GMC Vandura G3500 (1985-1996) air conditioning system Wiring diagrams

1995 VFTC 23 24 PNK WIRE 4.3L AND 5.7 W/O HD 452 455 PPL 5.7 HD AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SIGNAL LO SIDE INJ A ECM I FUSE ECM-B FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID TRANS SHIFT 2/3 SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENGINE COOLANT TEMP SENS EVAP CONTROL EVAPORATIVE CANISTER PURGE SOLENOID (TOP RIGHT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY DRIVE PCM TRANS FORCE MTR LO FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IGNITION BYPASS KNOCK SENSOR IN LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 1 2 3 4 PPL 21 22 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BATTERY FEED FUEL PUMP SIGNAL IC REFERENCE LOW BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN/WHT WIRE CRANK SIGNAL ECT SIGNAL MAP SIGNAL CRNK FUSE ECM-CRNK FUSE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF SHIPPING PANEL) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE EGR CONTROL MALFUNCTION INDICATOR LAMP IGN ECM FUSED ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START HOT IN START IAC B LOW IAC B HIGH IAC A HIGH IAC A LOW IC CONTROL IC BYPASS OXYGEN SENSOR GROUND OXYGEN SENSOR SIGNAL IC REFERENCE HIGH IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) INJ FUSE INJECTOR 2 CONTROL INJECTOR 1 CONTROL INJECTOR 1 CONTROL KNOCK SIGNAL A/C SIGNAL LT BLU/BLK WIRE LT BLU/WHT WIRE LT BLU/WTH WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT GRN/WTH WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL/WHT WIRE RED WIRE SERIAL DATA DIAGNOSTIC TEST TERMINAL VSS SIGNAL SENSOR GROUND SYSTEM GROUND SYSTEM GROUND MAP SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) THROTTLE POSITION SENSOR (TOP RIGHT SIDE OF ENGINE) TP SIGNAL 5 VOLT REF INJECTOR 2 CONTROL BATTERY FEED WHT WIRE WHT/BLK WIRE YEL WIRE

1995 VFTC 23 24 PNK WIRE 4.3L AND 5.7 W/O HD 452 455 PPL 5.7 HD AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SIGNAL LO SIDE INJ A ECM I FUSE ECM-B FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID TRANS SHIFT 2/3 SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENGINE COOLANT TEMP SENS EVAP CONTROL EVAPORATIVE CANISTER PURGE SOLENOID (TOP RIGHT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY DRIVE PCM TRANS FORCE MTR LO FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IGNITION BYPASS KNOCK SENSOR IN LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 1 2 3 4 PPL 21 22 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

1995 VFTC 23 24 PNK WIRE 4.3L AND 5.7 W/O HD 452 455 PPL 5.7 HD AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE IND REG GRD DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DLC THROTTLE POSITION SIGNAL LO SIDE INJ A ECM I FUSE ECM-B FUSE EGR ELECTRONIC VACUUM REGULATOR SOLENOID VALVE (TOP RIGHT SIDE OF ENGINE) EGR VALVE SOLENOID TRANS SHIFT 2/3 SOLENOID ELEC FUEL PUMP IN MAP SENSOR IN ENGINE COOLANT TEMP SENS EVAP CONTROL EVAPORATIVE CANISTER PURGE SOLENOID (TOP RIGHT OF ENGINE) EXHAUST GAS RECIRCULATION VALVE SOLENOID (TOP RIGHT SIDE OF ENGINE) FUEL PUMP RELAY DRIVE PCM TRANS FORCE MTR LO FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START IDLE AIR CONTROL UNIT (RIGHT SIDE OF THROTTLE BODY) IGNITION BYPASS KNOCK SENSOR IN LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BLK WIRE OXYGEN SENSOR LO PCM TO TRANS TEMP SENSOR PCM TRANS RANGE A PCM TRANS RANGE B PCM TRANS RANGE C MIL INDICATOR CTRL PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (BEHIND RIGHT KICK PANEL) PPL PPL 1 2 3 4 PPL 21 22 PPL/WHT WIRE RED WIRE RED/BLK WIRE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) TRANS FUSE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

AIR CONDITIONING SYSTEM BATTERY FEED FUEL PUMP SIGNAL IC REFERENCE LOW BLK WIRE BLK/RED WIRE BLK/WHT WIRE BRN/WHT WIRE CRANK SIGNAL ECT SIGNAL MAP SIGNAL CRNK FUSE ECM-CRNK FUSE DATA LINK CONNECTOR (BEHIND LEFT SIDE OF SHIPPING PANEL) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BAT FUSE EGR CONTROL MALFUNCTION INDICATOR LAMP IGN ECM FUSED ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FUEL PUMP RELAY FUSE BLOCK GRY WIRE HOT AT ALL TIMES HOT IN RUN, BULB TEST OR START HOT IN START IAC B LOW IAC B HIGH IAC A HIGH IAC A LOW IC CONTROL IC BYPASS OXYGEN SENSOR GROUND OXYGEN SENSOR SIGNAL IC REFERENCE HIGH IDLE AIR CONTROL ACTUATOR (TOP REAR OF ENGINE) INJ FUSE INJECTOR 2 CONTROL INJECTOR 1 CONTROL INJECTOR 1 CONTROL KNOCK SIGNAL A/C SIGNAL LT BLU/BLK WIRE LT BLU/WHT WIRE LT BLU/WTH WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE LT GRN/WTH WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (TOP REAR OF ENGINE) ORG/ WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF SHIPPING PANEL) PPL PPL/WHT WIRE RED WIRE SERIAL DATA DIAGNOSTIC TEST TERMINAL VSS SIGNAL SENSOR GROUND SYSTEM GROUND SYSTEM GROUND MAP SENSOR GROUND TAN WIRE TAN/BLK WIRE THROTTLE BODY FUEL INJECTOR #1 (TOP OF THROTTLE BODY UNIT) THROTTLE BODY FUEL INJECTOR #2 (TOP OF THROTTLE BODY UNIT) THROTTLE POSITION SENSOR (TOP RIGHT SIDE OF ENGINE) TP SIGNAL 5 VOLT REF INJECTOR 2 CONTROL BATTERY FEED WHT WIRE WHT/BLK WIRE YEL WIRE

"SERVICE THROTTLE" LAMP 12 13 PNK WIRE A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG BARO SENSOR (NO LOCATION AVAILABLE) BLK WIRE BLK/WHT WIRE BLU WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECM-CRNK FUSE FUEL HEATER (NO LOCATION AVAILABLE) FUEL PUMP (NO LOCATION AVAILABLE) FUEL PUMP OIL PRESSURE SWITCH FUEL PUMP RELAY (NO LOCATION AVAILABLE) FUSIBLE LINK FUSIBLE LINKS GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GROUND (NO LOCATION AVAILABLE) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSE BLOCK STOP FUSE HOT IN RUN, BULB TEST OR START HOT IN START OR RUN ALT FUSE IGNITION FEED INSTRUMENT CLUSTER INSTRUMENT CLUSTERS SYSTEM LEFT BANK GLOW PLUGS LT GRN WIRE LT GRN/WHT WIRE MANIFOLD ABSOLUTE PRESSURE SENSOR (NO LOCATION AVAILABLE) ORG/ WIRE ORG/BLK WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT SIDE OF DRIVER'S ISLAND) PPL 15 16 PPL/WHT WIRE RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE ENGINE SOON LAMP STARTING/ CHARGING SYSTEM STOP LAMP/ CRUISE CONTROL BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TCC BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) PPL WAIT LAMP WASTEGATE SOL CTRL WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

3-2 SHIFT SOL CTRL "SERVICE THROTTLE" LAMP 8 9 10 PPL PPL A/C SIG AIR CONDITIONING SYSTEM APP 3 SENS SIG FUEL TEMP SIG IAT SIG BLK WIRE BLU WIRE BRK FUSE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (TOP FRONT OF ENGINE, INSIDE INJECTION PUMP) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMI FUSE EGR VENT SOLENOID (LEFT REAR TOP OF ENGINE) FUEL HEATER (TOP REAR OF ENGINE) FUSE BLOCK FUSIBLE LINK (12 GA- FUSIBLE LINKS GLO PLUG FUSE GLOW PLUG CONTROL RELAY (RIGHT REAR TOP OF ENGINE) GLOW PLUG SIG GRN WIRE GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES STOP FUSE HOT IN HOT IN RUN, BULB TEST OR START HOT IN START OR RUN GAUGES FUSE IGNITION FEED 3-2 SHIFT SOL CTRL INJECTION TIMING STEPPER (ITS) MOTOR (TOP FRONT OF ENGINE) INSTRUMENT CLUSTER LEFT BANK GLOW PLUGS LT BLU WIRE ORG/ WIRE ORG/BLK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (UNDER RIGHT END OF I/P) PPL RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS RUN WIRE SERVICE ENGINE SOON LAMP SERVICE THROTTLE LAMP WAIT LAMP TAN WIRE TAN/BLK WIRE TCC BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) WHT WIRE WHT/BLK WIRE YEL (OR WHT) WIRE YEL WIRE YEL/BLK WIRE

"TRANS" LAMP 1-2 SHIFT SOL 2-3 SHIFT SOL TCC SOL 2-3 SHIFT SOL CTRL 1-2 SHIFT SOL CTRL DIAGNOSTIC TEST A/C INPUT BRAKE SIGNAL TCC CONTROL PPL AIR CONDI- TIONING SYSTEM AIR CONDITIONING SYSTEM B/H BATTERY FEED BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE/TRANS- MISSION SHIFT INTERLOCK RELAY (ON STEERING COLUMN) BRN WIRE DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECM BAT FUSE ELECTRONIC 4-SPEED AUTOMATIC OVERDRIVE TRANSMISSION ENGINE SPEED SENSOR (TOP REAR OF ENGINE) ENGINE SPEED SIGNAL SENSOR GROUND TP SENSOR INPUT FUSE BLOCK FUSIBLE LINK (20 GA- RUST) FUSIBLE LINK FUSIBLE LINKS GAGES FUSE GLOW PLUG CONTROLLER (LEFT SIDE OF ENGINE) GLOW PLUG WAIT LAMP GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HOT AT ALL TIMES HOT AT ALL TIMES FUSIBLE LINK HOT IN CRANK HOT IN RUN, BULB TEST OR START HOT IN START OR RUN IGNITION SWITCH INPUTS INSTRUMENT CLUSTER (LEFT SIDE OF I/P) LEFT BANK GLOW PLUGS LT BLU/WHT WIRE LT GRN WIRE LT PPL ORG/ WIRE ORG/BLK WIRE PCS HI PCS LO IGNITION PNK RANGE SIGNAL A RANGE SIGNAL B RANGE SIGNAL C WIRE PNK WIRE PNK/BLK WIRE PPL PRESSURE CONTROL SOLENOID RANGE MODE SELECTOR RED WIRE RED/BLK WIRE RIGHT BANK GLOW PLUGS SERVICE TRANS OUTPUT SERIAL DATA STARTER MOTOR (LOWER RIGHT REAR OF ENGINE) SYSTEM GROUND SYSTEM GROUND 452 416 SENSOR GROUND 5 VOLTS REF TAN WIRE TCC/BRAKE SWITCH (ON BRAKE PEDAL SUPPORT) TRAN- SMISSION FLUID TEMP (TFT) SENSOR TRANS FLUID TEMP SIG MAP SENS TRANS FUSE ECM I FUSE TRANSMISSION CONTROL MODULE (TCM) (BELOW DRIVER SEAT) TRANSMISSION INPUT SPEED SENSOR (LEFT FRONT SIDE OF TRANSMISSION) VEHICLE SPEED INPUT TRANS INPUT SPD LO TRANS INPUT SPD HI VEHICLE SPEED SENSOR (REAR OF TRANSMISSION) VEHICLE SPEED SENSOR BUFFER (UNDER RIGHT SIDE OF I/P) VEHICLE SPD OUTPUT VSS WHT WIRE WHT/BLK WIRE YEL/BLK WIRE

900 900 SERVICE CIRCUIT POWER SERVICE CIRCUIT POWER A/C REQUEST SIGNAL A/T INPUT SPEED SENSOR (INSIDE FRONT OF TRANSMISSION) AIR CONDITIONING SYSTEM B(+) BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL MODULE (FRONT OF ENGINE COMPT NEAR LEFT FENDER) CRUISE CTRL ENGAGED CRUISE CTRL SIG-ENGAGED CYLINDER NO.1 CYLINDER NO.4 CYLINDER NO.5 CYLINDER NO.3 CYLINDER NO.6 CYLINDER NO.7 CYLINDER NO.2 CYLINDER NO.8 DATA LINK CONNECTOR (UNDER LEFT SIDE OF I/P) DISTRIBUTOR DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM I FUSE ECM-B FUSE ELEC SPK TIMING CTRL SIGNAL EST CTRL EVAP CAN PURGE VAC IN FORCE MTR RTN GROUND GROUND SENS GROUND FORCE MTR FEED SENS RTN SENS RTN ELEC SPK TIMING CTRL SIG FUEL PMP RLY CTRL 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 FUEL PUMP PRIME CONNECTOR FUEL PUMP RELAY UNDERHOOD FUSE-RELAY CENTER GROUND GRY WIRE HIGH VOLTAGE COIL WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN FEED IGN FEED PRESS SW SIG PRESS SW SIG IGNITION COIL (TOP RIGHT SIDE OF ENGINE) IGNITION COIL DRIVER (ON BRACKET AT REAR OF INTAKE PLENUM) LT BLU/BLK WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE PNK IGN FEED WIRE PNK WIRE PPL PPL PNK PNK PNK 1 2 3 4 5 6 WIRE PPL PPL ANTI-LOCK BRAKES SYSTEM PPL PPL BRAKE SW INPUT SERIAL DATA PPL TCC/STOPLAMP INPUT PRESS SW SIG RED WIRE RED/BLK WIRE SOUND SYSTEMS SPARK PLUGS SPEED SENSOR INPUT TAN/WHT WIRE UNDERHOOD FUSE/RELAY CENTER VEHICLE CONTROL MODULE (VCM) (ENGINE COMPARTMENT, ON LEFT FENDER APRON) VSS SIGNAL VSS OUTPUT CHECK ENGINE LP CTRL WHT WIRE WHT/BLK WIRE