Dodge Pickup R3500 (1996-2010) hot at all times Wiring diagrams

28 30 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 9 10 11 12 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD(-) DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE FUEL PUMP, AUTOMATIC SHUTDOWN RELAYS FUSE 14 FUSE 9 FUSED B(+) TP SENS SIG GND GND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/DK BLU WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

5 VOLT SUPPLY 9 10 11 12 PNK WIRE BLK WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GRN WIRE GRY/BLK WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OVERDRIVE SOLENOID CONTROL VARIABLE FORCE SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE SENSOR GROUND GOVERNOR PRESSURE SIGNAL TAN WIRE TAN/BLK WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTION PUMP) TORQUE CONVERTER CLUTCH SOLENOID CONTROL TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE WHT/ORG WIRE YEL WIRE

2 4 6 8 FUSED IGN (ST/RUN) SENSOR GND PNP SW SENSE ENG SPEED SENS SIG 22 23 31 32 FUSED B(+) TP SENS SIG GND GND 40 41 CCD (-) CCD (+) 6 13 24 25 OD LAMP DRIVER TRANS OD SW SENSE BRAKE SW SENSE GENERATOR OUTPUT 9 10 11 PNK WIRE BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRN WIRE CCD (+) CCD (-) CSI RECEIVE DATA LINK CONNECTOR (PARTIAL) (LEFT BOTTOM OF DASH) DK BLU WIRE DK BLU/BLK WIRE ENGINE CONTROL MODULE ENGINE CONTROL MODULE (LEFT SIDE OF ENG, BEHIND FUEL FILTER) FUSE 14 FUSE 9 GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 JOINT CONNECTOR 3 JOINT CONNECTOR 6 JOINT CONNECTOR 7 JUNCTION BLOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE MIL IND ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVER- DRIVE OFF IND OVERDRIVE SWITCH PNK SCI TRANSIT WIRE PNK WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED/WHT WIRE SENSOR GND SENSOR GROUND ECT SIG CKP SIG TPS SIG ENG SPEED SENS SIG STOP LAMP SWITCH (TOP OF BRAKE PEDAL BRACKET) SWITCH (ON FRONT AXLE TUBE) TAN/BLK WIRE TRANSMISSION OUTPUT SHAFT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE YEL WIRE

5 VOLT SUPPLY 9 10 11 PNK WIRE BLK WIRE BLK/DK BLU WIRE BLK/LT BLU WIRE BLK/WHT WIRE BRN WIRE CONTROLLER ANTI-LOCK BRAKE DK BLU WIRE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (ON LEFT SIDE OF CYLINDER HEAD, AT REAR END) ENGINE SPEED SENSOR (ON FRONT OF ENG, IN TIMING CHAIN CASE/COVER) ENGINE STARTER MOTOR RELAY FUSE FUSE 3 GENERATOR GOVERNOR PRESSURE SIGNAL SENSOR GROUND VARIABLE FORCE SOLENOID CONTROL GRN WIRE GRY WIRE HOT AT ALL TIMES INNER FENDER) JOINT CONNECTOR 2 LT BLU WIRE LT GRN/WHT WIRE OF HYDRAULIC CONTROL UNIT) ORG/ WIRE ORG/BLK WIRE OVERDRIVE SOLENOID CONTROL TORQUE CONVERTER CLUTCH SOLENOID CONTROL PARK/ NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE POWER DISTRIBUTION CENTER RED WIRE RED/WHT WIRE TAN WIRE TAN/BLK WIRE TRANS CTRL RLY OUTPUT TRANSMISSION CONTROL RELAY TRANSMISSION SOLENOID ASSEMBLY (TRANSMISSION) TRANSMISSION TEMPERATURE SENSOR SIGNAL VIO WIRE VIO/WHT WIRE WHT WIRE WHT/ORG WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE BLK/YEL WIRE BRN WIRE BRN/RED WIRE CENTER HIGH MOUNTED STOP LAMP 2 COMBINATION FLASHER DK GRN/BRN WIRE DK GRN/RED WIRE FUSE 10 FUSE 4 FUSE 5 FUSE F GRN WIRE HAZARD HEAD HEADLAMP SWITCH HOT AT ALL TIMES HOT IN ACC OR RUN INSTRUMENT CLUSTER J/C 6 (LEFT SIDE OF DASH) JUNCTION BLOCK LEFT LEFT FRONT PARK/TURN SIGNAL LAMP LEFT LICENSE LAMP LEFT TAIL/ STOP/TURN SIGNAL LAMP LEFT TURN IND LT GRN WIRE LT GRN/TAN WIRE OFF PARK PNK WIRE PNK/DK BLU WIRE PNK/RED WIRE POWER DISTRIBUTION CENTER RED WIRE RED/GRY WIRE RIGHT RIGHT FRONT PARK/TURN SIGNAL LAMP RIGHT LICENSE LAMP RIGHT TAIL/ STOP/TURN SIGNAL LAMP RIGHT TURN IND STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN WIRE TIMING CONTROL TURN SIGNAL/ HAZARD SWITCH (PART OF MULTI- FUNCTION SWITCH) NORMAL VIO WIRE W/ DUAL REAR WHEELS W/O DUAL REAR WHEELS W/O TRAILER TOW W/ TRAILER TOW WHT TAN/ WIRE WHT WIRE WHT/TAN WIRE

1 2 3 4 BATTERY (+) BRAKE (+) STOPLIGHT SW GROUND AFTERMARKET CENTER HIGH MOUNTED STOP LAMP BACK-UP LAMPS CIRCUIT BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLK/YEL WIRE BRN/RED WIRE CENTER IDENTIFICATION LAMP DK GRN/RED WIRE ELECTRIC BRAKE (HIGHLINE) FUSE 8 HOT AT ALL TIMES J/C 1 (IN POWER DISTRIBUTION CENTER) J/C 2 (IN POWER DISTRIBUTION CENTER) LEFT FRONT FENDER LAMP LEFT LICENSE LAMP LEFT OUTBOARD CLEARANCE LAMP LEFT OUTBOARD IDENTIFICATION LAMP LEFT REAR FENDER LAMP LT BLU WIRE ORG/ WIRE POWER DISTRIBUTION CENTER RED WIRE RED/ORG WIRE RIGHT FRONT FENDER LAMP RIGHT OUTBOARD CLEARANCE LAMP RIGHT OUTBOARD IDENTIFICATION LAMP RIGHT REAR FENDER LAMP RIGHT TAILGATE LAMP TAN WIRE TRAILER TOW CONNECTOR OR AFTERMARKET TRAILER TOW CONNECTOR (IF EQUIPPED) TRAILER TOW RELAY (W/ TRAILER PACKAGE) (IN POWER DISTRIBUTION CENTER) VIO/BLK WIRE W/ HIGHLINE ONLY W/0 AFTERMARKET TRAILER TOW WHT WIRE WHT/TAN WIRE

1 2 3 IGNITION TEMP SELECT GROUND A/C COMPRESSOR CLUTCH A/C COMPRESSOR CLUTCH RELAY A/C HEATER CONTROL A/C HEATER TEMPERATURE SELECT A/C HIGH PRESSURE SWITCH (ON DISCHARGE LINE, NEAR A/C COMPRESSOR) A/C LOW PRESSURE SWITCH (ON TOP OF A/C ACCUMULATOR) A/C SELECT INPUT A/C SWITCH SENSE BI-LEVEL BLEND DOOR ACTUATOR BLK WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR RELAY BLOWER MOTOR RESISTOR BLOCK (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER HOUSING) BLOWER MOTOR SPEED SWITCH BLU WIRE BRN WIRE DIESEL DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/YEL WIRE FUSE FUSE 11 FUSE 12 FUSE 2 GASOLINE GRN WIRE HOT AT ALL TIMES HOT IN RUN JUNCTION BLOCK (LEFT END OF DASH) HOT IN RUN OR START ILLUM J/C 1 J/C 8 (BEHIND CENTER OF DASH) LT BLU WIRE LT GRN WIRE LT GRN/WHT WIRE LT LT MED 1 MED 2 MODE SELECT SWITCH ORG/ WIRE PANEL FLOOR RECIRC FLOOR/DEFROST DEFROST OFF PNK WIRE PNK/DK BLU WIRE RELAY CTRL TAN WIRE WHT WIRE YEL WIRE YEL/ORG WIRE

AIRBAG CONTROL MODULE (LOWER CENTER OF DASH) BLK WIRE BLK/LT GRN WIRE BLK/PNK WIRE DK BLU WIRE DRIVER DOOR JAMB SWITCH PASS- ENGER SEAT SOLENOID DRIVER SEAT SOLENOID FAULT SIGNAL FUSE 12 FUSE 16 GROUND HOT AT ALL TIMES HOT IN ACC AND RUN J/C 5 (BEHIND LEFT SIDE OF DASH) JUNCTION BLOCK (RIGHT END OF DASH) LH DOOR AJAR RH DOOR AJAR FUSED IGN FUSED B(+) GROUND LH BELT SOL RH BELT SOL LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE ORG/RED WIRE PAS- SENGER DOOR JAMB SWITCH PNK WIRE RED WIRE SEAT BELT CONTROL MODULE (UNDER FRONT SEAT CENTER CUSHION) TAN WIRE TAN/RED WIRE WARNING SYSTEMS

1 2 3 4 5 6 7 8 TRANS RLY OUT A/C REQUEST A/C SELECT IN BRAKE SW IN GEN FIELD OUT A/T AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL OVERDRV IND BATT TEMP SENS BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CCD(-) CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV CRUISE SW IN DATA LINK CONNECTOR (LEFT BOTTOM OF DASH) DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE FUSE 17 FUSE M GENERATOR HOT AT ALL TIMES HOT AT ALL TIMES JUNCTION BLOCK (RIGHT END OF DASH) FUSE 14 HOT IN RUN OR START IND INSTRUMENT CLUSTER JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR NO 6 (TOP OF STEERING COLUMN, BEHIND INSTRUMENT PANEL) 2 3 LT GRN WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE OFF IND OVERDRIVE SWITCH PNK 4 5 6 WIRE PNK WIRE PNK/DK BLU WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION CENTER (IN ENG COMPT, ON LEFT INNER FENDER PANEL) POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) RED WIRE RED/LT GRN WIRE SCI TRANSMIT CCD BUS (-) SCI RECEIVE CCD BUS (+) SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON TOP OF INJECTOR PUMP) TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WAIT TO WHT/BLK WIRE WHT/DK BLU WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 1 2 3 4 5 6 A/C CLUTCH RLY 31 32 GROUND GROUND A/T A/T (TRANS HARN, IN BREAKOUT TO PDC) AIR CONDI- TIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL AUTOMATIC SHUTDOWN RELAY BATTERY TEMPER- ATURE SENSOR (BELOW BATTERY TRAY) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE BLK/WHT WIRE BRAKE LAMP SWITCH (ON BRAKE PEDAL BRACKET) BRN WIRE CKP ENG SIG (PINS 9-21 NOT USED) 22 23 FUSED B(+) ACC PEDAL POS CONTROLLER ANTI-LOCK BRAKE CRUISE CONTROL SYSTEM CRUISE FEED ASD RELAY SENS TRANS OVERDRV 12 13 14 15 CRUISE SW IN DK BLU WIRE DK BLU/BLK WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE FUEL TANK MODULE (TOP OF FUEL TANK) FUSE 6 FUSE I GEN FIELD DRV TCC DRVR GENERATOR GRY/BLK WIRE HOT AT ALL TIMES IGN (POWER) JOINT CONNECTOR 1 (IN PDC) JOINT CONNECTOR 2 (IN PCD) LT BLU WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE M/T ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT SIDE OF TRANSMISSION) OVERDRV SOL PARK/NEUTRAL POSITION SWITCH (ON LEFT SIDE OF TRANSMISSION) PNK WIRE PNK/DK BLU WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (IN ENG COMPT, ON RIGHT SIDE OF FIREWALL) PRK/NEUTRAL RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/WHT WIRE SENSOR GRD SENSOR GRD GOV PRESS SIG VAR FORCE SOL OVERDRV SOL TCC SOL CTRL TRANS TEMP SNS STARTING/ CHARGING SYSTEM TAN/RED WIRE TRANS- MISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BRN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/BLK WIRE WHT/ORG WIRE WHT/PNK WIRE WHT/VIO WIRE YEL WIRE YEL/RED WIRE