Repair manual
Hyundai Santa Fe II Repair Manual
Step-by-step repair and maintenance instructions for the Hyundai Santa Fe II (2005–2010): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
- GENERAL
- SRSCM (SRS CONTROL MODULE)
- SPECIFICATION
- TIGHTENING TORQUES
- SPECIAL SERVICE TOOLS
- GENERAL PRECAUTIONS
- AIRBAG HANDLING AND STORAGE
- WIRING PRECAUTIONS
- SPRING-LOADED LOCK CONNECTOR
- DISCONNECTING
- CONNECTING
- WARNING LAMP BEHAVIOR AFTER IGNITION ON
- SRSCM INDEPENDENT WARNING LAMP ACTIVATION
- TELLTALE LAMP ACTIVATION
- COMPONENT REPLACEMENT AFTER DEPLOYMENT
- DESCRIPTION
- INSTALLATION
- DRIVER AIRBAG (DAB)
- REMOVAL
- FRONT SIDE IMPACT SENSOR
- REAR SIDE IMPACT SENSOR
- TERMINAL & CONNECTOR INSPECTION
- PREPARATION OF INSPECTION
- CHECKING OF SHORT OR OPEN CIRCUIT
- CLEAR THE DTC AND CHECK THE VEHICLE AGAIN
- DIAGNOSTIC TROUBLE CODES (DTC)
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- INSPECTION PROCEDURE
- SPECIAL TOOL REQUIRED
- DEPLOYING AIRBAGS IN THE VEHICLE
- DRIVER'S AIRBAG
- FRONT PASSENGER'S AIRBAG
- SIDE AIRBAG
- CURTAIN AIRBAG
- DEPLOYING THE AIRBAG OUT OF THE VEHICLE
- DISPOSAL OF DAMAGED AIRBAG
- SPECIFICATIONS
- SPECIAL TOOLS
- CLUTCHES AND BRAKES FOR EACH RANGE
- FUNCTIONS OF CLUTCHES AND BRAKES
- AUTOMATIC TRANSAXLE HYDRAULIC CIRCUIT
- INSPECTION CHART FOR DIAGNOSIS TROUBLE CODES (DTC)
- INSPECTION
- REPLACEMENT
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- TERMINAL & CONNECTOR INSPECTION
- VERIFICATION OF VEHICLE REPAIR
- COMPONENT LOCATION
- MONITOR SCANTOOL DATA
- COMPONENT INSPECTION
- SPECIFICATION
- SIGNAL CIRCUIT INSPECTION
- OPERATING ELEMENT OF EACH SHIFTING RANGE
- POWER SUPPLY CIRCUIT INSPECTION
- GROUND CIRCUIT INSPECTION
- REMOVAL
- INSTALLATION
- DESCRIPTION
- SPECIFICATION
- TIGHTENING TORQUE
- LUBRICANT
- SEALANT
- SPECIAL TOOLS
- DESCRIPTION
- CHARACTERISTICS
- OPERATION COMPONENTS AND FUNCTION
- OPERATING ELEMENTS
- TORQUE CONVERTER AND SHAFT
- CLUTCHES
- UNDERDRIVE CLUTCH
- REVERSE CLUTCH AND OVERDRIVE CLUTCH
- BRAKES
- LOW & REVERSE BRAKE AND SECOND BRAKE
- OWC
- ACCUMULATORS
- OBJECTIVE
- TRANSFER DRIVE GEAR
- OUTPUT SHAFT/TRANSFER DRIVEN GEAR
- MANUAL CONTROL LEVER
- PARKING MECHANISM
- P POSITION
- N POSITION
- 1ST GEAR POWER FLOW
- 2ND GEAR POWER FLOW
- 3RD GEAR POWER FLOW
- 4TH GEAR POWER FLOW
- REVERSE GEAR POWER FLOW
- VRS Function
- HYDRAULIC PRESSURE TABLE
- ELECTRIC CONTROL LOCATION
- OPERATING COMPONENTS AND FUNCTIONS
- SIGNALS OF SPORTS MODE SWITCH
- CONTROLLER AREA NETWORK (CAN)
- REPLACEMENT
- INSPECTION CHART FOR TROUBLE SYMPTOMS
- DTC TROUBLESHOOTING INDEX
- FAILSAFE
- FAILSAFE ACCORDING TO THE DTC
- SERVICE DATA LIST (WITH SCAN TOOL)
- HIVEC - SAT (SIEMENS ADAPTIVE TRANSMISSION CONTROL) MODE (SHIFT PATTERN)
- ACTUATOR INSPECTION
- ROAD TEST
- TORQUE CONVERTER STALL TEST
- STANDARD HYDRAULIC PRESSURE TEST
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- TERMINAL & CONNECTOR INSPECTION
- VERIFICATION OF VEHICLE REPAIR
- COMPONENT LOCATION
- SIGNAL WAVEFORM
- MONITOR SCANTOOL DATA
- POWER SUPPLY CIRCUIT INSPECTION
- COMPONENT INSPECTION
- SIGNAL CIRCUIT INSPECTION
- GROUND CIRCUIT INSPECTION
- REMOVAL
- INSTALLATION
- SOLENOID VALVES SCHEDULE
- Solenoid Valve for Pressure Control
- VFS CONTROL PRESSURE
- INSPECTION
- OUTPUT SHAFT SPEED SENSOR
- OIL TEMPERATURE SENSOR
- SPECIFICATION
- TIGHTENING TORQUE
- COMPRESSION PRESSURE
- VALVE CLEARANCE INSPECTION AND ADJUSTMENT
- TROUBLESHOOTING
- SPECIAL TOOLS
- REMOVAL
- INSTALLATION
- Sprockets, Chain Tensioner, Chain Guide, Chain Tensioner Arm
- BELT, IDLER, BELT TENSIONER, PULLEY
- DISASSEMBLY
- MLA
- REASSEMBLY
- DESCRIPTION
- CONNECTING RODS
- ENGINE COOLANT REFILLING AND BLEEDING
- THERMOSTAT
- WATER PUMP
- WATER TEMPERATURE CONTROL ASSEMBLY
- OIL AND FILTER
- ENGINE OIL
- SELECTION OF ENGINE OIL
- SPECIFICATIONS
- TIGHTENING TORQUE
- COMPRESSION PRESSURE INSPECTION
- VALVE CLEARANCE INSPECTION AND ADJUSTMENT
- TROUBLESHOOTING
- SPECIAL TOOLS
- DESCRIPTION
- CYLINDER BORING
- REASSEMBLY
- INSTALLATION
- ENGINE COOLANT REFILLING AND BLEEDING
- THERMOSTAT
- WATER PUMP
- WATER TEMPERATURE CONTROL ASSEMBLY
- RADIATOR
- INSPECTION
- SELECTION OF ENGINE OIL
- RELIEF SPRING
- OIL AND FILTER
- EXHAUST MANIFOLD ASSEMBLY
- REMOVAL
- DISASSEMBLY
- MLA (MECHANICAL LASH ADJUSTER)
- TIMING BELT
- DESCRIPTION OF ESC
- DESCRIPTION OF ESC CONTROL
- VARIANT CODING
- ABS WARNING LAMP MODULE
- EBD/PARKING BRAKE WARNING LAMP MODULE
- ESC WARNING LAMP (ESC SYSTEM)
- ESC FUNCTION LAMP (ESC SYSTEM)
- ESC ON/OFF SWITCH (ESC SYSTEM)
- FAILURE DIAGNOSIS
- MEMORY OF FAIL CODE
- FAILURE CHECKUP
- COUNTERMEASURES IN FAIL
- WARNING LAMP ON
- NOTES WITH REGARD TO DIAGNOSIS
- PROBLEM SYMPTOMS TABLE
- DETECTING CONDITION
- DTC INSPECTION
- CHECK THE WHEEL SPEED SENSOR CIRCUIT
- CHECK THE HYDRAULIC CIRCUIT FOR LEAKAGE
- CHECK THE POWER SUPPLY CIRCUIT FOR THE DIAGNOSIS
- CHECK THE GROUND CIRCUIT FOR THE DIAGNOSIS
- CHECK FOR CONTINUITY IN THE DIAGNOSIS LINE
- CHECK THE POWER SOURCE OF ESC CONTROL MODULE
- CHECK FOR POOR GROUND
- PROBLEM VERIFICATION
- CHECK FOR BLOWN FUSE
- CHECK DTC OUTPUT.
- CHECK INSTRUMENT CLUSTER
- CHECK FOR OPEN IN THE WIRE
- BLEEDING BRAKE SYSTEM
- DIAGNOSTIC TROUBLE CODE CHART (DTC)
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- TERMINAL & CONNECTOR INSPECTION
- VERIFICATION OF VEHICLE REPAIR
- COMPONENT LOCATION
- ALTERNATOR OUTPUT VOLTAGE INSPECTION
- GROUND CIRCUIT INSPECTION
- COMPONENT INSPECTION
- MONITOR SCANTOOL DATA
- TERMINAL AND CONNECTOR INSPECTION
- INSTALLATION
- INSPECTION
- DESCRIPTION
- GENERAL DATA
- MEASURING PRINCIPLE
- SPECIFICATION
- HOOD ASSEMBLY REPLACEMENT
- TAILGATE TRIM REPLACEMENT
- TAILGATE WEATHERSTRIP REPLACEMENT
- FRONT DOOR TRIM REPLACEMENT
- POWER WINDOW SWITCH REPLACEMENT
- GLASS ADJUSTMENT
- DOOR POSITION ADJUSTMENT
- DOOR STRIKER ADJUSTMENT
- REAR DOOR TRIM REPLACEMENT
- GLASS REPLACEMENT
- ROOF RACK REPLACEMENT
- MUD GUARD AND WHEEL GUARD REPLACEMENT
- SIDE GARNISH AND SIDE SILL REPLACEMENT
- WHEN TO INITIALIZE THE MOTOR
- OUTSIDE REAR VIEW MIRROR REPLACEMENT
- AIR CONDITIONER
- BLOWER UNIT
- HEATER AND EVAPORATOR UNIT
- PROBLEM SYMPTOMS TABLE
- SPECIAL TOOLS
- FLANGE WITH GUIDE PIN
- HANDLING TUBING AND FITTINGS
- THE FOLLOWING PRECAUTIONS MUST BE OBSERVED
- REFRIGERANT RECOVERY
- SYSTEM EVACUATION
- SYSTEM CHARGING
- REFRIGERANT LEAK TEST
- OIL SPECIFICATION
- HANDLING OF OIL
- COMPRESSOR OIL CHECK
- OIL RETURN OPERATION
- INSPECTION
- DESCRIPTION
- REPLACEMENT
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- SPECIFICATION
- TERMINAL AND CONNECTOR INSPECTION
- VERIFICATION OF VEHICLE REPAIR
- COMPONENT INSPECTION
- SIGNAL CIRCUIT INSPECTION
- MONITOR SCANTOOL DATA
- VISUAL/PHYSICAL INSPECTION
- DESCRIPTION
- SMARTRA UNIT (B)x
- TRANSPONDER (BUILT-IN KEYS)
- ANTENNA COIL
- PROBLEMS AND REPLACEMENT PARTS
- REPLACEMENT OF ECM AND SMARTRA
- NEUTRALIZING OF ECM
- DIAGNOSIS OF IMMOBILIZER FAULTS
- IMMOBILIZER (SMARTRA) DTC LIST
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- MONITOR DTC STATUS
- VERIFICATION OF VEHICLE REPAIR
- SCHEMATIC DIAGRAM
- COMPONENT LOCATION
- COMPONENT INSPECTION
- TERMINAL AND CONNECTOR INSPECTION
- VISUAL / PHYSICAL INSPECTION
- General information
- FLOOR CONSOLE REPLACEMENT
- CLUSTER REPLACEMENT
- CENTER FASCIA PANEL REPLACEMENT
- COVER REPLACEMENT
- CRASH PAD REPLACEMENT
- SUNVISOR REPLACEMENT
- OVERHEAD CONSOLE LAMP REPLACEMENT
- ROOM LAMP AND REPLACEMENT
- ASSIST HANDLE REPLACEMENT
- HEADLINER REPLACEMENT
- FRONT DOOR AND REAR DOOR SCUFF TRIM REPLACEMENT
- FRONT PILLAR TRIM REPLACEMENT
- COWL SIDE TRIM REPLACEMENT
- CENTER LOWER AND UPPER PILLAR TRIM REPLACEMENT
- REAR PILLAR TRIM REPLACEMENT
- LUGGAGE SIDE TRIM REPLACEMENT
- REMOVAL
- SPECIFICATION
- TIGHTENING TORQUE
- SERVICE STANDARD
- LUBRICANTS
- SPECIAL TOOLS
- TRANSMISSION OIL INSPECTION AND REPLACEMENT
- REMOVAL
- INSTALLATION
- INSPECTION
- POWER FLOW MECHANISM
- CONTROL ALGORITHM FLOW CHART
- DTC TROUBLESHOOTING
- GENERAL DESCRIPTION
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- TERMINAL AND CONNECTOR INSPECTION
- VERIFICATION OF VEHICLE REPAIR
- COMPONENT LOCATION
- SIGNAL WAVEFORM & DATA
- STEERING ANGLE SENSOR REFERENCE VOLTAGE INSPECTION
- STEERING ANGLE SENSOR GROUND HARNESS OPEN CIRCUIT INSPECTION
- CAN SIGNAL INSPECTION
- CAN COMM. LINE INSPECTION
- SIGNAL CIRCUIT INSPECTION
- WAVEFORM INSPECTION
- CHECK FOR TRANSFER OIL
- TRANSFER OIL REPLACEMENT
- REASSEMBLY
- General information
- SYSTEM FAULT
- SENSOR REMOVAL
- SENSOR FIT
- TIRE FIT
- OPERATION
- REPLACEMENT
- TROUBLESHOOTING
- TREAD WARNINGS
- DTC'S
- DTC DESCRIPTION
- DTC DETECTING CONDITION
- VERIFICATION OF VEHICLE REPAIR
- TPMS RECEIVER
- TERMINAL AND CONNECTOR INSPECTION
- COMPONENT LOCATION
- GENERAL DESCRIPTION
- MONITOR SCANTOOL DATA
- CHARGING SYSTEM INSPECTION
- COMPONENT INSPECTION
- LOW FREQUENCY INITIATOR
- SIGNAL CIRCUIT INSPECTION
- CONTROL CIRCUIT INSPECTION