Manual sections

• A/c Compressor
• Abbreviations
• Accessory Drive Belts
• Adjustments
• Airbag
• Anti-Lock/traction Control
• Application
• Automatic Trans
• Auxiliary Emission Control Systems
• Basic Trouble Shooting
• Brakes
• Charging System
• Check Lists
• Communication Devices
• Computer Relearn
• Cooling Fan
• Cooling System (mechanical)
• Cruise Control Systems
• Diagnostic Connector Locations
• Differentials & Drive Axles
• Door Locks & Anti-Theft Systems
• Drive Cycles
• Driveline/axles
• Driveshaft & Universal Joints
• DTC Index
• Electrical Component Locations
• Emission Applications
• Engine
• Engine Controls - Pin Voltage Charts - 4.3l.
• Engine Controls - Tests W/codes - 4.3l
• Engine Controls - Tests W/codes - 5.7l
• Engine Controls - Tests W/codes - 6.5l Diesel.
• Engine Performance
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• General Servicing - All Makes
• Heated Glass/defoggers
• Heater
• Identification
• Ignition System
• Manual & Power Steering
• Manual HVAC System
• Manual Trans
• MAP Guidelines
• Mechanical
• Mechanical - Hydraulic
• Metric Conversions
• Mirrors
• Mode 6
• Passive Restraints
• Pin Voltage Charts
• Procedures
• Removal & Installation
• Reset Procedures
• Restraints
• Rpo Codes
• Seats
• Sensor Range Charts
• Specifications
• Starter
• Steering
• Steering Column
• Steering Column Switches
• Suspension Front
• Suspension Rear
• Testing & Diagnostics
• Theory & Operation
• Traction Control Disable
• Transmission
• Wheel Alignment
• Windows
• Wiper/washer Systems
• Wiring Diagrams - Engine Performance

Repair manual

Engine Controls - Tests W/codes - 5.7l Chevrolet Chevy Van G3500

Step-by-step instructions on "Engine Controls - Tests W/codes - 5.7l" for Chevrolet Chevy Van G3500 (1985–1999). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

84subsections

84articles

111illustrations

MODEL IDENTIFICATION

1 article

• MODEL IDENTIFICATION

INTRODUCTION

1 article

• INTRODUCTION

TERMINOLOGY

1 article

• TERMINOLOGY

OVERVIEW

1 article

• OVERVIEW

Hard Failures

1 article

• Hard Failures

Intermittent Failures

1 article

• Intermittent Failures

DIAGNOSTIC PROCEDURE

1 article

• DIAGNOSTIC PROCEDURE

RETRIEVING CODES (NON-SCAN)

1 article

• RETRIEVING CODES (NON-SCAN) 2

READING TROUBLE CODES

1 article

• READING TROUBLE CODES

CLEARING TROUBLE CODES

1 article

• CLEARING TROUBLE CODES

ECM LOCATION

1 article

• ECM LOCATION

Diagnostic Aids

1 article

• Diagnostic Aids

Field Service Mode Check

1 article

• Field Service Mode Check

SPECIAL TOOLS (DIAGNOSTIC)

1 article

• SPECIAL TOOLS (DIAGNOSTIC)

SCAN TESTER USAGE

1 article

• SCAN TESTER USAGE

SCAN TESTER DATA

1 article

• SCAN TESTER DATA

TROUBLE CODE CHARTS

1 article

• TROUBLE CODE CHARTS

DTC 13: OPEN OXYGEN SENSOR CIRCUIT

1 article

• DTC 13: OPEN OXYGEN SENSOR CIRCUIT 2

DTC 14: COOLANT SENSOR SIGNAL VOLTAGE LOW

1 article

• DTC 14: COOLANT SENSOR SIGNAL VOLTAGE LOW 2

DTC 15: COOLANT SENSOR SIGNAL VOLTAGE HIGH

1 article

• DTC 15: COOLANT SENSOR SIGNAL VOLTAGE HIGH 1

DTC 16: VSS BUFFER FAULT

1 article

• DTC 16: VSS BUFFER FAULT 3

DTC 21: TPS SIGNAL VOLTAGE HIGH

1 article

• DTC 21: TPS SIGNAL VOLTAGE HIGH 2

DTC 22: TPS SIGNAL VOLTAGE LOW

1 article

• DTC 22: TPS SIGNAL VOLTAGE LOW 1

DTC 24: VSS - "C" & "K" SERIES EXCEPT 5.7L M/T

1 article

• DTC 24: VSS - "C" & "K" SERIES EXCEPT 5.7L M/T 1

DTC 24: VSS TRANSMISSION OUTPUT SIGNAL - A/T

1 article

• DTC 24: VSS TRANSMISSION OUTPUT SIGNAL - A/T 1

DTC 24: VSS - M/T

1 article

• DTC 24: VSS - M/T 3

DTC 28: TRANSMISSION RANGE PRESSURE SWITCH

1 article

• DTC 28: TRANSMISSION RANGE PRESSURE SWITCH 3

DTC 31: ENGINE SPEED GOVERNOR - "G" SERIES

1 article

• DTC 31: ENGINE SPEED GOVERNOR - "G" SERIES 2

DTC 32: EGR CIRCUIT ERROR BACKPRESSURE EGR WITH SOLENOID

1 article

• DTC 32: EGR CIRCUIT ERROR BACKPRESSURE EGR WITH SOLENOID 4

DTC 32: EGR CIRCUIT ERROR WITH EVRV SOLENOID

1 article

• DTC 32: EGR CIRCUIT ERROR WITH EVRV SOLENOID 3

DTC 32: EGR CKT ERROR - "C", "G", "K" SERIES W/ LINEAR EGR

1 article

• DTC 32: EGR CKT ERROR - "C", "G", "K" SERIES W/ LINEAR EGR 2

DTC 33: MAP SENSOR SIGNAL VOLTAGE HIGH

1 article

• DTC 33: MAP SENSOR SIGNAL VOLTAGE HIGH 2

DTC 34: MAP SENSOR SIGNAL VOLTAGE LOW

1 article

• DTC 34: MAP SENSOR SIGNAL VOLTAGE LOW 1

DTC 35: IDLE SPEED ERROR

1 article

• DTC 35: IDLE SPEED ERROR

IAC Valve Reset Procedure

1 article

• IAC Valve Reset Procedure

System Too Lean

1 article

• System Too Lean

System Too Rich

1 article

• System Too Rich

Throttle Body

1 article

• Throttle Body

IAC Valve Connections

1 article

• IAC Valve Connections

PCV Valve

1 article

• PCV Valve 2

DTC 36: IDLE SPEED ACTUATOR FAULT - A/T

1 article

• DTC 36: IDLE SPEED ACTUATOR FAULT - A/T 2

DTC 37/38: TCC BRAKE SWITCH ON/OFF

1 article

• DTC 37/38: TCC BRAKE SWITCH ON/OFF 2

DTC 39: TCC STUCK OFF - 4L80-E TRANSMISSION

1 article

• DTC 39: TCC STUCK OFF - 4L80-E TRANSMISSION 2

DTC 42: IGNITION CONTROL

1 article

• DTC 42: IGNITION CONTROL 3

DTC 43: KNOCK SENSOR WITHOUT SPARK MODULE (DUAL SENSORS)

1 article

• DTC 43: KNOCK SENSOR WITHOUT SPARK MODULE (DUAL SENSORS) 2

DTC 43: KNOCK SENSOR WITHOUT SPARK MODULE (SINGLE SENSOR)

1 article

• DTC 43: KNOCK SENSOR WITHOUT SPARK MODULE (SINGLE SENSOR) 2

DTC 43: KNOCK SENSOR WITH SPARK CONTROL MODULE

1 article

• DTC 43: KNOCK SENSOR WITH SPARK CONTROL MODULE 3

DTC 44: LEAN EXHAUST INDICATION

1 article

• DTC 44: LEAN EXHAUST INDICATION

O2 Sensor Wire

1 article

• O2 Sensor Wire

Fuel Contamination

1 article

• Fuel Contamination

Fuel Pressure

1 article

• Fuel Pressure

Exhaust Leaks

1 article

• Exhaust Leaks 1

DTC 45: RICH EXHAUST INDICATION

1 article

• DTC 45: RICH EXHAUST INDICATION

Fuel Pressure High

1 article

• Fuel Pressure High

Ignition Ground

1 article

• Ignition Ground

Fuel Canister

1 article

• Fuel Canister

MAP Sensor

1 article

• MAP Sensor

TPS

1 article

• TPS

O2 Sensor Contamination

1 article

• O2 Sensor Contamination

EGR Problem

1 article

• EGR Problem 1

DTC 51: PROM ERROR (FAULTY OR INCORRECT PROM)

1 article

• DTC 51: PROM ERROR (FAULTY OR INCORRECT PROM)

DTC 52: FAULTY CALPAK

1 article

• DTC 52: FAULTY CALPAK

DTC 52/53: SYSTEM VOLTAGE HIGH

1 article

• DTC 52/53: SYSTEM VOLTAGE HIGH 3

DTC 55: ECM/PCM ERROR

1 article

• DTC 55: ECM/PCM ERROR

DTC 54: FUEL PUMP CIRCUIT

1 article

• DTC 54: FUEL PUMP CIRCUIT 4

DTC 58: TRANSMISSION FLUID TEMPERATURE HIGH

1 article

• DTC 58: TRANSMISSION FLUID TEMPERATURE HIGH 3

DTC 59: TRANSMISSION FLUID TEMPERATURE LOW

1 article

• DTC 59: TRANSMISSION FLUID TEMPERATURE LOW 1

DTC 66: 3-2 CONTROL SOLENOID CKT FAULT 4L60-E TRANSMISSION

1 article

• DTC 66: 3-2 CONTROL SOLENOID CKT FAULT 4L60-E TRANSMISSION 2

DTC 67: TCC SOLENOID CIRCUIT CHECK - 4L60-E TRANSMISSION

1 article

• DTC 67: TCC SOLENOID CIRCUIT CHECK - 4L60-E TRANSMISSION 2

DTC 68: OVERDRIVE RATIO ERROR - 4L80-E TRANSMISSION

1 article

• DTC 68: OVERDRIVE RATIO ERROR - 4L80-E TRANSMISSION 1

DTC 69: TORQUE CONVERTER CLUTCH STUCK ON 4L60-E TRANSMISSION

1 article

• DTC 69: TORQUE CONVERTER CLUTCH STUCK ON 4L60-E TRANSMISSION 2

DTC 69: TORQUE CONVERTER CLUTCH STUCK ON 4L80-E TRANSMISSION

1 article

• DTC 69: TORQUE CONVERTER CLUTCH STUCK ON 4L80-E TRANSMISSION 1

DTC 72: VSS CIRCUIT LOSS TRANSMISSION OUTPUT SIGNAL

1 article

• DTC 72: VSS CIRCUIT LOSS TRANSMISSION OUTPUT SIGNAL 2

DTC 73: PRESSURE CONTROL SOLENOID (CURRENT ERROR)

1 article

• DTC 73: PRESSURE CONTROL SOLENOID (CURRENT ERROR) 2

DTC 74: TRANSMISSION INPUT SPEED ERROR 4L80-E TRANSMISSION

1 article

• DTC 74: TRANSMISSION INPUT SPEED ERROR 4L80-E TRANSMISSION 2

DTC 75: SYSTEM VOLTAGE LOW

1 article

• DTC 75: SYSTEM VOLTAGE LOW 2

DTC 79: TRANSMISSION FLUID TEMPERATURE HIGH

1 article

• DTC 79: TRANSMISSION FLUID TEMPERATURE HIGH 1

DTC 81: TRANSMISSION 2-3 ERROR

1 article

• DTC 81: TRANSMISSION 2-3 ERROR 2

DTC 82: TRANSMISSION 1-2 ERROR

1 article

• DTC 82: TRANSMISSION 1-2 ERROR 2

DTC 83: TCC SOLENOID CIRCUIT FAULT

1 article

• DTC 83: TCC SOLENOID CIRCUIT FAULT 1

DTC 85: UNDEFINED GEAR RATIO

1 article

• DTC 85: UNDEFINED GEAR RATIO 2

DTC 86: LOW GEAR RATIO ERROR

1 article

• DTC 86: LOW GEAR RATIO ERROR 1

DTC87: HIGH GEAR RATIO ERROR

1 article

• DTC87: HIGH GEAR RATIO ERROR 1

SUMMARY

1 article

• SUMMARY 19