Ford Club Wagon E350 (1996-1998) lt grn Wiring diagrams

ACCY B+ B- BLK WIRE BLK/ORG WIRE BRN WIRE CHARGE INDICATOR ENGINE COMPART- MENT FUSE BOX ENGINE COMPARTMENT BATTERY FUSE 23 FUSE LINK A (12 GA- FUSE LINK B (12 GA- FUSE LINK C 18 GA- GENERATOR/ REGULATOR GROUND DISTRIBUTION SYSTEM GRY WIRE I/P FUSE PANEL FUSE 14 IGNITION SWITCH INSTRUMENT CLUSTER LOCK OFF LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/LT BLU WIRE RED WIRE RED/LT GRN WIRE RUN WIRE STARTING CIRCUIT WHT/BLK WIRE WHT/YEL WIRE YEL WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

1 2 4.2L/4.6L 5.4L/6.8L 1 2 7 4 ANTI-LOCK IND RELAY CTRL BRAKE SWITCH BRAKE IND 4 WHEEL ANTI- LOCK BRAKES MODULE (ON LEFT FRONT FRAME RAIL) 45 12 9 ECT SIGNAL FUEL SIGNAL 1 2 AIR BAG IND ANTI-LOCK BRAKE IND ANTI-LOCK BRAKES SYSTEM BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CNG GAS CONN A CONN B CONN C CRUISE CONTROL DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE FASTEN SEATBELT IND FUEL PUMP MODULE (UNDER VEHICLE, IN FUEL TANK) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GND IGNITION SWITCH GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INSTRUMENTATION ENGINE COOLANT TEMPERATURE SENSOR (ON FRONT OF ENGINE) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND MIL IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PNK/ORG WIRE POWERTRAIN CONTROL MODULE (NEAR BRAKE MASTER CYLINDER) PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER STARTING/ CHARGING SYSTEM 608 1044 SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN WIRE TAN/LT GRN WIRE VANS, WAGONS CUTAWAYS VEHICLE SPEED SENSOR (UNDER VEHICLE, ON LEFT SIDE OF TRANS) VOLTMETER VSS SIGNAL W/ DRL W/O DRL WARNING SYSTEMS 603 932 WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/LT BLU WIRE YEL/RED WIRE YEL/WHT WIRE

464 643 (W/ ELEC FUEL PUMP) 643 464 (W/O ELECTRIC FUEL PUMP) 977 904 608 1044 STARTING/ CHARGING SYSTEM AIR BAG IND ANTI-LOCK BRAKE IND BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE WARNING IND CHARGE IND CONN A CONN B CONN C DAYTIME RUNNING LAMPS MODULE (IN RIGHT FRONT OF ENGINE COMPARTMENT, NEAR HORNS) DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE DUAL BRAKE WARNING SWITCH (BOTTOM OF MASTER CYLINDER) ENGINE COOLANT TEMPERATURE GAUGE ENGINE OIL PRESSURE GAUGE ENGINE OIL PRESSURE SWITCH (ON TOP RIGHT CENTER OF ENGINE) FASTEN SEATBELT IND FUEL FILTER IND (W/O ELECTRIC FUEL PUMP) FUEL WATER SWITCH (TOP RIGHT CENTER OF ENGINE) FUSE 14 FUSE 2 FUSE 36 FUSE 4 GRY/BLK WIRE GRY/WHT WIRE HEADLIGHTS SYSTEM HIGH BEAM IND HOT AT ALL TIMES HOT IN PARK OR HEAD HOT IN RUN OR START IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF DASH) LEFT TURN IND LOW OIL PRESS/HI COOLANT TEMP IND LT BLU WIRE LT BLU/RED WIRE LT GRN WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MALFUNCTION (MIL) IND OFF LOCK PARKING BRAKE SWITCH (NEAR LEFT KICK PANEL) PNK/LT GRN WIRE PPL/WHT WIRE PPL/YEL WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RED/YEL WIRE RELAY (BEHIND CENTER OF DASH) RIGHT TURN IND RUN WIRE SPEEDO- METER SUPPLEMENTAL RESTRAINTS SYSTEM TACHO- METER TAN/LT GRN WIRE VOLTMETER W/ DRL W/O DRL W/ ELEC FUEL PUMP W/O ELEC FUEL PUMP WAIT TO START IND WAIT TO START IND (W/O ELECTRIC FUEL PUMP) WARNING SYSTEMS 603 932 WATER IN FUEL IND (W/ ELECTRIC FUEL PUMP ONLY) WATER IN FUEL IND (W/O ELECTRIC FUEL PUMP) WATER IN FUEL SENSOR (TOP LEFT CENTER OF ENGINE) WHT WIRE WHT/LT BLU WIRE WHT/RED WIRE WHT/YEL WIRE YEL WIRE YEL/WHT WIRE

BLK WIRE DRIVER'S SEAT MOTOR ASSEMBLY DRIVER'S SEAT REGULATOR CONTROL SWITCH ENTIRE SEAT FRONT HEIGHT MOTOR FRONT OF SEAT FUSE 16 FWD RWD FWD/ RWD MOTOR HOT AT ALL TIMES I/P FUSE PANEL (BELOW LEFT SIDE OF DASH) LT BLU WIRE LT GRN WIRE NCA WIRE REAR HEIGHT MOTOR REAR OF SEAT RED WIRE UP DN WHT WIRE YEL WIRE

ANTENNA BLK WIRE BLK/LT GRN WIRE BRN/PNK WIRE BUTTON CONTACT CUTAWAYS DIMMER DK GRN/ORG WIRE FUSE 10 FUSE 22 FUSE 27 FUSE 3 GRY/LT BLU WIRE HINGED DOOR HOT AT ALL TIMES HOT IN HOT IN RUN OR ACC I/P FUSE PANEL I/P FUSE PANEL FUSE 36 LEFT FRONT DOOR SPEAKER LEFT MID SPEAKER (W/ 6 SPEAKERS) LEFT REAR SPEAKER LT BLU WIRE LT BLU/RED WIRE LT BLU/WHT WIRE LT GRN WIRE MAIN LIGHT SWITCH NCA WIRE NOT USED OFF HEAD PARK ORG/LT GRN WIRE ORG/RED WIRE RADIO RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SPEAKER RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT MID SPEAKER (W/ 6 SPEAKERS) RIGHT REAR SPEAKER SLIDING DOOR TAN WIRE TAN/LT GRN WIRE TAN/YEL WIRE VANS, WAGONS WHT WIRE WHT/LT GRN WIRE YEL WIRE YEL/BLK WIRE

APP REF VOLT RTN AUX TACH FEED AUXILIARY POWERTRAIN CONTROL CONNECTOR (PARTIAL) (BEHIND LEFT SIDE OF DASH) BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BRAKE ON/OFF SWITCH BRAKE PRESS SW BRAKE PRESSURE SWITCH (LEFT SIDE OF ENGINE COMPT, BOTTOM OF MASTER CYL) BRAKE WARNING IND BRN/ORG WIRE BUS - CAM POS SENS CRUISE CONTROL SYSTEM DK GRN WIRE DK GRN/LT GRN WIRE DLC EBP ENGINE OIL TEMPERATURE SENSOR (CENTER LEFT SIDE OF ENGINE) EOT FUSE 17 FUSE 20 FUSE 2 FUSE 4 FUSE 8 FUSE 9 GLOW PLUG RELAY GRN WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE HORN/SPEED CTRL HOT AT ALL TIMES HOT AT ALL TIMES ENGINE COMPARTMENT FUSE BOX FUSE 11 HOT IN RUN OR START HOT IN RUN OR START I/P FUSE PANEL FUSE 8 I/P FUSE PANEL IAT IDLE VALIDATION SW IDLE VALIDATION SWITCH (OPEN AT IDLE) (LEFT SIDE OF DASH) IDM RELAY INJECTION PRESSURE REGULATOR (TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM INTAKE AIR TEMPERATURE SENSOR (CENTER OF ENGINE COMPT, PART OF CLEAN AIR TUBE) LT GRN DK GRN/ WIRE LT GRN WIRE LT GRN/RED WIRE MALFUNCTION INDICATOR LAMP ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE PCM DLC PCM POWER DIODE PCM POWER RELAY PNK/LT BLU WIRE PNK/LT GRN WIRE PNK/ORG WIRE PPL PPL 13 10 2 DATA LINK CONNECTOR (PARTIAL) (BELOW LEFT SIDE OF DASH) PPL/LT BLU WIRE PPL/ORG WIRE RED WIRE RED/LT GRN WIRE RED/ORG WIRE RED/WHT WIRE RED/YEL WIRE SHIELD GND SW GND TAN/ORG WIRE TAN/WHT WIRE TCIL TCS TFT VSS GND WAIT TO START INDICATOR WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT GRN WIRE YEL/RED WIRE

A/C ON SIG ACCELERATOR PEDAL POSITION SENSOR (LEFT SIDE OF DASH, ABOVE ACCEL PEDAL) ACCL POS SENS AIR COND- ITIONING SYSTEM BARO BAROMETRIC PRESSURE (BARO) SENSOR (BELOW LEFT SIDE OF DASH) BLK WIRE BLK/LT BLU WIRE BLK/PNK WIRE BLK/WHT WIRE BLK/YEL WIRE BOO BRN/ORG WIRE BRN/WHT WIRE CAMSHAFT POSITION (CMP) SENSOR (FRONT CENTER OF ENGINE) CID SIG CMP RTN CRUISE CONTROL SYSTEM DK BLU/LT GRN WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE ECT EPC EPR EXHAUST BACK PRESSURE (EBP) SENSOR (TOP CENTER OF ENGINE) EXHAUST PRESSURE REGULATOR (TOP REAR OF ENGINE) FUEL DELIV SIG GLOW PLUG CTRL GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE ICP+ IDM ENABLE OUT IDM SIG IN INJECTION CONTROL PRESSURE (ICP) SENSOR (ON TOP OF ENGINE) INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM IPR KAPWR LT BLU WIRE LT BLU/BLK WIRE LT BLU/RED WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/BLK WIRE MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR (TOP RIGHT SIDE OF ENGINE COMPT) MAP NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE OVERDRIVE CANCEL SWITCH TCS PNK WIRE PNK/ORG WIRE PPL/LT BLU WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE SIG RTN SPEED CTRL SIG SPEEDOMETER TAN/WHT WIRE TCC TCIL VEHICLE SPEED SENSOR (LEFT SIDE OF TRANSMISSION) VPWR VREF VSS VSS IN WAIT TO START IND WHT/LT GRN WIRE WHT/PNK WIRE WHT/YEL WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE YEL/LT GRN WIRE YEL/RED WIRE

BLK/LT BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) BRAKE PRESSURE SWITCH BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/YEL WIRE CID SIG IN COAST CLUTCH SOLENOID ELECTRONIC PRESSURE CONTROL SOLENOID DIGITAL TRANSMISSION RANGE SENSOR (DTR SENSOR) (LEFT SIDE OF TRANSMISSION) DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/LT GRN WIRE DK GRN/YEL WIRE FUEL DELIVERY SIG FUEL INJ FEED LEFT FUEL INJ FEED RIGHT FUEL INJECTORS/ GLOW PLUGS FUEL LINE HEATER (TOP CENTER OF ENGINE) FUSE 8 FUSE LINK (20 GA- FUSE LINK D (14 GA- FUSE LINK E (14 GA- GLOW PLUG RELAY (TOP RIGHT SIDE OF ENGINE) GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN RUN OR START I/P FUSE PANEL FUSE 11 IDM FEEDBACK SIG INJ SHIELD GND INJECTOR DRIVER MODULE LT BLU WIRE LT BLU/YEL WIRE LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE NCA WIRE ORG/ WIRE ORG/BLK WIRE ORG/YEL WIRE P, 2, 1 P, N, 1 P, R, 2 P, R, N PNK/ORG WIRE PNK/YEL WIRE PPL/ORG WIRE PPL/YEL WIRE PWR GND RED WIRE RED/LT GRN WIRE SIG RTN SIGNAL RETURN SOLENOID TAN WIRE TAN/BLK WIRE TAN/RED WIRE TORQUE CONVERTER CLUTCH SOLENOID TRANSMISSION TRANSMISSION FLUID TEMPERATURE SENSOR VPWR WHT WIRE WHT/YEL WIRE YEL/LT BLU WIRE