Ford Club Wagon E350 (1996-1998) fuse 1 Wiring diagrams

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHERS ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ YEL WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE C (IN MAIN HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED YEL/ WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ PREMIUM SOUND SYSTEM W/DRL W/O DRL W/O DRL W/DRL WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BUS - DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) FUSE 1 HOT AT ALL TIMES INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PNK BUS- WIRE PNK/LT BLU WIRE PPL PPL GENERIC SCAN TOOL INPUT RED WIRE TAN WIRE TAN/ORG WIRE WHT WIRE

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHERS ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ YEL WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE C (IN MAIN HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED YEL/ WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ PREMIUM SOUND SYSTEM W/DRL W/O DRL W/O DRL W/DRL WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BUS - DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) FUSE 1 HOT AT ALL TIMES INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PNK BUS- WIRE PNK/LT BLU WIRE PPL PPL GENERIC SCAN TOOL INPUT RED WIRE TAN WIRE TAN/ORG WIRE WHT WIRE

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE ABS DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR BRAKE WARNING INPUT DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE A (ENGINE CONTROL SENSOR HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM (DIODE C) INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LOW VACUUM WARNING SWITCH (LEFT FRONT OF ENGINE COMPARTMENT) LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ DRL W/O DRL W/DRL W/O DRL WHT WIRE YEL BLK/ WIRE YEL RED/ WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

4 WABS RELAY 4 WHEEL ANTI-LOCK 4 WHEEL ANTI-LOCK BRAKES 497 498 495 496 PNK WIRE 5.8L FEDERAL OVER 8600 GVW, 7.5L EXCEPT CALIF. W/O DRL ALL OTHERS ANTI-LOCK BRAKE INDICATOR BLK TAN/ WIRE BLK WIRE BLK/ YEL WIRE BLK/ORG WIRE BLK/WHT WIRE BRAKE FLUID LEVEL SW MODULE POWER BRAKE SW INPUT BRAKE INDICATOR OUT PARK BRAKE ON INPUT BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE WARNING INDICATOR DAYTIME RUNNING LAMPS (DRL) MODULE (LOWER RIGHT FRONT OF ENGINE, NEAR HORNS) DIODE C (IN MAIN HARNESS) DK GRN WIRE DK GRN/YEL WIRE EMF CTRL OUTPUT ENGINE COMPARTMENT FUSE PANEL (LEFT SIDE OF ENGINE COMPARTMENT) FUSE 1 FUSE 17 FUSE 18 FUSE U FUSE V GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN HOT IN START OR RUN IGNITION SWITCH INSTRUMENT CLUSTER INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LAMP GROUND BRAKE WARNING IND REAR SPEED INPUT ABS IND CTRL LEFT FNT SIG GROUND LEFT FRONT DUMP VALVE LEFT FRONT ISO VALVE LEFT FRONT WHEEL SENSOR (AT LEFT FRONT WHEEL) LOCK OFF LT BLU WIRE LT BLU/PNK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NOT USED ORG TAN/ WIRE ORG/ WIRE ORG/YEL WIRE PARKING BRAKE SWITCH (ABOVE LEFT COWL PANEL) PNK WIRE PNK/LT BLU WIRE PNK/LT GRN WIRE POWER GROUND 2 PPL PPL PPL PPL/WHT WIRE PPL/YEL WIRE PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) PUMP MOTOR (ON LEFT FRONT FRAME RAIL) PUMP MOTOR POWER REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR DUMP VALVE REAR ISO VALVE REAR RESET REAR RESET SWITCH RED WIRE RED YEL/ WIRE RED/PNK WIRE RED/YEL WIRE RIGHT FNT SIG GROUND REAR SIG GROUND RIGHT FRONT DUMP VALVE RIGHT FRONT ISO VALVE RIGHT FRONT WHEEL SENSOR (AT RIGHT FRONT WHEEL) RLY CTRL OUTPUT SERIAL COMMUNICATION RUN WIRE TAN WIRE TAN/BLK WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/RED WIRE W/ PREMIUM SOUND SYSTEM W/DRL W/O DRL W/O DRL W/DRL WHT WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

BLK WIRE BLK/WHT WIRE BUS - DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF I/P) FUSE 1 HOT AT ALL TIMES INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE PNK BUS- WIRE PNK/LT BLU WIRE PPL PPL GENERIC SCAN TOOL INPUT RED WIRE TAN WIRE TAN/ORG WIRE WHT WIRE

2 4 5 7 GROUND REAR AXLE SPEED INPUT REAR AXLE SPEED INPUT VEHICLE SPEED OUTPUT 2200 OHMS 4 WHEEL ANTI-LOCK 4-WHEEL ABS SYSTEM 4.9L, 5.0L, 5.8L FEDERAL UNDER 8600 GVW, ALL CALIF. ENGINES 5.8L FEDERAL OVER 8600 GVW, 7.5L FEDERAL ENGINES 9 22 REAR SENSOR LOW REAR SENSOR HIGH BLK WIRE BLK/WHT WIRE BRAKE ON/OFF (BOO) SWITCH (ON BRAKE PEDAL BRACKET) BRAKE PRESSURE INPUT GROUND CLOCK SPRING ASSEMBLY (TOP OF STEERING COLUMN) COAST FUSE 1 FUSE 6 GRY/BLK WIRE HORN HORNS SYSTEM HOT AT ALL TIMES HOT IN ACCY OR RUN INTERIOR FUSE PANEL (BEHIND LEFT SIDE OF I/P) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE NCA WIRE OFF ON ORG/ WIRE ORG/YEL WIRE PNK WIRE PNK/ORG WIRE PPL PROGRAMMABLE SPEEDOMETER/ ODOMETER MODULE (PSOM) (BEHIND LEFT SIDE OF I/P) REAR ANTI-LOCK BRAKE SYSTEM (RABS) MODULE (BEHIND RIGHT SIDE OF I/P) REAR AXLE SPEED SENSOR (BELOW REAR OF VEHICLE, MOUNTED ON DIFFERENTIAL) REAR-WHEEL ABS SYSTEM RED WIRE RED/LT GRN WIRE RED/PNK WIRE RESUME SET/ ACCEL 680 OHMS 120 OHMS SPEED CONTROL/ HORN SWITCH (STEERING COLUMN ASSEMBLY) VEHICLE SPEED SENSOR OR PSOM INPUT (VSS +) WHEEL SPEED SENSOR HIGH WHEEL SPEED SENSOR LOW WHT WIRE WHT/PPL WIRE YEL WIRE