Dodge Pickup R3500 (1996-2010) hot at all times Wiring diagrams

33 42 28 27 APP 1 RET 36 37 6 25 SPEED CTRL BRAKE SW 6.7L 5.9L ACCEL ACCELERATOR PEDAL POSITION SENSOR (BEHIND LEFT SIDE OF DASH) ANTI-LOCK BRAKES MODULE (LEFT REAR OF ENGINE COMPT) APP 1 SIG APP 1 RET APP 2 RET APP 2 SIG APP 2 SIG APP 2 RET APP 1 SIG BLK WIRE BLU WIRE BRAKE SW 1 SIG BRN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE DECEL DK BLU WIRE DK BLU/DK GRN WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FUSE 28 GRN WIRE GRY WIRE HOT AT ALL TIMES LEFT SPEED CONTROL SWITCH OFF ORG/ WIRE PNK EXTERIOR LIGHTS SYSTEM WIRE PNK WIRE REAR OF ENGINE COMPT) RED WIRE RESUME RIGHT SPEED CONTROL SWITCH RWAL AWAL SENS GND S/C SW RET S/C SW 1 SIG S/C SW 2 SIG 33 40 56 46 56 STEERING CONTROL MODULE (ON STEERING COLUMN) STOP LAMP SWITCH (ON BRAKE PEDAL SUPPORT) TAN WIRE TOTALLY INTEGRATED POWER MODULE (AT LEFT FRONT FENDER) FUSE 26 VIO WIRE VIO/BRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE YEL WIRE

3.7L/5.7L 4.7L/ 5.7L A/C HEATER CONTROL AIR BAG CONTROL MODULE (BENEATH LOWER CENTER OF DASH) AUDIO AMPLIFIER (PREMIUM) (BEHIND UPPER RIGHT SIDE OF DASH) BLK/DK GRN WIRE COMPASS/ MINI-TRIP COMPUTER (EXCEPT BASE) CONTROLLER ANTI-LOCK BRAKE (ON LEFT REAR OF ENGINE COMPT) DATA LINK CONNECTOR (DLC) (BELOW LEFT SIDE OF DASH) DK BLU/VIO WIRE FRONT CONTROL MODULE FUSE 51 HOT AT ALL TIMES INSTRUMENT CLUSTER INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT SIDE IMPACT AIR BAG CONTROL MODULE (BASE OF LEFT "B" PILLAR, BEHIND TRIM) LT BLU/VIO WIRE LT GRN WIRE ORG/BLK WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) RADIO RIGHT SIDE IMPACT AIR BAG CONTROL MODULE SCI RECEIVE SCI TRANSMIT SENTRY KEY IMMOBILIZER MODULE (ON TOP OF STEERING COLUMN) TRANSFER CASE CONTROL MODULE TRANSMISSION CONTROL MODULE VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/DK BLU WIRE VIO/DK GRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/PNK WIRE VIO/YEL WIRE WHT/DK GRN WIRE

10 15 14 34 B(+) PARK RLY CTRL TRLR L TURN TRLR R TURN 19 43 44 38 2 17 18 4 RR TURN SIGNAL LEFT BRAKE LP LR TURN SIGNAL PCI BUS 45 42 19 16 RF TURN SIGNAL LF TURN SIGNAL 5 8 HDLP SW SIG TURN SW FEED 9 21 HDLP SW RTN PCI BUS BACK-UP LAMPS CIRCUIT BLK WIRE BLK/ORG WIRE BLK/YEL WIRE BRAKE LAMP SWITCH (ABOVE BRAKE PEDAL, ON SUPPORT BRACKET) BRAKE SW INPUT BRN WIRE BRN/RED WIRE CENTER HIGH MOUNTED STOP LAMP (AFTER- MARKET) CENTER HIGH MOUNTED STOP LAMP/ CARGO LAMP DK BLU WIRE DK GRN WIRE DK GRN/BLK WIRE DK GRN/RED WIRE ELECTRIC BRAKE PROVISION EXCEPT ABS ABS FRONT CONTROL MODULE FUSE 15 FUSE 24 FUSE 32 FUSE 33 FUSE 34 FUSE 46 FUSE 47 HAZARD HEADLAMP SWITCH HOT AT ALL TIMES INSTRUMENT CLUSTER INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) FUSE 1 L TURN LEFT FRONT PARK/ TURN SIGNAL LAMP LEFT TAIL/STOP, TURN SIGNAL LAMP LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/TAN WIRE MULTI- FUNCTION SWITCH OFF HEAD ORG/ WIRE PARK PARK LAMP RELAY PARK/ TURN SIGNAL LAMP PNK PNK WIRE PNK WIRE PNK/ (LEFT FRONT FENDER) WIRE PNK/ RIGHT FRONT FENDER LAMP (DUAL REAR WHEELS) WIRE PNK/ RIGHT REAR FENDER LAMP (DUAL REAR WHEELS) WIRE PNK/VIO WIRE PTC 5 R TURN RED WIRE RED/ORG WIRE RIGHT BRAKE LP RIGHT FRONT RIGHT INSTRUMENT PANEL RIGHT TAIL/ STOP/ TURN SIGNAL LAMP RIGHT LICENSE LAMP TAIL/ STOP LAMP TAIL/ TURN LAMP TAIL/ TURN LAMP TAIL/ STOP LAMP TAILGATE LAMP ASSEMBLY TAN WIRE TRAILER TOW CONNECTOR (BENEATH CENTER OF REAR BUMPER) TRAILER TOW CONNECTOR- ADD ON TRAILER TOW LEFT TURN RELAY TRAILER TOW RIGHT TURN RELAY TURN SW SENSE VIO WIRE VIO/BLK WIRE VIO/BRN WIRE VIO/PNK WIRE VIO/YEL WIRE W/ TRAILER TOW CONNECTOR ADD ON WHT WIRE WHT/LT GRN WIRE WHT/PNK WIRE WHT/RED WIRE WHT/TAN WIRE WHT/VIO WIRE YEL WIRE YEL/PNK WIRE

A/C HEATER CONTROL AUTO HDLP SIG AUTO- STICK SWITCH B(+) BEAM DRV LH HIGH BEAM DRV RH LOW BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/TAN WIRE CAN IHS BUS (-) CIRCUIT BOARD CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/WHT WIRE FOG LP SW SIG FUSE FUSED B (+) GROUND HDLP SW MUX RTN HEADLAMP SWITCH HOT AT ALL TIMES LEFT FRONT FOG LAMP LEFT HEADLAMP LF FOG LP CTRL LH HDLP RTN SIG LH LOW BEAM DRV LP CTRL RF FOG MLFCT SW RTN ORG/BRN WIRE PANEL LP DIM SIG PARKING BRAKE SWITCH (TOP OF PARKING BRAKE PEDAL) PRK BRK SW SENS RED WIRE RH HIGH BEAM DRV RIGHT FRONT FOG LAMP RIGHT HEADLAMP RTN SIG RH HDLP SUN SENSOR TOTALLY INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) WHT WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE

2 3 RF DR LOCK SW LF DR LOCK SW BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE CLUSTER DK BLU WIRE DK GRN WIRE DRIVER DOOR LATCH (DRIVER'S DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH FUSE 2 FUSE 29 FUSE 35 GROUND HOT AT ALL TIMES HOT IN RUN OR START LEFT REAR DOOR LATCH LOCK LT BLU WIRE LT GRN WIRE LT GRN/DK BLU WIRE MEGA CAB/ QUAD CAB PASSENGER DOOR LATCH PASSENGER DOOR LOCK SWITCH PNK WIRE RED WIRE RIGHT REAR DOOR LATCH (MEGA CAB/ QUAD CAB) (RIGHT REAR DOOR) TAN/LT GRN WIRE TAN/ORG WIRE TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) UNLOCK VIO WIRE VIO/DK GRN WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE

A/C PRESSURE TRANSDUCER (NEAR A/C COMPRESSOR) A/C SIG AMBIENT TEMPERATURE SENSOR (LEFT UNDERSIDE OF HOOD) ANTI-LOCK BRAKES SYSTEM BLK/LT BLU WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE BRN/WHT WIRE COIL DRIVER 2 COIL DRIVER 1 COIL DRIVER 7 INJ 8 DRIVER INJ 7 DRIVER DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/RED WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE COOLANT TEMPERATURE SENSOR ENGINE OIL PRESSURE SWITCH FUSE 19 FUSED B(+) IGN (START) GEN FIELD ECT SENS IN TP SENS SIG GROUND GRY WIRE GRY/LT BLU WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN (RUN-STRT) IGN (RUN-STRT) VSS IGNITION SWITCH INJ 4 DRIVER INJ 3 DRIVER INJ 2 DRIVER INJ 1 DRIVER TP SENS RET INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LEFT KNOCK SENSOR LOCK OFF LT BLU/BRN WIRE LT BLU/RED WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/BLK WIRE MAP SENS SIG KNOCK 1 RET KNOCK 1 SIG OIL PRES SIG A/C PRES SIG IDLE AIR 1 ORG/ WIRE ORG/DK BLU WIRE PCI BUS PNK SCI TRANSMIT WIRE PNK WIRE PNK/LT BLU WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTC 1 RED/WHT WIRE RUN WIRE SCI RECEIVE SCI TRANSMIT SENS GND SENSOR GND STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE TRANSMISSIONS SYSTEM VIO/BRN WIRE VIO/LT GRN WIRE VIO/TAN WIRE VIO/WHT WIRE VSS SIG 2 GROUND WHT WIRE WHT/DK BLU WIRE YEL WIRE YEL/BLK WIRE YEL/WHT WIRE

AUTO SHUTDOWN RELAY BLK/LT BLU WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/PNK WIRE COIL ON PLUG DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTOR FUEL PUMP RELAY FUSE 17 FUSE 2 GRY WIRE GRY/LT BLU WIRE HOT AT ALL TIMES HOT IN RUN OR START INTEGRATED POWER MODULE (ON LEFT FRONT OF ENGINE COMPT) LT BLU/BRN WIRE LT BLU/RED WIRE ORG/ WIRE ORG/DK BLU WIRE PNK/LT BLU WIRE PTC 1 TAN WIRE TAN/DK GRN WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/PNK WIRE TAN/RED WIRE TAN/WHT WIRE VIO/TAN WIRE VIO/WHT WIRE WHT WIRE WHT/DK BLU WIRE YEL/WHT WIRE

5 VOLT SPLY SENS GND SOL CTRL APPS 1 SIG APPS 2 SIG BRAKE SIG 2 BRAKE SIG 1 B(+) BATTERY TEMPERATURE SENSOR (UNDER BATTERY TRAY) BLK WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN B BUS (+) COIL SIG COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CTRL A/C CLUTCH DK BLU/DK GRN WIRE DK BLU/VIO WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE ELECTRONICS ENGINE CONTROL MODULE (LOWER LEFT FRONT OF ENGINE BLOCK) FP CTRL FUEL HTR CTRL OUT FUEL PMP CTRL OUT FUSE 28 FUSE 42 FUSE 6 FUSED B (+) FUSED B (+) GND FUSED B(+) A/C CLUTCH CTRL HOT AT ALL TIMES HOT IN RUN OR START TOTALLY INTEGRATED POWER MODULE (LEFT FRONT FENDER) LT BLU/ORG WIRE ORG/ WIRE ORG/RED WIRE PNK/GRY WIRE PNK/YEL WIRE PWM FAN SIG OSS SIG SENS GND S/C SW 1 SIG BATT TEMP SIG APPS 2 RET GND GND RADIATOR FAN DRIVE (FRONT OF ENGINE COMPT) RED WIRE RED/ORG WIRE RUN/START SENS GND SENS SIG SNS SOL CTRL 3-4 SOL CTRL STARTING/ CHARGING SYSTEM TEMP SENS SIG FUSED B(+) TRANS CTRL TRANS CTRL INTAKE RLY CTRL F/P CTRL TRANS CTRL OUT TRANSMISSION RANGE SENSOR (LEFT SIDE OF TRANSMISSION) TTVA POS SENS VIO WIRE VIO/BRN WIRE VIO/YEL WIRE WHT WIRE WHT/BRN WIRE WHT/ORG WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE

A/C PRESS SIG AUTO SHUT DOWN RELAY BLK/DK GRN WIRE BLK/GRY WIRE BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BRN WIRE BRN/DK BLU WIRE BRN/WHT WIRE BRN/YEL WIRE CALIF CAM POS SNS IDLE AIR 4 IDLE AIR 1 CAPACITOR CONTROLLER ANTI-LOCK BRAKE (LEFT REAR OF ENG COMPT) DK BLU WIRE DK BLU/BLK WIRE DK BLU/TAN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DK GRN/WHT WIRE FUEL INJECTORS FUEL PUMP RELAY FUSE 19 FUSE 17 FUSE 2 FUSED B(+) TPS SENS IN GROUND GROUND GRY WIRE GRY/BLK WIRE GRY/LT BLU WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES IAT SENS IN ECT SENS IN IGNITION COIL (LEFT) IGNITION COIL (RIGHT) INTEGRATED POWER MODULE (LEFT FRONT OF ENG COMPT) LEFT FRONT FENDER) LT BLU/BRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE MAP SENS IN NO 1 DRVR NO 2 DRVR NO 3 DRVR NO 4 DRVR NO 5 DRVR OIL PRESS SIG ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE OUTPUT SENS OUTPUT SPEED SENSOR (ON LEFT REAR OF TRANSMISSION) OVERDRV SOL PNK WIRE POWERTRAIN CONTROL MODULE (ON RIGHT SIDE OF FIREWALL) PTO SW SENS RED/WHT WIRE RED/YEL WIRE RLY OUT STARTING/CHARGING SYSTEM SWITCH TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TAN/YEL WIRE TO FUSE 49 (DIAGRAM 3 OF 3) TRANSMISSION RANGE SENSOR (ON LEFT SIDE OF TRANSMISSION) VAR FRCE SOL VIO WIRE VIO/BLK WIRE VIO/TAN WIRE VIO/WHT WIRE VSS IN OUTPUT SENS GOV PRESS SIG TRANS RELAY WHT/DK BLU WIRE WHT/ORG WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 TRANS RLY OUT 5-VOLT A/C PRESSURE TRANSDUCER (ON LEFT SIDE OF A/C COMPRESSOR) AIR CONDITIONING SYSTEM AUTO SHT RLY CRUISE VAC SOL CRUISE VNT SOL BLK/LT BLU WIRE BLK/RED WIRE BLK/TAN WIRE BLK/VIO WIRE BRAKE SW IN GEN FIELD OUT FUEL LVL SENS SIG SCI TRANSMIT BRN WIRE BRN/VIO WIRE BRN/WHT WIRE CRUISE CONTROL SYSTEM CRUISE SW IN DATA LINK CONNECTOR (LEFT SIDE OF DASH) DK BLU WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/ORG WIRE DK GRN/WHT WIRE DOWNSTREAM OXYGEN SENSOR RELAY (CALIFORNIA) FROM AUTO SHUT DOWN RELAY (DIAGRAM 1 OF 3) FUEL PMP RLY EVAP SOL CTRL FUSE 49 FUSE 5 GENERATOR HOT AT ALL TIMES INTAKE AIR TEMPERATURE SENSOR (IN LEFT FRONT SIDE OF INTAKE MANIFOLD) INTEGRATED POWER MODULE (LEFT FRONT OF ENGINE COMPT) LEAK DETECTION PUMP (ON RIGHT FRONT OF INNER FENDER) LT BLU/BLK WIRE LT BLU/VIO WIRE LT GRN WIRE LT GRN/RED WIRE ORG/ WIRE ORG/BLK WIRE ORG/DK BLU WIRE ORG/WHT WIRE OVERDRIVE SWITCH PNK WIRE PNK/BLK WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT SIDE OF FIREWALL) PRESS SIG RED WIRE RED/LT GRN WIRE SCI RECEIVE PCI BUS SENS GRD SENSOR GRD GOV PRESS SIG PRESS SOL CTRL 3-4 SOL CTRL TCC SOL CTRL TRANS TEMP SNS STOP LAMP SWITCH (ON BRAKE PEDAL BRACKET) TAN/RED WIRE THROTTLE POSITION SENSOR (ON THROTTLE BODY) TRANSMISSION RELAY TRANSMISSION SOLENOID ASSEMBLY (INSIDE TRANSMISSION) VIO WIRE VIO/BRN WIRE VIO/WHT WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/PNK WIRE YEL/RED WIRE