Home/Chevrolet/Camaro/Chevrolet Camaro IV (1992-1998)/Repair manual/Engine Controls - Tests W/codes - 5.7l/CODE 85, TCC STUCK ON

Contents

Wiring diagrams Section: Engine Controls - Tests W/codes - 5.7l

INTRODUCTION

SELF-DIAGNOSTIC SYSTEM

HARD FAILURES

INTERMITTENT FAILURES

DIAGNOSTIC PROCEDURE

READING TROUBLE CODES

TROUBLE CODE DEFINITIONS

HARD OR INTERMITTENT TROUBLE CODE DETERMINATION

CLEARING TROUBLE CODES

PCM LOCATION

Diagnostic Aids

Field Service Mode Check (If Available)

SPECIAL TOOLS (DIAGNOSTIC)

SCAN TESTER USAGE

SCAN DATA

ECM/PCM CODE CHARTS

CODE 11, MALFUNCTION INDICATOR LIGHT

CODE 13, OPEN OXYGEN SENSOR CIRCUIT

CODE 14, COOLANT TEMP SENS SGNL VLTGE LOW (HI TEMP INDICATED)

CODE 15, COOLANT TEMP SENSOR SIGNAL VOLTAGE LOW

CODE 16, OPTI-SPARK IGNITION SYSTEM LOW RESOLUTION PULSE

CODE 18, INJECTOR CIRCUIT

CODE 21, THROTTLE POSITION SENSOR SIGNAL VOLTAGE HIGH

CODE 22, THROTTLE POSITION SENSOR SIGNAL VOLTAGE LOW

CODE 23, IAT SENSOR SIGNAL VOLTAGE HIGH (LOW TEMP INDICATED)

CODE 24, VEHICLE SPEED SENSOR

CODE 25, IAT SENSOR SIGNAL VOLTAGE LOW (HIGH TEMP INDICATED)

CODE 26, CANISTER PURGE SOLENOID

CODE 27, EGR SOL VALVE

CODE 28, TRANS. RANGE PRESSURE SWITCH

CODE 29, SECONDARY AIR INJECTION

CODE 32, EGR SYSTEM ERROR

CODE 33, MAP SENSOR SIGNAL VOLTAGE HIGH

CODE 34, MAP SENSOR SIGNAL VOLTAGE LOW

CODE 36, OPTI-SPARK HIGH RESOLUTION PULSE

CODE 37, TCC BRAKE SWITCH ERROR

CODE 38, BRAKE SWITCH ERROR

CODE 41, OPTI-SPARK IGNITION SYSTEM OPEN OR SHORTED EST CIRCUIT

CODE 42, IC CIRCUIT GROUNDED

CODE 43, KNOCK SENSOR CIRCUIT (DUAL SENSORS)

CODE 44, LEAN EXHAUST INDICATION

O2 Sensor Wire

Fuel Contamination

Fuel Pressure

Exhaust Leaks

Misfire Or Stall

CODE 45, RICH EXHAUST INDICATION

Fuel Pressure High

Ignition Ground

Evaporative Fuel Canister

MAP Sensor

TPS

O2 Sensor Contamination

EGR Problem

CODE 46, PASS-KEY CIRCUIT

Pass-Key Diagnosis

CODE 47, KNOCK SENSOR MODULE

CODE 48, MASS AIRFLOW SENSOR

CODE 50, SYSTEM VOLTAGE LOW

CODE 52, FAULTY CAL-PAK

CODE 53, SYSTEM VOLTAGE HIGH

CODE 55, PCM ERROR

CODE 55, FUEL LEAN MONITOR

CODE 58, TRANS TEMPERATURE SENSOR HIGH TEMPERATURE

CODE 59, TRANS. TEMPERATURE SENSOR LOW TEMPERATURE

CODE 61, A/C SYSTEM PERFORMANCE

CODE 66, A/C PRESSURE SENSOR

CODE 67, A/C PRESSURE SENSOR

CODE 68, A/C RELAY CIRCUIT SHORTED

CODE 69, A/C COMPRESSOR RELAY

CODE 70, A/C COMPRESSOR RELAY DRIVER

CODE 71, A/C TEMPERATURE (CIRCUIT OPEN OR SHORTED)

CODE 72, VEHICLE SPEED SENSOR LOSS

CODE 73, PRESSURE CONTROL SOLENOID

CODE 74, TRACTION CONTROL VOLTAGE LOW

CODE 75, TRANSMISSION VOLTAGE LOW

CODE 77, PRIMARY COOLING FAN DRIVER

CODE 78, SECONDARY COOLING FAN DRIVER

CODE 79, TRANSMISSION FLUID OVERTEMP

CODE 81, 2-3 SHIFT SOLENOID

CODE 82, 1-2 SHIFT SOLENOID

CODE 83, REVERSE INHIBIT SOLENOID - M/T

CODE 83, TCC PWM SOLENOID - A/T

CODE 84, SKIP SHIFT SOLENOID - M/T

CODE 84, 3-2 CONTROL SOLENOID

CODE 85, TCC STUCK ON

CODE 90, TCC SOLENOID CIRCUIT

CODE 91, SKIP SHIFT LIGHT

CODE 95, CHANGE OIL LIGHT

CODE 96, LOW OIL LIGHT

CODE 97, VSS OUTPUT CIRCUIT

CODE 99 TACH OUTPUT CIRCUIT

SUMMARY

All sections

CODE 85, TCC STUCK ON Chevrolet Camaro IV

Engine Controls - Tests W/codes - 5.7l 2 illustrations

CODE 85, TCC STUCK ON

Note. Test numbers refer to numbers on diagnostic chart.

Checks mechanical state of TCC when PCM commands TCC solenoid off. TCC slip speed should increase.

Check for proper TP sensor operation. If TCC is mechanically stuck on, vehicle speed is zero, brakes are applied, and D2 is selected, TCC fluid will mechanically apply the TCC, causing an engine stall.

Code 85 Schematic (5.7L) TCC Stuck On. Scheme 161

Scheme 161: Code 85 Schematic (5.7L) TCC Stuck On

Scheme 161: Code 85 Schematic (5.7L) TCC Stuck On

Code 85 Diagnostic Flow Chart (5.7L) TCC Stuck On. Scheme 162

Scheme 162: Code 85 Diagnostic Flow Chart (5.7L) TCC Stuck On

Scheme 162: Code 85 Diagnostic Flow Chart (5.7L) TCC Stuck On