GMC Sierra 2500 (2000-2004) hot at all times Wiring diagrams

1 2 6 8 16 19 20 21 24 40 42 46 47 48 51 62 63 GND TCC PWM PC SOL HI PC SOL LO 1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 3-2 CTRL SOLENOID 407 (OR 720) A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK (OR GRY) WIRE BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY WIRING HARNESS JUNCTION BLOCK BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK GRN WIRE ECMB FUSE ENGINE COOLANT TEMPERATURE SENSOR (LEFT FRONT OF CYLINDER HEAD) ENGINE WIRING HARNESS JUNCTION BLOCK EX CAN BUILT CANADIAN BUILT FLUID TEMP SENSOR FRT AXLE SW VSS LO (GROUND) VSS HI (SIGNAL) FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, BULB TEST, START HOT IN RUN, START INSTRUMENT CLUSTER LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE SENS GND B+ CLS 2 DATA CLS 2 DATA SENS GND PRND B ECT SIG IGN 3-2 SS SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TCC PWM SOLENOID TCC SOLENOID THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSY) TP SIG GND TCC SOL MIL CTRL 2-3 SS 1-2 SS TFT SENS SIG PRND C TRANS RNG A VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VSS ADAPTER W/ TRACTION W/O TRACTION WHT WIRE YEL WIRE YEL/BLK WIRE

1-2 SHIFT SOLENOID 2-3 SHIFT SOLENOID 41 46 54 57 58 59 63 72 74 75 LO REF A/T FLUID PRESSURE MANUAL VALVE POSITION SWITCH AUTOMATIC TRANSMISSION BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (UNDER LEFT END OF DASH) BRAKE FUSE BRN WIRE BRN/WHT WIRE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECMB FUSE EXCEPT LIGHT DUTY FLUID TEMP SENSOR FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, BULB TEST, START HOT IN RUN, START INSTRUMENT CLUSTER INSTRUMENT PANEL CLUSTER (IPC) LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LIGHT DUTY LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE PARK/NEUTRAL POSITION SWITCH (LEFT SIDE OF TRANSMISSION) PNK PNK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL ABS SYSTEM PPL DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL PPL PPL/WHT WIRE PRESS CTRL SOLENOID RED WIRE RED/BLK WIRE REV, LO RUN WIRE SENS GND B+ CLS 2 DATA CLS 2 DATA SENS GND PRND B ECT SIG IGN SPLICE PACK STOPLIGHT SWITCH (TOP OF BRAKE PEDAL BRACKET) TCC PWM SOLENOID TRANSFER CASE) (ON TRANSMISSION) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VSS ADAPTER W/ TRACTION ASSIST W/O TRACTION ASSIST WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 TP SENSOR 1 SIG ACCELERATION PEDAL POSITION SENSOR (BEHIND ACCELERATOR PEDAL) APP SENSOR 1 SIG BLK WIRE BLK/WHT WIRE BRN WIRE CRUISE CONTROL ON/OFF SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ETC FUSE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN, START LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOW REF APP SENSOR 3 SIG LOW REF LOW REF APP SENSOR 2 SIG PPL LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) OF TRANSMISSION) OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SERIAL DATA SET/COAST STOP LPS FUSE STOPLAMP SWITCH (TOP OF BRAKE PEDAL) TAN WIRE THROTTLE ACTUATOR CONTROL MOTOR (ON THROTTLE BODY) THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) UNDERHOOD FUSE BLOCK (NEAR BATTERY) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND PNK WIRE BLK WIRE BLK/WHT WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IND BRAKE INPUT SERIAL DATA BRN WIRE CLUTCH START SWITCH (TOP OF CLUTCH CLUTCH ASSY) CPP SW SIG DIESEL DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) ENGINE CONTROLS SYSTEM FRONT AXLE ACT/SW INPUT VSS INPUT LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) FRONT AXLE ACTUATOR/ SWITCH (ON AXLE HOUSING) GAS GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LT BLU WIRE LT GRN/BLK WIRE M/T ONLY NCA WIRE OF TRANSFER CASE) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/ PPL/ PPL/ PPL/ PPL/WHT WIRE RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TRANSFER CASE SHIFT CONTROL MODULE (LEFT SIDE OF DASH, BEHIND HEADLAMP SWITCH) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

ABS FUSE ABS IND. BLK WIRE BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRAKE FLUID LEVEL SWITCH (ON LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE IN BRAKE IND BRN WIRE BRN/WHT WIRE DEL TORQUE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GAS DIESEL GROUND DISTRIBUTION SYSTEM GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) DELIVERED TORQUE INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) LOGIC LOW TRACTION INDICATOR ILLUM LAMP LT BLU WIRE LT GRN/BLK WIRE NCA WIRE OF TRANSFER CASE) ORG/BLK WIRE PNK PNK POWER DISTRIBUTION SYSTEM WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) PPL PPL 1122 832 PPL DATA LINK CONNECTOR (DLC) (BELOW STEERING COLUMN) PPL/WHT WIRE RED WIRE REQ TORQUE RIGHT FRONT WHEEL SPEED SENSOR SERVICE TRAC CNTL SIG SIDE OF TRANSMISSION) STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE TAN/BLK WIRE TRACTION CONTROL SWITCH TRACTION OFF INDICATOR UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUT WHT WIRE YEL WIRE YEL/BLK WIRE

ACCESSORY VOLTAGE BLK WIRE DK BLU WIRE GROUND LSD GRY WIRE HI LO OFF HOT AT ALL TIMES HOT IN RUN AND ACC LEFT I/P FUSE BLOCK (BEHIND LOWER LEFT SIDE OF DASH) LO PULSE MIST MIST WASH OFF ORG/ WIRE PNK WIRE RED WIRE TAN WIRE TURN SIGNAL/ MULTI-FUNCTION SWITCH UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/S WASH FUSE W/S WASH RELAY W/S WIPER FUSE WHT WIRE WINDSHIELD WASHER FLUID PUMP (ON WASHER FLUID RESERVOIR) WINDSHIELD WASHER RELAY CNTRL WINDSHIELD WIPER HIGH SIGNAL WINDSHIELD WIPER MOTOR MODULE (LEFT SIDE OF COWL) WINDSHIELD WIPER SUPPLY VOLTAGE WINDSHIELD WIPER SWITCH SIGNAL WINDSHIELD WIPER/ WASHER SWITCH YEL WIRE

BLK WIRE BLU WIRE DK PNK WIRE DK PPL PNK WIRE DRIVER DRIVER SEAT SEAT BOLSTER LUMBAR DRIVER LUMBAR/ BOLSTER SWITCH HOT AT ALL TIMES IN OUT IN LEFT I/P FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) ORG/ WIRE OUT OUT IN PASS- ENGER LUMBAR/ BOLSTER SWITCH PASSENGER PASSENGER SEAT SEAT BOLSTER LUMBAR PICKUP UTILITY POWER SEATS CIRCUIT SEAT CIRCUIT BREAKER TAN WIRE WHT WIRE

4.3L 7 8 9 10 11 12 13 14 15 PNK WIRE ANTENNA BASE BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CRUISE CONTROL MODULE DIM SIG IN DRAIN RT OUTPUT LT OUTPUT AUDIO RTN GROUND E&C LINE BATTERY BARE DIM SIG OUT DRAIN RT INPUT LT INPUT AUDIO RTN GROUND E&C LINE BATTERY BARE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EXCEPT 4.3L GRY WIRE HOT AT ALL TIMES HOT WITH RAP RELAY ENERGIZED IGNITION BATTERY INSTRUMENT CLUSTER LEFT BUSSED ELECTRICAL CENTER (ON LOWER LEFT SIDE OF DASH) LEFT FRONT DOOR SPEAKER LEFT REAR SPEAKER LF - LF + RF - RF + GROUND PARK LPS DIMMER LT BLU WIRE LT GRN WIRE MID BUSSED ELECTRICAL CENTER (NEAR LEFT KICK PANEL) NCA WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL/WHT WIRE PREMIUM RADIO RADIO FUSE RAO I FUSE REMOTE COMPACT DISK PLAYER RIGHT FRONT DOOR SPEAKER RIGHT REAR SPEAKER TAN WIRE UNDERHOOD BUSSED ELECTRICAL CENTER (ON LEFT SIDE OF ENGINE COMPT) VEHICLE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) VSS SIGNAL VSS SIGNAL RR (-) RR (+) LR (-) LR (+) YEL WIRE

2-HI IND 4-HI IND 4-LO IND 4.3L 4.8L, 5.3L, 6.0L ATC FUSE AUTO AUXILIARY BATTERY RELAY AWD IND B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER MOTOR ENCODER RTN ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INDICATOR LAMP INSTRUMENT CLUSTER LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR ENCODER LOGIC RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SELECT SWITCH YEL WIRE YEL/BLK WIRE

2-HI IND 4-HI IND 4-LO IND 4.3L 4.8L, 5.3L, 6.0L ATC FUSE AUTO AUXILIARY BATTERY RELAY AWD IND B+ MOTOR (CCW) MOTOR (CW) GND BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK BRAKE CONTROL BRN WIRE BRN/WHT WIRE CONTROL MODULE CTRL DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ENCODER MOTOR ENCODER RTN ENGINE WIRING HARNESS JUNCTION BLOCK FRONT AXLE ACTUATOR/ SWITCH FRONT PROP- SHAFT SPEED SENSOR FT SHAFT SIG FT SHAFT RTN FUSE FUSE BLOCK GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN HOT IN RUN, START ILLUMINATION LAMP (2) INDICATOR LAMP INSTRUMENT CLUSTER LOCK SOL OUT LOGIC LT BLU WIRE LT GRN/BLK WIRE MODULE GND 4-LO IND 4-HI IND NEUTRAL IND FT AXLE CTRL RR SHAFT SIG RR SHAFT RTN NCA WIRE NEUTRAL IND ORG/ WIRE PNK WIRE PPL PPL/WHT WIRE REAR PROP- SHAFT SPEED SENSOR ENCODER LOGIC RED WIRE RED/WHT WIRE REF RUN WIRE SHIFT MOTOR SOLID STATE SPLICE PACK TAN WIRE TAN/BLK WIRE TRANSFER CASE SELECT SWITCH YEL WIRE YEL/BLK WIRE