Repair manual
Wiring diagrams
BMW 7 series E65/E66 facelift Repair Manual
Step-by-step repair and maintenance instructions for the BMW 7 series E65/E66 facelift (2005–2008): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
83sections
1574articles
ENManual language
- Heating and Air Conditioning - Service Information 4
- Heating and Air Conditioning - Technical Data
- Heating and Air Conditioning - Tightening Torques
- Heating and Air Conditioning - Special Tools
- Heating and Air Conditioning - Repair 4
- Operating Fluids - Air Conditioning and Heating 2
- Ihka Automatic Heating & Air Conditioning System - Overview - E65 & E66 4
- Rear Air Conditioning - Overview 7
- Standard/automatic Transmission - Overview 5
- Automatic Transmission - Removal & Installation 2
- On-Vehicle Servicing - GA6HP26Z 4
- Gear Shift Mechanisms 2
- Automatic Transmission - Service Information 3
- Electronic Transmission Control - Overview 5
- Operating Fluids - Automatic Transmission 3
- Operating Fluids - Gear Shift Mechanism
- Smg Ii - Overview 3
- Automatic Transmission - Overview (GA6HP26Z) 3
- Automatic Transmission Control - Overview 6
- Most Bus Diagnostics - Overview 4
- Introduction to Bus Systems - Overview 4
- Body Electronics Iii - Overview 5
- Operating Fluids - Electrical System
- Most Bus Diagnosis - Overview 3
- Cip Programming - Overview
- Dvom - Overview 2
- Breakout Boxes & Connectors - Overview 3
- Electric Signals - Overview
- Power Module - Overview 5
- Central Body Electronics - Overview - 7-SERIES (E65/E66) 4
- 51 00... Safety instructions for working on cars with AIRBAG systems
- 51 00... Service position of engine hood
- 51 23 131 Adjusting left or right striker on engine hood
- 51 23 265 Removing and installing/replacing left or right gas strut for engine bonnet/hood
- 51 11... Installing/replacing license plate (without base)
- 51 11... Removing and installing/replacing cover for headlight washer system on left
- 51 11 050 Removing and installing / replacing carrier for front bumper trim
- 51 11 156 Removing and installing front bumper trim
- 51 11 157 Replacing front bumper trim
- 51 11 158 Replacing baseplate for license plate
- 51 11 170 Replacing body molding for left or right bumper
- 51 11 180 Removing and installing / replacing trim grille in bumper trim (up to 03/2005)
- 51 11 701 Replacing holder for bumper at front left and right
- 51 12 050 Removing and installing / replacing carrier for rear bumper trim
- 51 12 080 Removing and installing/replacing trim on bumper trim
- 51 12 156 Removing and installing rear bumper trim
- 51 12 157 Replacing rear bumper trim
- 51 12 432 Replacing central body molding on rear bumper
- 51 12 435 Replacing left or right body molding from sides of rear bumper
- If replacing version with Chromeline
- 51 12 437 Replacing all body moldings for rear bumper
- 51 12 801 Replacing bracket for rear bumper at left or right
- 51 12 825 Removing and installing/replacing guide for rear centre bumper
- 51 13... Removing and installing/replacing trim on front grille centre section
- 51 13 000 Removing and installing/replacing front grille centre section
- 51 13 007 Removing and installing/replacing trim ring for front grille centre section
- 51 13 081 Removing and installing trim grille for heater air inlet
- 51 13 082 Replacing trim grille for heater air inlet
- 51 13115 Removing and installing / replacing cowl panel cover
- 51 13 280 Removing and installing trim strip on roof frame at left or right
- 51 13 282 Replacing trim strip on roof frame at left or right
- 51 13 400 Removing and installing/replacing rear centre trim (up to 03/2005)
- 51 13 440 Removing and installing/replacing trim on left or right rear light
- 51 14... Instructions for attaching number/letter designation combination
- Removing
- 51 14 000 Removing and installing/replacing front BMW badge
- 51 14 010 Removing and installing/replacing rear BMW badge
- 51 14 110 Removing and installing/replacing rear model designation (up to 03/2005)
- 51 16... Cementing of mirror base
- 51 16... Removing and installing / replacing adapter for roller sun blind on left or right rear door
- 51 16... Removing and installing / replacing guide rail for roller sun blind of left or right rear door
- 51 16... Removing and installing / replacing trim on roller sun blind of left or right rear door
- Side panel on centre console, front
- Side panel on centre console, rear
- Removing Top Storage Tray (Drawer) From Function Carrier
- Removing bottom storage tray (drawer) from function carrier
- 51 16... Removing and installing/replacing inner trim on window frame (roller sun blind) of left or right rear door
- 51 16 000 Removing and installing / replacing mirror on left or right front door
- 51 16 026 Replacing mirror glass
- 51 16 040 Removing and installing/replacing housing (cover) on left or right door mirror
- 51 16 045 Removing and installing/replacing retaining ring on left or right door mirror
- 51 16 060 Removing and installing or replacing interior rearview mirror
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 170 Removing and installing function carrier on panel for instrument panel
- 51 16 175 Removing and installing / replacing decorative trims (all) on function carrier
- Side Decorative Trims
- Decorative Trim For Audio System Controller
- Decorative trim on storage tray (drawer)
- Decorative trim on bottom drawer
- 51 16 180 Removing and installing centre console carrier section
- 51 16 181 Replacing centre console carrier section
- 51 16 185 Removing and installing / replacing decorative trims on centre console carrier section
- 51 16 188 Replacing base for centre console on storage tray
- 51 16 190 Removing and installing / replacing lock cylinder in centre armrest
- 51 16 195 Removing and installing centre armrest (front)
- 51 16 196 Removing and installing / replacing (both) covers for centre armrest
- 51 16 197 Removing and installing / replacing decorative trim on centre armrest
- 51 16 202 Removing and installing/replacing front cup holder
- 51 16 204 Removing and installing/replacing rear cup holder
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 345 Removing and installing/replacing button and Bowden cable for glovebox
- 51 16 360 Removing and installing right glovebox (without active knee protector only)
- 51 16 361 Replacing right glovebox
- 51 16 366 Removing and installing right glovebox with housing
- 51 16 367 Removing and installing right glovebox (with active knee protector) with housing
- Version up to MY 2004
- Version from MY 2005
- 51 16 400 Removing and installing or replacing roller sun blind at fixed side window of left or right rear door
- 51 16 405 Removing and installing or replacing blind at side window of left or right rear door
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 480 Removing and installing or replacing front grab handle
- 51 23 004 Adjusting hood/bonnet lock
- 51 23 100 Removing and installing/replacing right engine hood lock
- 51 23 110 Removing and installing/replacing left hood/bonnet lock
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 211 Removing and installing/replacing cable for front engine hood locks (to passenger compartment)
- 51 23 215 Removing and installing/replacing cable for hood/bonnet locks (to locks)
- 51 21... Releasing door retainer from left or right door pillar
- 51 21... Replacing door reflector
- Front door
- Rear door
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 004 Adjusting front left or right door detent (lock wedge)
- 51 21 035 Removing and installing/replacing function carrier on left or right front door
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing carrier for left or right outside door handle with lock cylinder
- 51 21 126 Removing and installing/replacing carrier for left or right outside door handle without lock cylinder
- 51 21 170 Removing and installing or replacing outside handle from left or right front door
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outside door handle on left or right front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 280 Removing and installing or replacing door brake on left or right front door
- 51 21 302 Removing and installing/replacing chrome strip for window cavity cover strip (on outside of front door)
- 51 21 351 Replacing window cavity seal on left or right front door
- 51 21 370 Removing and installing/replacing cover (seal) on front door at bottom left or right
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 004 Adjusting rear left or right door detent (lock wedges)
- 51 22 035 Removing and installing function carrier (without roller sun blind) on left or right rear door
- 51 22 036 Replacing function carrier (without roller sun blind) on left or right rear door
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 126 Removing and installing/replacing carrier for outside door handle on left or right rear door
- 51 22 170 Removing and installing / replacing outside handle on left or right back door
- 51 22 225 Removing and installing/replacing inside door handle of rear left or right door
- 51 22 233 Removing and installing/replacing Bowden cable for outside door handle on left or right rear door
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 280 Removing and installing/replacing door stop on rear left or right door
- 51 22 302 Removing and installing/replacing chrome strip for window cavity cover strip, rear left or right
- 51 22 330 Removing and installing/replacing window cavity cover strip on inside rear door
- 51 22 351 Replacing window cavity seal in inside left or right rear door (with roller sun blind)
- Front window cavity seal
- Rear window cavity seal
- 51 22 370 Removing and installing/replacing cover (seal) on rear door at bottom left or right
- 51 22 435 Removing and installing function carrier (with roller sun blind) on left or right rear door
- 51 23 004Q Adjusting hood/bonnet lock
- 51 24... Notes and instructions on automatic rear lid actuation (from 02/2003) (electrohydraulic-fully automatic)
- 51 24... Notes on automatic rear lid actuation (electrohydraulic-fully automatic)
- 51 24... Removing and installing/replacing Bowden cable for rear lid lock (up to 03/2005)
- 51 24... Removing and installing/replacing angle transmitter for rear lid actuation (electrohydraulic-fully automatic)
- 51 24 004 Adjusting rear lid lock (lower section of rear lid lock)
- Correcting Contact Pattern
- 51 24 050 Removing and installing/replacing lock element (lock cylinder) for rear lid (up to 03/2005)
- 51 24 065 Removing and installing/replacing Bowden cable for manual rear lid unlocking (up to 03/2005)
- 51 24 100 Removing and installing/replacing rear lid lock (upper section)
- 51 24 149 Replacing valve on hydraulic unit
- 51 24 150 Removing and installing/replacing hydraulic unit for rear lid actuation (electrohydraulic-fully automatic)
- Detaching Hoses On Hydraulic Unit
- Sealing Connections On Hydraulic Unit And Hose Connections For Hydraulic Cylinders
- 51 24 150 Removing and installing/replacing hydraulic unit for rear lid actuation (from 02/2003) (electrohydraulic-fully automatic)
- When removing hydraulic unit only
- 51 24 151 Removing and installing/replacing hydraulic cylinder for rear lid (electrohydraulic-fully automatic)
- 51 24 300 Removing and installing or replacing left or right gas strut for rear lid
- 51 24 391 Replacing rubber mount on trunk lid support
- Ideal Filling
- 51 31... Instructions on gluing windscreen
- Work Steps For Removing And Installing Windscreens
- General
- On-The-Job Safety
- Tools For Cutting Through Adhesive Bead
- Storage Temperature
- Adhesive
- When Using Accelerator (Hot Processing)
- Adhesive Best Before Date
- Adhesive Disposal
- Accelerator
- Bonding Agent (Activator)
- Bonding Agent Best Before Date
- Damage To Paintwork In Body Aperture
- Treatment Of Glass Ceramic Surface (Inside Of Window)
- Adhesive Quantities
- Effect Of Differing Adhesive Quantities
- Spacer Buffers
- Hardening
- Glues And Their Minimum Hardening Times
- Locate Leaks
- Version With GPS Navigation System 1 (Up To 9/97)
- Version With Rain Sensor Or Rain/Light Sensor
- Version With Fogging Sensor
- Version With Head-Up Display (HUD)
- 51 31... Instructions for repairing stone-chipped laminated safety glass windscreens (clear and tinted)
- 51 31... Removing windscreen with "Roll Out 2000"
- Preparatory Work
- Laying Cutting Wire Around Windscreen
- Protecting Car Interior
- Windlass With Double Coil
- 51 31 000 Removing and installing/replacing windscreen
- 51 31 021 Removing and installing / replacing rubber frame for windscreen (top)
- 51 31 200 Removing and installing/replacing rear window
- 51 31 221 Replacing rear window (rear window broken)
- 51 31 231 Replacing Rear Window (Complete Rear Window)
- 51 31 241 Replacing rubber frame (top) for rear window
- 51 31 242 Replacing rubber frame (bottom) for rear window
- 51 32 154 Adjusting left or right front door window glass
- 51 32 160 Removing and installing / replacing housing cover on inner left or right door window frame
- 51 32 170 Removing And Installing / Replacing Door Window Glass, Front Left Or Right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- 51 32 390 Removing and installing / replacing decorative strip on front left or right door
- 51 32 420 Removing and installing/replacing trim on front door window frame, left or right
- 51 33 000 Removing and installing power window unit in left or right front door
- 51 34... Removing and installing/replacing trim on window frame on left or right rear door (rear/outer)
- 51 34 160 Removing and installing/replacing cover on door window frame (rear door) at inside left or right
- 51 34 171 Replacing rear left or right door window glass (without roller sun blind)
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 380 Removing and installing/replacing decorative strip on window frame of rear door (outer) on left or right
- 51 34 420 Removing and installing/replacing trim on window frame of rear door (front), left or right
- 51 34 471 Replacing rear left or right door window glass (with roller sun blind)
- 51 34 491 Replacing left or right fixed door window in rear window frame (with roller sun blind)
- 51 37 000 Removing and installing/replacing complete rear left or right power window unit
- 51 37 003 Replacing rear left or right power window unit
- 51 41... Removing and installing/replacing air duct on front left or right door trim
- Air Duct
- Air Inlet Trim
- Air Outlet Trim
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41 001 Replacing front left or right door trim
- 51 41 018 Replacing speaker frame on front left or right door trim panel
- 51 41 030 Removing and installing/replacing decorative strip (light strip) on left or right door trim (front)
- 51 41 065 Removing and installing/replacing wooden strip on left or right door trim (front)
- 51 41 070 Removing and installing/replacing upper section on left or right armrest
- 51 41 300 Removing and installing/replacing chest strip (chrome strip) on left or right front door
- 51 42... Replacing AIRBAG badge on rear left or right door trim panel
- Version up to 03/2004
- Build date from 03/2004
- 51 42 000 Removing and installing left or right rear door trim panel
- 51 42 001 Replacing left or right rear door trim panel
- 51 42 018 Replacing speaker frame on rear left or right door trim panel
- 51 42 030 Removing and installing/replacing decorative strip (light strip) on left or right door trim (rear)
- 51 42 040 Removing and installing/replacing trim for ashtray on rear left or right door trim panel
- 51 42 065 Removing and installing/replacing wooden strip on left or right door trim (rear)
- 51 42 070 Removing and installing/replacing upper section on armrest (rear)
- 51 42 300 Removing and installing/replacing chest strip (chrome strip) on left or right rear door (without roller sun blind)
- 51 42 400 Removing and installing/replacing chest strip (chrome strip) on left or right rear door (with roller sun blind)
- 51 43... Removing and installing/replacing decorative strip on panel for left or right door pillar
- 51 43 070 Removing and installing / replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing / replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing or replacing trim for front left or right roof pillar
- 51 43 230 Removing and installing / replacing trim on C-pillar at bottom left or right
- 51 43 251 Removing and installing / replacing trim for rear left or right roof pillar (rear)
- 51 43 255 Removing and installing / replacing trim for rear left or right roof pillar (front)
- 51 44... Removing and installing / replacing front console insert
- 51 44 001 Removing and installing/replacing headliner (without slide/tilt sunroof)
- 51 44 011 Removing and installing / replacing headliner (with slide / tilt sunroof)
- 51 44 180 Removing and installing / replacing rear console insert / make-up mirror in rear compartment
- 51 45... Removing and installing/replacing center instrument panel trim
- 51 45... Removing and installing/replacing control display trim
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 115 Removing and installing speaker frame on panel for instrument panel at top
- 51 45 175 Removing and installing/replacing panel for knee protector on left
- 51 45 177 Removing and installing/replacing panel for active knee protector on left
- 51 45 181 Removing and installing instrument panel trim at bottom right
- 51 45 263 Removing and installing/replacing instrument panel trim on right
- 51 45 360 Removing and installing/replacing wood trim on left
- 51 45 363 Removing and installing/replacing center wood trim on instrument panel
- 51 46 000 Removing and installing/replacing trim for rear parcel shelf
- 51 46 001 Removing and installing trim for oddments tray (back shelf with rear window roller blind)
- 51 46 002 Replacing trim for oddments tray (back shelf with rear window roller blind)
- 51 46 009 Removing and installing/replacing decorative strip for oddments tray (back shelf)
- Replacing Seatbelt Finisher Strip
- 51 46 013 Removing and installing/replacing rear window roller blind
- 51 46 050 Removing and installing / replacing trim for rear panel at top
- 51 47... Removing and installing/replacing left or right underbody paneling
- 51 47... Removing and installing/replacing rear left or right underbody paneling
- 51 47 000 Removing and installing / replacing entrance cover strip, front (inside) left or right
- 51 47 065 Removing and installing / replacing finishing strip at front left or right entrance
- 51 47 072 Removing and installing/replacing finishing strip at rear left or right entrance
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 140 Removing and installing / replacing panel for luggage compartment partition
- 51 47 151 Removing and installing / replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing / replacing right luggage compartment wheel arch trim
- 51 47 172 Removing and installing / replacing flap in luggage compartment trim, left or right
- 51 47 490 Removing and installing / replacing front underbody protection
- Underbody protection, petrol/gasoline engines
- Underbody protection, diesel engines
- 51 48 001 Removing and installing/replacing insulation lining on hood/bonnet
- 51 49 005 Removing and installing/replacing trim for lower rear lid
- 51 49 006 Removing and installing/replacing trim for rear lid at top
- 51 13 115 Removing and installing / replacing cowl panel cover
- 51 71... Removing and installing/replacing front bottom right wheel arch trim
- 51 71 000 Removing and installing/replacing seal on front door, left or right
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 200 Removing and installing/replacing seal on rear door, left or right
- 51 71 387 Removing and installing/replacing rear water gutter trim (rear lid) on left or right
- 51 71 447 Removing and installing or replacing panel for cover on left or right side member
- 51 72 000 Replacing mucket for left or right front door
- Breakout Boxes and Connectors
- Relay Holder Disengaging Tool
- Circular Connector Lock Disengager
- Circular Plug 7--8 Pin System D2.5
- Circular plug 13 Pin System D2.5
- Circular Plug 20 Pin System D2.5
- Circular Plug 4-7-10-12-25 Pin System D1.5/D2.5
- In-line Plug 15 Pin System D2.5
- In-line Plug 8-, 12 Pin System D2.5
- In-line Plug 20 Pin System D2.5
- In-line Plug 30 Pin System D2.5
- In-line plug 2 Pin System JPT ELA
- In-line plug 2 Pin System MDK 3 plus 2.8
- In-line plug 4 Pin System DFK ELA
- In-line Plug 3-,6 Pin System Elo-Power 2.8
- In-line plug 4-,10 Pin System Elo
- In-line Plug 6-,50 Pin System Elo
- In-line Plug 6-,8 Pin System MQS
- In-line Plug 2 Pin System MPQ 2.8
- Control Unit Plug 25-, 35-, 55-,83-,88 Pin
- In-line Plug 24 Pin Hybrid System MQS/MPQ
- Socket Housing
- Pin Housing
- Socket Housing 42-,43 Pin Hybrid Systems MQS/MPQ
- Socket Housing 2x27-, 2x27 Pin Hybrid System MQS/MPQ, Elo/Elo Power
- In-line Plug 30 Pin Hybrid System MQS/MPQ
- Socket Housing 5-, 8 Pin System MQS/MPQ
- Socket housing 5 pin (Hybrid System MQS/MPQ)
- Socket Housing 8 Pin (MQS)
- Socket Housing (Radio Plug) Hybrid system MQS/MPS
- Removing MPQ contacts from radio plug
- Removing MQS contacts from carrier
- Removing MPQ contacts from contact carrier
- Fuse Strip
- ECM Main Relay Connector
- Solderless Terminals And Connectors
- Electrical Repair Kit IV
- Cable Stripper
- Crimping Tool
- Cable Stripping
- Crimping
- Soldering Connections
- Soldering Preparation and Procedure
- Breakout Boxes and "V" Cables
- 55 pin Breakout Box P/N 81 12 9 425 091
- 83 Pin Breakout Box (Red Face) P/N 90 88 6 614 420
- 88 Pin Breakout Box (Green Face) P/N 88 88 6 614 410
- 134 Pin SKE Control Module Breakout Box Set P/N 90 88 6 121 300
- 26 Pin Breakout Box P/n 88 88 6 611 459
- 60 Pin Breakout Box P/N 90 88 6 614 390
- Tester and Adapter Set for Relays
- "V" Cables
- What is Coding?
- What is Programming?
- What is the Purpose of Coding and Programming?
- Where is Data Stored in a Control Module?
- EPROM (Electrically Programmable Read Only Memory)
- EEPROM (Electrically Programmable Read Only Memory)
- What is needed to Code and Program?
- Coding & Programming Equipment
- Equipment and Software
- GT1 (Group Tester 1)
- SSS (Software Service Station)
- OPS Head - (Optical Programming System)
- Deutronic Automatic Battery Charger
- Hardware Operating Conditions
- Coding & Programming Software
- Networks
- Vehicle Bus Systems
- Workshop LAN Network
- Workshop Network
- Network Structure
- Network Connections
- Accessing Configuration Information - DISplus/GT1 & Interface(s)
- Workshop Layout Index
- Workshop Network Components
- Network
- Local Area Network (LAN)
- Ethernet
- Ethernet Cable (CAT 5)
- RJ-45 Connectors
- Wall Jack
- Switched HUB
- Network Server
- Automatic/Online Updates
- Access Point
- Interface Name
- IP Address
- IP Subnet Mask
- Gateway
- Software Service Station
- OPPS
- OPS
- MOST Direct Access Port
- Equipment Configurations
- Procedure for Coding & Programming
- Coding Plug
- From 2/89 to 9/91 Production
- 9/90 Revision
- E32/34 as of 9/91 (1992 Model Year)
- 318i/is, 325i/is and M3
- 318ti and Z3 Roadster
- Federal Odometer Disclosure Requirement 92-513
- Variant Coding
- Variant Code Structure
- Variant Code Procedure
- Adopt a Variant Code
- Manually Entering a Variant Code
- Coding Code
- Coding Code (Code Number)
- Coding Code Procedure
- Ordering Pre-Coded Modules
- Workshop Exercise
- Vehicle Coding Information
- ZCS Structure
- Accessing Stored ZCS Information
- Accessing ZCS Information Label
- ZCS Codable Control Modules
- Vehicle Order
- EPROMs & EEPROMs
- Engine Control Module EPROM Programming
- M3.1 Engine Control Modules
- M3.3 & M3.3.1 Engine Control Modules
- Engine Control Modules Flash (EEPROM) Programming
- Transmission EPROMS
- Transmission Control Module Flash (EEPROM) Programming
- DME/ECM EPROM
- TCM
- Programming Procedure
- Workshop Exercise - SIB Look-up
- Determination Process for DME EPROM
- Automatic Determination
- Manual Determination
- Progman
- Administration
- JETstream
- Multiconsole/Multisession
- CIP
- What Will Progman Do For Me?
- Before Progman (CIP 15.0)
- With Progman (CIP15.0)
- Getting Started With Progman
- Interfaces
- Explanation of Status Indicators
- Version
- External Interface
- Configuration
- Interface Update
- Updating Interface after Initial Install
- Self-Test
- Settings
- Operating Status
- FASTA
- Date and Time
- Operating Times
- User Interface
- Workshop Exercise - Configuration Check
- Starting a Programming or Coding Session with Progman
- Disconnecting From Interface To Be Used By Progman
- Starting A Session With Progman
- Access CIP Functions For E31E32/E34/E36/E38/E39/E46/E52/E53
- Access CIP Functions For E60/E62/E63/E64/E65/E83/E85...
- Return To Progman "Home" Screen
- Progman "Home" Screen Session Status
- Shutting Down the SSS
- Workshop Exercise - Access CIP & ZCS
- Coding, Individualization & Programming (CIP)
- Integration Levels
- Measures Plan
- CIP Functions - If No (MOST-Bus Vehicles)
- Control Module Selection - Programming - Update Software
- Control Module Selection-Programming-Special Measures
- Retrofits
- Management
- Management - Reports
- Management - Application - Test & Version
- Vehicle
- Vehicle - Vehicle Order
- Vehicle - Initialization
- Vehicle - Service Function
- Vehicle - Complete Encoding
- CIP Functions - If Yes
- ZCS Coding Procedure
- Coding Control Modules That Store The ZCS
- Manual Input of ZCS Data
- Automatic Coding Procedure
- Retrofit
- Conversion
- Coding & Programming
- What is the Purpose of Coding and Programming?
- Where is the Data Stored in a Control Module?
- EPROM (Electrically Programmable Read Only Memory)
- EEPROM (Electrically Erasable Programmable Read Only Memory)
- Central Coding Key (ZCS)
- ZCS Structure
- Central Coding Code Labels
- ZCS Coding Procedures
- Automatic ZCS Retrieval and Coding of Control Modules
- Automatic Coding Procedure
- Manual Input of ZCS Code
- Manual ZCS Coding Procedure
- Retrofit
- Display of ZCS for Printout
- Conversion
- Service Measures
- DME Variant Code
- Variant Code Structure
- Variant Encoding Procedure
- Procedure for Adopting Existing Variant Code
- Manually Entering the Variant Code
- Recoding
- DME Variant Codes
- DME Control Module Programming
- Storage of Programming Data
- Programming Update
- Programming Procedure
- Programming Procedures for "Customer Service Measures"
- Programming Procedures for "Exchange Control Unit"
- Programming Procedures for "Exchange EPROM"
- Flash Programming
- Body Equipment - Tightening Torques
- Audio, Navigation, Anti-Theft and Restraints - Tightening Torques
- Electrical Drives - Tightening Torques
- Body Equipment - Special Tools 4
- Audio, Navigation, Anti-Theft and Restraints - Special Tools
- Body Equipment - Repair Instructions 7
- Audio, Navigation, Anti-Theft and Restraints - Repair Instructions 3
- Electrical Drives - Repair Instructions
- Remote Keyless Entry - Service Information 3
- Remote Control Services - Overview - E65 2
- Driveaway Protection - Overview 3
- 67 11 510 Removing and installing/replacing servodrive for front left or right door locking mechanism
- 67 11 530 Removing and installing/replacing servodrive for rear left or right door locking mechanism
- 67 11 555 Removing and installing/replacing servodrive for tank filler flap
- 67 11 560 Replacing servodrive for rear lid lock
- 67 65 010 Removing and installing or replacing drive unit for roller sun blind
- 67 13 001 Replacing drive unit for electrically operated left or right door mirror
- 67 13 005 Replacing drive unit for electrically operated left or right door mirror (with memory)
- 67 16 011 Removing and installing/replacing left headlight vertical aim adjuster (xenon headlight)
- 67 16 016 Removing and installing/replacing right headlight vertical aim adjuster (xenon headlamp)
- 67 31... Notes on initializing electric seat servodrives
- 67 31 560 Removing and installing/replacing drive unit for thigh support
- 67 32 600 Replacing fan for front seat surface (comfort seat)
- 67 32 610 Replacing fan for backrest on front seat (comfort seat)
- 67 32 620 Replacing fan for thigh support on front seat (comfort seat)
- 67 32 650 Replacing fan for rear seat surface (comfort seat)
- 67 32 660 Replacing fan for backrest on rear seat (comfort seat)
- 67 33 510 Removing and installing/replacing servolock drive
- 67 61 005 Removing and installing (replacing) drive with gear for actuating slide/tilt sunroof
- 67 62... Notes on initializing power window
- 67 62 000 Removing and installing/replacing flat motor for front left or right power window
- 67 62 020 Removing and installing/replacing flat motor for rear left or right power window regulator
- 67 65 019 Removing and installing/replacing drive for left or right roller sun blind
- 67 66 010 Removing and installing/replacing lumbar support drive mechanism on front seat, left or right
- 67 66 012 Removing and installing/replacing drive unit for lumbar support on left or right front seat (comfort seat)
- 67 66 013 Removing and installing/replacing drive unit for lumbar support on left or right front seat (active seat)
- 67 66 019 Removing and installing/replacing drive unit for lumbar support on left or right rear seat (comfort seat)
- Removal & Installation (3-Series - Z3)
- Removal & Installation (3-Series - E46)
- Removal & Installation (5-Series & 7-Series)
- Removal & Installation (6-Cylinder)
- Removal & Installation (V8 & V12)
- Removal & Installation
- Removal & Installation (V8)
- Removal & Installation (V12)
- Removal & Installation (Left Cap)
- Removal & Installation (Right Cap)
- Removal & Installation (5-Series)
- Removal & Installation (7-Series)
- Removal (6-Cylinder)
- Removal (V8 & V12)
- Removal & Installation (7-Series V8)
- Removal & Installation (6-Cylinder - E36)
- Removal & Installation (M Roadster)
- Removal & Installation (V12 - Cylinders 1-6)
- Removal & Installation (V12 - Cylinders 7-12)
- Removal & Installation (Cylinders 1-6)
- Removal & Installation (Cylinders 7-12)
- 12 00... Information on working on ignition system
- 12 00... Instructions for disconnecting and connecting battery
- Vehicles with a two-battery system
- 12 00... Instructions for removing and installing electronic control units
- 12 00... Instructions on starting aid
- 12 00... Instructions for welding work (overload protection of control units)
- Firing Order
- 12 12 011 Replacing all spark plugs (N62)
- 12 13 Notes on checking ignition system
- 12 13... Checking secondary signal for stationary ignition distribution
- 12 13... Further fault patterns with evaluation
- N42 / N62
- 12 13... Fault in fuel injection system
- 12 13... Spark-Plug Faults
- 12 13... Ignition Coil Faults
- 12 13 009 Checking rod-type ignition coils (M54, M56, N40, N42, N45, N46, N52, N62, N73)
- Secondary measurement
- Primary measurement
- M54 / M56 / N40 / N42 / N45 / N46 / N62 / N73
- 12 13 511 Replacing ignition coil (N62)
- 11 37 700 Replacing control unit (Valvetronic)
- 12 14 512 Replacing pulse generator on left exhaust camshaft (N62)
- 12 14 513 Replacing pulse generator on right exhaust camshaft (N62)
- 12 14 521 Replacing crankshaft pulse generator (N62)
- 12 14 522 Replacing pulse generator on left inlet camshaft (N62)
- 12 14 526 Replacing pulse generator on right inlet camshaft (N62)
- 12 14 550 Replacing control unit (Digital Motor Electronics) (N62)
- 12 14 610 Replacing right knock sensors (N62)
- 12 14 611 Replacing left knock sensors (N62)
- 12 14 700 Coding control module (DME / DDE)
- 12 14 705 Programming control unit (DME / DDE)
- 12 52 005 Removing and installing/replacing integrated supply module (N62)
- 12 90 100 Replacing fan for electronics box (N62)
- 12 31... Replacing alternator belt pulley
- 12 31 009 Checking alternator (BSD)
- 12 31 020 Removing and installing or replacing alternator (N62)
- 12 41 020 Removing and installing/replacing starter motor (N62)
- 12 41 041 Replacing solenoid switch
- 12 42 500 Removing and installing or replacing battery positive lead (between alternator, starter motor and battery positive terminal) (N62)
- 12 42 540 Replacing safety battery terminal (SBK)
- 12 61 280 Removing and installing/replacing oil pressure switch (N62)
- 12 61 285 Replacing engine oil level switch (N62)
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- 00 00 610 Engine oil service (N62)
- Necessary preliminary tasks
- 11 00 050 Removing and installing engine (N62)
- Vehicles with Dynamic Drive only
- 11 12 005 Removing and installing / sealing left cylinder head cover (N62 / N62TU)
- 11 12 006 Removing and installing / sealing right cylinder head cover (N62 / N62TU)
- 11 12 105 Removing and installing left cylinder head (N62 from 9 / 03
- After removing exhaust manifolds
- E65 only
- 11 12 105 Removing and installing left cylinder head (N62 to 9 / 03)
- 11 12 106 Removing and installing right cylinder head (N62 from 9 / 03 and N62TU)
- 11 12 106 Removing and installing right cylinder head (N62 to 9 / 03)
- 11 12 110 Replacing left cylinder head gasket (M62 / S62 / N62)
- 11 12 111 Replacing right cylinder head gasket (M62 / S62 / N62)
- 11 12 595 Checking a valve guide for wear (N62)
- 11 12 719 Milling cylinder head sealing Face (N62)
- 11 12 729 Checking cylinder head for water leaks (N62)
- 11 13 010 Removing and installing/replacing oil sump top section (N62)
- 11 13 020 Removing and installing/replacing oil sump bottom section (N62)
- 11 14 080 Removing and installing top left timing case cover (N62)
- 11 14 085 Removing and installing top right timing case cover (N62 / N62TU)
- 11 14 110 Removing and installing bottom timing case cover (N62 / N62TU)
- 11 14 141 Replacing radial shaft seal in timing case cover at bottom (N62 / N62TU)
- 11 14 151 Replacing crankshaft radial shaft seal (N62 / N62TU)
- 11 21 500 Replacing crankshaft (N62 / N62TU)
- 11 21 531 Replacing all main crankshaft bearing shells (N62)
- Checking main bearing clearance
- 11 22 000 Removing and installing/replacing flywheel (N62)
- 11 24 571 Replacing all conrod bearings (N62)
- 11 25 530 Removing and installing/replacing all pistons (N62)
- Cylinder bank 1 to 4
- Cylinder bank 5 to 8
- N62 B44
- N62 B36
- 11 25 671 Replacing piston rings on all pistons (N62)
- 11 28 010 Replacing alternator drive belt (N62)
- 11 28 050 Replacing A/C compressor drive belt with belt tensioner (N62)
- 11 31 032 Removing and installing/replacing left inlet camshaft (N62 from 9/03)
- 11 31 032 Removing and installing/replacing left inlet camshaft (N62 to 9/03)
- 11 31 034 Removing and installing/replacing right inlet camshaft (N62 from 9/03)
- 11 31 034 Removing and installing/replacing right inlet camshaft (N62 to 9/03)
- 11 31 036 Removing and installing/replacing left exhaust camshaft (N62)
- 11 31 038 Removing and installing/replacing right exhaust camshaft (N62)
- 11 31 052 Replacing both timing chains (N62/N62TU)
- 11 31 070 Checking camshaft timing on left side (N62)
- 11 31 071 Checking camshaft timing on right side (N62)
- 11 31 573 Adjusting camshaft timing on left side (N62 / N62TU)
- 11 31 574 Adjusting camshaft timing on right side (N62 / N62TU)
- 11 33 516 Removing and installing/replacing rocker arms on left inlet side (N62 from 9/03)
- 11 33 516 Removing and installing/replacing rocker arms on left inlet side (N62 to 9/03)
- 11 33 517 Removing and installing/replacing rocker arms on right inlet side (N62 from 9/03)
- 11 33 517 Removing and installing/replacing rocker arms on right inlet side (N62 to 9/03)
- 11 34 552 Removing and installing/replacing all valves (N62)
- 11 34 560 Replacing all valve stem seals (N62)
- 11 36 715 Removing and installing/replacing both solenoid valves on left side (N62)
- 11 36 720 Removing and installing/replacing both solenoid valves on right side (N62)
- 11 37 006 Removing and installing/replacing left eccentric shaft (N62 from 9/03)
- 11 37 006 Removing and installing/replacing left eccentric shaft (N62 to 9/03)
- 11 37 008 Removing and installing/replacing right eccentric shaft (N62 from 9/03)
- 11 37 008 Removing and installing/replacing right eccentric shaft (N62 to 9/03)
- 11 37 012 Removing and installing/replacing left intermediate lever (N62 from 9/03)
- 11 37 012 Removing and installing/replacing left intermediate lever (N62 to 9/03)
- 11 37 014 Removing and installing/replacing right intermediate lever (N62 from 9/03)
- 11 37 014 Removing and installing/replacing right intermediate lever (N62 to 9/03)
- 11 37 022 Removing and installing/replacing servomotor for left eccentric shaft (N62)
- 11 37 024 Removing and installing/replacing servomotor for right eccentric shaft (N62)
- 11 37 035 Removing and installing/replacing left eccentric shaft sensor (N62)
- 11 37 040 Removing and installing/replacing right eccentric shaft sensor (N62)
- 11 37 700 Replacing control unit (Valvetronic)
- 11 40 000 Checking engine oil pressure
- Check engine oil pressure with DIS Tester
- Check engine oil pressure with pressure gauge
- 11 41 000 Removing and installing/replacing oil pump (N62)
- 11 43 000 Removing and installing/sealing guide tube for oil dipstick (N62)
- 11 51 000 Removing and installing water pump (N62)
- 11 52 020 Removing and installing or replacing fan clutch (N62)
- 11 53 000 Removing and installing/replacing coolant thermostat (N62)
- 11 61 050 Removing and installing intake air manifold (N62)
- 11 66 000 Removing and installing/replacing vacuum pump (N62)
- 11 72 000 Removing and installing/replacing air pump (N62)
- 11 78 530 Replacing left oxygen control sensor (N62)
- 11 78 533 Replacing right oxygen control sensor (N62)
- 11 78 543 Replacing right oxygen monitor sensor (N62)
- 16 00 Fuel supply system E38 / E39 (spark-ignition engines)
- Fuel supply systems, spark-ignition engines
- Fuel supply systems, diesel engines
- M47, M57
- Drawing off fuel
- Insertion length
- Drawing off residual fuel quantity
- Fuel filling
- Drawing off after fault in suction jet pump
- 16 00 100 Checking fuel tank and tank ventilation system for leaks
- 16 11 030 Removing and installing fuel tank
- 16 11 060 Removing and installing/replacing fuel filler pipe
- 16 11 120 Removing and installing / replacing expansion tank for tank ventilation
- 16 11 130 Checking filler cap pressure relief valve
- Measurement evaluation
- Check filler cap pressure relief!
- 16 12 000 Removing and installing / replacing fuel gauge sensor (right)
- 16 12 001 Removing and installing / replacing fuel gauge sensor (left)
- 16 12 010 Removing and installing / replacing carbon canister
- 16 14 010 Removing and installing / replacing fuel pump
- 16 14 060 Removing and installing/replacing dust filter with seal grommet
- 16 14 530 Replacing sucking jet pump
- Right side
- Left side
- Fuel System - Technical Data
- Fuel Supply System - Technical Data
- Fuel System - Tightening Torques
- Fuel Supply System - Tightening Torques
- Fuel System - Special Tools
- Fuel Supply System - Special Tools 2
- Fuel System - Repair Instructions 2
- Fuel Supply System - Repair Instructions 3
- Fuel System - Operating Fluids 2
- Engine Diagnosis - Overview 3
- Engine Electrical System - Service Techniques
- Engine Electrical System - Technical Data 2
- Engine Electrical System - Tightening Torques
- Engine Electrical System - Special Tools 2
- Instruments - Special Tools - 745i - E65 2
- Engine Electrical System - Repair Instructions 3
- Instruments - Repair Instructions
- Instrument Cluster - Overview - E65 6
- Telephone - Overview - E65 2
- Cellular Communication Systems - Overview 3
- Idrive - Driving Area - Overview 3
- Idrive - Comfort Area - Overview 2
- Speech Processing System - Overview 2
- 12 00... Instructions on starting aid
- Preparation
- Carrying out
- 61 00... Battery
- 61 00... Battery charging
- 61 00... Notes on handling optical fibers
- 61 13... Treating cables and optical fibers
- Battery acid is highly corrosive
- In event of contact with acid
- Explosion hazard
- 61 13.. Unlocking and disconnecting different plug connections
- 61 12 002 Replacing positive battery cable (from battery to luggage compartment connector)
- 61 13... Antenna elbow plug on radio receiver
- 61 13... Base of tab connector housings
- 61 13... Crimping Micro Power Quadlock contacts (MPQ)
- 61 13... Crimping Micro Quadlock System contacts (MQS)
- 61 13... Crimping annular contacts
- 61 13... Crimping optical fibres
- 61 13... Cutting off, stripping insulation and cutting optical fibres to length
- Cutting optical fibre
- Stripping insulation from optical fibre
- Cutting optical fibre to length
- Ultrasonic-welded connectors
- Plug system D 1.5/D 2.5
- Plug system JPT/MDK/DFK
- Plug system Elo/Elo-Power
- Plug system MQS/MPQ
- 61 13... Plug housing, LCC contact (load current contact)
- 61 13... Relay carrier
- H261 13... Repairing ribbon cables
- 61 13... Retaining bracket
- 61 13... Socket housing (radio plug), Hybrid System MQS/MPQ
- Removing MPQ contacts from radio plug
- Removing MQS contacts from contact carrier
- Removing MPQ contacts from contact carrier
- 12 00... Instructions for disconnecting and connecting battery
- Before disconnecting battery
- General notes on disconnecting battery
- After connecting battery
- Vehicles with a two-battery system
- 61 20 900 Disconnecting and connecting battery negative lead
- 61 21... Removing and installing / replacing battery cover
- 61 21 010 Removing and installing battery
- 61 31 006 Removing and installing (replacing) fixture for steering column stalk
- 61 31 011 Removing and installing/replacing volute spring cassette
- 61 31 016 Removing and installing/replacing turn indicator/dimmer stalk
- 61 31 018 Removing and installing/replacing cruise control switch
- 61 31 019 Removing and installing (replacing) ignition starter switch
- 61 31 037 Removing and installing/replacing lighting control unit
- 61 31 040 Removing and installing/replacing stalk for windshield wipers
- 61 31 062 Removing and installing/replacing button for steering wheel heating
- 61 31 066 Removing and installing/replacing hotel setting switch
- 61 31 067 Removing and installing/replacing distribution switch
- 61 31 084 Removing and installing/replacing switch for automatic rear lid actuation
- 61 31 152 Removing and installing (replacing) control unit in center armrest at front
- 61 31 156 Removing and installing (replacing) control unit in center armrest at rear
- Version with eject box only
- Version with center armrest storage tray (2) only
- 61 31 162 Removing and installing/replacing front left or right switch combination
- 61 31 164 Removing and installing/replacing rear left or right switch combination (seat heating, head restraint)
- 61 31 166 Removing and installing/replacing rear left or right switch combination (seat heating, seat A/C for comfort seat in rear compartment)
- 61 31 175 Removing and installing/replacing switch for slide/tilt sunroof
- 61 31 176 Removing and installing/replacing emergency call button
- 61 31 190 Removing and installing/replacing phone board
- 61 31 192 Replacing knob for controller
- 61 31 195 Removing and installing (replacing) front controller
- 61 31 196 Removing and installing (replacing) rear controller
- 61 31 218 Removing and installing/replacing switch for Park Distance Control
- 61 31 220 Removing and installing/replacing multifunction steering wheel switch
- 61 31 231 Removing and installing/replacing steering wheel electronics control unit
- 61 31 232 Removing and installing/replacing steering wheel module control unit (sports steering wheel)
- 61 31 241 Removing and installing/replacing engine hood contact switch
- 61 31 246 Removing and installing/replacing rear lid button
- 61 31 261 Removing and installing/replacing gear selection switch
- 61 31 267 Removing and installing/replacing Steptronic switch
- 61 31 310 Replacing brake light switch
- 61 31 371 Removing and installing/replacing audio unit (on rear center armrest)
- 61 31 382 Replacing level switch for coolant
- 61 31 492 Replacing level switch for windshield washer system
- 61 35... Notes on ESD protection (Electro Static Discharge)
- 61 35 001 Removing and installing (replacing)trailer module
- 61 35 030 Removing and installing (replacing) power module
- 61 35 091 Removing and installing control unit for seat heating (normal rear seat)
- 61 35 177 Removing and installing (replacing) rain/light sensor
- 61 35 196 Removing and installing (replacing) control unit for automatic rear lid actuation
- 61 35 220 Removing and installing (replacing) control unit for left or right front door
- 61 35 224 Removing and installing (replacing) control unit for left or right rear door
- 61 35 285 Removing and installing (replacing) light module
- 61 35 592 Replacing control unit for seat heating (normal rear seat)
- 61 35 679 Initializing rain/light sensor
- 61 35 795 Removing and installing (replacing) control unit for adaptive headlight
- 61 35 950 Removing and installing (replacing) control unit for comfort access system
- 61 35 955 Removing and installing/replacing interior antenna for comfort access system - driver's side front
- 61 35 960 Removing and installing/replacing interior antenna for comfort access system - driver's side rear
- 61 35 965 Removing and installing/replacing rear parcel antenna for comfort access system
- 61 35 970 Removing and installing/replacing rear luggage compartment antenna for comfort access system
- 61 35 975 Removing and installing/replacing bumper antenna for comfort access system
- 64 11 970 Replacing fogging sensor
- 61 36 510 Removing and installing / replacing wiper heater relay
- 61 36 520 Removing and installing / replacing relief relay (EDC)
- 61 36 530 Removing and installing / replacing cigarette lighter relay
- 61 36 540 Replacing relay for air supply unit
- 61 61 010 Checking/adjusting approach angle of windshield wiper arms on front windscreen
- Checking contact angle
- Adjusting left wiper arm
- Adjusting right wiper arm
- 61 61 041 Replacing both windshield wiper blades
- 61 61 082 Removing and installing left windscreen wiper arm (driver's side)
- Version 1
- Type 2
- 61 61 082 Removing and installing/replacing right windscreen wiper arm (passenger side)
- 61 61 101 Removing and installing/replacing both windscreen wiper arms
- 61 61 270 Removing and installing complete wiper console
- 61 67 010 Removing and installing/replacing washer pump of headlight cleaning system
- 61 67 040 Adjusting spray nozzles for headlight cleaning system
- 61 67 083 Removing and installing/replacing left or right high-pressure nozzle of headlight cleaning system
- 61 71... Checking function of spray nozzles for windshield washer system
- 61 71... Procedure for replacing high-pressure lines
- 61 71 016 Removing and installing/replacing a jet nozzle in windshield washer system
- Removing left spray nozzle
- Removing right spray nozzle
- 61 71 100 Removing and installing/replacing windshield washer pump
- 64 11 ... Installing servodrive
- 64 11 205 Removing and installing/replacing heater (Basis automatic A/C)
- 64 11 206 Removing and installing/replacing heater (High automatic A/C)
- 64 11 207 Replacing heating element (Basic automatic A/C)
- 64 11 208 Replacing heating element (High automatic A/C)
- 64 11 212 Removing and installing/replacing fan for heater/air conditioner (automatic A/C Basic)
- 64 11 213 Removing and installing/replacing fan for heater/air conditioner (automatic A/C High)
- 64 11 224 Removing and installing/replacing controller for heater - A/C system fan (automatic A/C Basic)
- 64 11 225 Replacing controller for heater - A/C system fan (automatic A/C High)
- 64 11 260 Removing and installing/replacing auxiliary water pump (automatic A/C Basic)
- 64 11 262 Removing and installing/replacing auxiliary water pump (automatic A/C High)
- 64 11 273 Replacing water valve for heater (automatic A/C Basic)
- 64 11 274 Replacing water valve for heater (automatic A/C High)
- 64 11 377 Removing and installing (replacing) control panel for heater - A/C system
- 64 11 475 Removing and installing complete cooler box
- 64 11 478 Removing and installing/replacing cooler box lid
- 64 11 480 Removing and installing/replacing cooler box button
- 64 11 482 Removing and installing/replacing cooler box cooling unit
- 64 11 738 Replacing front panel (on heater - A/C system control panel)
- 64 11 810 Replacing servodrive for left hot air flap (automatic A/C Basic)
- 64 11 811 Replacing servodrive (automatic A/C High) for left hot air flap
- 64 11 813 Replacing servodrive for right hot air flap (automatic A/C High)
- 64 11 815 Replacing servodrive for left cold air duct (automatic A/C Basic)
- 64 11 816 Replacing servodrive for left cold air duct (automatic A/C High)
- 64 11 818 Replacing servodrive for right cold air duct (automatic A/C High)
- 64 11 820 Replacing servodrive for fresh air flaps (automatic A/C Basic)
- 64 11 821 Replacing servodrive for fresh air flaps (automatic A/C High)
- 64 11 825 Replacing servodrive for recirculated air flaps (automatic A/C Basic)
- 64 11 826 Replacing servodrive for recirculated air flaps (automatic A/C High)
- 64 11 840 Replacing servodrive for left footwell flap (automatic A/C High)
- 64 11 841 Replacing servodrive for right footwell flap (automatic A/C Basic)
- 64 11 842 Replacing servodrive for right footwell flap (automatic A/C High)
- 64 11 843 Replacing servodrive for ventilation/defrosting flaps (automatic A/C Basic)
- 64 11 844 Replacing servodrive for ventilation/defrosting flaps (automatic A/C High)
- 64 11 851 Replacing servodrive for left rear compartment flap (automatic A/C High)
- 64 11 853 Replacing servodrive for right rear compartment flap (automatic A/C High)
- 64 11 889 Replacing sensor fan for interior temperature.
- 64 11 910 Removing and installing/replacing temperature sensor for heating unit (automatic A/C Basic)
- 64 11 911 Removing and installing/replacing temperature sensor for heating unit (automatic A/C High)
- 64 11 912 Removing and installing/replacing temperature sensor for heating unit (automatic A/C Basic)
- 64 11 913 Removing and installing/replacing temperature sensor for heating unit (automatic A/C High)
- 64 11 942 Replacing evaporator temperature sensor (Basic automatic A/C)
- 64 11 943 Replacing evaporator temperature sensor (High automatic A/C)
- 64 11 970 Replacing fogging sensor
- 64 11 990 Removing and installing/replacing sensor for automatic recirculated air control (automatic A/C Basic)
- 64 11 991 Removing and installing/replacing sensor for automatic recirculated air control (automatic A/C High)
- 64 11 992 Removing and installing/replacing solar sensor
- 64 12 ... Initializing independent heating remote control
- 64 12 021 Removing and installing complete independent heater
- 64 12 525 Replacing complete independent heater
- 64 12 572 Replacing auxiliary water pump for auxiliary heater
- 64 12 577 Replacing changeover valve for independent heater
- 64 12 590 Removing and installing or replacing muffler
- 64 22 135 Removing and installing/replacing left fresh air grill (automatic A/C Basic)
- 64 22 136 Removing and installing/replacing right fresh air grill (automatic A/C Basic)
- 64 22 137 Removing and installing/replacing left fresh air grill (automatic A/C High)
- 64 22 138 Removing and installing/replacing right fresh air grill (automatic A/C High)
- 64 22 161 Removing and installing/replacing center fresh air grill (automatic A/C Basic)
- 64 22 162 Removing and installing/replacing center fresh air grill (automatic A/C High)
- 64 22 190 Removing and installing/replacing rear compartment fresh air grill (automatic A/C Basic)
- 64 22 191 Removing and installing/replacing rear compartment fresh-air grille (automatic A/C High)
- Build date up to 03/2005
- Build date from 03/2005
- 64 31 009 Replacing microfilter for interior ventilation (automatic A/C Basic)
- 64 31 010 Replacing microfilter for interior ventilation (automatic A/C High)
- 64 31 030 Removing and installing/replacing left or right microfilter air duct (automatic A/C Basic)
- 64 31 031 Removing and installing/replacing left or right microfilter air duct (automatic A/C High)
- 64 31 055 Removing and installing/replacing left or right fresh air duct (automatic A/C Basic)
- 64 31 056 Removing and installing/replacing left or right fresh-air duct (automatic A/C High)
- 64 50 ... Safety instructions for handling refrigerant R 134a
- 64 50 ... Safety precautions when handling refrigerant oil (for refrigerant R 134a)
- 64 50 009 Drawing off, evacuating and filling A/C system (R 134a)
- 64 51 001 Cleaning evaporator
- 64 51 522 Removing and installing/replacing expansion valve (automatic A/C Basic)
- 64 51 525 Removing and installing/replacing expansion valve (automatic A/C High)
- 64 51 590 Removing and installing/replacing evaporator (Basic automatic A/C)
- 64 51 591 Removing and installing/replacing evaporator (High automatic A/C)
- 64 52 521 Replacing A/C compressor (N62, Basic automatic A/C)
- 64 52 522 Replacing A/C compressor (N62, Basic automatic A/C, with Dynamic Drive)
- 64 52 523 Replacing A/C compressor (N62, High automatic A/C)
- Version with Dynamic Drive only
- Version with Dynamic Drive
- Version without Dynamic Drive
- 64 52 524 Replacing A/C compressor (N62, High automatic A/C, with Dynamic Drive)
- 64 53 ... Notes on replacing drier bottle or drier insert
- 64 53 515 Replacing drier insert for A/C system (automatic A/C Basic)
- 64 53 517 Replacing desiccant insert for A / C system (automatic A / C High)
- 64 53 518 Replacing desiccant insert for A/C system (condenser removed)
- 64 53 550 Removing and installing/replacing condenser for A/C system (automatic A/C Basic)
- 64 53 551 Removing and installing / replacing condenser for A / C system (N62)
- 64 53 551 Removing and installing / replacing condenser for A / C system (automatic A / C High)
- 63 10 004 Adjusting headlights
- 63 10 014 Adjusting fog lamps
- 63 12... Replacing upper holder on headlight (repair kit)
- 63 12 001 Removing and installing/replacing left headlight (up to 03/2005)
- 63 12 002 Removing and installing/replacing right headlight
- 63 12 010 Removing and installing left headlight (xenon headlight)
- 63 12 011 Replacing left headlight (xenon headlight)
- 63 12 012 Removing and installing right headlight (xenon headlight)
- 63 12 013 Replacing right headlight (xenon headlight)
- 63 12 016 Replacing left headlight (adaptive headlight)
- 63 12 017 Removing and installing/replacing right headlight (adaptive headlight)
- 63 12 860 Replacing control unit for left xenon headlight (up to 03/2005)
- 63 12 861 Replacing control unit for right xenon headlamp
- 63 12 870 Replacing ignition unit for left xenon headlight (up to 03/2005)
- 63 12 871 Replacing ignition unit for right xenon headlight
- 63 12 895 Replacing drive for left adaptive headlight
- 63 12 950 Replacing a lower holder for headlight mounting
- 63 13 200 Removing and installing/replacing front left or right auxiliary turn signal lamp
- 63 17 060 Removing and installing (replacing) left or right front fog lamp
- 63 21 055 Replacing a socket housing for left or right rear light (on side panel)
- 63 21 101 Replacing sealing frame for left or right rear light (on side panel)
- 63 21 104 Replacing sealing frame for left or right rear light (up to 03/2005) (on rear lid)
- 63 21 107 Replacing sealing frame for rear light (on center of rear lid)
- 63 21 180 Removing and installing/replacing left or right rear light (on side panel)
- 63 21 183 Removing and installing/replacing left or right rear light (up to 03/2005) (on rear lid)
- 63 21 186 Removing and installing/replacing rear light (on center of rear lid)
- 63 21 300 Replacing circuit board for left or right rear light (up to 03/2005) (on side panel)
- 63 21 310 Replacing circuit board for left or right rear light (up to 03/2005) (on rear lid)
- 63 25 000 Removing and installing/replacing additional stop light
- 63 31 000 Removing and installing/replacing complete ceiling light (front)
- 63 31 003 Removing and installing/replacing complete ceiling light (rear)
- 63 31 020 Removing and installing/replacing footwell light
- 63 31 050 Removing and installing/replacing mirror light
- 63 31 080 Removing and installing/replacing luggage compartment light
- 63 31 085 Removing and installing/replacing luggage compartment lamp (on rear lid)
- 63 31 150 Removing and installing/replacing glovebox light
- 63 99... Instructions for handling light bulbs (exterior lights)
- 63 99... Instructions for replacing light bulbs (interior lights)
- 63 99... Replacing bulb for rear make-up mirror
- 63 99 076 Replacing left lamp for left xenon light
- 63 99 077 Replacing right lamp for xenon light
- 63 99 273 Replacing bulb for turn indicator, front left
- 63 99 295 Replacing bulb for auxiliary turn signal light, front left or right
- 63 99 401 Replacing bulb for left or right license-plate light
- 63 99 486 Replacing light module for front left or right outside door handle lighting (up to 09/2004)
- 63 99 491 Replacing light module for rear left or right outside door handle lighting (from 09/2004)
- 63 99 491 Replacing light module for rear left or right outside door handle lighting (up to 09/2004)
- 63 99 492 Replacing light module for rear left or right outside door handle lighting (up to 09/2004) (with roller sun blind on rear door)
- Objectives Of The Article
- Purpose Of The System
- System Components
- Components
- Power Supply
- Integrated Voltage Supply Module (IVM)
- Air Management
- Starting The Engine
- Ensuring A Constant Vacuum Of 50 mbar In The Intake Manifold
- The Backup Running Function
- The Valvetronic Control Module Is Assigned (Programming) To The Appropriate Engine And ECM By The DISplus.
- Fuel Management
- Tank Ventilation Components
- Tank Ventilation Function
- Fuel Supply System Components
- Fuel Pressure Regulator
- Electric Fuel Pump (EKP)
- Electric Fuel Pump (EKP) Regulation
- Injection Valves / Fuel Rail
- The Fuel Pump (EKP)
- Ignition Management
- Emission Optimized - IGNITION KEY OFF
- Knock Control
- Emissions Management
- Oxygen Sensor Signals
- PHASE 1 - Reference Measurement
- PHASE 2 - Leak Detection
- Emission Increase
- Catalyst Damage
- Hydraulic Actuation
- Vacuum Pump
- Oil Condition
- Electric Cooling Fan
- Alternator
- Regulation
- Electronic Box Cooling Fan
- Comfort Start
- Cruise Control
- Engine - Technical Data (N62) 2
- Engine - Tightening Torques (N62) 2
- Engine and Gearbox Suspension - Tightening Torque
- Engine - Repair (N62) 5
- Engine and Gearbox Suspension - Repair
- Engine Introduction - Overview (N62) 5
- Operating Fluids - Engine 3
- Basic Measuring Techniques - Overview
- Engine - Overview (N62) 3
- 00 Danger of Poisoning If Oil Is Ingested/Absorbed Through the Skin
- 00 Risk of Injury If Oil Comes Into Contact With Eyes and Skin
- 00 Safety Instructions For Handling Oil
- 33 00... Information On Replacing Shock Absorbers
- 33 00... Instructions (Chassis Components Made of Aluminum)
- 33 00... Notes on Repairing Threads
- 33 10... Rear Differential: Assignment to Model Series
- 33 10 010 Removing and Installing/Replacing Rear Differential
- 33 11... Replacing Rear Cover Gasket On Rear Differential (188K)
- 33 11... Replacing Rear Cover Gasket On Rear Differential (188L/188LW)
- 33 11... Replacing Rear Cover Gasket On Rear Differential (215K)
- 33 11... Replacing Rear Cover Gasket On Rear Differential (230K)
- 33 11 021 Replacing Shaft Seal For Input Flange On Rear Differential
- 33 11 091 Replacing Drive Flange On Left or Right Of Rear Differential
- 33 11 151 Replacing Shaft Seal For Drive Flange Left or Right
- 33 11 271 Replacing Rear Cover Gasket On Rear Differential
- 33 17 004 Replacing All Front Rubber Mounts For Rear Differential Mounting
- 33 17 005 Replacing Rubber Mount For Rear Differential Mounting At Rear
- 33 21... Pressing Output Shaft Out of Drive Flange and Drawing In (Output Shaft Removed From Rear Differential)
- 33 21... Ribbed Teeth
- 33 21 001 Removing and Installing/Replacing Left Output Shaft
- 33 21 002 Removing and Installing/Replacing Right Output Shaft
- 33 21 035 Replacing Gaiter On Left Output Shaft
- 33 21 036 Replacing Gaiter On Right Output Shaft
- 33 31 000 Removing and Installing Complete Rear Axle Carrier
- 33 31 011 Replacing Rear Axle Carrier
- 33 31 503 Lowering/Raising Rear Axle Carrier
- 33 32 051 Removing and Installing/Replacing Left Or Right Push Rod/Integral Link
- 33 32 064 Removing and Installing/Replacing Left Or Right Swinging Arm
- 33 32 071 Replacing One Upper Control Arm
- 33 32 091 Replacing a Guide Arm
- 33 32 125 Replacing a Ball Joint In Lower Steering Knuckle/Wheel Carrier
- 33 32 131 Removing and Installing/Replacing a Steering Knuckle/Wheel Carrier
- 33 33 001 Replacing Left Or Right Rear Axle Carrier Tension Strut
- 33 33 111 Replacing All Rubber Mounts For Rear Axle Carrier
- 33 41 000 Replacing Drive Flange On Left/Right Rear Axle Shaft
- 33 41 151 Replacing Left Or Right Wheel Bearing On Rear Axle Shaft
- 33 53... Measuring Ride-Level Height Of Vehicle
- 33 55 000 Removing and Installing/Replacing Rear Stabilizer
- 33 55 021 Replacing Both Rubber Mounts For Stabilizer Mounting
- 33 55 040 Replacing Stabilizer Link For Rear Left Or Right Stabilizer