GMC Sierra 2500 (2000-2004) hot in Wiring diagrams

1 2 6 8 16 19 20 21 24 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 CTRL SOLENOID 407 (OR 720) A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK (OR GRY) WIRE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY WIRING HARNESS JUNCTION BLOCK BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECMB FUSE ENGINE COOLANT TEMPERATURE SENSOR (LEFT FRONT OF CYLINDER HEAD) ENGINE WIRING HARNESS JUNCTION BLOCK EX CAN BUILT CANADIAN BUILT FLUID TEMP SENSOR FRT AXLE SW VSS LO (GROUND) VSS HI (SIGNAL) FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, BULB TEST, START HOT IN RUN, START INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE SENS GND B+ CLS 2 DATA CLS 2 DATA SENS GND PRND B ECT SIG IGN 3-2 SS SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSY) TP SIG GND TCC SOL MIL CTRL 2-3 SS 1-2 SS TFT SENS SIG PRND C TRANS RNG A VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS ADAPTER W/ TRACTION W/O TRACTION WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 41 46 54 57 58 59 63 72 74 75 LO REF A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (UNDER LEFT END OF DASH) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE EXCEPT LIGHT DUTY FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, BULB TEST, START HOT IN RUN, START INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LIGHT DUTY LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL ABS SYSTEM PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE SENS GND B+ CLS 2 DATA CLS 2 DATA SENS GND PRND B ECT SIG IGN SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TCC PWM SOLENOID TRANSFER CASE) (ON TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VSS ADAPTER W/ TRACTION ASSIST W/O TRACTION ASSIST WHT WIRE YEL WIRE YEL/BLK WIRE

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (IN LOWER LEFT FLOOR DUCT ASSEMBLY) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM CENTER OF HVAC BOX, IN FLOOR DUCT) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) WHT WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE HOT AT ALL TIMES HOT IN HVAC CONTROL MODULE (BEHIND CENTER OF DASH) LEFT I/P FUSE BLOCK LT BLU WIRE OFF ORG/ WIRE PPL RED WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE

1382 39 INTERIOR LIGHTS SYSTEM ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BODY RELAY BLOCK BODY RELAY BLOCK (UNDER LEFT SIDE) BODY WIRING RELAY BLOCK BRAKE IND BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CRUISE CONTROL MODULE CRUISE FUSE CRUISE IND DATA LINES DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER ENG SPD SERIAL IGN 1 ENGINE OIL PRESSURE SENSOR EXTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM (DIESEL) FUEL GAUGE GAS GND VSS OIL PRESS GRY WIRE HIGH BEAM IND HOT AT ALL TIMES UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) RADIO FUSE HOT IN HOT IN OFF, RUN OR START HOT IN RUN AND START IGN IGN 1 FUSE IGN O FUSE IGNITON 1 OFF/RUN/ ILLUM PWR ILLUMINATION INSTRUMENT CLUSTER LED DIM LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT TURN IND LO WASHER FLUID LOGIC LOW WASH LT BLU WIRE MESSAGE CENTER NCA WIRE NOT USED NOT USED OIL GAUGE ORG/ WIRE PARK SW PARK SWITCH (PART OF THE PARK BRAKE ASSEMBLY) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL/WHT WIRE RADIO RIGHT TURN IND RUN WIRE SEAT BELT IND SERVICE ENGINE SOON IND SHIFT IND SPARE SPEEDOMETER TACH OUT TACHOMETER TAN/WHT WIRE TEMP GAUGE TRANS TEMP GAUGE TRIP ODOMETER HOUR METER UNDERHOOD FUSE BLOCK VOLTS GAUGE VSS OUT WAIT TO START WASHER FLUID LEVEL SWITCH (IN WASHER FLUID RESERVOIR) WHT WIRE

2-HI IND 4-HI IND 4-LO IND ATC FUSE AUTO AUXILIARY BATTERY RELAY B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER LOGIC ENCODER MOTOR ENCODER RTN FRONT AXLE ACTUATOR FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INSTRUMENT PANEL CLUSTER LAMP LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE YEL/BLK WIRE

2-HI IND 4-HI IND 4-LO IND 4.3L 4.8L, 5.3L, 6.0L ATC FUSE AUTO AUXILIARY BATTERY RELAY AWD IND B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER MOTOR ENCODER RTN ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INDICATOR LAMP INSTRUMENT CLUSTER LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR ENCODER LOGIC RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SELECT SWITCH YEL WIRE YEL/BLK WIRE

2-HI IND 4-HI IND 4-LO IND 4.3L 4.8L, 5.3L, 6.0L ATC FUSE AUTO AUXILIARY BATTERY RELAY AWD IND B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER MOTOR ENCODER RTN ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INDICATOR LAMP INSTRUMENT CLUSTER LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR ENCODER LOGIC RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SELECT SWITCH YEL WIRE YEL/BLK WIRE

4.3L 4.8L, 5.3L, 6.0L 1694 1695 AUXILIARY BATTERY RELAY, VEHICLE CONTROL MODULE (4.3L) BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRN WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) ENGINE COMPT) ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN, START INDICATOR LAMP INSTRUMENT CLUSTER LOGIC LT BLU WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF PPL RUN WIRE SPLICE PACK TRANSFER CASE SWITCH (TOP LEFT OF TRANSFER CASE) VEHICLE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT)

4.3L 4.8L, 5.3L, 6.0L 1694 1695 AUXILIARY BATTERY RELAY, VEHICLE CONTROL MODULE (4.3L) BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRN WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (ON LEFT SIDE OF INNER FRAME) ENGINE COMPT) ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT IN HOT IN RUN, START INDICATOR LAMP INSTRUMENT CLUSTER LOGIC LT BLU WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF PPL RUN WIRE SPLICE PACK TRANSFER CASE SWITCH (TOP LEFT OF TRANSFER CASE) VEHICLE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT)