BUZZERS, RELAYS & TIMERS
| Component | Location |
|---|---|
| A/C Wide Open Throttle (WOT) Relay | In battery junction box. |
| Battery Saver Relay | In central junction box. |
| Daytime Running Lamps (DRL) Relay | In battery junction box. |
| Engine Cooling Fan Relay | In central junction box. |
| Fog Lamp Relay | In battery junction box. |
| Fuel Pump Relay | In battery junction box. |
| High Beam Relay | In battery junction box. |
| High Speed Engine Cooling Fan Relay | In battery junction box. |
| Horn Relay | In central junction box. |
| Ignition Relay | In battery junction box. |
| Low Beam Relay | In battery junction box. |
| One-Touch Window Relay | In driver's front door, behind trim panel. |
| Power Hold Relay | In battery junction box. |
| Rear Window Defrost Relay | In central junction box. |
| Rear Wiper Relay | In central junction box. |
| Starter Relay | In central junction box. |
| Stop Lamp Relay | In battery junction box. |
| Windshield Wiper Relay | In central junction box. |
BUZZERS, RELAYS & TIMERS LOCATION
CIRCUIT PROTECTION DEVICES
| Component | Location |
|---|---|
| A/C Compressor Clutch Diode | In right front corner of engine compartment. (Схема №6) |
| Battery Junction Box (BJB) | In left rear corner of engine compartment. (Схема №5) |
| Central junction box | Behind left side of dash. |
| Cooling Fan Motor Diode | In battery junction box. |
| Diode | In battery junction box. |
CIRCUIT PROTECTION DEVICES LOCATION
CONTROL UNITS
| Component | Location |
|---|---|
| ABS Control Module | In left rear corner of engine compartment, under master cylinder. (Схема №5) |
| Air Bag Diagnostic Monitor | Under center console, forward of park brake lever. |
| Anti-Theft/Central Locking Module | Behind right side of dash, at base of "A" pillar. |
| Central Timer Module | On rear of central junction box. |
| Electronic Stability Program (ESP) Module | On left side of engine compartment. |
| Fuel Pump Driver Module | Under right rear seat. (Схема №9) |
| Inlet Manifold Runner Control (IMRC) Module (2.0L CVH) | On rear of engine. (Схема №2) |
| Passive Anti-Theft Transceiver Module | On upper right side of steering column. |
| Powertrain Control Module (PCM) | Behind right side of dash, at base of "A" pillar. |
| Side Air Bag Module (Left) | Under left front seat. |
| Side Air Bag Module (Right) | Under right front seat. |
| Speed Control Module | On center of firewall. (Схема №5) |
CONTROL UNITS LOCATION
MOTORS
| Component | Location |
|---|---|
| Engine Cooling Fan Motor | In left front of engine compartment, behind radiator. |
| Fuel Tank Unit | On top rear of fuel tank. |
| Heater Blower Motor | Behind right side of dash. |
| Rear Window Wiper Motor (3 Door/Wagon) | In tailgate, behind trim. |
| Recirculation Air Actuator | Behind right side of dash, next to blower motor. |
| Second Cooling Fan Motor | In right front of engine compartment, behind radiator. |
| Two-Way Washer Pump Motor | On bottom of washer fluid reservoir. |
| Windshield Wiper Motor | On top center of firewall. |
MOTORS LOCATION
SENDING UNITS & SENSORS
| Component | Location |
|---|---|
| Camshaft Position Sensor (2.0L CVH) | On right rear of cylinder head. (Схема №2) |
| Camshaft Position Sensor (2.0L ZETEC-E) | On right rear of cylinder head. (Схема №4) |
| Crankshaft Position Sensor (2.0L CVH) | On right front of engine, near crankshaft pulley. (Схема №2) |
| Crankshaft Position Sensor (2.0L ZETEC-E) | On lower left rear of engine. (Схема №3) |
| Cylinder Head Temperature Sensor (2.0L ZETEC-E) | On right front of cylinder head, near generator. (Схема №4) |
| Engine Coolant Temperature (ECT) Sensor (2.0L CVH) | On rear of cylinder head, below ignition coil. (Схема №1) |
| Exhaust Pressure Transducer (EPT) Sensor | On left side of firewall, near brake master cylinder. (Схема №5) |
| Fuel Gauge Sensor | Integral to fuel tank unit. |
| Fuel Rail Pressure Transducer Sensor (2.0L CVH) | On right side of engine, mounted on fuel rail. (Схема №2) |
| Fuel Rail Pressure Transducer Sensor (2.0L ZETEC-E) | On right side of engine, above generator. (Схема №4) |
| Fuel Tank Pressure Transducer Sensor | On top rear side of fuel tank. |
| Heated Oxygen Sensor (HO2S) No. 21 (2.0L CVH) | On front left side of engine, on exhaust downpipe. (Схема №1) |
| Heated Oxygen Sensor (HO2S) No. 21 (2.0L ZETEC-E) | On front left side of engine, on exhaust downpipe. (Схема №3) |
| Heated Oxygen Sensor (HO2S) No. 22 (2.0L CVH) | On exhaust downpipe, downstream of catalytic converter. |
| Heated Oxygen Sensor (HO2S) No. 22 (2.0L ZETEC-E) | On exhaust downpipe, downstream of catalytic converter. |
| Knock Sensor (2.0L CVH) | On right side of engine. |
| Knock Sensor (2.0L ZETEC-E) | On right side of cylinder block, under intake manifold. (Схема №4) |
| Mass Airflow (MAF) Sensor | On left side of engine compartment, behind battery. |
| Output Shaft Speed (OSS) Sensor | On right side of transmission. |
| Side Air Bag Sensor (Left) | Under left front seat. |
| Side Air Bag Sensor (Right) | Under right front seat. |
| Steering Position Sensor | On steering column. |
| Throttle Position Sensor (TPS) (2.0L CVH) | On throttle body. (Схема №2) |
| Throttle Position Sensor (TPS) (2.0L ZETEC-E) | On throttle body. (Схема №4) |
| Transmission Range Sensor (2.0L CVH) | On left side of transmission. (Схема №1) |
| Transmission Range Sensor (2.0L ZETEC-E) | On left side of transmission. |
| Turbine Shaft Speed (TSS) Sensor (2.0L CVH) | On top rear of transmission. (Схема №1) |
| Turbine Shaft Speed (TSS) Sensor (2.0L ZETEC-E) | On top rear of transmission. |
| Vehicle Speed Sensor (VSS) (2.0L CVH) | On right side of transmission, near driveshaft flange. (Схема №2) |
| Vehicle Speed Sensor (VSS) (2.0L ZETEC-E) | On right side of transmission, near driveshaft flange. (Схема №4) |
| Wheel Speed Sensor (4) | On respective wheel hub. |
SENDING UNITS & SENSORS LOCATION
SOLENOIDS & SOLENOID VALVES
| Component | Location |
|---|---|
| Electronic Vacuum Regulator (EVR) Solenoid Valve | On left side of firewall, near brake master cylinder. (Схема №5) |
| Evaporative Emission (EVAP) Canister Purge Valve | In left rear corner of engine compartment. (Схема №7) |
| Evaporative Emission (EVAP) Canister Vent Valve | On evap canister, under right rear of vehicle. |
| Idle Speed Control Valve (2.0L CVH) | On right side of engine, below throttle body. (Схема №2) |
| Idle Speed Control Valve (2.0L ZETEC-E) | On right side of engine, on intake manifold. |
| Transmission Hardware Unit (2.0L CVH) | Inside transmission. (Схема №1) |
| Transmission Hardware Unit (2.0L ZETEC-E) | Inside transmission. |
SOLENOIDS & SOLENOID VALVES LOCATION
SWITCHES
| Component | Location |
|---|---|
| A/C Compressor Cycling Switch | In left rear corner of engine compartment. (Схема №7) |
| Brake Fluid Level Switch | On top of master cylinder reservoir. (Схема №5) |
| Brake Pedal Position Switch | Under left side of dash, on lower right side of pedal bracket. |
| Clutch Pedal Position Switch | Under left side of dash, on left side of pedal bracket. |
| Dual Pressure Switch | In right front corner of engine compartment. (Схема №6) |
| Engine Compartment Switch | In front center of engine compartment. |
| Inertia Fuel Shut-Off (IFS) Switch | Behind right kick panel. (Схема №8) |
| Oil Pressure Switch (2.0L CVH) | On right side of cylinder block. (Схема №2) |
| Oil Pressure Switch (2.0L ZETEC-E) | On right side of cylinder block, near oil filter. (Схема №4) |
| Park Brake Switch | Under center console, at base of park brake lever bracket. |
| Park/Neutral Position (PNP) Switch (2.0L CVH) | On lower left side of transmission. |
| Park/Neutral Position (PNP) Switch (2.0L ZETEC-E) | On top rear of transmission. (Схема №3) |
| Power Steering Pressure Switch (2.0L CVH) | Near left front of cylinder head, on power steering pump. (Схема №1) |
| Power Steering Pressure Switch (2.0L ZETEC-E) | Near left front of cylinder head, on power steering pump. (Схема №3) |
| Seat Belt Buckle Switch | On driver's side seat belt latch. |
| Start Inhibit Switch | Under left side of dash, on left side of pedal bracket. |
| Stoplamp Switch | Under left side of dash, on upper right side of pedal bracket. |
| Tailgate/Decklid Anti-Theft Switch (Wagon) | On center of tailgate, near locking mechanism. |
SWITCHES LOCATION
MISCELLANEOUS
| Component | Location |
|---|---|
| Anti-Theft Horn | Above left rear fenderwell. |
| Data Link Connector (DLC) | Under left side of dash, on central junction box. |
| Daytime Running Lamps Resistor | In left rear corner of engine compartment. |
| Engine Cooling Fan Resistor | In front of engine compartment, near engine cooling fan. |
| Heater Blower Series Resistor | Under right side of dash, next to blower motor. |
| Horn | In left front corner of engine compartment, behind bumper bracket. |
| Ignition Coil (2.0L CVH) | On rear of cylinder head. (Схема №1) |
| Ignition Coil (2.0L ZETEC-E) | On rear of cylinder head. (Схема №3) |
| Ignition Coil Capacitor (2.0L ZETEC-E) | On rear of cylinder head, beside ignition coil. (Схема №3) |
| Ignition Transformer Capacitor (2.0L CVH) | On rear of cylinder head, beside ignition coil. (Схема №1) |
| Second Horn | In left front corner of engine compartment, behind bumper bracket. |
| Subwoofer Amplifier | In luggage compartment. |
MISCELLANEOUS LOCATION
CONNECTORS
| Component | Location |
|---|---|
| C30 (Black, 10 Pin) | Under driver seat. |
| C31 (Black, 10 Pin) | Under passenger seat. |
| C41 (Black, 20 Pin) | At left "A" pillar. |
| C42 (Gray, 20 Pin) | At left "A" pillar. |
| C43 (Black, 20 Pin) | At right "A" pillar. |
| C45 (Black, 15 Pin) | At left "A" pillar. |
| C46 (Black, 15 Pin) | At right "A" pillar. |
| C48 (Gray, 13 Pin) | In luggage compartment. |
| C50 (Blue, 16 Pin) | In luggage compartment. |
| C51a (Black, 71 Pin) | At left "A" pillar. |
| C51b (Black, 71 Pin) | At left "A" pillar. |
| C57 (Black, 5 Pin) | At left "A" pillar. |
| C58 (Black, 5 Pin) | In luggage compartment. |
| C59 (Black, 5 Pin) | In luggage compartment. |
| C61 (Black, 36 Pin) | At right "A" pillar. (Схема №8) |
| C62 (Black, 11 Pin) | At right "A" pillar. |
| C63 (Black, 15 Pin) | At right "A" pillar. |
| C67 (Gray, 10 Pin) | Behind center of dash. |
| C70 (Gray, 40 Pin) | At left "A" pillar. |
| C71 (Brown, 40 Pin) | At left "A" pillar. |
| C73 (2 Pin) | At left front side of engine compartment. |
| C80 (Black, 16 Pin) | At left rear of engine compartment. (Схема №5) |
| C87 (2 Pin) | At rear of vehicle underbody. |
| C90 (Black/Gray, 16 Pin) | On engine. |
| C91 (Black, 16 Pin) | At left rear of engine compartment. (Схема №7) |
| C92 (Gray, 14 Pin) | At left rear of engine compartment. (Схема №7) |
| C95 (2.0L CVH) (Gray, 16 Pin) | At left side of engine compartment. (Схема №1) |
| C95 (2.0L ZETEC-E) (Gray, 16 Pin) | At left side of engine compartment. (Схема №3) |
| C96 (2.0L CVH) (Black, 16 Pin) | At left side of engine compartment. (Схема №1) |
| C107 (3 Door) (Gray, 2 Pin) | In tailgate. |
| C107 (4 Door) (Gray, 2 Pin) | In deck lid. |
| C107 (Wagon) (Gray, 2 Pin) | In tailgate. |
| C376 (Gray, 3 Pin) | In dash. |
| C555 (Gray, 4 Pin) | At left side of engine compartment. (Схема №5) |
| C556 (Gray, 4 Pin) | At left side of engine compartment. (Схема №5) |
| C557 (Gray, 2 Pin) | Under right side of dash. |
| C558 (Gray, 2 Pin) | Under right side of dash. |
| C789 (Gray, 2 Pin) | In center of dash. |
CONNECTORS LOCATION
GROUNDS
| Component | Location |
|---|---|
| G1 | At left side of engine compartment. |
| G8 | On cylinder head. |
| G13 | At left "A" pillar. |
| G14 | At left "A" pillar. |
| G15 | At left "A" pillar. |
| G24 | At right "A" pillar. (Схема №8) |
| G34 | In tailgate. |
| G35 | In tailgate. |
| G37 | At front left of engine compartment. |
| G41 | At right "A" pillar. |
| G43 | At right "A" pillar. |
| G46 (3 Door) | At left side of luggage compartment. |
| G46 (4 Door) | At left side of luggage compartment. |
| G46 (Wagon) | At left "D" pillar. |
| G47 (3 Door) | At right side of luggage compartment. |
| G47 (4 Door) | At right side of luggage compartment. |
| G47 (Wagon) | At right "D" pillar. |
| G53 | At right "A" pillar. (Схема №8) |
| G54 | Under right rear seat. (Схема №9) |
| G55 | At left front of engine compartment. |
| G56 | At right front of engine compartment. |
GROUNDS LOCATION