Ford Econoline E150 (1997-2012) hot at all times Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 DATA LINK CONN BPP SWITCH INPUT 7.3L ABS CONTROL MODULE (AT LEFT SIDE OF ENGINE COMPT) ANTI-LOCK BRAKE INDICATOR BATTERY JUNCTION BOX (BJB) (IN LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BRAKE FLUID LEVEL SWITCH (AT LEFT SIDE OF ENGINE COMPT) BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE WARNING INDICATOR DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK GRN WIRE ELECTRONIC CRASH SENSOR (ECS) MODULE (BEHIND RIGHT SIDE OF DASH) FUSE 1 FUSE 11 FUSE 19 GRN WIRE GROUND VBATT GROUND VBATT BRAKE WARNING LAMP LOW HOT AT ALL TIMES HOT IN RUN IGNITION SWITCH INSTRUMENT CLUSTER LEFT FRONT SENSOR (LOW) RIGHT FRONT SENSOR (LOW) REAR SENSOR (LOW) LEFT FRONT WHEEL SPEED SENSOR (BEHIND LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE NCA WIRE PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (NEAR BRAKE MASTER CYLINDER) RED WIRE RED/PNK WIRE RIGHT FRONT WHEEL SPEED SENSOR (BEHIND RIGHT FRONT WHEEL) RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE VACUUM WARNING SWITCH VIO/WHT WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

3 11 MS CAN + MS CAN - 4.6L, 5.4L 6.8L DIESEL ABS TEST CONNECTOR (W/ ADVANCE TRAC) (GAS: LEFT FRONT CORNER OF ENGINE COMP) AUDIO CONTROL MODULE (ACM) BLK/BLU WIRE BLK/GRY WIRE BRN WIRE CAN (+) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) FEPS FUSE 20 GRN/RED WIRE GRY/ORG WIRE HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) MS CAN + PARKING AID MODULE (PAM) (IF EQUIPPED) (UNDER LEFT SIDE OF DASH) POWERTRAIN CONTROL MODULE (PCM) (LEFT REAR OF ENGINE COMPT) RESTRAINTS CONTROL MODULE (RCM) (UNDER DRIVER'S SEAT) SMART JUNCTION BOX (SJB) (LEFT KICK PANEL) MS MS CAN- CAN+ TRAILER BRAKE CONTROL (TBC) MODULE (TOP CENTER OF DASH) VIO/ORG WIRE W/ ADVANCE TRAC W/ PARKING AID W/O ADVANCE TRAC WHT WIRE WHT/BLU WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE CENTRAL JUNCTION BOX (CJB) (LEFT SIDE OF DASH, NEAR KICK PANEL) CUTAWAYS DK GRN/ORG WIRE FUSE 22 FUSE 27 FUSE 3 FUSE 36 GRY/LT BLU WIRE HINGED SIDE DOOR HOT AT ALL TIMES HOT IN HOT IN PARK OR HEAD HOT IN RUN OR ACC ILLUMINATION GROUND NOISE REDUCTION LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE NCA WIRE NOT USED ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER RIGHT SLIDING DOOR CONTACT SWITCH SLIDING SIDE DOOR TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

360 648 1145 1146 570 527 (ENDS IN HARNESS) AIR CONDITIONING SYSTEM BATTERY JUNCTION BLK/LT BLU WIRE BLK/WHT WIRE BLK/YEL WIRE BOX (LEFT FRONT OF ENGINE COMPT) BRN/PNK WIRE CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DATA LINK CONNECTOR (PARTIAL) (LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE EGR SOL CTRL NOT USED F GAUGE SENDER PRGRM SIGNAL FUSE 20 FUSE 8 FUSE 4 FUSE 9 GROUND GROUND IGN COIL 1 TCIL GROUND IGN COIL GRY WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IAT INPUT FUEL PUMP OUT A/C ON SIG IMRC IGNITION COIL (LEFT FRONT OF ENGINE) IGNITION TRANSFORMER CAPACITOR 1 (ATTACHED TO IGNITION COIL) IMRC MONITOR INSTRUMENT CLUSTER SYSTEM 29 107 KS + LT BLU/BLK WIRE LT GRN/RED WIRE MAF RTN TFTS INPUT NCA WIRE OD CANCEL SW OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE SCP BUS SCP BUS SPARK PLUGS SPARK PLUGS SPARK PLUGS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TO DTR SENSOR (DIAGRAM 4 OF 4) TRANSMISSION CONTROL INDICATOR LAMP VIO WIRE VIO/ORG WIRE WATER TEMP SENS WHT/LT GRN WIRE WHT/PNK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/WHT WIRE

BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (TOP RIGHT FRONT OF ENGINE) DK BLU WIRE DK BLU/LT GRN WIRE DK BLU/YEL WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE GAUGE ENGINE COOLANT TEMPERATURE SENDER (TOP FRONT CENTER OF ENGINE) EXCEPT STRIPPED CHASSIS FUEL PUMP RELAY FUEL TANK PRESSURE TRANSDUCER SENSOR (UNDER LEFT CENTER OF VEHICLE) FUSE 17 GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES INSTRUMENT CLUSTER INTAKE MANIFOLD RUNNER CONTROL MODULE (ON REAR OF INTAKE) LT BLU/ORG WIRE MALFUNCTION INDICATOR ORG/BLK WIRE ORG/YEL WIRE PNK/LT GRN WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE STRIPPED CHASSIS TAN/LT BLU WIRE THROTTLE POSITION SENSOR (ON TOP OF ENGINE, NEAR AIR INTAKE) VIO/ORG WIRE WHT/LT GRN WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

240 OHMS A/C SYSTEM BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (ON FRONT CENTER OF ENGINE) CENTRAL JUNCTION BOX (BELOW LEFT SIDE OF DASH, NEAR LEFT KICK PANEL) DIGITAL TRANSMISSION RANGE (DTR) SENSOR (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DK GRN/VIO WIRE DPFE INPUT CHT INPUT CANISTER VENT VSS (+) A/C RLY CNTRL EVAPORATIVE EMISSIONS CANISTER VENT SOLENOID (REAR OF VEHICLE, NEAR FUEL TANK) FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS FUSE 11 GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR 11 HEATED OXYGEN SENSOR 12 HEATED OXYGEN SENSOR 21 HEATED OXYGEN SENSOR 22 HEATER CTRL HOT AT ALL TIMES IAC CTRL OSS (-) CMP SENSOR INJ 5 CTRL INJ 3 CTRL INJ 1 CTRL GND GND IGN COIL TCIL FUEL PUMP CTRL EPC SOL INJ 6 CTRL INJ 4 CTRL INJ 2 CTRL LT BLU/ORG WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE MAF SENS OUT TP SENS IN REF OUTPUT VOLT SIG RTN BRAKE ON/OFF MASS AIR FLOW SENSOR (ON TOP (CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT REAR OF ENGINE COMPT, NEAR MASTER CYLINDER) RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/YEL WIRE TCC SOL KAP B(+) EVAP VALVE KNOCK SENSOR VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C SYSTEM AIR CTRL SENS EVR SOL TACH SIG BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/ WHT WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/PNK WIRE CAPACITOR 2 CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 2 COIL ON PLUG COIL ON PLUG 6 DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE ENDS IN HARNESS EXCEPT STRIPPED CHASSIS FUSE 27 FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANSFORMER KNOCK SENSOR LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT MAF VPWR A/C ON SIG MISFIRE SENS (+) MISFIRE SENS (-) NCA WIRE OD OFF ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 21 PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 3 COIL ON PLUG 4 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/ORG WIRE WHT/ BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN WIRE BRN/LT GRN WIRE BRN/PNK WIRE BRN/WHT WIRE BUS (+) BUS (-) FUEL LEVEL VREF CRANKSHAFT POSITION SENSOR (LOWER RIGHT FRONT OF ENGINE) DIFFERENTIAL PRESSURE FEEDBACK EGR SENSOR (TOP LEFT REAR OF ENGINE) DK BLU WIRE DK GRN/YEL WIRE EXCEPT STRIPPED CHASSIS FUEL PUMP RELAY FUSE 13 GRY WIRE GRY/RED WIRE GRY/WHT WIRE HEATED POSITIVE CRANKCASE VENTILATION (PCV) ELEMENT (TOP OF RIGHT CYLINDER BANK) HOT AT ALL TIMES INJECTION PRESSURE SENSOR (TOP LEFT SIDE OF ENGINE) INSTRUMENT CLUSTER LT BLU/ORG WIRE LT BLU/RED WIRE MALFUNCTION INDICATOR LAMP NCA WIRE ORG/BLK WIRE ORG/YEL WIRE PNK/LT BLU WIRE PNK/WHT WIRE RED WIRE RED/LT GRN WIRE RED/PNK WIRE STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE THROTTLE POSITION SENSOR (ON TOP OF ENGINE, NEAR AIR INTAKE) VIO/ORG WIRE WHT/RED WIRE YEL WIRE YEL/WHT WIRE

240 OHMS BLK/LT GRN WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION SENSOR (FRONT OF LEFT CYLINDER HEAD) CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU/YEL WIRE DK GRN WIRE DPFE SENS CYL HEAD TEMP EVAP SOL VSS (+) EXCEPT STRIPPED CHASSIS FROM DTR SENSOR (DIAGRAM 1 OF 4) FUEL TANK PRESS IPS SENSOR FUSE 11 GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/WHT WIRE HEATED OXYGEN SENSOR HEATER CTRL HOT AT ALL TIMES IAC SOL OSS (+) CYLINDER ID LT BLU WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/RED WIRE MAF SENS IN TP SENS IN MASS AIR FLOW SENSOR (TOP CENTER OF ENGINE COMPT) NCA WIRE OVER- HEAD CONSOLE PNK/LT BLU WIRE PNK/WHT WIRE PWR GND COIL ON PLUG 2 RED WIRE RED/BLK WIRE RED/LT GRN WIRE RED/PNK WIRE RED/WHT WIRE SIG RTN BRAKE ON/OFF STRIPPED CHASSIS TAN WIRE TAN/BLK WIRE TAN/LT BLU WIRE TAN/RED WIRE TAN/YEL WIRE VIO/LT GRN WIRE VIO/WHT WIRE VIO/YEL WIRE VPWR FUEL INJ 8 FUEL INJ 6 FUEL INJ 4 FUEL INJ 2 VSS INPUT WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C SYSTEM BATTERY JUNCTION BOX (LEFT SIDE OF ENGINE COMPT) BLK/ WHT WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BRN/ORG WIRE BRN/PNK WIRE CAPACITOR 2 CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FUSE 2 COAST SOL MISFIRE SENS (+) MISFIRE SENS (-) COIL ON PLUG COIL ON PLUG 6 DATA LINK (-) DATA LINK (+) DATA LINK CONNECTOR (LEFT SIDE OF DASH) 10 2 DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK GRN/VIO WIRE ENDS IN HARNESS EVR SOL TACH SIG EXCEPT STRIPPED CHASSIS FUSE 27 FUSE 8 GRY WIRE HOT AT ALL TIMES HOT IN RUN OR START IGNITION TRANSFORMER KNOCK SENSOR LT BLU/BLK WIRE LT BLU/RED WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MAF TFT MAF VPWR A/C ON SIG NCA WIRE OD OFF ORG/BLK WIRE ORG/LT BLU WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH PCM POWER DIODE PCM POWER RELAY FUSE 21 PNK/LT BLU WIRE PNK/WHT WIRE PWR GND PWR GND COIL ON PLUG 3 COIL ON PLUG 4 PWR GND GND COIL ON PLUG 1 COIL ON PLUG 5 RED WIRE RED/LT GRN WIRE RED/YEL WIRE SHIFT SOL A SHIFT SOL B TCIL IND FEPS (EPROM) STRIPPED CHASSIS TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TCIL LAMP TCS TO DTR SENSOR (DIAGRAM 4 OF 4) VIO WIRE VIO/LT BLU WIRE VIO/ORG WIRE WHT/ BLK WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE