Special Tools
Special Tools Illustration Tool Number / Description J 3049-A Valve Lifter Remover J 5239 Connecting Rod Bolt Guide Set J 5590 Pinion Bearing Race Installer-Rear J 5825-A Crankshaft Gear Remover J 5830-02 Valve Guide Reamer Set J 5892-D Valve Spring Compressor J 7872 Magnetic Base Dial Indicator J 8001 Dial Indicator Set J 8037 Ring Compressor J 8062 Valve Spring Compressor J 8087 Cylinder Bore Gage J 8089 Carbon Removing Brush J 8092 Universal Driver Handle J 9666 Valve Spring Tester J 21882 Oil Suction Pipe Installer J 22794 Spark Plug Port Adapter J 23523-F Balancer Remover and Installer J 24086-C Piston Pin Remover/Installer J 24270 Cylinder Bore Ridge Reamer J 26941 Bushing/Bearing Remover J 28428-E High Intensity Black Light Kit J 33049 Camshaft Bearing Service Kit J 35468 Cover Aligner/Seal Installer J 35621-B Rear Main Seal Installer J 35667-A Cylinder Head Leakdown Tester J 36996 Balance Shaft Installer J 38606 Valve Spring Compressor J 38834 Balance Shaft Service Kit J 41240 Fan Clutch Remover and Installer J 41427 Engine Lift Bracket J 41712 Oil Pressure Switch Socket J 42073 Valve Stem Seal Installer J 43690 Rod Bearing Clearance Checking Tool J 45059 Angle Meter J 45299 Engine Preluber
Scheme 65
Scheme 66
Scheme 67
Scheme 68
Scheme 69
Scheme 70
Scheme 71
Scheme 72
Scheme 73
Scheme 74
Scheme 75
Scheme 76
Scheme 77
Scheme 78
Scheme 79
Scheme 80
Scheme 81
Scheme 82
Scheme 83
Scheme 84
Scheme 85
Scheme 86
See also:
• Diagnostic System Check - Engine Controls
• Strategy Based Diagnosis
• Checking Aftermarket Accessories
• Spark Plug Inspection
• Battery Disconnect Caution
• Spark Plug Replacement
• Diagnostic Starting Point - Vibration Diagnosis and Correction
• Fan Clutch Replacement
• Fastener Notice
• Engine Mounting Notice
• Lifting and Jacking the Vehicle
• Starter Motor Replacement (4.8L, 5.3L, and 6.0L)
• Engine Cover Replacement
• Cruise Control Cable Replacement
• Heater Hose Replacement - Inlet
• Power Steering Pulley Replacement
• Exhaust Manifold Replacement - Left (4.3L)
• Refrigerant Recovery and Recharging
• Differential Carrier Assembly Replacement
• Transmission Replacement
• Air Cleaner Assembly Replacement
• Bumper Replacement - Front
• Grille Replacement (Uplevel)
• Radiator Support Replacement
• Power Steering Pump Replacement (4.3L)
• Capacities - Approximate Fluid
• Explanation of Scheduled Services
• Safety Glasses Caution
• Disassembled Views
• Lubrication Description
• New Product Information
• Drive Belt System Description
• Base Engine Misfire without Internal Engine Noises
• Base Engine Misfire with Abnormal Internal Lower Engine Noises
• Base Engine Misfire with Abnormal Valve Train Noise
• Base Engine Misfire with Coolant Consumption
• Base Engine Misfire with Excessive Oil Consumption
• Engine Compression Test
• Engine Noise on Start-Up, but Only Lasting a Few Seconds
• Upper Engine Noise, Regardless of Engine Speed
• Lower Engine Noise, Regardless of Engine Speed
• Engine Noise Under Load
• Engine Will Not Crank - Crankshaft Will Not Rotate
• Oil Consumption Diagnosis
• Oil Pressure Diagnosis and Testing
• Oil Leak Diagnosis
• Cylinder Head Cleaning and Inspection
• Piston, Connecting Rod, and Bearing Removal
• Piston, Connecting Rod, and Bearing Installation
• Engine Block Cleaning and Inspection
• Fastener Tightening Specifications
• Intake Manifold Disassemble (LU3)
• Camshaft and Bearings Cleaning and Inspection
• Cylinder Head Disassemble
• Cylinder Head Assemble
• Timing Chain, Sprockets, and/or Tensioner Replacement
• Balance Shaft Replacement
• Oil Pump Cleaning and Inspection
• Engine Mechanical Specifications