Manual a/c circuit for Ford Explorer II (1994-2003)

.25 OHMS +/- 10% .8 OHMS +/- 10% 2.7 OHMS +/- 10% BLOWER MOTOR RESISTOR (NEAR BLOWER MOTOR) 5.0L A/C COMPRESSOR CLUTCH SOLENOID (LEFT FRONT SIDE OF ENGINE COMPARTMENT) A/C PRESSURE CUTOFF SWITCH (NEAR BREAKOUT TO A/C COMPRESSOR CLUTCH SOLENOID) A/C RELAY (MOUNTED IN BATTERY JUNCTION BOX) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) FUSE 1 BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) BLOWER MOTOR RELAY (IN BATTERY JUNCTION BOX) BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUNCTION SELECTOR SWITCH ASSEMBLY FUSE 10 FUSE 2 FUSE 6 GRN WIRE GRY WIRE HIGH MH ML HIGH SPEED BLOWER RELAY (IN AUXILIARY RELAY BOX 1) HOT AT ALL TIMES HOT IN RUN ILLUMI- NATION LT BLU WIRE LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MED MODE SELECTOR SWITCHES NCA WIRE OFF OFF PANEL PANEL/FLOOR NORM A/C FLOOR MAX A/C DEF/FLR DEFROST ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PANEL/FLOOR PANEL FLOOR NORM A/C DEF/FLR MAX A/C DEFROST PCM POWER RELAY (MOUNTED IN BATTERY JUNCTION BOX AT RIGHT FENDER APRON) PNK PNK WIRE PNK WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) REAR BLOWER MOTOR (IN REAR OF CENTER CONSOLE) REAR BLOWER MOTOR RESISTOR (IN CENTER CONSOLE) REAR INTEGRATED CONTROL PANEL (RICP) (REAR BLOWER SWITCH) RED WIRE RED/ORG WIRE RED/YEL WIRE SOLID STATE SUPPLEMENTAL RESTRAINTS SYSTEM TEMPERATURE CONTROL POTENTIOMETER VIO WIRE WARM COLD WHT WIRE YEL WIRE YEL/RED WIRE

41 69 86 A/C DEMAND SIGNAL A/C CLUTCH RELAY CTRL A/C CLUTCH RELAY OUTPUT A/C CLUTCH RELAY A/C CLUTCH SOLENOID (CENTER FRONT OF ENGINE COMPARTMENT) A/C HIGH PRESSURE SWITCH (AT FRONT CENTER OF ENGINE COMPARTMENT) AUXILIARY RELAY BOX 1 (RIGHT SIDE OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) (LEFT SIDE OF ENGINE COMPARTMENT, AT FENDER APRON) BLK WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR RELAY BRN WIRE BRN/ORG WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM FRONT HEATER BLOWER MOTOR (RIGHT SIDE OF ENGINE COMPARTMENT) FUSE GRN/RED WIRE GRY WIRE GRY/WHT WIRE GRY/YEL WIRE HIGH SPEED FAN CONTROL RELAY HOT AT ALL TIMES HOT IN HOT IN RUN OR START LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PCM MODULE POWER DIODE PCM POWER RELAY PNK WIRE PNK/LT BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (PCM) (MOUNTED THROUGH FIREWALL) RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/YEL WIRE RUN WIRE VIO WIRE W/HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE WHT WIRE YEL WIRE YEL/BLK WIRE

AIR TEMP DR RESISTOR - IGNITION GROUND AIR TEMP DR RESISTOR WIPER AIR TEMP DR RESISTOR + BLK WIRE BLK/LT GRN WIRE BLOWER MOTOR SWITCH BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DEFROST MAX FRONT FUNCTION SELECTOR SWITCH ASSEMBLY FUSE GRN/RED WIRE GRY/YEL WIRE HIGH MEDIUM HIGH BLOWER MOTOR SWITCH HOT IN ILLUMINATION INTERIOR LIGHTS SYSTEMS LT BLU/ORG WIRE LT GRN WIRE LT GRN/WHT WIRE MAX DEFROST MEDIUM LOW MEDIUM LOW LOW MIX NORMAL FLOOR VENT OFF MODE SWITCH OFF OFF FLOOR VENT NORMAL MIX ORG/ WIRE ORG/BLK WIRE REAR FUNCTION SELECTOR SWITCH ASSEMBLY (W/HIGH SERIES CENTER CONSOLE) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RUN WIRE TEMPERATURE BLEND DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, TOP OF A/C PLENUM) TEMPERATURE CONTROL POTENTIOMETER VIO WIRE W/HIGH SERIES CENTER CONSOLE W/O HIGH SERIES CENTER CONSOLE YEL WIRE YEL/LT GRN WIRE YEL/RED WIRE