GMC Sierra 2500 (2000-2004) hot at all times Wiring diagrams

59 33 (DIESEL) (GAS) ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IND BRN WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE IGNITION INSTRUMENT CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SEO SEO IGN FUSE STOP- LAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TCC BRAKE SW TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRASFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

59 33 (DIESEL) (GAS) ABS FUSE ANTI-LOCK IND BLK WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) DEL TORQUE DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) EXCEPT SEO GRY WIRE HOT AT ALL TIMES HOT IN RUN LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) BRAKE FUSE HOT IN RUN OR START IGN E FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE ILLUM LAMP INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) ORG/BLK WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL PPL PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SEO SEO IGN FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC BRAKE SW TRACTION CONTROL SWITCH TRANSFER CASE SHIFT CONTROL MODULE TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM (TRASFER CASE CIRCUIT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUT YEL WIRE YEL/BLK WIRE

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) AMBIENT AIR TEMPERATURE SENSOR (IN RIGHT FRONT BUMPER FILLER ASSEMBLY AUTO BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR BLOWER MOTOR CONTROL PROCESSOR (BEHIND RIGHT SIDE OF DASH) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FAN DN FAN UP FRT DEF GROUND TEMP SEN ASS CTRL BLOWER SPEED CTRL GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INSIDE AIR TEMPERATURE SENSOR ASSEMBLY (IN HEADLINER ABOVE DRIVER) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL LOGIC LOW REF LOWER LEFT AIR TEMPERATURE SENSOR (IN LOWER LEFT FLOOR DUCT ASSEMBLY) LOWER RIGHT AIR TEMPERATURE SENSOR (BOTTOM CENTER OF HVAC BOX, IN FLOOR DUCT) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE MODE MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RECIR RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE SPEED CTRL B(+) GROUND TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) UPPER LEFT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) UPPER RIGHT AIR TEMPERATURE SENSOR (BELOW DASH TRIM PANEL, IN UPPER DUCT) WHT WIRE WHT/BLK WIRE YEL WIRE

1056 1037 INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM 2353 1382 4040 1732 230 2240 INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM 244 255 1391 193 (BASE) (UPPER LEVEL) 710 308 COMPUTER DATA LINES SYSTEM EXTERIOR LIGHTS SYSTEM 812 1140 1969 1080 1353 ANTI-THEFT SYSTEM AMBIENT LIGHT SENSOR AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-LOCK BRAKES SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM ANTI-THEFT SYSTEM HEADLIGHTS SYSTEM HORNS SYSTEM ANTI-THEFT SYSTEM SOUND SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BRN/WHT WIRE CLASS 2 SERIAL DATA CLASS 2 SERIAL DATA PARK LAMP SW ON SIG DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DEFOGGER SYSTEM DOOR LOCKS SYSTEM HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT AT ALL TIMES TBC BATT FUSE I/P RELAY BLOCK INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM LEFT I/P FUSE BLOCK LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE PASS DOOR LOCK SW LOCK CTRL DRIVER DOOR UNLOCK RLY CTRL REAR DEFOG RLY CTRL PASS DOOR LOCK SW UNLOCK CTRL HEADLAMP LOW BEAM RELAY CTRL FOG LIGHT RELAY CTRL PNK WIRE PNK/BLK WIRE POWER DISTRIBUTION SYSTEM PPL PPL INTERIOR LAMP DEFEAT SW SIG PPL/WHT WIRE RED WIRE RED/WHT WIRE SOLAR SENSOR SOLAR SENSOR SOUND SYSTEM STEERING CTRL SUPPLY VOLT SUNLOAD SENSOR TAN/WHT WIRE TOW/HAUL SW SIG TOW/HAUL SWITCH UNDERHOOD FUSE BLOCK UPPER LEVEL W/ AUTOMATIC A/C W/ MANUAL A/C WHT WIRE YEL WIRE

80 51 45 28 14 68 43 34 58 58 (GASOLINE) (DIESEL) A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C RECIRC A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN A/C MUFFLER HOSE ASSEMBLY) BLK WIRE BLK/WHT WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE BRN/WHT WIRE CLASS 2 SER DATA CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT DEF GRY WIRE HOT AT ALL TIMES HOT AT ALL TIMES A/C COMP FUSE HOT IN HOT IN RUN OR START IGN E FUSE HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC/ ECAS FUSE I/P RELAY BLOCK (LEFT SIDE OF DASH) INST LAMP DIM CTRL GROUND LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT TEMP CONTROL LOGIC LOW REF LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MODE CONTROL MODE DOOR CTRL MODE DOOR CTRL IGN 3 LOW REF B(+) OFF OFF BLOW MT CTRL LO PRESS SENS SIG RT TEMP DOOR CTRL LT TEMP DOOR CTRL ORG/ WIRE POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL RECIR DOOR CTRL RT TEMP DOOR CTRL LT TEMP DOOR CTRL RECIRC SWITCH RED WIRE RED/BLK WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT TEMP CONTROL RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE WHT/BLK WIRE YEL WIRE

4 5 RF + GROUND 6 7 8 9 10 DIMMER I/P LAMP ANTENNA BLK WIRE BRN WIRE DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR SPEAKER LF+ LR (-) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE RADIO RADIO FUSE RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER RR (-) TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) YEL WIRE

4 5 RF + GROUND 6 7 8 9 10 DIMMER I/P LAMP ANTENNA BLK WIRE BODY RELAY BLOCK BRN WIRE DATA LINK CONNECTOR DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER LF+ LR (-) LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE RADIO RADIO FUSE RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER RR (-) SERIAL DATA TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) YEL WIRE

19 20 LR - LR + 4 5 6 7 8 9 10 RF + GROUND DIMMER I/P LAMP ANTENNA BARE BLK WIRE BLK/WHT WIRE BODY JUNCTION BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CD PLAYER- REMOTE PLAY- BACK DEVICE CRUISE CONTROL MODULE DATA LINK CONNECTOR DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY INSTRUMENT CLUSTER LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER (CREW CAB) LEFT REAR SPEAKER (EXCEPT CREW CAB) LF+ LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RADIO RADIO FUSE RADIO ON SIG DIM SIG IN DRAIN RT OUTPUT RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER (CREW CAB) RIGHT REAR SPEAKER (EXCEPT CREW CAB) RR (-) SERIAL DATA VSS SIGNAL RR - TAN WIRE UNDERHOOD JUNCTION BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE INTERFACE UNIT (IN THE RIGHT SIDE OF I/P NEAR THE INSTRUMENT CLUSTER) VSS SIGNAL YEL WIRE

19 20 LR - LR + 4 5 6 7 8 9 10 RF + GROUND DIMMER I/P LAMP ANTENNA BARE BLK WIRE BLK/WHT WIRE BODY JUNCTION BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK BRN WIRE BRN/WHT WIRE CD PLAYER- REMOTE PLAY- BACK DEVICE CRUISE CONTROL MODULE DATA LINK CONNECTOR (ON LEFT LOWER DASH BELOW THE STEERING COLUMN) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY INSTRUMENT CLUSTER LEFT FRONT DOOR SPEAKER LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LEFT REAR DOOR SPEAKER (CREW CAB) LEFT REAR SPEAKER (EXCEPT CREW CAB) LF+ LT BLU WIRE LT GRN WIRE NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RADIO RADIO FUSE RDO I FUSE RF+ RIGHT FRONT DOOR SPEAKER RIGHT REAR DOOR SPEAKER (CREW CAB) RIGHT REAR SPEAKER (EXCEPT CREW CAB) RR (-) SERIAL DATA VSS SIGNAL RR - TAN WIRE UNDERHOOD JUNCTION BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS SIGNAL YEL WIRE

2-HI IND 4-HI IND 4-LO IND ATC FUSE AUTO AUXILIARY BATTERY RELAY B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER LOGIC ENCODER MOTOR ENCODER RTN FRONT AXLE ACTUATOR FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INSTRUMENT PANEL CLUSTER LAMP LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSFER CASE SHIFT CONTROL SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE YEL/BLK WIRE