Special Tools
Special Tools Illustration Tool Number/Description J 3049-A Valve Lifter Remover J 6125-1B Slide Hammer J 7872 Magnetic Base Dial Indicator Set J 8001 Dial Indicator Set J 8037 Piston Ring Compressor J 8062 Valve Spring Compressor - Head Off J 8087 Cylinder Bore Gage J 8089 Carbon Removal Brush J 8433-1 Two Jaw Puller J 8520 Camshaft Lobe Lift Dial Indicator Set J 9666 Valve Spring Tester J 22794 Spark Plug Port Adapter J 24086-C Piston Pin Remover/Installer Set J 24270 Cylinder Ridge Remover J 28410 Gasket Remover J 28428-E Leak Detector Kit J 28467-B Universal Engine Support Fixture J 28467-501 Engine Support Fixture Adapters J 33049 Camshaft Bearing Service Set J 34730-1A Fuel Pressure Gage J 35667-A Cylinder Leakdown Tester J 37378-1 Valve Guide Reamer J 38606 Valve Spring Compressor J 38722 Compression Gage J 38836 Bushing Installer/Clutch Arbor J 41476 Front and Rear Cover Alignment Tool J 41478 Crankshaft Front Oil Seal Installer J 41479 Crankshaft Rear Oil Seal Installer J 41480 Front and Rear Cover Alignment J 41556 Connecting Rod Guide J 41558 Crankshaft Sprocket Remover J 41665 Crankshaft Balancer and Sprocket Installer J 41712 Oil Pressure Switch Socket J 41798 Engine Lifting Brackets J 41803 Engine Support Fixture J 41816 Crankshaft Balancer Remover J 41816-2 Crankshaft End Protector J 41818 Crankshaft Bearing Cap Remover J 42385-100 Head/Main Bolt Thread Repair Kit J 42385-200 Common Thread Repair Kit J 42385-300 Fixtures and Hardware Kit J 42386-A Flywheel Holding Tool J 42640 Steering Column Anti-rotation Pin J 42907 Oil Pressure Testing Tool J 43276 Clutch Pilot Bearing Remover J 43690 Rod Bearing Checking Tool J 43690-100 Rod Bearing Checking Tool - Adapter Kit J 45059 Angle Meter J 45299 Engine Preluber
Scheme 161
Scheme 162
Scheme 163
Scheme 164
Scheme 165
Scheme 166
Scheme 167
Scheme 168
Scheme 169
Scheme 170
Scheme 171
Scheme 172
Scheme 173
Scheme 174
Scheme 175
Scheme 176
Scheme 177
Scheme 178
Scheme 179
Scheme 180
Scheme 181
Scheme 182
Scheme 183
Scheme 184
Scheme 185
Scheme 186
Scheme 187
Scheme 188
See also:
• Diagnostic System Check - Engine Controls
• Strategy Based Diagnosis
• Checking Aftermarket Accessories
• Diagnostic Starting Point - Engine Cooling
• Spark Plug Inspection
• Detonation/Spark Knock
• Clutch Assembly Replacement (CTS)
• Vibration Analysis - Engine
• Air Cleaner Outlet Duct Replacement
• Cooling Fan Replacement - Electric (LS6)
• Fastener Notice
• Engine Support Fixture
• Engine Mount Replacement - Left
• Battery Negative Cable Replacement (LHD)
• Lifting and Jacking the Vehicle
• Brace Replacement - Cross Vehicle
• Fuel Rail Stop Bracket Installation Caution
• Power Steering Pump Replacement (5.7L)
• Exhaust Manifold Replacement - Left (LS6)
• Radiator Replacement (LS6)
• Condenser Replacement (MAE)
• Frame Replacement - Front
• Capacities - Approximate Fluid
• Transmission Replacement
• Intermediate Steering Shaft Replacement - Lower
• Refrigerant Recovery and Recharging
• Suction Hose Replacement (LS6)
• Liquid Line Replacement (LS6)
• Harness Routing Views
• Tire and Wheel Removal and Installation
• Brake Pressure Modulator Valve (BPMV) Replacement (CTS)
• Washer Solvent Container Replacement (w/o CE4)
• Master Cylinder Replacement
• Fluid and Lubricant Recommendations
• Transmission Fluid Level Inspection
• GM Oil Life System - Resetting
• Safety Glasses Caution
• Sealant Notice
• Disassembled Views
• New Product Information
• Base Engine Misfire without Internal Engine Noises
• Base Engine Misfire with Abnormal Internal Lower Engine Noises
• Base Engine Misfire with Abnormal Valve Train Noise
• Base Engine Misfire with Coolant Consumption
• Base Engine Misfire with Excessive Oil Consumption
• Engine Compression Test
• Engine Noise on Start-Up, but Only Lasting a Few Seconds
• Upper Engine Noise, Regardless of Engine Speed
• Lower Engine Noise, Regardless of Engine Speed
• Engine Noise Under Load
• Engine Will Not Crank - Crankshaft Will Not Rotate
• Coolant in Combustion Chamber
• Coolant in Engine Oil
• Oil Consumption Diagnosis
• Oil Pressure Diagnosis and Testing
• Oil Leak Diagnosis
• Drive Belt Tensioner Diagnosis
• Piston, Connecting Rod, and Bearing Installation
• Cylinder Head Cleaning and Inspection
• Crankshaft Balancer Removal
• Crankshaft Balancer Cleaning and Inspection
• Engine Flywheel Removal
• Engine Mechanical Specifications (LS6)
• Oil Pump Cleaning and Inspection
• Fastener Tightening Specifications
• Engine Valley Cover Cleaning and Inspection
• Valve Rocker Arm Cover Cleaning and Inspection
• Cylinder Head Removal - Left
• Cylinder Head Installation - Left
• Cylinder Head Removal - Right
• Cylinder Head Installation - Right
• Crankshaft Balancer Installation
• Engine Front Cover Cleaning and Inspection
• Engine Rear Cover Removal
• Engine Rear Cover Cleaning and Inspection
• Engine Rear Cover Installation
• Engine Flywheel Installation
• Oil Pan Removal
• Oil Pan Cleaning and Inspection
• Oil Pan Installation
• Engine Front Cover Replacement
• Timing Chain and Sprockets Cleaning and Inspection
• Camshaft Removal
• Valve Lifter Installation
• Engine Front Cover Installation
• Intake Manifold Installation
• Engine Balancing
• Separating Parts
• Cleanliness and Care
• Camshaft and Bearings Cleaning and Inspection
• Thread Repair
• Sealers, Adhesives, and Lubricants
• Diagnostic Starting Point - Engine Mechanical
• Special Tools
• Crankshaft and Bearings Cleaning and Inspection