Repair manual
Wiring diagrams
BMW X3 E83 facelift Repair Manual
Step-by-step repair and maintenance instructions for the BMW X3 E83 facelift (2006–2010): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
76sections
1547articles
ENManual language
- Standard/automatic Transmission - Overview 5
- Electronic Transmission Control - Overview 5
- Automatic Transmission Control - Overview 6
- Automatic Transmission - Repair 3
- Gear Shift - Repair
- Automatic Transmission - Technical Data
- Automatic Transmission - Tightening Torques 3
- Gear Shift Mechanism - Tightening Torques
- Automatic Transmission - Service Techniques 2
- Automatic Transmission - Special Tools 4
- Gear Shift Mechanism - Special Tools
- Automatic Transmission - Operating Fluids 3
- Gear Shift Mechanism - Operating Fluids
- Diagnostic Trouble Codes - 6-SPEED Zf Transmission
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 23 Transmission designations
- 23 .. Universal transmission bracket
- 23 .. ... Universal transmission retaining bridge
- 24 00 018 Adjusting selector lever (A5S 360R / 390R, A4S 200R, 6HP26Z/19Z)
- 24 00 018 Adjusting selector lever (GA6L45R) AWD
- 24 00 018 Adjusting selector lever (GA6L45R)
- 24 00 032 Removing and installing automatic transmission (GA6L45R)
- 24 11 007 Replacing sealing plug (GA6L45R)
- 24 11 011 Removing and installing/sealing or replacing transmission sump (GA6L45R)
- 24 11 665 Removing and installing/replacing transmission oil filter (GA6L45R)
- 24 11 666 Removing and installing/replacing transmission oil filter gasket (GA6L45R)
- 24 13 014 Replacing output flange radial shaft seal (GA6L45R) AWD
- 24 13 014 Replacing output flange shaft seal (GA6L45R)
- 24 14 005 Replacing sealing cap for selector shaft (GA6L45R)
- 24 14 003 Replacing selector shaft seal (GA6L45R)
- 24 31 575 Replacing oil pump O-rings (GA6HP26/19Z)
- 24 33 530 Replacing gear selector valve (GA6L45R)
- 24 34 561 Notes on mechatronics (GA6L45R)
- 24 34 562 Replacing mechatronics (GA6L45R)
- 24 35 700 Removing and installing/replacing input and output speed sensor (GA6L45R)
- 24 35 610 Removing and installing/replacing transmission position switch (GA6L45R)
- 24 50 030 Replacing selector shaft (GA6L45R)
- Driveline/axle - Overview 2
- Front Axle - Repair 2
- Rear Axle - Repair
- Front Axle - Technical Data
- Rear Axle - Technical Data
- Front Axle - Tightening Torques
- Rear Axle - Tightening Torques
- Rear Axle - Service Information 3
- Front Axle - Special Tools 3
- Rear Axle - Special Tools 2
- Front Axle - Operating Fluids 2
- Rear Axle - Operating Fluids 2
- 51 00 ... Instructions on sticking film
- 51 00 ... Notes on bonding/attaching components with double-sided adhesive tape
- 51 00 ... Safety instructions for working on cars with airbag systems
- 51 00 ... Service position of engine hood/bonnet
- 51 11 ... Removing and installing/replacing cover for headlight washer system on left or right (from 09/2006)
- 51 11 ... Removing and installing/replacing front cover for headlight washer system on left or right (M Technic aerodynamic kit)
- 51 11 ... Removing and installing/replacing left or right front fog lamp trim (M Technic aerodynamic kit)
- 51 11 050 Removing and installing / replacing carrier for front bumper trim
- 51 11 140 Removing and installing/replacing bumper trim upper section (from 09/2006)
- 51 11 140 Removing and installing/replacing bumper trim upper section (up to 09/2006)
- 51 11 141 Removing and installing/replacing bumper trim lower section (from 09/2006)
- 51 11 141 Removing and installing/replacing bumper trim lower section (up to 09/2006)
- 51 11 145 Removing and installing/replacing center insert for bumper trim
- 51 11 156 Removing and installing front bumper trim (from 09/2006)
- 51 11 156 Removing and installing front bumper trim (up to 09/2006)
- 51 11 156 Removing and installing/replacing front bumper trim (M Technic aerodynamic kit)
- 51 11 157 Replacing front bumper trim
- 51 11 158 Replacing baseplate for license plate
- 51 11 180 Removing and installing/replacing grille in bumper trim (M Technic aerodynamic kit)
- 51 11 180 Removing and installing/replacing middle trim grille in bumper trim (up to 09/2006)
- 51 11 180 Removing and installing/replacing trim grille for bumper trim (up to 09/2006)
- 51 11 182 Removing and installing/replacing upper grille in bumper trim (from 09/2006)
- 51 11 185 Removing and installing/replacing side grille in bumper trim (from 09/2006)
- 51 11 701 Replacing left or right bracket for front bumper
- 51 11 710 Removing and installing/replacing left or right headlight bracket (M Technic aerodynamic kit)
- 51 11 770 Removing and installing/replacing left or right deformation element for front bumper
- 51 12 ... Removing and installing/replacing diffuser on rear bumper trim (M Technic aerodynamic kit)
- 51 12 ... Removing and installing/replacing trim for bumper trim at rear
- 51 12 ... Removing and installing/replacing trim on loading sill for rear bumper (M Technic aerodynamic kit)
- 51 12 050 Removing and installing / replacing carrier for rear bumper trim
- 51 12 080 Removing and installing/replacing trim on loading sill for rear bumper (from 09/2006)
- 51 12 156 Removing and installing rear bumper trim (from 09/2006)
- 51 12 156 Removing and installing rear bumper trim (up to 09/2006)
- 51 12 156 Removing and installing/replacing rear bumper trim (M Technic aerodynamic kit)
- 51 12 157 Replacing rear bumper trim
- 51 12 185 Removing and installing/replacing trim for bumper trim on left or right
- 51 12 801 Replacing bracket for rear bumper at left or right
- 51 12 825 Removing and installing/replacing guide for rear center bumper
- 51 12 828 Removing and installing/replacing left or right guide for rear bumper
- 51 13 ... Replacing front radiator grill, middle left or right
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13 115 Removing and installing/replacing cowl panel cover
- 51 13 280 Removing and installing/replacing trim strip on roof frame at left or right
- 51 13 305 Removing and installing/replacing left or right rail
- 51 13 402 Removing and installing/replacing handle strip (on rear lid)
- 51 13 412 Removing and installing (replacing) lower trim on rear lid
- 51 13 420 Removing and installing/replacing center rear-end trim section
- 51 14 ... Instructions for attaching number/letter designation combination
- 51 14 000 Removing and installing/replacing front BMW badge
- 51 14 008 Replacing (removing and installing) number/letter combination on front left or right side panel
- 51 14 010 Removing and installing/replacing rear BMW badge
- 51 14 110 Removing and installing/replacing rear model designation
- 51 16 ... Cementing of mirror base
- 51 16 ... Removing and installing/replacing cover for center armrest (storage compartment with CD changer)
- 51 16 000 Removing and installing/replacing mirror on left or right front door
- 51 16 026 Replacing mirror glass
- 51 16 040 Removing and installing/replacing housing on left or right door mirror
- 51 16 045 Removing and installing/replacing retaining ring on left or right door mirror
- 51 16 060 Removing and installing/replacing interior rearview mirror (with Japanese toll mirror)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with full foot)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with mirror arm end caps)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with rain sensor)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 194 Removing and installing/replacing front side left or right cup holder
- 51 16 196 Removing and installing/replacing cover for center armrest
- 51 16 200 Removing and installing storage compartment
- 51 16 200 Removing and installing/replacing storage compartment (with CD changer)
- 51 16 201 Replacing storage compartment
- 51 16 202 Removing and installing/replacing front cup holder
- 51 16 210 Removing and installing/replacing trim for preselector lever
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 342 Removing and installing/replacing lock cylinder for passenger airbag deactivation
- 51 16 360 Removing and installing right glovebox
- 51 16 361 Replacing right glovebox
- 51 16 366 Removing and installing right glovebox with housing
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 480 Removing and installing or replacing front grab handle
- 51 17 400 Removing and installing/replacing bump stop with ejector for filler flap
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 004 Adjusting front left or right door detent (lock wedge)
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing carrier for left or right outside door handle with lock cylinder
- 51 21 126 Removing and installing/replacing carrier for left or right outside door handle without lock cylinder
- 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door
- 51 21 170 Removing and installing or replacing outside handle from left or right front door
- 51 21 180 Removing and installing/replacing cover on outside handle
- 51 21 200 Removing and installing/replacing outside handle and lock actuation of left or right front door
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outside door handle on left or right front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 280 Removing and installing or replacing door brake on left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/replacing window cavity cover strip on inner front door
- 51 21 360 Replacing seal for door seam/roof frame on left or right front door
- 51 21 370 Removing and installing/replacing cover at bottom left or right on front door
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 004 Adjusting rear left or right door detent (lock wedges)
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 126 Removing and installing/replacing carrier for outside door handle on left or right rear door
- 51 22 170 Removing and installing / replacing outside handle on left or right back door
- 51 22 180 Removing and installing/replacing cover on outside handle, left or right
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 233 Removing and installing/replacing Bowden cable for outside door handle on left or right rear door
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 280 Removing and installing/replacing door retainer on rear left or right door
- 51 22 300 Removing and installing/replacing window cavity cover strip on rear door on left or right
- 51 22 330 Removing and installing/replacing window cavity cover strip on inside rear door
- 51 22 351 Replacing window cavity seal on inner left or right rear door
- 51 22 360 Replacing seal for door seam/roof frame on left or right rear door
- 51 22 370 Removing and installing/replacing cover at bottom left or right on rear door
- 51 23 ... Adjusting/replacing bump stops
- 51 23 ... Removing/installing ball sockets with clip
- 51 23 004 Adjusting hood/bonnet lock
- 51 23 100 Removing and installing/replacing right engine hood lock
- 51 23 110 Removing and installing/replacing left engine hood lock
- 51 23 131 Adjusting left or right striker on engine hood
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 211 Removing and installing/replacing cable for front engine hood/bonnet locks (to passenger compartment)
- 51 23 212 Removing and installing/replacing cable for front engine hood locks (to locks)
- 51 23 265 Removing and installing/replacing left or right gas strut for engine bonnet/hood
- 51 24 004 Adjusting rear lid lock
- 51 24 105 Removing and installing/replacing rear lid lock (lower section of lock)
- 51 24 130 Removing and installing/replacing striker for rear lid lock (Touring)
- 51 24 145 Removing and installing/replacing button for rear lid actuation
- 51 24 165 Removing and installing/replacing side left or right buffer stops on rear lid
- 51 24 300 Removing and installing or replacing left or right gas strut for rear lid
- 51 31 ... Instructions on gluing windscreen
- 51 31 ... Removing windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing / replacing windscreen
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31 021 Removing and installing/replacing rubber frame for windscreen (top)
- 51 31 030 Removing and installing or replacing left or right gutter along windshield
- 51 31 200 Removing and installing/replacing rear window
- 51 32 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 32 170 Removing and installing / replacing door window glass, front left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- 51 32 420 Removing and installing/replacing trim on front door window frame, left or right
- 51 33 000 Removing and installing (replacing) power window unit in left or right front door
- 51 34 ... Removing and installing/replacing trim on window frame of rear door (rear), left or right
- 51 34 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 34 171 Replacing rear left or right door window
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 211 Replacing rubber guide for rear left or right door window
- 51 34 420 Removing and installing/replacing trim on window frame of rear door (front), left or right
- 51 34 425 Removing and installing/replacing trim on window frame of rear door, rear left or right
- 51 36 ... Firmly tensioning rear left or right side window
- 51 36 030 Removing and installing/replacing left or right trim on C-pillar (outside on rear side window)
- 51 36 040 Removing and installing/replacing strip on side window at rear bottom left or right
- 51 36 070 Removing and installing / replacing left or right rear side window
- 51 37 000 Removing and installing/replacing complete rear left or right power window unit
- 51 37 261 Removing and installing/replacing window cavity cover strip for door window, rear left or right
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41 017 Removing and installing/replacing cover on door handle, front left or right
- 51 41 018 Replacing speaker trim on front left or right door trim panel
- 51 42 000 Removing and installing left or right rear door trim panel
- 51 42 001 Replacing left or right rear door trim panel
- 51 42 017 Removing and installing/replacing cover on door handle, rear left or right
- 51 42 018 Replacing speaker trim on rear left or right door trim panel
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing/replacing panel for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing/replacing trim panel for rear left or right roof pillar (C - pillar)
- 51 43 252 Replacing trim panel for rear left or right roof pillar (D-pillar)
- 51 44 ... Removing and installing front roofliner trim
- 51 44 002 Removing and installing roofliner (on version without panorama sunroof)
- 51 44 013 Removing and installing roofliner (on version with panorama sunroof)
- 51 45 ... Removing and installing storage tray in instrument panel
- 51 45 ... Removing and installing/replacing bottom right trim for instrument panel
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 055 Removing and installing/replacing airbag cover on passenger side
- 51 45 106 Removing and installing/replacing function carrier on instrument panel trim
- 51 46 050 Removing and installing/replacing top trim on rear apron
- 51 47 ... Removing and installing/replacing left or right underbody panelling
- 51 47 ... Removing and installing/replacing storage compartment in luggage compartment on right
- 51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip
- 51 47 030 Removing and installing/replacing rear (inside) left or right entrance cover strip
- 51 47 102 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 131 Replacing front trim for luggage compartment floor
- 51 47 135 Removing and installing/replacing left or right lashing rail in luggage compartment floor
- 51 47 151 Removing and installing / replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch trim
- 51 47 172 Removing and installing/replacing flap in luggage compartment trim, left or right
- 51 47 315 Removing and installing/replacing front carpet for passenger compartment
- 51 47 440 Removing and installing/replacing rear carpet on seat pan
- 51 47 490 Removing and installing / replacing front underbody protection
- 51 47 491 Removing and installing/replacing rear underbody protection
- 51 48 001 Removing and installing/replacing insulation lining on hood/bonnet
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
- 51 49 003 Removing and installing/replacing trim for rear window frame on left or right
- 51 49 008 Removing and installing/replacing panel for rear lid
- 51 49 015 Removing and installing/replacing trim for rear window frame at top
- 51 70 ... Fitting seals
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 080 Removing and installing/replacing heater bulkhead
- 51 71 200 Removing and installing / replacing seal on rear door, left or right
- 51 71 373 Removing and installing/replacing tension strut on spring strut dome
- 51 71 407 Replacing rear spoiler
- 51 71 412 Removing and installing rear spoiler
- 51 71 470 Removing and installing/replacing trim on front left or right wheel arch
- 51 71 472 Removing and installing/replacing cover on left or right sill
- 51 71 473 Removing and installing/replacing take-up for cover on left or right sill
- 51 71 478 Removing and installing/replacing trim on rear left or right wheel arch
- 51 71 495 Removing and installing/replacing emergency wheel pan
- 41 0 Contents of Body, General
- 41 00 ... Bonding plastic parts
- 41 00 ... Bonding steel parts
- 41 00 ... Corrosion protection
- 41 00 ... General cementing instructions
- 41 00 ... Grinding steel parts
- 41 00 ... Handling airbags and restraint systems
- 41 00 ... Handling electrical and electronic equipment
- 41 00 ... Information / warning labels
- 41 00 ... Information on hazards
- 41 00 ... Information on vehicle protection
- 41 00 ... Installing a cavity bulkhead (expanded)
- 41 00 ... Installing a cavity bulkhead (not expanded)
- 41 00 ... Materials science
- 41 00 ... Notes on repairing threads
- 41 00 ... Opening adhesive bonds
- 41 00 ... Opening weld joints
- 41 00 ... Quality standard
- 41 00 ... Riveting aluminium parts
- 41 00 ... Riveting steel parts
- 41 00 ... Safety at work
- 41 00 ... Spot-weld bonding steel parts
- 41 00 ... Straightening steel parts
- 41 00 ... Use of materials in outer shell
- 41 00 ... Welding and soldering steel parts
- 41 00 ... Welding in reinforcement plate (steel plate)
- 41 00 ... Workshop equipment
- 99 00 ... General instructions on painting
- 41 11 005 Replacing left cross-member mounting
- 41 11 048 Replacing front left engine carrier
- 41 11 620 Replacing rear axle take-up cross-member at rear (luggage compartment floor completely removed)
- 41 12 535 for details of stripping-down and rigging work. Place vehicle on straightening bench.
- 41 14 015 Replacing engine carrier with wheel arch, left
- 41 14 502 Replacing rear left outer wheel arch section (rear left side panel removed)
- 41 14 511 Replacing complete rear left wheel arch (rear left side panel removed)
- 41 21 510 Replacing front left door pillar (front side panel removed)
- 41 31 010 Replacing roof outer skin (version with slide/tilt sunroof)
- 41 33 040 Replacing front panel
- 41 34 038 Replacing outer section of tail panel
- 41 34 041 Replacing complete tail panel
- 41 35 000 Removing and installing/replacing side panel, front left or right
- 41 51 004 Adjusting front left or right door
- 41 51 080 Removing and installing front left or right door
- 41 52 004 Adjusting rear left or right door
- 41 52 080 Removing and installing rear left or right door
- 41 61 000 Removing and installing engine hood
- 41 61 014 Adjusting engine bonnet/hood
- 41 62 000 Removing and installing rear lid
- 41 62 014 Adjusting rear lid
- 41 62 519 Removing and installing/replacing left or right hinge for rear lid
- 41 63 000 Removing and installing flap for fuel filler neck
- 41 63 003 Replacing cover bowl
- 34 00 010 Checking thickness of brake pad
- 34 00 050 Bleeding brake system with DSC
- 34 10 014 Adjusting handbrake
- 34 11 000 Removing and installing/replacing brake linings of both front disc brakes
- 34 11 220 Removing and installing/replacing both front brake discs
- 34 11 250 Removing and installing/replacing a brake carrier/brake guard plate at front
- 34 11 519 Removing and installing/replacing left or right front brake caliper
- 34 11 667 Precision-turning both front brake discs on both sides
- 34 21 171 Removing and installing/replacing a brake carrier/brake guard plate at rear
- 34 21 173 Replacing rear left (or right) brake carrier/brake guard
- 34 21 200 Removing and installing/replacing both rear disc brakes
- 34 21 320 Removing and installing/replacing both brake disks
- 34 21 745 Removing and installing/replacing left or right rear brake caliper
- 34 21 947 Precision-turning both rear brake discs on both sides
- 34 31 181 Removing and installing/replacing expansion tank for hydraulic brake actuation
- 34 31 505 Removing and installing/replacing master brake cylinder for DSC
- 34 32 861 Replacing all brake pipes
- 34 32 881 Replacing front left or right brake hoses
- 34 32 980 Replacing rear left or right brake hoses
- 34 33 051 Removing and installing/replacing nonreturn valve for brake booster
- 34 33 505 Removing and installing/replacing brake booster
- 34 35 ... Replacing a brake pad sensor (rear)
- 34 35 001 Replacing a brake lining sensor (front)
- 34 41 000 Removing and installing/replacing handbrake lever
- 34 41 120 Removing and installing/replacing both handbrake Bowden cables
- 34 41 220 Removing and installing/replacing all handbrake shoes
- 34 41 250 Removing and installing/replacing expander lock for handbrake shoes
- 34 51 527 Removing and installing/replacing DSC hydraulic unit
- 34 52 516 Removing and installing/replacing DSC control unit
- 34 52 525 Replacing one front pulse generator
- 34 52 535 Replacing a rear pulse generator
- 34 52 550 Removing and installing/replacing DSC sensor
- Breakout Boxes and Connectors
- Relay Holder Disengaging Tool
- Circular Connector Lock Disengager
- Circular Plug 7--8 Pin System D2.5
- Circular plug 13 Pin System D2.5
- Circular Plug 20 Pin System D2.5
- Circular Plug 4-7-10-12-25 Pin System D1.5/D2.5
- In-line Plug 15 Pin System D2.5
- In-line Plug 8-, 12 Pin System D2.5
- In-line Plug 20 Pin System D2.5
- In-line Plug 30 Pin System D2.5
- In-line plug 2 Pin System JPT ELA
- In-line plug 2 Pin System MDK 3 plus 2.8
- In-line plug 4 Pin System DFK ELA
- In-line Plug 3-,6 Pin System Elo-Power 2.8
- In-line plug 4-,10 Pin System Elo
- In-line Plug 6-,50 Pin System Elo
- In-line Plug 6-,8 Pin System MQS
- In-line Plug 2 Pin System MPQ 2.8
- Control Unit Plug 25-, 35-, 55-,83-,88 Pin
- In-line Plug 24 Pin Hybrid System MQS/MPQ
- Socket Housing
- Pin Housing
- Socket Housing 42-,43 Pin Hybrid Systems MQS/MPQ
- Socket Housing 2x27-, 2x27 Pin Hybrid System MQS/MPQ, Elo/Elo Power
- In-line Plug 30 Pin Hybrid System MQS/MPQ
- Socket Housing 5-, 8 Pin System MQS/MPQ
- Socket housing 5 pin (Hybrid System MQS/MPQ)
- Socket Housing 8 Pin (MQS)
- Socket Housing (Radio Plug) Hybrid system MQS/MPS
- Removing MPQ contacts from radio plug
- Removing MQS contacts from carrier
- Removing MPQ contacts from contact carrier
- Fuse Strip
- ECM Main Relay Connector
- Solderless Terminals And Connectors
- Electrical Repair Kit IV
- Cable Stripper
- Crimping Tool
- Cable Stripping
- Crimping
- Soldering Connections
- Soldering Preparation and Procedure
- Breakout Boxes and "V" Cables
- 55 pin Breakout Box P/N 81 12 9 425 091
- 83 Pin Breakout Box (Red Face) P/N 90 88 6 614 420
- 88 Pin Breakout Box (Green Face) P/N 88 88 6 614 410
- 134 Pin SKE Control Module Breakout Box Set P/N 90 88 6 121 300
- 26 Pin Breakout Box P/n 88 88 6 611 459
- 60 Pin Breakout Box P/N 90 88 6 614 390
- Tester and Adapter Set for Relays
- "V" Cables
- Remote Keyless Entry - Service Information 3
- Body Equipment - Repair 4
- Electrical Drives - Repair 2
- Audio, Navigation, Anti-Theft and Restraints - Repair
- Body - Tightening Torques
- Body Equipment - Tightening Torques
- Electrical Drives - Tightening Torques
- Audio, Navigation, Anti-Theft and Restraints - Service Information 2
- Body Equipment - Service Information 3
- Body Equipment - Special Tools 2
- Audio, Navigation, Anti-Theft and Restraints - Special Tools
- Body Equipment -- Operating Fluids 2
- 2007 NG6 Engine
- NG6 Engine
- New Engine Designations
- New NG6 Versions
- New Vehicles for 2007
- Crankcase
- Bolts
- Cylinder Head Cover
- Cylinder Head
- Valvetrain
- Camshafts
- VANOS
- Valvetronic
- Head Gasket
- Oil Pan Gasket
- Bedplate Sealing
- Crankshaft
- Piston and Connecting Rods
- Intake Manifold
- Crankcase Ventilation
- Crankcase Ventilation (N51 and N52KP)
- Crankcase Ventilation (N54)
- Summary of Mechanical Changes
- Air Management N52KP and N51
- Throttle Valve
- Air Intake Ducting
- Exhaust Gas Turbocharging
- Bi-turbocharging
- Boost-pressure Control
- Blow-off Control
- Charge-air Cooling
- Load Control
- Controlled Variables
- Limp-home Mode
- N52KP and N51 Fuel System
- N54 Engine
- HPI Function
- High Pressure Pump Function and Design
- Pressure Generation in High-pressure Pump
- Fuel System Safety
- Piezo Fuel Injectors
- Injector Design and Function
- Injection Strategy
- Piezo Element
- Injector Control and Adaptation
- Injector Adaptation
- Optimization
- Ignition Management
- Spark Plugs
- Emissions Management
- Cooling System
- Engine-oil Cooling
- Radiator
- Electric Coolant Pump
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- 00 00 250 BMW engine oil service including supplementary service (N52K)
- 11 00 Removing and installing/replacing ignition coil cover (N52K)
- 11 12 000 Removing and installing/sealing cylinder head cover (N52K)
- 11 12 100 Removing and installing cylinder head (N52K)
- 11 12 101 Replacing cylinder head gasket (N52K)
- 11 12 719 Resurfacing cylinder head sealing face (N52K)
- 11 12 729 Checking cylinder head for water leaks (N52K)
- 11 13 000 Removing and installing, sealing or replacing oil sump (N52K)
- 11 14 005 Replacing front crankshaft radial seal (N52K)
- 11 14 010 Replacing sealing cover for vacuum pump (N52K)
- 11 14 151 Replacing crankshaft radial seal (transmission side) (N52K)
- 11 21 500 Replacing crankshaft (N52K)
- 11 21 505 Sealing the crankcase's lower part (N52K)
- 11 21 531 Replacing all main crankshaft bearing shells (N52K)
- 11 21 571 Replacing roller ball bearing in crankshaft (N52K)
- 11 22 500 Removing and installing/replacing flywheel (N52K)
- 11 22 513 Replacing roller bearing for dual-mass flywheel
- 11 24 571 Replacing all connecting rod bearing shells (N52K)
- 11 25 530 Removing and installing/replacing all pistons (N52K)
- 11 25 671 Replacing piston rings on all pistons (N52K)
- 11 28 010 Replacing alternator drive belt (N51)
- 11 28 010 Replacing alternator drive belt (N52K)
- 11 28 020 Replacing tensioning device for alternator drive belt (N51)
- 11 28 020 Replacing tensioning device for alternator drive belt (N52K)
- 11 31 005 Checking timing of camshaft(s) (N52K)
- 11 31 025 Removing and installing/replacing inlet camshaft (N52K)
- 11 31 028 Removing and installing/replacing exhaust camshaft (N52K)
- 11 31 051 Replacing timing chain (N52K)
- 11 31 090 Installing and removing/replacing chain tensioner piston (N52K)
- 11 31 505 Adjusting timing of camshaft(s) (N52K)
- 11 33 050 Removing and installing/replacing all cam followers (N52K)
- 11 34 552 Removing and installing/replacing all valves (N52K)
- 11 34 560 Replacing all valve stem seals (N52K)
- 11 34 715 Replacing all valve springs (N52K)
- 11 37 005 Removing and installing/replacing eccentric shaft (N52K)
- 11 37 010 Removing and installing/replacing intermediate levers (N52K)
- 11 40 000 Checking engine oil pressure (N52, N52K)
- 11 41 000 Removing and installing/replacing oil pump (N52K)
- 11 41 010 Removing and installing/replacing chain module for oil pump/vacuum pump (N52K)
- 11 41 115 Removing and installing/replacing hydraulic valve (N52K)
- 11 42 020 Removing and installing/replacing fullflow oil filter (N52)
- 11 51 000 Removing and installing/replacing water pump (N52K)
- 11 53 000 Removing and installing/replacing coolant thermostat (N52K)
- 11 61 050 Removing and installing air intake manifold (N52K)
- 18 40 050 Removing and installing/replacing front exhaust manifold (N52/ N52K/ N51)
- 11 66 000 Removing and installing or replacing vacuum/oil pump (N47 D20 O1)
- 11 78 513 Replacing both lambda oxygen control sensors (N52K)
- 11 78 545 Replacing both lambda oxygen monitoring sensors (N52K)
- 63 10 004 Adjusting headlights
- 63 10 014 Adjusting fog lamps
- 51 11 710 Removing and installing/replacing left or right headlight bracket (M Technic aerodynamic kit)
- 63 12 001 Removing and installing/replacing left headlight
- 63 12 002 Removing and installing/replacing right headlight
- 63 12 010 Removing and installing/replacing left headlight (xenon headlight)
- 63 12 012 Removing and installing right headlight (xenon headlight)
- 63 12 015 Removing and installing left headlight (adaptive headlight)
- 63 12 016 Replacing left headlight (adaptive headlight)
- 63 12 017 Removing and installing/replacing right headlight (adaptive headlight)
- 63 12 860 Replacing control unit for left xenon headlight
- 63 12 861 Replacing control unit for right xenon headlight
- 63 12 870 Replacing ignition unit for left xenon headlight
- 63 12 871 Replacing right ignition unit for right xenon headlight
- 63 12 895 Replacing drive for left adaptive headlight
- 63 12 896 Replacing drive for right adaptive headlight
- 63 12 950 Replacing a lower holder for headlight mounting
- 63 13 200 Removing and installing/replacing front left or right auxiliary turn signal lamp
- 63 14 120 Removing and installing or replacing rear reflector
- 63 17 060 Removing and installing (replacing) left or right front fog lamp
- 63 17 060 Removing and installing/replacing left or right front fog lamp (M aerodynamic kit)
- 63 21 055 Replacing a socket housing for left or right tail light
- 63 21 101 Replacing sealing frame for left or right rear light (on side panel)
- 63 21 104 Replacing sealing frame for left or right rear light (on rear lid)
- 63 21 180 Removing and installing/replacing left or right rear light (on side panel)
- 63 21 183 Removing and installing/replacing left or right tail light (on rear lid)
- 63 25 000 Removing and installing/replacing auxiliary brake light
- 63 26 000 Removing and installing/replacing left or right number/license plate light
- 63 31 000 Removing and installing/replacing complete ceiling light (front)
- 63 31 015 Removing and installing/replacing left or right interior light (side roofliner)
- 63 31 020 Removing and installing/replacing footwell light
- 63 31 050 Removing and installing/replacing mirror light
- 63 31 080 Removing and installing/replacing luggage compartment light (D-pillar)
- 63 31 085 Removing and installing/replacing luggage compartment lamp (on rear lid)
- 63 31 150 Removing and installing/replacing glovebox light
- 63 99 ... Instructions for handling light bulbs (exterior lights)
- 63 99 ... Instructions for replacing light bulbs (interior lights)
- 63 99 002 Replacing halogen bulb for high-beam headlight on left
- 63 99 003 Replacing halogen bulb for high-beam headlamp on right
- 63 99 072 Replacing halogen bulb for left (or right) headlight
- 63 99 076 Replacing bulb for left xenon headlight
- 63 99 077 Replacing bulb for right xenon headlight
- 63 99 140 Replacing bulb for side marker lamp, front left
- 63 99 141 Replacing bulb for side marker lamp, front right
- 63 99 201 Replacing halogen bulb for left or right front fog lamp
- 63 99 273 Replacing bulb for turn indicator, front left
- 63 99 275 Replacing bulb for turn indicator, front right
- 63 99 295 Replacing bulb for auxiliary turn signal light, front left or right
- 63 99 312 Replacing bulb(s) for left or right rear light (rear lid)
- 63 99 315 Replacing light bulb(s) for left or right rear light
- 63 99 401 Replacing bulb for left or right license plate light
- 63 99 431 Replacing bulb for front ceiling light
- 63 99 435 Replacing light bulb for left or right interior light
- 63 99 437 Replacing light bulb for footwell light
- 63 99 451 Replacing light bulb for luggage compartment lighting
- 63 99 452 Replacing light bulb for luggage compartment light (on rear lid)
- 63 99 461 Replacing bulb for glovebox light
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00 ... ... Raising vehicle with trolley jack
- 31 00 ... Information on replacing shock absorbers
- 31 00 ... Notes on repairing threads
- 31 10 010 Removing and installing/replacing reinforcement plate
- 51 47 490 Removing and installing / replacing front underbody protection
- 51 47 491 Removing and installing/replacing rear underbody protection
- 31 11 001 Replacing front axle carrier (6-cylinder)
- 31 11 506 Lowering/raising front axle carrier
- 31 12 000 Removing and installing/replacing left or right control arm
- 31 12 003 Removing and installing / replacing top right wishbone
- 31 12 023 Measuring play of wheel control joints
- 31 12 026 Removing and installing/replacing guide joint in swivel bearing
- 31 12 050 Removing and installing/replacing left or right tension strut
- 31 12 135 Replacing rubber mounts on both control arms
- 31 12 138 Replacing rubber mounts on both tension struts
- 31 12 640 Replacing rubber mounts in both control arms (control arms removed)
- 31 21 090 Replacing (removing and installing) left or right swivel bearing
- 31 21 180 Replacing bearing for front wheel
- 31 31 000 Removing and installing complete left or right spring strut shock absorber
- 31 31 031 Replacing front left or right spring strut shock absorber
- 51 71 373 Removing and installing/replacing tension strut on spring strut dome
- 31 33 001 Replacing front left or right spring strut support bearing
- 31 33 095 Measuring ride-level height of vehicle
- 31 33 100 Removing and installing/replacing coil spring for left or right front spring strut
- 31 35 000 Removing and installing/replacing front stabilizer
- 31 35 005 Removing and installing/replacing push rod (stabilizer link) for left/right stabilizer
- 31 35 021 Replacing rubber mounts of stabilizer retaining fixture on front axle subframe
- 31 50 ... Changing front differential oil
- 31 50 001 Removing and installing/replacing front differential
- 31 51 010 Replacing radial seal for drive flange of front differential
- 31 51 015 Replacing shaft seal for left output shaft
- 31 51 020 Replacing shaft seal for right output shaft
- 31 51 060 Replacing O-ring for front differential on right
- 31 51 065 Replacing O-ring for bearing block
- 31 53 040 Removing and installing/replacing right output shaft bearing block
- 31 60 ... Pressing output shaft out of drive flange (wheel hub) and drawing in
- 31 60 000 Removing and installing/replacing left or right output shaft
- 31 60 530 Replacing an output shaft gaiter (on transmission side) (output shaft removed)
- 31 60 535 Replacing both gaiters on left and right of output shaft
- Fuel System - Special Tools
- Engine Diagnosis - Overview 3
- Fuel Supply System - Repair 2
- Fuel System - Repair 3
- Fuel System - Technical Data
- Fuel Supply System - Technical Data
- Fuel System - Tightening Torques
- Fuel Supply System - Tightening Torques
- Fuel Supply System - Special Tools 2
- Fuel System - Operating Fluids
- 12 00 ... Instructions on starting aid
- 61 00 ... Battery
- 61 00 ... Repairing airbag cables
- 61 00 ... Safety instructions for handling vehicle battery
- 61 13 Opening plug housings and removing contacts of different plug systems
- 61 13 .. Unlocking and disconnecting different plug connections
- 61 13 ... Treating cables and fibre-optic cables
- 61 12 004 Replacing battery positive lead (from battery to engine compartment partition connector)
- 61 12 013 Replacing negative battery cable
- 61 13 Butt connector for repairing a plug connection
- 61 13 Crimping stop parts
- 61 13 Cutting to length and stripping insulation from cables
- 61 13 ... DME master relay connector
- 61 13 Installing fan connector for retrofitting/repairs
- 61 13 ... Base of tab connector housings
- 61 13 ... Crimping Micro Power Quadlock contacts (MPQ)
- 61 13 ... Crimping Micro Quadlock System contacts (MQS)
- 61 13 ... Crimping annular contacts
- 61 13 ... Crimping optical fibres
- 61 13 ... Cutting off, stripping insulation and cutting optical fibres to length
- 61 13 ... In-line plugs, 30-pin, Hybrid System MQS/MPQ
- 61 13 ... Plug housing, LCC contact (load current contact)
- 61 13 ... Relay carrier
- 61 13 ... Repairing ribbon cables
- 61 13 ... Socket housing (radio plug), Hybrid System MQS/MPQ
- 12 00 ... Instructions for disconnecting and connecting battery
- 61 20 ... Battery charging
- 61 20 900 Disconnecting and connecting battery negative lead
- 61 21 010 Removing and installing battery
- 61 31 005 Removing and installing/replacing fixture for steering column stalk
- 61 31 016 Removing and installing/replacing turn indicator/headlight dipping switch
- 61 31 020 Removing and installing/replacing ignition starter switch
- 61 31 037 Removing and installing/replacing light control unit
- 61 31 040 Removing and installing/replacing switch for windscreen wipers
- 61 31 057 Removing and installing/replacing switch unit in center console
- 61 31 069 Removing and installing/replacing indicator for front passenger airbag deactivation
- 61 31 079 Removing and installing/replacing switch for hazard warning flashers/central locking
- 61 31 175 Removing and installing/replacing switch for slide/tilt sunroof
- 61 31 176 Removing and installing/replacing emergency call button
- 61 31 208 Removing and installing/replacing switch for front lumbar support
- 61 31 225 Replacing switch on impact cushion for left and right airbags
- 61 31 228 Replacing switch on sports steering wheel
- 61 31 241 Removing and installing/replacing engine hood contact switch
- 61 31 255 Replacing switch for outside mirror
- 61 31 270 Removing and installing/replacing switch for reversing light
- 61 31 299 Removing and installing/replacing clutch switch module
- 61 31 310 Replacing brake-light switch
- 61 31 382 Replacing level switch for coolant
- 61 31 440 Removing and installing/replacing temperature switch for heated windshield spray jets
- 61 31 465 Removing and installing/replacing relay/module (in device holder on left)
- 61 31 470 Removing and installing/replacing relay/module (in instrument panel at bottom right)
- 61 31 492 Replacing level switch for windscreen washer system
- 61 33 040 Removing and installing/replacing a fanfare horn (left or right)
- 61 35 ... Notes on ESD protection (Electro Static Discharge)
- 61 35 000 Removing and installing/replacing module (for trailer two hitch)
- 61 35 122 Removing and installing/replacing general module
- 61 35 177 Removing and installing (replacing) rain/light sensor
- 61 35 285 Removing and installing (replacing) light module
- 61 35 679 Initializing rain/light sensor
- 61 35 714 Removing and installing/replacing control unit for slide/tilt sunroof
- 61 35 795 Removing and installing (replacing) control unit for adaptive headlight
- 61 35 900 Removing and installing/replacing ring antenna of electronic immobilizer
- 61 35 910 Removing and installing/replacing control unit of electronic immobilizer
- Vehicle programming and coding
- 61 61 01. Adjusting left or right windscreen wiper
- 61 61 010 Checking/adjusting contact angle of windscreen wiper arms on windscreen
- 61 61 041 Replacing both windscreen wiper blades
- 61 61 100 Removing and installing/replacing both windscreen wiper arms
- 61 61 270 Removing and installing complete wiper console
- 61 62 020 Removing and installing/replacing rear window wiper blade
- 61 62 030 Replacing wiper arm for rear window wiper
- 61 62 060 Removing and installing/replacing rear window wiper motor
- 61 62 100 Adjusting jet nozzle for rear window washer unit
- 61 62 110 Removing and installing/replacing spray nozzle for rear window wiper
- 61 62 150 Removing and installing/replacing window washer pump for rear window washer system
- 61 62 170 Removing and installing/replacing nonreturn valve for rear window washer system
- 61 67 010 Removing and installing/replacing washer pump of headlight cleaning system
- 61 67 040 Adjusting spray nozzles for headlight cleaning system
- 61 67 045 Removing and installing/replacing spray nozzles for left or right headlight cleaning system (up to 9/2006)
- 61 67 045 Removing and installing/replacing spray nozzles of headlight washer system on left or right (from 09/2006)
- 61 67 083 Removing and installing/replacing high - pressure nozzle of left or right headlight washer system (M aerodynamic kit)
- 61 71 015 Removing and installing/replacing a jet nozzle in windshield washer system
- 61 71 100 Removing and installing/replacing windshield washer pump
- 64 11 077 Removing and installing/replacing Bowden cable for temperable ventilation
- 64 11 213 Removing and installing/replacing heater - A/C unit fan
- 64 11 227 Replacing output stage/switch for heater - A/C system blower
- 64 11 377 Removing and installing control panel for heater - A/C system (replacing, automatic air conditioning)
- 64 11 807 Removing and installing/replacing servodrive for right fresh-air flap
- 64 11 992 Removing and installing/replacing solar sensor
- 64 11 910 Removing and installing/replacing temperature sensor for heater core
- 64 11 845 Replacing actuator drive of defroster flaps
- 64 11 839 Replacing actuator drive of footwell flap
- 64 11 829 Replacing actuator drive of ventilation flaps
- 64 11 942 Replacing evaporator temperature sensor
- 64 11 208 Replacing heater core
- 64 11 800 Replacing servodrive on gear for flap control (A/C control)
- 64 22 135 Removing and installing/replacing left fresh-air grill
- 64 22 136 Removing and installing/replacing right fresh-air grill
- 64 22 162 Removing and installing/replacing center fresh-air grill
- 64 31 010 Replacing microfilter for interior ventilation
- 64 31 080 Removing and installing/replacing microfilter housing
- 64 50 ... Instructions for handling refrigerant R 134a
- 64 50 ... Instructions for handling refrigerant oil (for refrigerant R 134a)
- 64 50 ... Safety instructions for handling refrigerant R134a
- 64 50 009 Drawing off, evacuating and filling A/C system (R 134a)
- 64 52 ... Instructions for opening and replacing parts in refrigerant circuit
- 64 51 522 Removing and installing or replacing expansion valve
- 64 52 521 Replacing A/C system compressor (N52K)
- 64 52 521 Replacing air conditioning compressor (N54, N55)
- 64 53 ... Notes on replacing drier bottle or drier insert
- 64 53 ... Replacing valve insert for refrigerant line
- 64 53 510 Removing and installing/replacing dryer bottle for air conditioner
- 64 53 520 Replacing safety pressure switch
- 64 53 550 Removing and installing or replacing capacitor for the heating and air conditioning system
- Steering - Overview 2
- Steering & Wheel Alignment - Repair 5
- Steering and Wheel Alignment - Technical Data
- Steering and Wheel Alignment - Tightening Torques
- Steering and Wheel Alignment - Service Techniques 4
- Steering and Wheel Alignment - Special Tools
- Steering and Wheel Alignment - Operating Fluids
- 23 0 000 Attachment
- 23 0 020 Holder
- 23 0 030 Support
- 23 0 040 Support
- 23 0 050 Support
- 23 0 060 Support
- 23 0 070 Mounting bracket
- 23 0 080 Fixture
- 23 0 090 Support
- 23 0 100 Support
- 23 0 130 Take-up support for transmission
- 23 0 140 Support
- 23 0 150 Support
- 23 0 160 Support
- 23 0 170 Support
- 23 0 180 Impact ring with slip sleeve
- 23 0 190 Impact bush
- 23 0 200 Socket 41 A/F
- 23 0 250 Holder
- 23 0 370 Drift
- 23 0 490 Extractor
- 23 1 000 Fixture
- 23 1 010 Fiture for removing rear section of transmission casing
- 23 1 020 Fixture for removing transmission casing (front and rear section)
- 23 1 030 Drift for fitting inner bearing race on countershaft
- 23 1 040 Drift
- 23 1 050 Puller (Kukko)
- 23 1 060 Fixture
- 23 1 070 Measuring ring
- 23 1 080 Drift
- 23 1 090 Drift
- 23 1 100 Puller claws
- 23 1 110 Drift
- 23 1 120 Drift
- 23 1 130 Drift
- 23 1 170 Fixture
- 23 1 180 Drift
- 23 1 190 Drift
- 23 1 200 Guide bush
- 23 1 220 Drift
- 23 1 230 Spindle (2)
- 23 1 240 Drift
- 23 1 270 Drift
- 23 1 300 Fixture
- 23 1 310 Tool
- 23 1 350 Puller fixture
- 23 1 360 Drift
- 23 1 370 Drift
- 23 1 380 Drift
- 23 1 390 Drift
- 23 1 400 Fixture
- 23 1 410 Drift
- 23 1 420 Fixture
- 23 1 430 Thrust piece
- 23 1 440 Holding sleeve
- 23 1 450 Guide pins (2 x)
- 23 1 460 Puller plate
- 23 1 480 Drift
- 23 1 490 Fixture
- 23 2 000 Rillex ball bearing extractor 6206
- 23 2 010 Rellex ball bearing extractor 6206 E
- 23 2 020 Rillex ball bearing extractor
- 23 2 050 Rillex ball bearing extractor 6205
- 23 2 060 Rillex ball bearing extractor 6306
- 23 2 080 Adapter
- 23 2 100 Pliers
- 23 2 150 Pressure sleeve
- 23 2 160 Impact bush
- 23 2 170 Fixture
- 23 2 180 Guide bush
- 23 2 200 Circlip pliers (straight)
- 23 2 210 Circlip pliers (straight)
- 23 2 220 Drift
- 23 2 230 Disc
- 23 2 250 Bracket
- 23 2 270 Fixture
- 23 2 280 Puller plate
- 23 2 290 Fixture
- 23 2 300 Drift
- 23 2 310 Fixture
- 23 2 320 Socket for socket wrench WAF 36
- 23 2 330 Fixture
- 23 2 340 Drift
- 23 2 350 Drift
- 23 2 360 Drift
- 23 2 370 Fixture
- 23 2 470 Impact bush
- 23 2 480 Impact bush
- 23 2 490 Impact bush and slip sleeve
- 23 3 010 Fixture
- 23 3 020 Mounting sleeve
- 23 3 110 Drift
- 23 3 160 Set of tools
- 23 3 169 Set of tools
- 23 3 200 Extractor
- 23 3 210 Extractor
- 23 3 220 Drift
- 23 3 230 Drift
- 23 4 000 Drift set
- 23 4 030 Fixture
- 23 4 040 Grease gun
- 23 4 150 Universal transmission bracket
- Basic Measuring Techniques - Overview
- Engine Technology - Overview
- Engine General Information (N54, N52) 4
- Engine - Repair (N52) 4
- Engine and Gearbox Suspension - Repair
- Engine - Technical Data 2
- Engine - Tightening Torques (N52) 2
- Engine and Gearbox Suspension - Tightening Torques
- Engine - Service Techniques (N52) 3
- Engine - Special Tools 2
- Engine and Gearbox Suspension - Special Tools
- Engine - Operating Fluids 3
- Maintenance and General Information - Service Techniques 2
- Maintenance and General Information - Tightening Torques 2
- Product Overview - X3 3
- Maintenance and General Information - Repair 6
- Maintenance and General Information - Special Tools 4
- Maintenance and General Information - Operating Fluids 3
- Car Care Products -- Operating Fluids
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00 ... ... Raising vehicle with trolley jack
- 33 00 ... Information on replacing shock absorbers
- 33 00 ... Notes on repairing threads
- 33 10 ... Rear differential: Assignment to model series
- 33 10 010 Removing and installing/replacing rear differential
- 00 11 ... Checking/topping up oil level in rear differential
- 00 11 259 Oil change in rear differential incl. used oil disposal
- 33 11 ... Replacing rear cover gasket on rear differential (168K)
- 33 11 ... Replacing rear cover gasket on rear differential (188K)
- 33 11 ... Replacing rear cover gasket on rear differential (188L / 188LW)
- 33 11 ... Replacing rear cover gasket on rear differential (215K)
- 33 11 021 Replacing shaft seal for input flange on final drive
- 33 11 080 Replacing left drive flange on rear differential
- 33 11 085 Replacing right drive flange on rear differential
- 33 11 140 Replacing shaft seal for left drive flange
- 33 11 145 Replacing shaft seal for right drive flange
- 33 11 271 Replacing rear cover gasket on rear differential
- 33 11 271 Replacing cover gasket on rear differential (235L)
- 33 17 004 Replacing all rubber mounts for differential mounting at front
- 33 17 005 Replacing rubber mount for rear differential mounting at rear
- 33 21 ... Pressing output shaft out of drive flange and drawing in (output shaft removed from rear differential)
- 33 21 ... Ribbed teeth
- 33 21 001 Removing and installing / replacing left output shaft
- 33 21 002 Removing and installing / replacing right output shaft
- 33 21 035 Replacing gaiter on left output shaft
- 33 21 035 Replacing gaiter on left output shaft (altered sealing cover)
- 33 21 036 Replacing gaiter on right output shaft
- 33 31 000 Removing and installing complete rear axle carrier
- 33 31 011 Replacing rear axle carrier
- 33 31 503 Lowering/raising rear axle carrier
- 33 32 ... Replacing bearing block for front trailing arm
- 33 32 000 Removing and installing complete left or right trailing arm
- 33 32 021 Replacing left or right trailing arm
- 33 32 042 Replacing a rubber mount in trailing arm, front
- 33 32 044 Replacing one rubber mount/ball joint in trailing arm for lower control arm
- 33 32 047 Replacing a ball joint in trailing arm for upper control arm
- 33 32 071 Replacing one upper control arm
- 33 32 086 Removing and installing/replacing bottom left control arm
- 33 32 087 Removing and installing/replacing bottom right control arm
- 33 32 160 Removing and installing/replacing compression strut for rear axle carrier
- 33 32 170 Removing and installing/replacing left or right tension strut
- 33 32 525 Replacing one ball joint in the semitrailing arm (semi-trailing arm removed)
- 33 32 671 Replacing one rubber mount in the upper control arm (control arm removed)
- 33 32 681 Replacing one rubber mount in lower control arm (control arm removed)
- 33 33 101 Replacing two rubber mounts for rear axle carrier
- 33 33 111 Replacing all rubber mounts for rear axle support
- 33 33 515 Replacing two further rubber mounts for rear axle carrier
- 33 41 005 Replacing left drive flange on rear axle shaft
- 33 41 007 Replacing right drive flange on rear axle shaft
- 33 41 153 Replacing left wheel bearing on rear axle shaft
- 33 41 155 Replacing right wheel bearing on rear axle shaft
- 33 52 000 Removing and installing / replacing rear left or right shock absorber
- 33 52 161 Replacing rear left or right thrust bearing for spring strut / shock absorber
- 33 53 ... Measuring ride-level height of vehicle
- 33 53 000 Removing and installing / replacing rear left or right coil spring
- 33 55 000 Removing and installing/replacing rear stabilizer
- 33 55 021 Replacing both rubber mounts for stabilizer mounting
- 33 55 040 Replacing stabilizer links for stabilizer
- 52 13 ... Removing and installing/replacing guide for front left or right head restraint
- 52 13... Removing and installing/replacing seat pan and flexmat (normal/manual), left or right
- 52 13 015 Removing and installing / replacing controls on left / right front seat (normal / manual)
- 52 13 025 Removing and installing/replacing seat mechanism (on front seat normal/manual), left or right
- 52 13 030 Removing and installing / replacing backrest frame on left or right front seat (normal / manual).
- 52 13 040 Removing and installing / replacing outer cover on left or right front seat back-rest (normal / manual)
- 52 13 041 Removing and installing / replacing inner cover on left or right front seat backrest (normal/ manual)
- 52 13 050 Replacing lumbar cushion on front left or right seat
- 52 13 070 Removing and installing/replacing seat angle adjuster (normal/manual) on left or right front seat
- 52 13 198 Removing and installing / replacing rear panel on left or right front seat backrest (normal/manual)
- 52 13 390 Removing and installing / replacing front headrest (normal/ manual)
- 52 13 400 Replacing seat cover on left or right front seat (normal/manual)
- 52 13 405 Replacing back-rest cover for left or right front seat (normal / manual)
- 52 13 410 Replacing seat and backrest covers for front seat (normal/manual), left or right
- 52 13 415 Replacing left or right support for front seat (normal / manual)
- 52 13 420 Replacing left or right support for front seat back-rest (normal / manual)
- 52 14... Removing and installing/replacing guide for front left or right head restraint (normal/electric)
- 52 14 000 Removing and installing left or right front seat (normal/electric)
- 52 14 025 Removing and installing/replacing seat mechanism on left or right front seat (normal/electric)
- 52 14 030 Removing and installing/replacing backrest frame on front left or right seat (normal/electric)
- 52 14 040 Removing and installing/replacing outer cover on front left or right seat (normal/electric)
- 52 14 041 Removing and installing/replacing inner cover on front left or right seat (normal/electric)
- 52 14 050 Replacing lumbar cushion on front left or right seat (normal/electric)
- 52 14 060 Removing and installing / replacing valve housing for front left or right lumbar support (normal / manual)
- 52 14 070 Removing and installing/replacing seat angle adjuster on left or right front seat (normal/electric)
- 52 14 198 Removing and installing/replacing rear panel on left or right front seat backrest (normal/electric)
- 52 14 390 Removing and installing or replacing front left or right head restraints (normal/electric)
- 52 14 400 Replacing seat cover for left or right front seat (normal/electric)
- 52 14 405 Replacing backrest cover for front left or right seat (normal/electric)
- 52 14 415 Replacing support for left or right front seat (normal/electric)
- 52 14 420 Replacing padding for left or right front seat backrest (normal/electric)
- 52 15... Removing and installing/replacing guide for front left or right head restraint (sports/normal)
- 52 15 000 Removing and installing front seat (sports/manual), left or right
- 52 15 015 Removing and installing/replacing actuating unit on front left or right seat (sports/manual)
- 52 15 025 Removing and installing/replacing seat mechanism on left or right front seat (sport/manual)
- 52 15 030 Removing and installing/replacing backrest frame on left or right front seat (sport/manual)
- 52 15 040 Removing and installing/replacing outer cover on front left or right seat (sports/manual)
- 52 15 041 Removing and installing/replacing inner cover on front left or right seat (sports/manual)
- 52 15 050 Replacing lumbar cushion on front left or right seat (sports/manual)
- 52 15 070 Removing and installing/replacing seat angle adjuster (sport/manual) on left or right front seat
- 52 15 095 Removing and installing/replacing thigh support holder on front left or right seat (sports/manual)
- 52 15 198 Removing and installing/replacing rear panel on front left or right seat backrest (sports/manual)
- 52 15 390 Removing and installing or replacing front left or right head restraints (sports/manual)
- 52 15 400 Replacing seat cover for left or right front seat (sport/manual)
- 52 15 405 Replacing backrest cover for left or right front seat (sport/manual)
- 52 15 415 Replacing padding for left or right front seat (sport/manual)
- 52 15 420 Replacing padding for left or right front seat backrest (sport/manual)
- 52 16... Removing and installing/replacing carrier for outer cover on left or right front seat (sports/electric)
- 52 16... Removing and installing/replacing guide for front left or right head restraint (sports/electric)
- 52 16... Removing and installing/replacing seat pan and flex mat on front left or right seat (sports/electric)
- 52 16 000 Removing and installing front seat (sports/electric), left or right
- 52 16 025 Removing and installing/replacing left or right seat mechanism (on sport/electric front seat)
- 52 16 030 Removing and installing/replacing backrest frame on left or right front seat (sport/electric)
- 52 16 040 Removing and installing/replacing outer cover on front left or right seat (sports/electric)
- 52 16 041 Removing and installing/replacing inner cover on front left or right seat (sports/electric)
- 52 16 070 Removing and installing/replacing seat angle adjuster on left or right front seat (sport/electric)
- 52 16 095 Removing and installing/replacing thigh support holder on front left or right seat (sports/electric)
- 52 16 198 Removing and installing/replacing rear panel on front left or right seat backrest (sports/electric)
- 52 16 390 Removing and installing/replacing front head restraint (sports/electric) on left or right
- 52 16 400 Replacing seat cover for left or right front seat (sports/electric)
- 52 16 405 Replacing backrest cover on front left or right seat (sports/electric)
- 52 16 415 Replacing support for left or right front seat (sport/electric)
- 52 16 420 Replacing padding for left or right front seat backrest (sport/electric)
- 52 26... Removing and installing/replacing finishing strip on armrest for rear seat
- 52 26... Removing and installing/replacing fixture for roller blind on rear seat (through - loading system) on left/right
- 52 26... Removing and installing/replacing ski bag with casing on rear seat (through-loading system)
- 52 26 005 Removing and installing/replacing rear seat (through-loading system)
- 52 26 008 Removing and installing/replacing left/right sides of backrest on rear seat backrest (through-loading)
- 52 26 015 Removing and installing/replacing left or right rear seat backrest (through-loading system)
- 52 26 030 Removing and installing/replacing armrest for rear seat backrest (through-loading system)
- 52 26 033 Removing and installing/replacing upper cover section on armrest for rear seat
- 52 26 080 Removing and installing/replacing backrest frame for left rear seat (through - loading system)
- 52 26 085 Removing and installing/replacing backrest frame for right rear seat (through-loading system)
- 52 26 199 Removing and installing/replacing rear panel on left rear seat backrest (through - loading system)
- 52 26 200 Removing and installing/replacing rear panel on right rear seat backrest (through - loading system)
- 52 26 301 Removing and installing /replacing actuating mechanism for left rear seat backrest (through-loading system)
- 52 26 309 Removing and installing/replacing lock for left rear seat backrest (through-loading system)
- 52 26 388 Removing and installing/replacing rear head restraints (through-loading system), middle (Compact)
- 52 26 388 Removing and installing/replacing rear middle head restraint
- 52 26 390 Removing and installing or replacing left or right rear head restraint
- 52 26 390 Removing and installing/replacing rear head restraint (through-loading system), left or right (Compact)
- 52 26 400 Replacing seat cover for rear seat (through-loading system)
- 52 26 411 Replacing backrest cover for rear seat (through-loading system) on left
- 52 26 412 Replacing backrest cover for right rear seat (through-loading system)
- 52 26 450 Replacing padding for rear seat
- 54 0 ... Repair instructions for bonded seals
- 54 10 ... Removing and installing/replacing drive cable plate
- 54 10 ... Eliminating floating roofliner clicking noises
- 54 10 020 Removing and installing mechanism for front glass lid
- 54 10 030 Removing and installing mechanism for rear glass lid
- 54 10 050 Removing and installing/replacing mechanism for floating roofliner
- 54 10 070 Removing and installing/replacing slider set for floating roofliner
- 54 10 160 Replacing left or right gaiter for glass slide/tilt sunroof
- 54 10 170 Removing and installing front glass slide/tilt sunroof cover
- 54 10 175 Removing and installing rear glass slide/tilt sunroof cover
- 54 13 130 Removing and installing front cross - member
- 54 13 150 Removing and installing rear cross - member
- 54 0 ... Notes on panorama glass roof (initialization/normalization/learning of characteristic curve)
- 54 13 003 Adjusting glass slide/tilt sunroof lid
- 54 13 050 Replacing seal for slide/tilt sunroof lid at rear
- 54 13 055 Replacing seal for slide/tilt sunroof frame
- 54 13 060 Removing and installing/replacing front floating roofliner for glass slide/tilt sunroof
- 54 13 065 Removing and installing/replacing rear floating roofliner for glass slide/tilt sunroof
- 54 13 070 Removing and installing/replacing both floating roofliners for glass slide/tilt sunroof
- 54 13 080 Removing and installing complete glass slide/tilt sunroof
- 54 13 090 Removing and installing/replacing wind deflector
- 54 13 095 Replacing/cleaning net for wind deflector
- 54 13 100 Removing and installing/replacing drip molding
- 54 13 105 Removing and installing/replacing rear drip molding
- 32 00 ... Information on replacing steering gear after accident damage
- 32 00 ... Moving vehicle into design position
- 32 00 ... Moving vehicle into normal position
- 32 00 ... Performing rim runout compensation
- 32 00 610 Adjusting toe-in and camber on front axle
- 32 00 620 Adjusting rear axle
- 32 11 100 Replacing gaiter for steering gear on left or right
- 32 13 ... Fitting repair kit for FCD coupling
- 32 13 ... Notes on removing/installing FCD clutches
- 32 13 006 Bleeding power steering unit
- 32 13 060 Removing and installing/replacing power steering gear
- 32 13 650 Removing and installing/replacing EH converter for Servotronic
- 32 21 151 Replacing left or right tie rod
- 32 21 231 Replacing left or right tie rod
- 32 31 003 Replacing upper section of steering column trim
- 32 31 020 Removing and installing / replacing lower section of steering column trim
- 32 31 070 Removing and installing / replacing lower section of steering spindle
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 090 Removing and installing/replacing steering column
- 32 31 102 Replacing steering spindle sleeve
- 32 31 219 Removing and installing/replacing double joint with flexible disk
- 32 31 241 Replacing adjusting lever for steering column
- 32 32 050 Removing and installing/replacing steering lock cylinder
- 32 32 170 Removing and installing/replacing interlock cable
- 32 33 ... Replacing left or right cover for steering wheel (from 09/2006)
- 32 33 000 Removing and installing/replacing steering wheel (from 09/2006)
- 32 33 010 Removing and installing sports steering wheel
- 32 33 015 Replacing sports steering wheel
- 32 34 020 Removing and installing/replacing airbag unit (from 09/2006)
- 32 34 030 Removing and installing / replacing airbag unit (sport steering wheel)
- 32 41 ... Instructions for removing and installing ear clips
- 32 41 009 Checking function of power steering vane pump
- 32 41 060 Removing and installing/replacing power steering vane pump (N52)
- 32 41 100 Removing and installing/replacing belt pulley on vane pump for power steering
- 32 41 311 Replacing suction line for power steering (N52)
- 32 41 331 Replacing pressure line for power steering (N52)
- 32 41 341 Replacing cooler return line for power steering (M54, N46, N52)
- 32 41 351 Replacing return line for power steering
- 32 43 521 Replacing Servotronic control unit
- 00 00 ... Body and Underbody: Checking For Corrosion and Damage
- 00 00 ... Raising BMW Multi-Trailer
- General Notes On Using Twin-Pillar Lifting Platforms
- Becker & Sohne Twin-Strut Underfloor Platform
- MAHA Twin-Pillar Lifting Platform
- Romaico-Lift Twin-Pillar Lifting Platform
- Working Pit
- 86 10 ... Adjusting Brake System
- 86 10 ... Adjusting Spring Force Accumulator
- 86 10 ... Removing Camlock Retaining Cam on Loading Ramp
- 86 10 ... Removing Camlock Screw Cap
- 86 10 ... Removing and Installing or Replacing Left or Right Coil Spring
- 86 10 ... Removing Bolt On Loading Ramp
- 86 10 ... Removing Brake Shoes
- 86 10 ... Removing Entry Profile Section On Loading Ramp, Left, Right and Center
- 86 10 ... Removing Left or Right Shock Absorber
- 86 10 ... Removing Loading Ramp Lock
- 86 10 ... Removing Mounting Bracket Sealing Cap
- 86 10 ... Removing Mounting Bracket, Center, Left and Right
- 86 10 ... Removing Outer Pull Rod Mount, Left and Right
- 86 10 ... Removing Overrunning Equipment/Maintaining or Replacing Guide Bush/Installing Overrunning Equipment
- 86 10 ... Removing Plastic Bush/Metal Bush
- 86 10 ... Removing Rear Supports and Bracket
- 86 10 ... Removing Reflecting Rear Light
- 86 10 ... Removing Rest On Loading Ramp, Left, Right and Center
- 86 10 ... Removing Shock Absorber From Overrunning Equipment
- 86 10 ... Removing Trailing Arm, Removing and Installing or Replacing Mounting
- 86 10 ... Removing Wheel Bearing
- 86 10 ... Removing Wooden Rest On Loading Ramp, Left, Right and Center
- 86 10 ... Repair Work On GFP Components With Gelcoat Surface
- 86 10 ... Replacing 12 Volt Socket
- 86 10 ... Replacing Bar
- 86 10 ... Replacing Drawbar Members, Left and Right
- 86 10 ... Replacing Gaiter
- 86 10 ... Replacing Holder For Chock
- 86 10 ... Replacing Lashing Plate and Lashing Eye
- 86 10 ... Replacing License Plate Light
- 86 10 ... Replacing Position Light
- 86 10 ... Replacing Rear Light
- 86 21 ... Adjusting Hood Pretension - Camloc Fastener With Spacers
- 86 21 ... Adjusting Rear Lid To Fit
- 86 21 ... Adjusting Rotary Striker Lock
- 86 21 ... Adjusting Side Lid To Fit
- 86 21 ... Attaching/Replacing BMW Badge
- 86 21 ... Fitting BMW Logo
- 86 21 ... Installing Hood Seal
- 86 21 ... Installing Rubber Roof Strip
- 86 21 ... Installing Seal For Rear Lid and Side Lid
- 86 21 ... Installing Sponge Rubber Seal
- 86 21 ... Removing Ball Pivot
- 86 21 ... Removing Centering Pin From Mounting Bracket
- 86 21 ... Removing Gas Spring
- 86 21 ... Removing Gas Spring Retaining Bracket
- 86 21 ... Removing Hinge Bracket On Rear Lid
- 86 21 ... Removing Lid
- 86 21 ... Removing Lock Barrel
- 86 21 ... Removing Lock Striker Fixture On Rear Lid
- 86 21 ... Removing Plug For Inside Light
- 86 21 ... Removing Roof Railing
- 86 21 ... Removing Roof Railing Adapter
- 86 21 ... Removing Rotary Striker Lock
- 86 21 ... Removing Side Lid Hinge
- 86 21 ... Replacing Inside Light
- 86 21 ... Replacing Inside Light Power Cable
- 36 10 209 Checking front and rear wheel for face and radial runout
- 36 10 300 Removing or installing front or rear wheel
- 36 10 508 Stationary wheel balancing
- 36 10 713 Checking one road wheel on balancing machine for face and radial runout (wheel removed)
- 36 10 715 Checking rim for face and radial runout
- 36 11 105 Removing and installing RDC (Tire Pressure Control) control unit
- 36 11 115 Removing and installing/replacing RDC receiving aerial
- 36 11 121 Removing and installing/replacing an RDC trigger transmitter (front)
- 36 11 533 Removing and installing/renewing tire pressure control wheel electronics (2nd Generation)
- 36 11 500 Initializing Run Flat Indicator (RPA)
- 36 11 533 Removing and installing / replacing RDC wheel electronics
- 36 12 005 Replacing a runflat tire