GMC Sierra 2500 (2000-2004) blk Wiring diagrams

1320 1339 582 PNK WIRE 15 14 35 SERIAL DATA SERIAL DATA ACCELERATOR PEDAL POSITION SENSOR (ABOVE ACCELERATOR PEDAL) APP SENS BLK WIRE BLK/WHT WIRE BRN WIRE CLUTCH PEDAL POSITION SWITCH (TOP OF CLUTCH PEDAL) CLUTCH SW INPUT CRUISE CONTROL SWITCH CRUISE FUSE DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE ECT FUSE ENGINE WIRING HARNESS JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT NEAR BATTERY) FUSE BLOCK (ON LOWER LEFT SIDE OF DASH) GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START HOT IN RUN, START LT BLU WIRE LT BLU/BLK WIRE LT GRN/BLK WIRE NCA WIRE OFF ORG/ WIRE ORG/BLK WIRE PNK WIRE POWERTRAIN CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL/WHT WIRE RESUME/ACCEL SENS 1 GRD APP SENS 3 SENS 1 RT APP SENS SENS 3 RT SENS 2 RT APP SENSE PPL SET/COAST STOP LPS FUSE STOPLAMP SWITCH (ON TOP OF BRAKE PEDAL BRACKET) TAN WIRE THROTTLE ACTUATOR CONTROL (TAC) MODULE (NEAR FRONT OF ENGINE COMPT) THROTTLE ACTUATOR CONTROL MOTOR (NEAR FRONT OF ENGINE COMPT) THROTTLE POSITION SENSOR (DUAL TRACK) (NEAR FRONT OF ENGINE COMPARTMENT) VEH STOP FUSE VEHICLE SPEED SENSOR (VSS) VEHICLE SPEED SENSOR ADAPTER (4 WD) (ON LEFT SIDE OF TRANSMISSION) VSS HIGH VSS LOW WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

20 29 21 30 49 15 EXCEPT 4.3 L 4.3L ABS FUSE BLK WIRE BLK/WHT WIRE BODY WIRING HARNESS JUNCTION BLOCK (NEAR LEFT KICK PANEL) BRAKE FLUID LEVEL SW IN BRAKE FLUID LEVEL SWITCH (LEFT SIDE OF BRAKE FLUID RESERVOIR) BRAKE FUSE BRAKE INPUT SERIAL DATA BRAKE PRESSURE MODULATOR VALVE BRN WIRE DATA LINK CONNECTOR (BELOW STEERING COLUMN) DK GRN WIRE DK GRN/WHT WIRE ELECTRONIC BRAKE CONTROL MODULE (LEFT SIDE OF INNER FRAME) ENGINE CONTROL SYSTEM ENGINE WIRING HARNESS JUNCTION BLOCK (LEFT SIDE OF ENGINE COMPT) FRONT AXLE ACTUATOR/ SWITCH (ON AXLE HOUSING) FUSE BLOCK (LOWER LEFT SIDE OF DASH) GROUND MOTOR, SOLENOID PWR GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN AND START IGN 1 FUSE IGNITION LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR LOGIC LT BLU WIRE LT GRN/BLK WIRE NCA WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE OR VEHICLE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) PPL PPL PPL PPL/WHT WIRE PUMP MOTOR RED WIRE RIGHT FRONT WHEEL SPEED SENSOR SPLICE PACK 205 CENTER (NEAR LEFT KICK PANEL) STOPLAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) TAN WIRE VEHICLE SPEED SENSOR (LEFT REAR OF TRANSMISSION) VEHICLE SPEED SENSOR ADAPTER VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

AMBIENT LIGHT SENSOR (TOP CENTER OF DASH) ANTI-THEFT SYSTEM ANTI-THEFT SYSTEM DOOR LOCKS SYSTEM BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK (NEAR LEFT KICK PANEL) BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CARGO LP SW INPUT INTERIOR LAMP CTRL FLASH TO PASS SW SIG DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DOOR LATCH SW SIG COURTESY LAMP PWR DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM DRIVER DOOR KEY SW SIG LF DR OPEN SW SIG FRONT FOG LP SW INT LP DEFEAT SW SIG DRL RLY COIL CLASS 2 DATA GROUND IGN 1 EXTERIOR LIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM FOG LP RLY CTRL EXTERIOR COURTESY LPS RLY CTRL GROUND BATTERY DOOR UNLOCK CTRL DOOR LOCK CTRL GRY WIRE GRY/BLK WIRE HEADLAMP SW INPUT LED DIM SIG VSS HEADLIGHTS SYSTEM COMPUTER DATA LINES SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM HOT AT ALL TIMES TBC FUSE HOT IN RUN CRUISE FUSE HOT IN RUN, START IGN 1 FUSE IGN 3 PRK BK SW SIG LT SEAT BELT SW TOW/HAUL SW SIG IGNITION KEY ALARM SWITCH INST PANEL LP PWR AMBIENT LIGHT SEN SIG INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM KEY IN IGN SW SIG LEFT I/P FUSE BLOCK LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT TURN SIG LAMP PWR RT TURN SIG LAMP PWR NCA WIRE ORG/ WIRE ORG/BLK WIRE PARK BRAKE SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM (RAP) INTERIOR LIGHTS SYSTEM HORNS SYSTEM PPL PPL HIGH BEAM INPUT INTERIOR PARK LP PWR PPL/WHT WIRE RAP RELAY CTRL INADVERTENT PWR RLY CTRL HORN RLY CTRL RED/WHT WIRE SECURITY SYSTEM SEN SIG SERIAL DATA TAN WIRE TOW/HAUL SWITCH UNDERHOOD JUNCTION BLOCK WARNING SYSTEM WHT WIRE YEL WIRE

A/C COMP CL RLY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C ON SWITCH A/C REF PRE SENS SIG A/C REFRIGERANT PRESSURE SENSOR (IN HIGH SIDE PRESSURE LINE) BLK WIRE CLASS 2 SER DATA LO PRESS SENS SIG CLASS 2 SERIAL DATA DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES A/C COMP FUSE HOT IN RUN OR START IGN E FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) LOGIC LOW REF POWERTRAIN CONTROL MODULE OR ENGINE CONTROL MODULE (LEFT FRONT OF ENGINE COMPT) RED WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE

3 2 PPL BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (ON LOWER LEFT SIDE OF DASH, BELOW STEERING COLUMN) BODY RELAY BLOCK BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH, NEAR KICK PANEL) BRN/WHT WIRE CIGAR FUSE DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH, BELOW STEERING COLUMN) DIESEL DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) ELECTRONIC BRAKE CONTROL MODULE (EBCM) (ON LEFT SIDE OF INNER FRAME) GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE (BEHIND CENTER OF DASH) INSTRUMENT PANEL CLUSTER (IPC) LT BLU WIRE LT GRN WIRE MEMORY SEAT MODULE (UNDERSODE OF DRIVER SEAT) 15 14 13 12 11 10 9 8 7 6 NEAR KICK PANEL) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (ON LEFT FRONT OF ENGINE COMPT) SPLICE PACK TRANSFER CASE SHIFT CONTROL MODULE (BEHIND HEADLAMP SWITCH) TRANSMISSION CONTROL MODULE (AT LEFT FRONT OF ENG COMPT) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENG COMPT, NEAR BATTERY) UNDERHOOD FUSE BLOCK (AT LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) VEHICLE INTERFACE UNIT (BEHIND RIGHT SIDE OF DASH) WHT WIRE YEL WIRE

5 20 22 DOOR AJAR SW SIG DOOR SW LO REF SERIAL DATA AJAR SW BASE BATTERY PK LAMP REL HEADLIGHTS CTRL GROUND HORN RLY CTRL SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE BRN WIRE DK BLU WIRE DK GRN WIRE DRIVER DOOR MODULE DRIVER MINI-WEDGE DOOR JAMB SWITCH (REAR OF DRIVER'S DOOR) EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FRONT PASSENGER DOOR MODULE FRONT PASSENGER MINI-WEDGE DOOR JAMB SWITCH (REAR OF RIGHT FRONT DOOR) GROUND GRY/BLK WIRE HORNS SYSTEM HOT AT ALL TIMES I/P RELAY BLOCK (NEAR LEFT KICK PANEL) INSIDE DRIVER DOOR) KEY SW LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LEFT REAR MINI-WEDGE DOOR JAMB SWITCH (CREW CAB) (REAR OR LEFT REAR DOOR) LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE RF DOOR AJAR SW LF DOOR AJAR SW RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RIGHT REAR MINI-WEDGE DOOR JAMB SWITCH (CREW CAB) (REAR OR RIGHT REAR DOOR) RR DOOR AJAR SW LR DOOR AJAR SW SPLICE PACK TAN WIRE TBC BATT FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) WHT WIRE

BLK WIRE BLOWER FUSE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR CONTROL SWITCH BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BRN WIRE HOT AT ALL TIMES HOT IN HVAC CONTROL MODULE (BEHIND CENTER OF DASH) LEFT I/P FUSE BLOCK LT BLU WIRE OFF ORG/ WIRE PPL RED WIRE RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) RUN WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) YEL WIRE

A/C COMP RELAY CTRL A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESSURE RECIRCULATION SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RELAY ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BODY RELAY BLOCK (UNDER LEFT SIDE OF DASH) BRN WIRE CTRL RECIRC DOOR DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL ASSEMBLY HVAC CONTROL MODULE (BEHIND CENTER OF DASH) IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LOW OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE OF ENGINE COMPT) PPL PRESS SW A/C HIGH REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE

11 11 17 17 (GASOLINE) (DIESEL) A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C FUSE A/C HIGH PRESS SW A/C HIGH PRESSURE RECIRCULATING SWITCH (IN A/C MUFFLER HOSE) A/C HIGH PRESSURE SWITCH (REAR OF COMPRESSOR) A/C LOW PRESSURE SWITCH (RIGHT SIDE OF ACCUMULATOR) A/C REQUEST A/C SWITCH AIR TEMPERATURE ACTUATOR (BOTTOM CENTER OF BLK WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLOWER MOTOR RESISTOR ASSEMBLY (ON HVAC MODULE, NEAR BLOWER MOTOR) BLOWER RELAY BRN WIRE DEFOGGER SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE FRT HVAC FUSE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START HTR A/C FUSE HVAC 1 FUSE HVAC CONTROL MODULE (BEHIND CENTER OF DASH) HVAC MODULE IGN E FUSE LEFT I/P FUSE BLOCK (LOWER LEFT SIDE OF DASH) LO OFF LT BLU WIRE MODE ACTUATOR (LEFT SIDE OF HVAC MODULE) ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (LEFT FRONT OF ENGINE COMPT) PPL REAR DEFOG RLY IGN 3 VOL A/C REQUEST ACT POS SIG RECIRC DOOR CTRL RECIRCULATION ACTUATOR (TOP OF HVAC MODULE) RED WIRE RELAY CTRL A/C COMP RIGHT I/P FUSE BLOCK (LOWER RIGHT SIDE OF DASH) TAN WIRE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT, NEAR BATTERY) WHT WIRE YEL WIRE

58 59 15 16 DATA DATA BATTERY GROUND LOW REFERENCE SERIAL DATA BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (LOWER LEFT SIDE OF DASH, NEAR STEERING COLUMN) CLASS 2 SERIAL DATA DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH) PPL DK GRN WIRE EXCEPT 6.6L VIN 2 6.6L VIN 2 GRY WIRE HOT AT ALL TIMES HOT IN RUN, START I/P RELAY BLOCK (NEAR LEFT KICK PANEL) IGN IGN SW SIG IGN 1 VOLTAGE PNK WIRE IGNITION KEY ALARM SWITCH (ON IGNITION KEY CYLINDER) INSTRUMENT PANEL CLUSTER KEY LT GRN WIRE MAGNET LOCK CYLINDER ORG/ WIRE ORG/BLK WIRE PASSLOCK SENSOR (INTERNAL TO STEERING COLUMN) PNK WIRE PPL RED/WHT WIRE SEC SENS SIG SERIAL DATA GROUND SECURITY INDICATOR SECURITY SENSOR SPLICE PACK TAMPER SENSOR TBC BATT FUSE TBC IGN 1 FUSE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENG COMPT) YEL WIRE