Repair manual
Ford Taurus IV рестайлинг Repair Manual
Step-by-step repair and maintenance instructions for the Ford Taurus IV рестайлинг (2004–2006): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
80sections
665articles
ENManual language
- VECI Decal
- Engine/Evaporative Emission (EVAP) System Information
- VECI Acronym Definitions
- Catalyst Efficiency Monitor
- Switch Ratio Method
- Index Ratio Method
- Comprehensive Component Monitor (CCM)
- Evaporative Emission (EVAP) Leak Check Monitor
- Engine On EVAP Leak Check Monitor
- Engine Off Natural Vacuum (EONV) EVAP Leak Check Monitor
- Exhaust Gas Recirculation (EGR) System Monitor - Delta Pressure Feedback (DPFE) EGR and EGR System Module (ESM)
- Electric Exhaust Gas Recirculation (EEGR) System Monitor
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- Low Data Rate System (LDR)
- High Data Rate System (HDR)
- Generic Misfire Processing
- Profile Correction
- Positive Crankcase Ventilation (PCV) System Monitor
- Secondary Air Injection (AIR) System Monitor - Electric Secondary Air Injection Pump System
- Thermostat Monitor
- Variable Cam Timing (VCT) Monitor
- Malfunction Indicator Lamp (MIL)
- Modifications to OBD Vehicles
- Multiplexing
- Multiplexing Implementation
- Standard Corporate Protocol (SCP)
- High Speed Controller Area Network (CAN)
- Flash Electrically Erasable Programmable Read Only Memory (EEPROM)
- Idle Air Trim
- Short Term Fuel Trim
- Long Term Fuel Trim
- Failure Mode Effects Management
- Engine RPM/Vehicle Speed Limiter
- Powertrain Control Module (PCM)
- Fuel Injector Control Module
- Fuel Pump Driver Module (FPDM)
- Keep Alive Memory (KAM)
- Integrated Electronic Ignition System
- Electronic Throttle Control Reference Voltage (ETCREF)
- Electronic Throttle Control Return (ETCRTN)
- Gold Plated Pins
- Keep Alive Power (KAPWR)
- Mass Air Flow (MAF) Return
- Power Ground (PWR GND)
- Signal Return (SIG RTN)
- Vehicle Buffered Power (VBPWR)
- Vehicle Power (VPWR)
- Vehicle Reference Voltage (VREF)
- Powertrain Control Module (PCM) Inputs
- Accelerator Pedal Position (APP) Sensor
- Air Conditioning (A/C) Cycling Switch
- Air Conditioning Evaporator Temperature (ACET) Sensor
- Air Conditioning (A/C) Pressure Sensor
- Air Conditioning (A/C) High Pressure Switch
- Brake Pedal Position (BPP) Switch
- Brake Pedal Switch (BPS)/Brake Deactivator Switch
- Camshaft Position (CMP) Sensor
- Clutch Pedal Position (CPP) Switch
- Crankshaft Position (CKP) Sensor
- Cylinder Head Temperature (CHT) Sensor
- Differential Pressure Feedback EGR (DPFE) Sensor
- Electronic Throttle Body (ETB) Position Sensor
- Engine Coolant Temperature (ECT) Sensor
- Engine Oil Temperature (EOT) Sensor
- Fuel Level Input
- Fuel Rail Pressure (FRP) Sensor
- Fuel Rail Pressure Temperature (FRPT) Sensor
- Fuel Rail Temperature (FRT) Sensor
- Fuel Tank Pressure (FTP) Sensor
- Generator Load Input (GENLI)
- Heated Oxygen Sensor (HO2S)
- Intake Air Temperature (IAT) Sensor
- Intake Manifold Runner Control Monitor (IMRCM) - Electric Actuated
- Intake Manifold Runner Control Monitor (IMRCM) - Vacuum Actuated
- Knock Sensor (KS)
- Mass Air Flow (MAF) Sensor
- Output Shaft Speed (OSS) Sensor
- Power Steering Pressure (PSP) Switch
- Power Steering Pressure (PSP) Sensor
- Power Take-Off (PTO) Switch and Circuits
- Starter Motor Request (SMR) Circuit
- Throttle Position (TP) Sensor
- Transmission Control Switch (TCS)
- Vehicle Speed Sensor (VSS)
- Four-Wheel Drive (4WD) Mode Switch
- Powertrain Control Module (PCM) Outputs
- Air Conditioning Clutch Relay (A/CCR)
- Canister Vent (CV) Solenoid
- Coil Pack
- Coil On Plug (COP)
- Engine Crank/Engine Running
- CMP FMEM
- Electric EGR (EEGR) System
- EGR System Module (ESM)
- EGR Vacuum Regulator (EVR) Solenoid
- Electric Secondary Air Injection Pump
- Evaporative Emission (EVAP) Canister Purge Valve
- Fan Control
- Fuel Cap Indicator Lamp
- Fuel Injectors
- Fuel Pressure Regulator Control (FPRC) Solenoid
- Generator Regulator Control (GENRC)
- High Fan Control
- Idle Air Control (IAC) Solenoid
- Intake Manifold Runner Control (IMRC) - Electric Actuated
- Intake Manifold Runner Control (IMRC) - Vacuum Actuated
- Intake Manifold Tuning Valve (IMTV)
- Low Fan Control
- Medium Fan Control
- Reverse Lamp Control (RLC)
- Secondary Air Injection Bypass Solenoid
- Transmission Control Indicator Lamp (TCIL)
- Vapor Management Valve (VMV)
- Powertrain Control Module - Vehicle Speed Output (PCM-VSO)
- Wide Open Throttle A/C Cut-Off (WAC)
- Integrated Electronic Ignition (EI) System
- Returnable Fuel System
- Mechanical Returnless Fuel System
- Electronic Returnless Fuel System
- Fuel Pump Module and Reservoir
- Fuel Pump Module
- Fuel Filters
- Fuel Injector
- Fuel Pressure Regulator
- Fuel Rail Pulse Damper
- Inertia Fuel Shutoff (IFS) Switch
- Differential Pressure Feedback EGR (DPFE) System
- Tube Mounted Differential Pressure Feedback EGR (DPFE) Sensor
- Exhaust Gas Recirculation (EGR) Valve
- Highlights of the EEGR System
- Hardware
- Enhanced Evaporative Emission (EVAP) System
- EVAP Canister Purge Valve
- Intake Manifold Runner Control (IMRC) Electric Actuated System
- Intake Manifold Runner Control (IMRC) Vacuum Actuated System
- Throttle Body System Hardware
- Throttle Body Housing
- Electric Secondary AIR System
- Electric AIR Pump
- AIR Bypass Solenoid
- AIR Diverter Valve
- Variable Cam Timing (VCT) System
- Heated Tubes
- PCV Valves
- Catalytic Converter
- Light Off Catalyst
- Three-Way Catalyst (TWC) Conversion Efficiency
- Exhaust System
- Underbody Catalyst
- Three-Way Catalytic Converter
- Exhaust Manifold Runners
- Exhaust Pipes
- Heated Oxygen Sensors (HO2S)
- Muffler
- Supercharger Bypass (SCB) System
- Intercooler System
- Electronic Throttle Body (ETB)
- Electronic Throttle Control (ETC) System Strategy
- Accelerator and Throttle Position (TP) Sensor Inputs
- Throttle Plate Position Controller (TPPC) Outputs
- Fuel Select Switch Circuit
- Fuel Rails
- Fuel Injector Control Module (FICM)
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- Inspection and Verification
- ICP Self-Diagnostic Mode
- Symptom Chart
- PINPOINT TEST C: THE AUDIO DOES NOT OPERATE CORRECTLY - RESPONSE TIME BETWEEN PRESSING ANY OF THE ICP BUTTONS, AND SYSTEM RESPONSE TIME IS MORE THAN TWO SECONDS
- PINPOINT TEST F: POOR RECEPTION
- PINPOINT TEST G: POOR QUALITY/DISTORTED SOUND FROM ONE OR MORE SPEAKERS (NOT ALL SPEAKERS)
- PINPOINT TEST I: POOR QUALITY/DISTORTED SOUND FROM ONE OR MORE SPEAKERS (NOT ALL SPEAKERS) - POP OR CRACKLE WHEN DRIVEN OVER BUMPS
- PINPOINT TEST J: POOR QUALITY/DISTORTED SOUND FROM ONE OR MORE SPEAKERS (NOT ALL SPEAKERS) - EXHIBITS HUM
- PINPOINT TEST M: LOUD POPPING SOUND WHEN CYCLING THE IGNITION SWITCH
- Inspection and Verification
- Remote Climate Control Module Self-Test
- Powertrain Control Module Diagnostic Trouble Code (DTC) Index
- Remote Climate Control Module Diagnostic Trouble Code (DTC) Index
- Symptom Chart
- PINPOINT TEST J: THE A/C DOES NOT OPERATE/DOES NOT OPERATE CORRECTLY
- PINPOINT TEST K: THE A/C IS ALWAYS ON
- Heater Core-Pressure Test
- Heater Core-Bench Test
- A/C Evaporator/Condenser Core-On-Vehicle Leak Test
- A/C Compressor-External Leak Test
- Diagnostic Table
- Restraint System Diagnostic Tool Warning
- Diagnosing Customer Concerns Without Hard DTCs
- Diagnosing Customer Concerns with Hard DTCs
- Air Bag/Pretensioner Restraint System Diagnostic Tools
- Diagnostic Test Modes
- Diagnostic Trouble Codes (DTCs)
- Restraints Control Module (RCM) Diagnostic Trouble Code (DTC) Priority Table
- Inspection and Verification
- Symptom Chart
- PINPOINT TEST A: THE AIR BAG WARNING INDICATOR IS ILLUMINATED CONTINUOUSLY - RCM DISCONNECTED OR INOPERATIVE, LOSS OF IGNITION FEED, OR LOSS OF SIGNAL GROUND
- PINPOINT TEST B: DTC B1869 - LAMP AIR BAG WARNING INDICATOR CIRCUIT OPEN OR SHORT TO GROUND
- PINPOINT TEST C: DTC B1870 - AIR BAG INDICATOR CIRCUIT SHORT TO BATTERY
- PINPOINT TEST D: LFC 18/DTC B1884 - PAD WARNING LAMP CIRCUIT FAILURE
- PINPOINT TEST E: LFC 18/DTC B1890 - PAD WARNING LAMP CIRCUIT SHORT TO BATTERY
- PINPOINT TEST F: LFC 53/DTC B1891 - AIR BAG TONE WARNING INDICATOR CIRCUIT SHORTED TO VOLTAGE
- PINPOINT TEST G: LFC 53/DTC B1892 - AIR BAG TONE WARNING INDICATOR CIRCUIT FAILURE
- PINPOINT TEST H: LFC 14/DTC B1921 - AIR BAG DIAGNOSTIC MONITOR GROUND CIRCUIT OPEN
- PINPOINT TEST I: LFC 16/DTC B2290 - OCCUPANT CLASSIFICATION SYSTEM (OCS) FAULT
- PINPOINT TEST J: LFC 33 AND 34/DTC B2292 - RESTRAINT SYSTEM - SAFETY BELT PRETENSIONER STATUS
- PINPOINT TEST K: LFC 19 AND 21/DTC B2293 - RESTRAINT SYSTEM - AIR BAG STATUS
- PINPOINT TEST L: LFC 22 AND 23/DTC B2295 - RESTRAINT SYSTEM - SIDE AIR BAG STATUS
- PINPOINT TEST M: LFC 42, 43, AND 44/DTC B2296 - RESTRAINT SYSTEM - IMPACT SENSOR STATUS
- PINPOINT TEST N: LFC 51/DTC B2434 - DRIVER SAFETY BELT BUCKLE SWITCH CIRCUIT SHORT TO GROUND
- PINPOINT TEST O: LFC 51/DTC B2435 - DRIVER SAFETY BELT BUCKLE SWITCH RESISTANCE OUT OF RANGE
- PINPOINT TEST P: LFC 52/DTC B2438 - PASSENGER SAFETY BELT BUCKLE SWITCH CIRCUIT SHORT TO GROUND
- PINPOINT TEST Q: LFC 52/DTC B2439 - PASSENGER SAFETY BELT BUCKLE SWITCH RESISTANCE OUT OF RANGE
- PINPOINT TEST R: LFC 51/DTC B2691 - DRIVER SAFETY BELT BUCKLE SWITCH CIRCUIT FAULT
- PINPOINT TEST S: LFC 52/DTC B2692 - PASSENGER SAFETY BELT BUCKLE SWITCH CIRCUIT FAULT
- PINPOINT TEST T: LFC 16/DTC B2909 - BELT TENSION SENSOR FAULT
- PINPOINT TEST U: LFC 15/DTC C1414 - INCORRECT MODULE DESIGN LEVEL
- PINPOINT TEST V: LFC 49/DTC C1947 - SEAT TRACK POSITION SWITCH CIRCUIT SHORT TO GROUND
- Pinpoint Test W: LFC 49/DTC C1948 - Seat Track Position Switch Circuit Resistance Out of Range
- PINPOINT TEST X: LFC 49/DTC C1981 - SEAT TRACK POSITION SWITCH CIRCUIT FAULT
- PINPOINT TEST Y: NO COMMUNICATION WITH THE RESTRAINTS CONTROL MODULE (RCM)
- Inspection and Repair After a Supplemental Restraint System (SRS) Deployment
- Engine Controls - Introduction (Except Diesel & Hybrid) 3
- Engine Controls - Symptom Charts (Except Diesel & Hybrid) 2
- Engine Controls - Pinpoint Tests (Except Diesel & Hybrid)
- Engine Controls - Diagnostic Methods (Except Diesel & Hybrid) 8
- Engine Controls - Description & Operation (Except Diesel & Hybrid) 7
- Engine Controls - Powertrain DTC Charts & Description (Except Diesel & Hybrid)