Keyless Security & Anti-Theft) (4 Pin) | Above right kick panel, in door grommet. |
| H34 (Rodeo Sport W/ Hardtop) (White, 8 Pin) | Behind trim panel, at left rear of luggage compartment. |
| H34 (Rodeo) (White, 8 Pin) | Behind trim, on lower left "D" pillar. |
| H35 (White, 22 Pin) | Below carpet, under driver's seat. |
| H37 (White, 4 Pin) | Behind trim, on upper left "D" pillar. |
| H44 (Green, 16 Pin) | At lower right rear of engine. |
| I1 (Green, 30 Pin) | Behind left side of dash, on top of instrument cluster. |
| I2 (Green, 16 Pin) | Behind left side of dash, on top of instrument cluster. |
| I3 (White, 6 Pin) | Behind left side of dash, behind instrument cluster. |
| I9 (Green, 14 Pin) | Behind left side of dash, on top of instrument cluster. |
| I13 (Yellow, 2 Pin) | On connector bracket, behind left side of dash. |
| I25 (Yellow, 2 Pin) | Behind glove box. |
| I31 (White, 13 Pin) | Behind left side of dash, on connector bracket. |
| I32 (Black, 13 Pin) | Behind left side of dash, on connector bracket. |
| I33 (White, 8 Pin) | Behind center side of dash. |
| I40 (White, 6 Pin) | Below front of center console. |
| I46 (White, 8 Pin) | Behind left side of dash, on connector bracket. |
| J3 (White, 2 Pin) | Behind headliner, at center front of roof. |
| L1 (White, 2 Pin) | Behind headliner, at center front of roof. |
| L4 (Black, 2 Pin) | In headliner, behind fastener for left vanity mirror. |
| L6 (Black, 2 Pin) | In headliner, behind fastener for right vanity mirror. |
| M8 (1 Pin) | On top of transmission. |
| M9 (1 Pin) | On top of transmission. |
| M13 (Black, 4 Pin) | On transmission, at lower of left rear of engine. |
| M14 (Black, 4 Pin) | On bracket, at left underside of vehicle. |
| M16 (Black, 8 Pin) | At left side of transmission. |
| P2 | Right side of engine compartment, on fuse/relay box. |
| P11 | Right side of engine compartment, on fuse/relay box. |
| T10 | At right side of passenger's seat. |
CONNECTORS LOCATION
GROUNDS
| Component | Component Location |
|---|---|
| B6 | Below center console. |
| B8 | Below center console. |
| C16 | On inner fender panel, at left rear corner of engine compartment. |
| C36 | At right side of engine compartment, behind battery. |
| E28 (2.2L) | At right rear of engine. |
| E28 (3.2L) | At left side of intake manifold. |
| E29 (2.2L) | At left side of intake manifold. |
| E29 (3.2L) | At top left of engine. |
| E30 | At right side of intake manifold. |
| I43 | Above kick panel, below left side of dash. |
| P6 | At right side of engine compartment, behind battery. |
| P10 | At lower right front of engine. |
GROUNDS LOCATION