GMC Vandura G3500 (1985-1996) headlights system Wiring diagrams

1995 VFTC AIR BAG IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (NEAR MASTER CYLINDER) BRN WIRE BRN/WHT WIRE COOLANT TEMP GAUGE CRUISE CONTROL SYSTEM DAYTIME RUNNING LIGHTS IND DAYTIME RUNNING LIGHTS RELAY (LEFT SIDE OF I/P) DIAGNOSTIC ENERGY RESERVE MODULE (LEFT SIDE OF I/P) DIESEL DIESEL ONLY DIODE ARRAY MODULE (BEHIND LEFT SIDE OF I/P, IN HARNESS) DK BLU WIRE DK GRN WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT LEVEL INDICATOR MODULE (LEFT SIDE OF I/P) ENGINE COOLANT LEVEL SENSOR (RIGHT REAR OF RADIATOR) ENGINE COOLANT TEMPERATURE SENDER (REAR OF ENGINE) FASTEN BELTS IND. FUEL GAUGE FUEL PUMP AND SENDER (TOP OF FUEL TANK) GASOLINE ONLY FUEL PUMP OIL PRESSURE SWITCH (TOP REAR OF ENGINE) FUEL TANK SENDER (TOP OF FUEL TANK) FUSE BLOCK GASOLINE GAUGES FUSE BRK FUSE GRY WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM (DRL SYSTEM) HOT IN START OR RUN HOT IN RUN ILLUM. LAMPS INSTRUMENT CLUSTER LEFT TURN IND LOW COOLANT IND. (DIESEL) LT BLU WIRE LT BLU/BLK WIRE LT GRN (OR WHT) WIRE LT GRN WIRE LT GRN/BLK WIRE MAL- FUNCTION IND NCA WIRE OIL PRESS GAUGE OIL PRESSURE SENDER (TOP FRONT OF ENGINE) PARK BRAKE WARNING SWITCH (PARK BRAKE) BRACKET) PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF I/P) PPL PPL PNK WIRE PPL/WHT WIRE PRESSURE MODULATOR VALVE (RIGHT SIDE FRAME RAIL) RIGHT TURN IND. HI BEAM IND. SPEED- OMETER TAN WIRE TAN/WHT WIRE VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VOLT- METER W/ DRL W/O DRL WARNING SYSTEMS WHT TAN/ WIRE WHT WIRE YEL WIRE YEL/BLK WIRE

AIR BAG IND ANTI-LOCK BRAKES SYSTEM ENGINE CONTROLS SYSTEM ANTI-LOCK BRAKES WARNING IND BAT IND BLK WIRE BLK/WHT WIRE BRAKE IND IN PARK BRAKE IN BRAKE PRESSURE DIFFERENTIAL SWITCH (PART OF ELECTRONIC BRAKE CONTROL MODULE) BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CHECK GAUGES IND CHECK GAUGES LAMP DRIVER DIESEL ONLY EXTERIOR LIGHTS SYSTEM DIODE DIODE-I DK BLU WIRE DK GRN WIRE DRL LAMP IND (W/ DRL) FUEL GAUGE GAUGES FUSE 4 GRY WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT IN RUN OR START I/P FUSE BLOCK (BEHIND LEFT SIDE OF I/P) IGNITION SWITCH ILLUMIN- ATION LAMPS INSTRUMENT CLUSTER LEFT TURN IND LOCK LOW COOLANT IND. (DIESEL) LOW ENGINE COOLANT LEVEL INDICATOR MODULE (DIESEL ONLY) (LEFT SIDE OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE OFF OIL PRESS GAUGE PARK/NEUTRAL POSITION, BACKUP LAMP SWITCH (LEFT SIDE OF TRANSMISSION) PNK 1 2 3 WIRE PNK IGN FEED IND CTRL GND WIRE PNK WIRE PPL PPL/WHT WIRE PRNDL CIRCUIT BOARD RIGHT TURN IND RUN WIRE SAFETY BELT IND SERVICE ENGINE SOON IND SERVICE THROTTLE SOON IND (DIESEL) SOLID STATE SPEEDOMETER/ ODOMETER STARTING/CHARGING SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM TAN WIRE TAN/WHT WIRE TEMP GAUGE UNDERHOOD FUSE-RELAY CENTER (LEFT FENDER) UNDERHOOD FUSE-RELAY CENTER (LEFT FENDER) ENG-I MINI FUSE VOLT- METER W/ DRL W/ DRL ONLY W/O DRL W/O DRL W/ DRL WAIT IND (DIESEL) WARNING SYSTEM ENGINE CONTROLS SYSTEM DIESEL ONLY WATER IN FUEL IND. (DIESEL) WATER-IN-FUEL SENSOR (DIESEL ONLY) (REAR OF INTAKE MANIFOLD) WHT (OR LT GRN) WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 4.3L, 7.4L ONLY 5.7L, 6.5L ONLY ACCY ALT FUSE AUTO APPLY PARK BRAKE BLK WIRE BLK/ORG WIRE BRAKE PRESSURE WARNING SWITCH (REAR OF ENGINE COMPT) BRN/WHT WIRE BULB TEST COOLANT TEMP GAUGE DAYTIME RUNNING LAMPS MODULE DAYTIME RUNNING LIGHTS IND DIESEL DIESEL ONLY DK BLU (OR BRN) WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/BLK WIRE ECM-CRNK FUSE ENGINE CONTROLS OR TRANSMISSIONS SYSTEM ENGINE COOLANT LEVEL INDICATOR MODULE ENGINE COOLANT LEVEL INDICATOR PROBE (IN RADIATOR) (FRONT OF ENGINE) ENGINE COOLANT TEMPERATURE SENDER (LEFT SIDE OF ENGINE) FASTEN BELTS IND. FUEL GAUGE FUEL PUMP, SENDER (IN FUEL TANK) FUEL PUMP/ OIL PRESSURE SWITCH, SENDER (LEFT SIDE OF ENGINE) FUSE BLOCK FUSIBLE LINK GAUGES FUSE GLOW PLUG CONTROLLER (REAR OF ENGINE) GLOW PLUGS IND. (DIESEL) GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN HOT IN RUN, BULB TEST OR START I/P GROUND (IN I/P HARNESS) IGNITION SWITCH ILLUM. LAMPS INSTRUMENT CLUSTER LEFT TURN IND LOW COOLANT IND. (DIESEL) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MAL- FUNCTION IND OFF OIL PRESS GAUGE ORG/ WIRE PARK BRAKE IND PARK BRAKE WARNING SWITCH (PARK BRAKE SUPPORT BRACKET) PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) RIGHT FRAME RAIL) RIGHT TURN IND RUN WIRE SERVICE BRAKES IND. SERVICE TRANS- MISSION IND. SPEED- OMETER TAN WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND RIGHT SIDE OF I/P) VOLT- METER W/ DRL W/ DRL LOCK W/O DRL WARNING SYSTEMS WATER IN FUEL IND. (DIESEL) WATER-IN-FUEL SENSOR (DIESEL ONLY) (REAR OF ENGINE) WHT WIRE YEL WIRE YEL/BLK WIRE

0.5 WATT) 1995 VFTC BLK WIRE BLK/YEL WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (ON LEFT FRAME RAIL) IGNITION SWITCH BRAKE WARNING ALARM BUZZER (BEHIND LEFT SIDE OF I/P, NEAR FUSE BLOCK) BRN WIRE BRN/WHT WIRE COOLANT TEMP GAUGE CRUISE CONTROL SYSTEM DAYTIME RUNNING LAMPS IND DAYTIME RUNNING LAMPS MODULE (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) DAYTIME RUNNING LAMPS RELAY (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC DELAY MODULE (BEHIND LEFT SIDE OF I/P, ON PARK BRAKE SUPPORT BRACKET) ENGINE CONTROLS SYSTEM FLOW SWITCH (NEAR POWER STEERING PUMP) FUEL GAUGE FUSE BLOCK GAGES FUSE GRY WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START HYDRO-BOOST PRESSURE WARNING SWITCH (NEAR MASTER CYLINDER) ILLUM LAMP ILLUM. LAMPS IN-LINE DIODE (BEHIND LEFT SIDE OF I/P, ABOVE FUSE BLOCK) IN-LINE DIODE (BEHIND LEFT SIDE OF I/P, ABOVE STEERING COLUMN) INSTRUMENT CLUSTER LEFT TURN IND LOW COOLANT IND LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAL- FUNCTION IND OIL PRESS GAUGE PARK BRAKE WARNING SWITCH PNK PNK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (UNDER DRIVER'S SEAT) PPL RESISTOR RIGHT TURN IND SAFETY BELT IND SPEED- OMETER TAN WIRE TAN/WHT WIRE VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (BEHIND LEFT SIDE OF I/P) VOLT- METER W/ DRL W/ DRL PPL PPL W/O DRL WARNING SYSTEMS WHT WIRE YEL WIRE

1995 VFTC ACCY ALT FUSE AUDIO ALARM MODULE CONVENIENCE CENTER BLK WIRE BRAKE IND BRAKE PRESSURE WARNING SWITCH (NEAR MASTER CYLINDER) BRAKE WARNING ALARM BUZZER MODULE (BRAKE WARNING HARNESS) BRN WIRE BRN/WHT WIRE BULB TEST COOLANT TEMP GAUGE DAYTIME RUNNING LAMPS MODULE (TOP RIGHT SIDE OF SHIPPING HARNESS) DAYTIME RUNNING LAMPS RELAY DAYTIME RUNNING LIGHTS IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/YEL WIRE ELECTRONIC DELAY MODULE (BRAKE WARNING HARNESS) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENDER (LEFT FRONT OF ENGINE) FLOW SWITCH (BRAKE BOOSTER) FUEL GAUGE FUEL PUMP OIL PRESSURE SWITCH, SENDER (TOP REAR OF ENGINE) FUEL PUMP, SENDER (IN FUEL TANK) FUSE BLOCK GAUGES FUSE GRY WIRE HEAD- LIGHTS SYSTEM HEADLIGHTS SYSTEM HI-BEAM IND HOT IN RUN OR START HOT IN RUN, BULB TEST OR START HYDRO-BOOST PRESSURE WARNING SWITCH (BRAKE WARNING HARNESS) I/P GROUND (AT LEFT SHIPPING PANEL) IGNITION SWITCH ILLUM. LAMPS INSTRUMENT CLUSTER LEFT TURN IND LOCK OFF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MAL- FUNCTION IND NCA WIRE OIL PRESS GAUGE PARK BRAKE IND PARK BRAKE WARNING SWITCH (PARK BRAKE PEDAL BRACKET) PNK PPL WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF I/P, BEHIND SHIPPING PANEL) PPL RESISTOR RIGHT TURN IND. SAFETY BELT IND. RUN WIRE SHUNT SPEED- OMETER TAN WIRE TAN/WHT WIRE VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (LEFT SIDE OF SHIPPING PANEL) VOLT- METER W/ DRL W/O DRL WHT WIRE YEL WIRE