Ford Econoline E150 (1997-2012) hot at all times Wiring diagrams

35 36 IGNITION (ST/RUN) IGNITION (ST/RUN) 45 8 CLUSTER PWR BPP SW BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 23 FUSE 27 FUSE 8 GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE TAN WIRE TAN/WHT WIRE TAN/YEL WIRE WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL/BLK WIRE

24 45 8 REV LMP CTRL KAPWR BPP SW 27 1 4 5 6 16 17 18 28 47 48 49 50 10 OD CANCEL SW VSS APPA_+ 35 36 VPWR VPWR APPA_- APPB_+ APPB_- AUXILIARY RELAY BOX 1 (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) FUSE 23 BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DK BLU/WHT WIRE DK GRN WIRE DK GRN/ORG WIRE ENDS IN HARNESS ENGINE CONTROLS SYSTEM FUSE 11 FUSE 2 FUSE 21 FUSE 27 FUSE 8 GROUND GROUND GROUND GROUND GROUND GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/RED WIRE NCA WIRE OD OFF OVERDRIVE CANCEL SWITCH OVERHEAD CONSOLE (IF EQUIPPED) PCM POWER DIODE PCM POWER RELAY RED WIRE RED/LT GRN WIRE RED/YEL WIRE REVERSING LAMP RELAY TAN WIRE TAN/WHT WIRE TAN/YEL WIRE W/ ADVANCE TRAC W/ REMOTE KEYLESS ENTRY OR ADVANCE TRAC W/ STRIPPED CHASSIS WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE YEL/BLK WIRE

BATTERY BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK GRN WIRE DRIVE FUSE 18 FUSE 33 FUSE 7 HOT AT ALL TIMES IGNITION SWITCH LOCK OFF LT BLU WIRE LT GRN WIRE NEUTRAL PARK PNK WIRE RED WIRE REV RUN WIRE STARTER MOTOR (LOWER RIGHT REAR OF ENGINE) STARTER RELAY TAN WIRE VIO WIRE WHT WIRE YEL WIRE

6.8L 6.8L EXCEPT 6.8L ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK/BLU WIRE BLK/GRY (OR BLK/BLU) WIRE BLK/GRY WIRE BLK/YEL WIRE BLU/BRN WIRE BLU/ORG WIRE BPS BRAKE FLUID SW BRAKE FLUID SW RTN BRAKE PEDAL POSITION SWITCH BRN/BLU WIRE BRN/GRN WIRE CAN (+) COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 33 FUSE 47 FUSE 53 FUSE 76 GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES HOT IN START OR RUN ISS LEFT FRONT WHEEL SPEED SENSOR NCA WIRE OSS + OUTPUT SHAFT SPEED (OSS) SENSOR OUTPUT SHAFT SPEED (OSS) SENSOR (TORQSHIFT) (RIGHT REAR OF TRANSMISSION) POWERTRAIN CONTROL MODULE (PCM) (STRIPPED CHASSIS: CENTER REAR OF ENGINE COMPT) RED WIRE RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) SIG RTN SMART JUNCTION BOX (SJB) STRIPPED CHASSIS TRANSMISSION TRANSMISSIONS SYSTEM TRGND TSS TURBINE SHAFT SPEED (TSS) SENSOR TURBINE SHAFT SPEED SENSOR VBATT VIO WIRE VIO/GRN WIRE VIO/ORG WIRE VIO/WHT WIRE VPWR ABS ACTIVE VREF WHEEL SPD LF+ WHEEL SPD LF- WHEEL SPD RF+ WHEEL SPD RF- HS CAN + HS CAN - WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE WIRING HARNESS, NEAR BREAKOUT TO TORQSHIFT TRANS- MISSION) YEL WIRE YEL/GRY WIRE YEL/ORG WIRE

15 2 9 8 IND CTRL SW CAN+ CAN- 6 14 DATA LINK CONNECTOR (LEFT SIDE OF DASH) ABS IND. ABS TEST CONNECTOR (LEFT FRONT CORNER OF ENG COMPT) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/YEL WIRE BRAKE PRESSURE SWITCH (LEFT SIDE OF ENG COMPT) BRK PRESS SW CAN 2 HIGH CAN 2 LOW CAN LOW CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CHASSIS GND COIL B+ CAN HIGH DK GRN WIRE FUSE 11 FUSE 19 FUSE 2 FUSE 22 FUSE 6 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START INSTRUMENT CLUSTER LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LT BLU/RED WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/BLK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE RED WIRE RED/PNK WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) STABILITY CONTROL SENSOR CLUSTER (CENTER OF FLOOR) STABILITY/ TRACTION CONTROL RELAY STABILITY/TRACTION CONTROL SWITCH STEERING ANGLE INPUT STEERING WHEEL ROTATION SENSOR (BOTTOM OF STEERING COLUMN) STOP LAMP SW TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VBATT VPWR VPWR WHT WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

ANTI-LOCK BRAKE SYSTEM (ABS) MODULE (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) (LEFT FRONT OF ENGINE COMPT) BLK/BLU WIRE BLK/GRY (OR BLK/BLU) WIRE BLK/GRY WIRE BLK/YEL WIRE BLU WIRE BLU/ORG WIRE BRAKE BRAKE FLUID FLUID SW SW RTN BRN WIRE BRN/GRN WIRE COMPUTER DATA LINES COMPUTER DATA LINES SYSTEM EXCEPT STRIPPED CHASSIS FUSE 33 GRN WIRE GRN/VIO WIRE GROUND GRY WIRE GRY/BRN WIRE GRY/VIO WIRE HOT AT ALL TIMES HS CAN+ LEFT FRONT WHEEL SPEED SENSOR (LEFT FRONT WHEEL HUB ASSEMBLY) LEFT REAR WHEEL SPEED SENSOR (LEFT REAR WHEEL HUB ASSEMBLY) LF_SEN+ LF_SEN- LR_SEN- LR_SEN+ RR_SEN+ RR_SEN- GROUND MICRO - NCA WIRE ORG/ WIRE RED WIRE RF_SEN+ RF_SEN- RIGHT FRONT WHEEL SPEED SENSOR (RIGHT FRONT WHEEL HUB ASSEMBLY) RIGHT REAR WHEEL SPEED SENSOR (RIGHT REAR WHEEL HUB ASSEMBLY) SMART JUNCTION BOX (SJB) STEER ANGLE 1 STEER ANGLE 2 STEER SENS GND STRIPPED CHASSIS SUPPLEMENTAL RESTRAINTS SYSTEM SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM VBATT HS CAN + VBATT VPWR VIO WIRE VIO/ORG WIRE VIO/WHT WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE YEL/GRY WIRE

BACK-UP LAMPS CIRCUIT BLK WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY ELECTRONIC FLASHER MODULE (BEHIND LEFT SIDE OF DASH) EXCEPT CUTAWAY FUSE 10 FUSE 7 GRN WIRE HAZARD SWITCH HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER LEFT FRONT PARK/ TURN LAMP RIGHT FRONT PARK/ TURN LAMP LEFT REAR LAMP ASSEMBLY (CUTAWAY) LEFT REAR PARK/ STOP/ TURN LAMP LEFT TURN LEFT TURN IND LICENSE PLATE LAMP LT BLU WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAIN LIGHT SWITCH MICROPROCESSOR MULTI- FUNCTION SWITCH NCA WIRE OFF HEAD ORG/ WIRE ORG/LT BLU WIRE OVERHEAD (AT RIGHT CONSOLE FRONT OF (IF EQUIPPED) ENG COMPT) PARK (IN MAIN WIRING HARNESS, NEAR BREAKOUT TO INSTRUMENT CLUSTER) PNK WIRE RED WIRE RIGHT REAR LAMP ASSEMBLY (CUTAWAY) RIGHT REAR PARK/ STOP/ TURN LAMP RIGHT TURN RIGHT TURN IND TAN WIRE TO LEFT TURN TRAILER TOW RELAY (DIAGRAM 2 OF 3) TO PARKING LAMP TRAILER TOW RELAY (DIAGRAM 2 OF 3) TO RIGHT TURN TRAILER TOW RELAY (DIAGRAM 2 OF 3) W/ REMOTE KEYLESS ENTRY WHT WIRE WHT/LT BLU WIRE YEL WIRE

AUXILIARY BATTERY RELAY (RIGHT FRONT OF ENGINE COMPT, NEAR BATTERY) BACK-UP LAMPS CIRCUIT BATTERY 2 BATTERY CHARGE TRAILER TOW RELAY BATTERY JUNCTION BOX (BJB) BATTERY JUNCTION BOX (BJB) (DIESEL: AT RIGHT FRONT OF ENGINE COMPT) BLK WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CLASS I CLASS II CLASS II CLASS I CUTAWAY: ENDS IN HARNESS DIESEL EXCEPT DIESEL DK BLU WIRE DK GRN WIRE EXCEPT DIESEL, W/ AUXILIARY BATTERY EXCEPT DIESEL, W/ AUXILIARY BATTERY JUMPER FUSE 10 FUSE 20 FUSE 24 FUSE 26 FUSE 8 HOT AT ALL TIMES HOT IN RUN FUSE 12 HOT IN RUN OR ACC FUSE 15 LEFT TURN TRAILER TOW RELAY LT GRN WIRE LT GRN/ORG WIRE ORG/ WIRE ORG/LT BLU WIRE PARKING LAMP TRAILER TOW RELAY PNK WIRE RED WIRE RED/YEL WIRE REVERSING LAMP TRAILER TOW RELAY TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR (AT LEFT KICK PANEL) TRAILER TOW CONNECTOR (4-PIN) (UNDER OF REAR BUMPER) TRAILER TOW CONNECTOR (7 PIN) (CLASS II) (UNDER REAR BUMPER) TRAILER TOW CONNECTOR (7-PIN) (UNDER REAR BUMPER) VIO WIRE W/O AUXILIARY BATTERY WHT WIRE WHT/VIO WIRE YEL WIRE

ABS CONTROL MODULE (W/ ADVANCE TRAC) (LEFT FRONT OF ENGINE COMPT) ABS CONTROL MODULE (W/O ADVANCE TRAC) (LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX (BJB) BLK WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE SHIFT INTERLOCK (ON STEERING COLUMN) CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CUTAWAY DK GRN WIRE EXCEPT CUTAWAY FROM MULTIFUNCTION SWITCH (DIAGRAM 1 OF 3) FUSE 11 FUSE 39 GRN WIRE HIGH MOUNTED STOPLAMP HOT AT ALL TIMES LT GRN WIRE LT GRN/RED WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT) RED WIRE RESISTOR STABILITY/ TRACTION CONTROL RELAY (W/ ADVANCE TRAC) TO TRAILER ELECTRONIC BRAKE CONTROL CONNECTOR (DIAGRAM 2 OF 3) W/ ADVANCE TRAC WHT WIRE

16-WAY STRIPPED CHASSIS CONNECTOR BLK WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER 44 DK BLU WIRE DK GRN WIRE FUSE 9 HOT AT ALL TIMES HOT IN RUN OR ACC LT BLU WIRE LT GRN WIRE MULTI- FUNCTION SWITCH 1 2 3 4 5 6 7 8 9 ORG/ WIRE RED WIRE WASH OFF INT 1 INT 2 INT 3 INT 4 INT 5 LOW HIGH WASH WHT WIRE YEL WIRE