Manual sections

• Abbreviations
• Accessories Control Systems
• Accessory Drive Belts
• Adjustments
• Airbag
• Anti-Lock/traction Control
• Application
• Automatic HVAC System
• Automatic Trans
• Auxiliary Emission Control Systems
• Axle Shafts
• Basic Trouble Shooting
• Body, Cab Control Systems
• Brakes
• Cabin Air Filter
• Charging System
• Check Lists
• Computer Relearn
• Cooling Fan
• Cruise Control Systems
• Diagnostic Connector Locations
• Differentials & Drive Axles
• Door Locks & Anti-Theft Systems
• Drive Cycles
• Driveline/axles
• Driveshaft & Universal Joints
• DTC Index
• Electrical Component Locations
• Emission Applications
• Engine
• Engine Controls - Tests W/codes
• Engine Performance
• Entertainment Systems
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• Heated Glass/defoggers
• Heater
• How to Overhaul & Installation the Removal (T850)
• HVAC System - Compressor Servicing
• HVAC Systems - General Servicing
• Identification
• Manual & Power Steering
• MAP Guidelines
• Mechanical
• Mechanical - Hydraulic
• Metric Conversions
• Mirrors
• Mode 6
• Rear Driveline Module
• Removal & Installation
• Removal & Overhaul & Installation - 41te & 41ae Automatic Transmission
• Removal & Overhaul & Installation - Power Transfer Unit
• Reset Procedures
• Restraints
• Seats
• Specifications
• Starter
• Steering
• Steering Column
• Steering Column Switches
• Steering Gear
• Suspension Front
• Suspension Rear
• Testing & Diagnostics
• Theory & Operation
• Traction Control Disable
• Transmission
• Warning System
• Wheel Alignment
• Windows
• Wiper/washer Systems
• Wiring Diagrams - Engine Performance

Repair manual

Engine Controls - Tests W/codes Chrysler Town & Country IV

Step-by-step instructions on "Engine Controls - Tests W/codes" for Chrysler Town & Country IV (2000–2005). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

120subsections

120articles

85illustrations

INTRODUCTION

1 article

• INTRODUCTION

COMPONENT LOCATIONS

1 article

• COMPONENT LOCATIONS 32

SELF-DIAGNOSTIC SYSTEM

1 article

• SELF-DIAGNOSTIC SYSTEM

ON-BOARD DIAGNOSTICS

1 article

• ON-BOARD DIAGNOSTICS

Monitored Circuits

1 article

• Monitored Circuits

Non-Monitored Circuits

1 article

• Non-Monitored Circuits

Hard Failures

1 article

• Hard Failures

Intermittent Failures

1 article

• Intermittent Failures

SERVICE PRECAUTIONS

1 article

• SERVICE PRECAUTIONS

DIAGNOSTIC PROCEDURE

1 article

• DIAGNOSTIC PROCEDURE

VISUAL INSPECTION

1 article

• VISUAL INSPECTION

RETRIEVING DIAGNOSTIC TROUBLE CODES

1 article

• RETRIEVING DIAGNOSTIC TROUBLE CODES

Using Scan Tool

1 article

• Using Scan Tool

Using Odometer Display

1 article

• Using Odometer Display

CLEARING DIAGNOSTIC TROUBLE CODES

1 article

• CLEARING DIAGNOSTIC TROUBLE CODES

POWERTRAIN CONTROL MODULE LOCATION

1 article

• POWERTRAIN CONTROL MODULE LOCATION

POWERTRAIN CONTROL MODULE

1 article

• POWERTRAIN CONTROL MODULE

Programming Powertrain Control Module

1 article

• Programming Powertrain Control Module

Updating Secret Key Data

1 article

• Updating Secret Key Data

SUMMARY

1 article

• SUMMARY

FUEL SYSTEM PRESSURE RELEASE

1 article

• FUEL SYSTEM PRESSURE RELEASE

DIAGNOSTIC TROUBLE CODE DEFINITIONS

1 article

• DIAGNOSTIC TROUBLE CODE DEFINITIONS

CONNECTOR IDENTIFICATION

1 article

• CONNECTOR IDENTIFICATION 53

DIAGNOSTIC TESTS

1 article

• DIAGNOSTIC TESTS

DTC P0071: AMBIENT AIR TEMP SENSOR PERFORMANCE

1 article

• DTC P0071: AMBIENT AIR TEMP SENSOR PERFORMANCE

Monitored & Set Conditions

1 article

• Monitored & Set Conditions

Testing

1 article

• Testing

DTC P0106: BAROMETRIC PRESSURE OUT OF RANGE

1 article

• DTC P0106: BAROMETRIC PRESSURE OUT OF RANGE

DTC P0107: MAP SENSOR VOLTAGE TOO LOW

1 article

• DTC P0107: MAP SENSOR VOLTAGE TOO LOW

DTC P0108: MAP SENSOR VOLTAGE TOO HIGH

1 article

• DTC P0108: MAP SENSOR VOLTAGE TOO HIGH

DTC P0111: INTAKE AIR TEMP SENSOR PERFORMANCE

1 article

• DTC P0111: INTAKE AIR TEMP SENSOR PERFORMANCE

DTC P0117: ECT SENSOR VOLTAGE TOO LOW

1 article

• DTC P0117: ECT SENSOR VOLTAGE TOO LOW

DTC P0118: ECT SENSOR VOLTAGE TOO HIGH

1 article

• DTC P0118: ECT SENSOR VOLTAGE TOO HIGH

DTC P0121: TPS VOLTAGE DOES NOT AGREE WITH MAP

1 article

• DTC P0121: TPS VOLTAGE DOES NOT AGREE WITH MAP

DTC P0122: THROTTLE POSITION SENSOR VOLTAGE LOW

1 article

• DTC P0122: THROTTLE POSITION SENSOR VOLTAGE LOW

DTC P0123: THROTTLE POSITION SENSOR VOLTAGE HIGH

1 article

• DTC P0123: THROTTLE POSITION SENSOR VOLTAGE HIGH

DTC P0125: CLOSED LOOP TEMP NOT REACHED

1 article

• DTC P0125: CLOSED LOOP TEMP NOT REACHED

DTC P0131: 1/1 O2 SENSOR SHORTED TO GROUND

1 article

• DTC P0131: 1/1 O2 SENSOR SHORTED TO GROUND

DTC P0132: 1/1 O2 SENSOR SHORTED TO VOLTAGE

1 article

• DTC P0132: 1/1 O2 SENSOR SHORTED TO VOLTAGE

DTC P0133: 1/1 O2 SENSOR SLOW RESPONSE

1 article

• DTC P0133: 1/1 O2 SENSOR SLOW RESPONSE

DTC P0134: 1/1 O2 SENSOR STAYS AT CENTER

1 article

• DTC P0134: 1/1 O2 SENSOR STAYS AT CENTER

DTC P0135: 1/1 O2 SENSOR HEATER FAILURE

1 article

• DTC P0135: 1/1 O2 SENSOR HEATER FAILURE

DTC P0137: 1/2 O2 SENSOR SHORTED TO GROUND

1 article

• DTC P0137: 1/2 O2 SENSOR SHORTED TO GROUND

DTC P0138: 1/2 O2 SENSOR SHORTED TO VOLTAGE

1 article

• DTC P0138: 1/2 O2 SENSOR SHORTED TO VOLTAGE

DTC P0139: 1/2 O2 SENSOR SLOW RESPONSE

1 article

• DTC P0139: 1/2 O2 SENSOR SLOW RESPONSE

DTC P0140: 1/2 O2 SENSOR STAYS AT CENTER

1 article

• DTC P0140: 1/2 O2 SENSOR STAYS AT CENTER

DTC P0141: 1/2 O2 SENSOR HEATER FAILURE

1 article

• DTC P0141: 1/2 O2 SENSOR HEATER FAILURE

DTC P0171: 1/1 FUEL SYSTEM LEAN

1 article

• DTC P0171: 1/1 FUEL SYSTEM LEAN

DTC P0172: 1/1 FUEL SYSTEM RICH

1 article

• DTC P0172: 1/1 FUEL SYSTEM RICH

DTC P0201: INJECTOR #1 CONTROL CIRCUIT

1 article

• DTC P0201: INJECTOR #1 CONTROL CIRCUIT

DTC P0202: INJECTOR #2 CONTROL CIRCUIT

1 article

• DTC P0202: INJECTOR #2 CONTROL CIRCUIT

DTC P0203: INJECTOR #3 CONTROL CIRCUIT

1 article

• DTC P0203: INJECTOR #3 CONTROL CIRCUIT

DTC P0204: INJECTOR #4 CONTROL CIRCUIT

1 article

• DTC P0204: INJECTOR #4 CONTROL CIRCUIT

DTC P0205: INJECTOR #5 CONTROL CIRCUIT (3.3L & 3.8L)

1 article

• DTC P0205: INJECTOR #5 CONTROL CIRCUIT (3.3L & 3.8L)

DTC P0206: INJECTOR #6 CONTROL CIRCUIT (3.3L & 3.8L)

1 article

• DTC P0206: INJECTOR #6 CONTROL CIRCUIT (3.3L & 3.8L)

DTC P0300: MULTIPLE CYLINDER MISFIRE, DTC P0301: CYLINDER #1 MISFIRE, DTC P0302: CYLINDER #2 MISFIRE, DTC P0303: CYLINDER #3 MISFIRE, DTC P0304: CYLINDER #4 MISFIRE, DTC P0305: CYL

1 article

• DTC P0300: MULTIPLE CYLINDER MISFIRE, DTC P0301: CYLINDER #1 MISFIRE, DTC P0302: CYLINDER #2 MISFIRE, DTC P0303: CYLINDER #3 MISFIRE, DTC P0304: CYLINDER #4 MISFIRE, DTC P0305: CYL

DTC P0320: NO CRANK REFERENCE SIGNAL AT PCM

1 article

• DTC P0320: NO CRANK REFERENCE SIGNAL AT PCM

DTC P0325: KNOCK SENSOR #1 CIRCUIT

1 article

• DTC P0325: KNOCK SENSOR #1 CIRCUIT

DTC P0340: NO CAM SIGNAL AT PCM

1 article

• DTC P0340: NO CAM SIGNAL AT PCM

DTC P0351: IGNITION COIL #1 PRIMARY CIRCUIT

1 article

• DTC P0351: IGNITION COIL #1 PRIMARY CIRCUIT

DTC P0352: IGNITION COIL #2 PRIMARY CIRCUIT

1 article

• DTC P0352: IGNITION COIL #2 PRIMARY CIRCUIT

DTC P0353: IGNITION COIL #3 PRIMARY CIRCUIT (3.3L & 3.8L)

1 article

• DTC P0353: IGNITION COIL #3 PRIMARY CIRCUIT (3.3L & 3.8L)

DTC P0401: EGR SYSTEM FAILURE

1 article

• DTC P0401: EGR SYSTEM FAILURE

DTC P0403: EGR SOLENOID CIRCUIT

1 article

• DTC P0403: EGR SOLENOID CIRCUIT

DTC P0420: 1/1 CATALYTIC CONVERTER EFFICIENCY

1 article

• DTC P0420: 1/1 CATALYTIC CONVERTER EFFICIENCY

DTC P0441: EVAP PURGE FLOW MONITOR

1 article

• DTC P0441: EVAP PURGE FLOW MONITOR

DTC P0442: EVAP LEAK MONITOR MEDIUM (.040") LEAK DETECTED, DTC P0455: EVAP LEAK MONITOR LARGE LEAK DETECTED OR DTC P0456: EVAP LEAK MONITOR (.020") SMALL LEAK DETECTED

1 article

• DTC P0442: EVAP LEAK MONITOR MEDIUM (.040") LEAK DETECTED, DTC P0455: EVAP LEAK MONITOR LARGE LEAK DETECTED OR DTC P0456: EVAP LEAK MONITOR (.020") SMALL LEAK DETECTED

DTC P0443: EVAP PURGE SOLENOID CIRCUIT

1 article

• DTC P0443: EVAP PURGE SOLENOID CIRCUIT

DTC P0460: FUEL LEVEL UNIT NO CHANGE OVER MILES

1 article

• DTC P0460: FUEL LEVEL UNIT NO CHANGE OVER MILES

DTC P0462: FUEL LEVEL SENDING UNIT VOLTS TOO LOW

1 article

• DTC P0462: FUEL LEVEL SENDING UNIT VOLTS TOO LOW

DTC P0463: FUEL LEVEL SENDING UNIT VOLTS TOO HIGH

1 article

• DTC P0463: FUEL LEVEL SENDING UNIT VOLTS TOO HIGH

DTC P0500: NO VEHICLE SPEED SENSOR SIGNAL (3SP AUTO TRANS)

1 article

• DTC P0500: NO VEHICLE SPEED SENSOR SIGNAL (3SP AUTO TRANS)

DTC P0500: NO VEHICLE SPEED SENSOR SIGNAL (4SP AUTO TRANS)

1 article

• DTC P0500: NO VEHICLE SPEED SENSOR SIGNAL (4SP AUTO TRANS)

DTC P0505: IDLE AIR CONTROL MOTOR CIRCUITS (2.4L)

1 article

• DTC P0505: IDLE AIR CONTROL MOTOR CIRCUITS (2.4L)

DTC P0508: IAC MOTOR SENSE CIRCUIT LOW (3.3L & 3.8L)

1 article

• DTC P0508: IAC MOTOR SENSE CIRCUIT LOW (3.3L & 3.8L)

DTC P0509: IAC MOTOR SENSE CIRCUIT HIGH (3.3L & 3.8L)

1 article

• DTC P0509: IAC MOTOR SENSE CIRCUIT HIGH (3.3L & 3.8L)

DTC P0600: PCM FAILURE SPI COMMUNICATIONS

1 article

• DTC P0600: PCM FAILURE SPI COMMUNICATIONS

DTC P0601: INTERNAL CONTROLLER FAILURE

1 article

• DTC P0601: INTERNAL CONTROLLER FAILURE

DTC P0645: A/C CLUTCH RELAY CIRCUIT

1 article

• DTC P0645: A/C CLUTCH RELAY CIRCUIT

DTC P0703: BRAKE SWITCH SENSE CIRCUIT

1 article

• DTC P0703: BRAKE SWITCH SENSE CIRCUIT

DTC P0740: TORQUE CONVERTER CLU, NO RPM DROP AT LOCKUP (3SP AUTO TRANS)

1 article

• DTC P0740: TORQUE CONVERTER CLU, NO RPM DROP AT LOCKUP (3SP AUTO TRANS)

DTC P0743: TORQUE CONVERTER CLUTCH SOLENOID/TRANS RELAY CIRCUITS (3SP AUTO TRANS)

1 article

• DTC P0743: TORQUE CONVERTER CLUTCH SOLENOID/TRANS RELAY CIRCUITS (3SP AUTO TRANS)

DTC P1192: INLET AIR TEMP SENSOR VOLTAGE LOW

1 article

• DTC P1192: INLET AIR TEMP SENSOR VOLTAGE LOW

DTC P1193: INLET AIR TEMP SENSOR VOLTAGE HIGH

1 article

• DTC P1193: INLET AIR TEMP SENSOR VOLTAGE HIGH

DTC P1195: 1/1 O2 SENSOR SLOW DURING CATALYST MONITOR

1 article

• DTC P1195: 1/1 O2 SENSOR SLOW DURING CATALYST MONITOR

DTC P1281: ENGINE IS COLD TOO LONG

1 article

• DTC P1281: ENGINE IS COLD TOO LONG

DTC P1282: FUEL PUMP RELAY CONTROL CIRCUIT

1 article

• DTC P1282: FUEL PUMP RELAY CONTROL CIRCUIT

DTC P1294: TARGET IDLE NOT REACHED (2.4L)

1 article

• DTC P1294: TARGET IDLE NOT REACHED (2.4L)

DTC P1294: TARGET IDLE NOT REACHED (3.3L & 3.8L)

1 article

• DTC P1294: TARGET IDLE NOT REACHED (3.3L & 3.8L)

DTC P1297: NO CHANGE IN MAP FROM START TO RUN

1 article

• DTC P1297: NO CHANGE IN MAP FROM START TO RUN

DTC P1299: VACUUM LEAK FOUND (IAC FULLY SEATED)

1 article

• DTC P1299: VACUUM LEAK FOUND (IAC FULLY SEATED)

DTC P1388: AUTO SHUTDOWN RELAY CONTROL CIRCUIT

1 article

• DTC P1388: AUTO SHUTDOWN RELAY CONTROL CIRCUIT

DTC P1389: NO ASD RELAY OUTPUT VOLTAGE AT PCM

1 article

• DTC P1389: NO ASD RELAY OUTPUT VOLTAGE AT PCM

DTC P1391: INTERMITTENT LOSS OF CMP OR CKP (2.4L)

1 article

• DTC P1391: INTERMITTENT LOSS OF CMP OR CKP (2.4L)

DTC P1391: INTERMITTENT LOSS OF CMP OR CKP (3.3L & 3.8L)

1 article

• DTC P1391: INTERMITTENT LOSS OF CMP OR CKP (3.3L & 3.8L)

DTC P1398: MISFIRE ADAPTIVE NUMERATOR AT LIMIT (2.4L)

1 article

• DTC P1398: MISFIRE ADAPTIVE NUMERATOR AT LIMIT (2.4L)

DTC P1398: MISFIRE ADAPTIVE NUMERATOR AT LIMIT (3.3L & 3.8L)

1 article

• DTC P1398: MISFIRE ADAPTIVE NUMERATOR AT LIMIT (3.3L & 3.8L)

DTC P1486: EVAP LEAK MONITOR PINCHED HOSE FOUND

1 article

• DTC P1486: EVAP LEAK MONITOR PINCHED HOSE FOUND

DTC P1491: RAD FAN CONTROL RELAY CIRCUIT

1 article

• DTC P1491: RAD FAN CONTROL RELAY CIRCUIT

DTC P1494: LEAK DETECT PUMP SW OR MECHANICAL FAULT

1 article

• DTC P1494: LEAK DETECT PUMP SW OR MECHANICAL FAULT

DTC P1495: LEAK DETECTION PUMP SOLENOID CIRCUIT

1 article

• DTC P1495: LEAK DETECTION PUMP SOLENOID CIRCUIT

DTC P1496: 5 VOLT SUPPLY, OUTPUT TOO LOW

1 article

• DTC P1496: 5 VOLT SUPPLY, OUTPUT TOO LOW

DTC P1598: A/C PRESSURE SENSOR VOLTS TOO HIGH

1 article

• DTC P1598: A/C PRESSURE SENSOR VOLTS TOO HIGH

DTC P1599: A/C PRESSURE SENSOR VOLTS TOO LOW

1 article

• DTC P1599: A/C PRESSURE SENSOR VOLTS TOO LOW

DTC P1685: WRONG OR INVALID KEY MSG RECEIVED FROM SKIM

1 article

• DTC P1685: WRONG OR INVALID KEY MSG RECEIVED FROM SKIM

DTC P1686: NO SKIM BUS MESSAGE RECEIVED

1 article

• DTC P1686: NO SKIM BUS MESSAGE RECEIVED

DTC P1695: NO CCD/J1850 MESSAGE FROM BODY CONTROL MODULE

1 article

• DTC P1695: NO CCD/J1850 MESSAGE FROM BODY CONTROL MODULE

DTC P1696: PCM FAILURE EEPROM WRITE DENIED OR DTC P1697: PCM FAILURE SRI MILE NOT STORED

1 article

• DTC P1696: PCM FAILURE EEPROM WRITE DENIED OR DTC P1697: PCM FAILURE SRI MILE NOT STORED

DTC P1698: NO BUS MESSAGE FROM TRANS CONTROL MODULE (3.3L & 3.8L)

1 article

• DTC P1698: NO BUS MESSAGE FROM TRANS CONTROL MODULE (3.3L & 3.8L)

DTC P1899: P/N SWITCH STUCK IN PARK OR IN GEAR (3SP AUTO TRANS)

1 article

• DTC P1899: P/N SWITCH STUCK IN PARK OR IN GEAR (3SP AUTO TRANS)

DTC P1899: P/N SWITCH STUCK IN PARK OR IN GEAR (4SP AUTO TRANS)

1 article

• DTC P1899: P/N SWITCH STUCK IN PARK OR IN GEAR (4SP AUTO TRANS)

VERIFICATION TESTS

1 article

• VERIFICATION TESTS

POWERTRAIN VERIFICATION TEST VER-1

1 article

• POWERTRAIN VERIFICATION TEST VER-1

POWERTRAIN VERIFICATION TEST VER-2

1 article

• POWERTRAIN VERIFICATION TEST VER-2

POWERTRAIN VERIFICATION TEST VER-4

1 article

• POWERTRAIN VERIFICATION TEST VER-4

POWERTRAIN VERIFICATION TEST VER-5

1 article

• POWERTRAIN VERIFICATION TEST VER-5

POWERTRAIN VERIFICATION TEST VER-6

1 article

• POWERTRAIN VERIFICATION TEST VER-6

SKIS VERIFICATION TEST

1 article

• SKIS VERIFICATION TEST

31TH TRANSMISSION VERIFICATION TEST

1 article

• 31TH TRANSMISSION VERIFICATION TEST

41TE TRANSMISSION VERIFICATION TEST

1 article

• 41TE TRANSMISSION VERIFICATION TEST