Repair manual
Wiring diagrams
Honda Pilot I Repair Manual
Step-by-step repair and maintenance instructions for the Honda Pilot I (2004–2009): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
80sections
695articles
ENManual language
- GA-Net Bus Configuration
- Audio Glossary
- Audio Unit Connector for Inputs and Outputs
- XM Receiver Connector for Inputs and Outputs (With XM)
- Serial Number Display Mode
- Error Codes
- Poor Am Or Fm Radio Reception Or Interference
- Power Switch Will Not Turn ON (No Information Display And No Sound)
- Radio Stays Powered With The Ignition Switch OFF
- No Sound Is Heard From Speaker(s) (Display Is Normal)
- Audio Unit Button Illumination Does Not Work
- Radio Preset Memory Is Lost
- Poor Or No Sound With XM Radio (Audio Unit Can Display XM Channels)
- XM Radio Display Is Blank And No Station Information Is Displayed
- Error Code: XM NO SIGNAL or XM ANTENNA Is Displayed
- XM Radio Preset Memory Is Lost
- Audio Disc Does Not Eject
- Audio Disc Changer Does Not Load All Six Discs
- Audio Disc Changer Does Not Move Between Discs
- Volume Does Not Change
- Radio Tuner Does Not Change Stations
- Audio Disc Does Not Load
- Audio Disc Does Not Play
- Audio Disc Skips
- Audio Remote Switch Does Not Work Properly
- Booming Sound While Driving With Audio Unit On or Off
- Left/Right Channel ID
- Frequency Sweep
- Sound Judging
- With Navigation System
- Without Navigation System (Except LX Model)
- Without Navigation System (LX Model)
- 2WD
- Except LX model
- AM/FM Antenna Repair
- Engine Electrical
- Battery
- Relays 2
- Under Dash Fuse/relays
- Relay and Control Unit Locations
- Body Electrical (General Troubleshooting) 3
- Connectors and Harnesses 2
- Fuse/relay Boxes
- Power Distribution (Fuse ID)
- Ground Distribution
- Accessory Power Sockets
- AC Power Outlet
- Underhood Fuse/relay Box
- Battery Cable Reset
- Crankshaft Pulley Removal and Installation
- Timing Belt Installation
- Timing Belt Replacement
- Camshaft Replacement
- Valve, Spring, and Valve Seal Removal
- Valve Guide Replacement
- Valve, Spring, and Valve Seal Installation
- Camshaft Oil Seal Installation - In Car
- Sealing Bolt Installation
- Rocker Arm Assembly Removal
- Camshaft, Rocker Arm, Camshaft Seal, and Pulley Installation
- Diagnostic Trouble Code (DTC)
- Self-diagnosis
- How to Troubleshoot Circuits at the VTM-4 Control Unit
- How to End a Troubleshooting Session (required after any troubleshooting)
- DTC Troubleshooting Index
- Symptom Troubleshooting Index
- DTC 21-1, 21-2, 22-1, 22-2: Front Wheel Sensors
- DTC 23-1,23-2,24-1,24-2: Rear Wheel Sensors
- DTC 26-1: VSA Modulator-Control Unit or Wire Harness
- DTC 37-1,38-1: Engine RPM Signal Circuit
- DTC 41-1,41-2: CAN Communication (PCM/VSA System)
- DTC 44-1: VTM-4 Relay
- DTC 51-1,52-1,53-1,53-2,54-1: Left Clutch Electromagnetic Coil
- DTC 53-2, 55-1, 56-1, 57-1,58-1: Right Clutch Electromagnetic Coil
- DTC 59-1: Right/Left Clutch Electromagnetic Coil Power Supply
- DTC 73-1: MAP (Manifold Absolute Pressure) Sensor or PCM
- DTC 77-1: PCM
- DTC 78-1: VTM-4 Control Unit
- Backlash Inspection
- Front Door Panel Removal/Installation
- Front Door Outer Handle Replacement
- Front Door Latch Replacement
- Front Door Glass and Regulator Replacement
- Front Door Sash Trim Replacement
- Front Door Glass Outer Weatherstrip Replacement
- Front Door Glass Inner Weatherstrip Replacement
- Front Door Weatherstrip Replacement
- Front Door Upper Seal Replacement
- Front Door Side Sill Seal Replacement
- Rear Door Panel Removal/Installation
- Rear Door Outer Handle Replacement
- Rear Door Latch Replacement
- Rear Door Glass, Quarter Glass, and Regulator Replacement
- Rear Door Sash Trim Replacement
- Rear Door Glass Outer Weatherstrip Replacement
- Rear Door Glass Inner Weatherstrip Replacement
- Rear Door Weatherstrip Replacement
- Rear Door Upper Seal Replacement
- Rear Door Side Sill Seal Replacement
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- Diagnostic Trouble Code Definitions - General Information
- How to Retrieve a Diagnostic Trouble Codes
- Symptom Troubleshooting Index
- Diagnostic Trouble Codes Troubleshooting
- Radiator and A/C Condenser Fan Low Speed Circuit Troubleshooting
- A/C Condenser Fan High Speed Circuit Troubleshooting
- Radiator and A/C Condenser Fan High Speed Circuit Troubleshooting
- A/C Compressor Clutch Circuit Troubleshooting
- A/C Pressure Switch Circuit Troubleshooting
- Refrigerant Leak Test
- Performance Test
- Front Seat Removal/Installation
- Front Seat Torsion Bar Replacement - Manual Height Adjustable
- Front Seat Cover Replacement
- Second Row Seat Removal/Installation
- Second Row Seat-Back Recline Lever Replacement
- Second Row Seat-Back Recline Cable Replacement
- Third Row Seat Access Cable Replacement
- Second Row Seat Beverage Holder/Tray Replacement
- Second Row Seat Cover Replacement
- Third Row Seat Removal/Installation
- Third Row Seat Recline Adjuster Replacement
- Right Third Row Seat Pivot Replacement
- Third Row Seat-Back Recline Lever Replacement
- Third Row Seat-Back Recline Cable Replacement
- Third Row Seat Cover Replacement
- General Precautions
- Airbag Handling and Storage
- Spring-loaded Lock Connector
- Disconnecting
- Connecting
- Backprobing Spring-loaded Lock Connectors
- Seats with Side Airbags
- Disconnecting System Connectors
- Checking the Front Passenger's Weight Sensors after a Vehicle Collision
- ODS Unit Initialization
- After Replacing Front Passenger's Seat Component(s)
- Airbags
- Front Passenger's Weight Sensors
- Driver's Seat Position Sensor
- Roll Rate Sensor
- Rear Safing Sensor
- Passenger Airbag Cutoff Indicator
- Seat Belt Tensioners
- Driver's and Front Passenger's Airbag(s)
- Side Airbag(s)
- Side Curtain Airbag(s)
- Self-Diagnostic System
- SRS indicator stays on, but no DTCs are stored
- Checking and Adjusting the Headliner/Pillar Trim Overlap
- Airbag and Tensioner Disposal
- Deploying Airbags in the Vehicle
- Deploying Components Out of the Vehicle
- Disposal of Damaged Components
- Deployment Tool Check
- Opening the SRS Unit Shorting Connectors For Diagnosis
- DTC (Diagnostic Trouble Codes)
- Clear the DTC Memory with the HDS
- Clear the DTC Memory Using MES Connector without the HDS
- Troubleshooting Intermittent Failures
- DTC Troubleshooting Index
- Symptom Troubleshooting Index
- DTC 11-1x ("x" can be 0 thru 9 or A thru F): Open in Driver's Airbag First Inflator; DTC 11-4x ("x" can be 0 thru 9 or A thru F): Open in Driver's Airbag Second Inflator
- DTC 11-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Driver's Airbag First Inflator; DTC 11-6x ("x" can be 0 thru 9 or A thru F): Short to
- DTC 11-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Driver's Airbag First Inflator; DTC 11-Ax ("x" can be 0 thru 9 or A thru F): Short to Power in Driver's Airbag Second
- DTC 11-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Driver's Airbag First Inflator; DTC 11-Bx ("x" can be 0 thru 9 or A thru F): Short to Ground in Driver's Airbag Seco
- DTC 12-1x ("x" can be 0 thru 9 or A thru F): Open in Front Passenger's Airbag First Inflator; DTC 12-4x ("x" can be 0 thru 9 or A thru F): Open in Front Passenger's Airbag Second I
- DTC 12-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Front Passenger's Airbag First Inflator; DTC 12-6x ("x" can be 0 thru 9 or A thru F):
- DTC 12-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Front Passenger's Airbag First Inflator; DTC 12-Ax ("x" can be 0 thru 9 or A thru F): Short to Power in Front Passeng
- DTC 12-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Front Passenger's Airbag First Inflator; DTC 12-Bx ("x" can be 0 thru 9 or A thru F): Short to Ground in Front Passe
- DTC 21-1x ("x" can be 0 thru 9 or A thru F): Open in Driver's Seat Belt Tensioner
- DTC 21-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Driver's Seat Belt Tensioner
- DTC 21-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Driver's Seat Belt Tensioner
- DTC 21-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Driver's Seat Belt Tensioner
- DTC 22-1x ("x" can be 0 thru 9 or A thru F): Open in Front Passenger's Seat Belt Tensioner
- DTC 22-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Front Passenger's Seat Belt Tensioner
- DTC 22-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Front Passenger's Seat Belt Tensioner
- DTC 22-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Front Passenger's Seat Belt Tensioner
- DTC 31-1x ("x" can be 0 thru 9 or A thru F): Open in Driver's Side Airbag Inflator
- DTC 31-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Driver's Side Airbag Inflator
- DTC 31-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Driver's Side Airbag Inflator
- DTC 31-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Driver's Side Airbag Inflator
- DTC 32-1x ("x" can be 0 thru 9 or A thru F): Open in Front Passenger's Side Airbag Inflator
- DTC 32-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Front Passenger's Side Airbag Inflator
- DTC 32-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Front Passenger's Side Airbag Inflator
- DTC 32-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Front Passenger's Side Airbag Inflator
- DTC 33-1x ("x" can be 0 thru 9 or A thru F): Open in Left Side Curtain Airbag Inflator
- DTC 33-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Left Side Curtain Airbag Inflator
- DTC 33-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Left Side Curtain Airbag First Inflator
- DTC 33-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Left Side Curtain Airbag First Inflator
- DTC 34-1x ("x" can be 0 thru 9 or A thru F): Open in Right Side Curtain Airbag First Inflator
- DTC 34-3x ("x" can be 0 thru 9 or A thru F): Short to Another Wire or Decreased Resistance in Right Side Curtain Airbag First Inflator
- DTC 34-8x ("x" can be 0 thru 9 or A thru F): Short to Power in Right Side Curtain Airbag First Inflator
- DTC 34-9x ("x" can be 0 thru 9 or A thru F): Short to Ground in Right Side Curtain Airbag First Inflator
- DTC 41-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Left Front Impact Sensor
- DTC 42-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Right Front Impact Sensor
- DTC 41-2x, 41-3x, 41-Bx ("x" can be 0 thru 9 or A thru F): Internal Failure of the Left Front Impact Sensor DTC 42-2x, 42-3x, 42-Bx ("x" can be 0 thru 9 or A thru F): Internal Fail
- DTC 43-2x, 43-3x, 43-Bx ("x" can be 0 thru 9 or A thru F): Internal Failure of the Left Side Impact Sensor (first); DTC 44-2x, 44-3x, 44-Bx ("x" can be 0 thru 9 or A thru F): Inter
- DTC 43-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Left Side Impact Sensor (first)
- DTC 44-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Right Side Impact Sensor (first)
- DTC 45-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Left Side Impact Sensor (second)
- DTC 46-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Right Side Impact Sensor (second)
- DTC 45-2x, 45-3x, 45-Bx ("x" can be 0 thru 9 or A thru F): Internal Failure of the Left Side Impact Sensor (second); DTC 46-2x, 46-3x, 46-Bx ("x" can be 0 thru 9 or A thru F): Inte
- DTC 51-xx, 52-xx, 53-xx, 54-xx, 55-xx, 56-xx ("x" can be 0 thru 9 or A thru F): Internal Failure of the SRS Unit
- DTC 61-1x ("x" can be 0 thru 9 or A thru F): Open in Driver's Seat Belt Buckle Switch
- DTC 61-2x ("x" can be 0 thru 9 or A thru F): Short in Driver's Seat Belt Buckle Switch
- DTC 62-1x ("x" can be 0 thru 9 or A thru F): Open in Front Passenger's Seat Belt Buckle Switch
- DTC 62-2x ("x" can be 0 thru 9 or A thru F): Short in Front Passenger's Seat Belt Buckle Switch
- DTC 71-1x ("x" can be 0 thru 9 or A thru F): Open in Driver's Seat Position Sensor
- DTC 71-2x ("x" can be 0 thru 9 or A thru F): Short in Driver's Seat Position Sensor
- DTC 81-61,85-61: No Signal from the ODS Unit; DTC 81-62,85-62: Response Data Error from the ODS unit
- DTC 81-4x, 81-5x, 81-63,81-64,85-4x, 85-5x, 85-63,85-64 ("x" can be 0 thru 9 or A thru F): Internal Failure of the ODS Unit
- DTC 81-79: Front Passenger's Weight Sensors Initial Check Failure
- DTC 85-79: OPDS Sensor Initial Check Failure
- DTC 82-1x ("x" can be 0 thru 9 or A thru F): No Signal from the Inner Side Front Passenger's Weight Sensor; DTC 83-2x ("x" can be 0 thru 9 or A thru F): No Signal from the Outer Si
- DTC 86-1x, 86-2x ("x" can be 0 thru 9 or A thru F): Faulty OPDS Sensor
- DTC 87-3 ("x" can be 0 thru 9 or A thru F): Side Airbag Cutoff Indicator Stays On/Off
- DTC 91-1x ("x" can be 0 thru 9 or A thru F): Short to Ground in the SRS Indicator Circuit
- DTC 92-1x ("x" can be 0 thru 9 or A thru F): Open in the Front Passenger's Airbag Cutoff Indicator
- DTC 92-2x ("x" can be 0 thru 9 or A thru F): Open or Short to Ground in the Passenger's Airbag Cutoff Indicator
- DTC A1-1x ("x" can be 0 thru 9 or A thru F): Faulty Power Supply (VA line)
- DTC A2-1x ("x" can be 0 thru 9 or A thru F): Faulty Power Supply (VB line)
- DTC B1-11: No Signal from the Roll Rate Sensor
- DTC B1-17, B1-8x, B1-9x, B1-Ax, B1-Bx ("x" can be 0 thru 9 or A thru F): Internal Failure of the Roll Rate Sensor
- DTC B2-11: No Signal from the Rear Safing Sensor
- DTC B2-17, B2-84, B2-90, B2-Ax, B2-Bx ("x" can be 0 thru 9 or A thru F): Internal Failure of the Rear Safing Sensor
- Component Replacement/Inspection After Deployment