Volvo 850 I (1991-1997) 1995 early production Wiring diagrams

1995 EARLY PRODUCTION 1995 LATE PRODUCTION 30-RAIL CONNECTOR 9 10 11 8 12 M+ 9 10 11 8 M+ ALARM RELAY ATR BATTERY BLK WIRE BLU/BRN WIRE BLU/PNK WIRE BLU/RED WIRE BODY GROUND CONNECTOR BRN WIRE CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) CENTRAL LOCKING/DELAYED INTERIOR LIGHTING RELAY DEADLOCK SETTING RELAY FUSE 3 FUSE 32 FUSE 6 FUSE 15 GRN/BRN WIRE GRN/YEL WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN ACC OR RUN W/ OVERLOAD RELAY #1 (X+) ENERGIZED HOT IN RUN OR START W/ OVERLOAD RELAY #2 (15+) ENERGIZED LA 15 AT LEFT FRONT DOOR LOCK LEFT REAR DOOR LOCK LOCK MBH MBL MBLS MBLS M- NCA WIRE PNK/BLK WIRE POWER GROUND CONNECTOR RED WIRE RIGHT FRONT DOOR LOCK RIGHT REAR DOOR LOCK SEDAN SOLID STATE TANK CAP CENTRAL LOCKING MOTOR UNLOCK VIO WIRE VIO/WHT WIRE WAGON TRUNK/TAILGATE LOCK WARNING SYSTEM WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/VIO WIRE YEL/WHT WIRE

1995 EARLY PRODUCTION 1995 LATE PRODUCTION 2-STAGE LOCKING RELAY POSITION OR DEADLOCK SETTING RELAY POSITION 30-RAIL CONNECTOR 31 M+ UNLOCK 9 10 11 7 13 AT ALARM RELAY ATR BATTERY BLK WIRE BLU/BRN WIRE BLU/PNK WIRE BLU/RED WIRE BODY GROUND CONNECTOR BRN WIRE CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) CENTRAL LOCKING/DELAYED INTERIOR LIGHTING RELAY FUSE 3 FUSE 32 FUSE 6 FUSE 15 GRN/BRN WIRE GRN/YEL WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN ACC OR RUN W/ OVERLOAD RELAY #1 (X+) ENERGIZED HOT IN RUN OR START W/ OVERLOAD RELAY #2 (15+) ENERGIZED LA 15 AT LEFT FRONT DOOR LOCK LEFT REAR DOOR LOCK LOCK NCA WIRE PNK/BLK WIRE POWER GROUND CONNECTOR RED WIRE RIGHT FRONT DOOR LOCK RIGHT REAR DOOR LOCK SEDAN SOLID STATE TANK CAP CENTRAL LOCKING MOTOR UNLOCK WAGON TRUNK/TAILGATE LOCK WARNING SYSTEM WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/VIO WIRE YEL/WHT WIRE

1995 EARLY PRODUCTION 2 13 (1995) (1996-97) A/T M/T ALARM RELAY BATTERY BLK WIRE BLU WIRE BLU/BLK WIRE BLU/YEL WIRE BRAKE LIGHT SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE PEDAL SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) CLUTCH PEDAL SWITCH (ON BRACKET, ABOVE CLUTCH PEDAL) CONNECTOR CRUISE CONTROL MODULE (UNUSED PINS NOT SHOWN) CRUISE CONTROL SWITCH CRUISE CONTROL VACUUM PUMP (LEFT FRONT OF ENGINE COMPT) DEC ENGINE CONTROLS SYSTEM FUSE 12 FUSE 28 GRN/BLK WIRE GRN/RED WIRE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT IN IGNITION SWITCH INSTRUMENT CLUSTER NCA WIRE OFF ON-BOARD DIAGNOSTIC CONNECTOR (1996-97 PARTIAL) (CENTER CONSOLE FORWARD SHIFTER) RED WIRE RED/BLK WIRE RES+ RUN WIRE SIGNAL GROUND CONNECTOR SPEEDOMETER W/ A/T ONLY WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/GRY WIRE YEL/RED WIRE

1995 EARLY PRODUCTION 1995 ONLY ANTI-THEFT SYSTEM BACK UP LAMP BACK-UP LAMPS CIRCUIT BLK WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/RED WIRE BULB MALFUNCTION INDICATOR CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) FUSE 13 FUSE 27 GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE GRY/WHT WIRE HAZARD FLASHER RELAY/ SWITCH ILLUM- INATION LAMP HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LEFT TAILLIGHT ASSEMBLY LEFT TURN INDICATOR PARK LAMP PNK WIRE POWER GROUND CONNECTOR REAR FOG LAMP REAR FOG LAMP PARK LAMP RED WIRE RED/WHT WIRE RIGHT TAILLIGHT ASSEMBLY RIGHT TURN INDICATOR SOLID STATE STOP LAMP TRAILER INDICATOR TURN SIGNAL LAMP TURN SIGNAL/ HIGH-LOW BEAM SWITCH VIO/WHT WIRE YEL/BRN WIRE YEL/GRY WIRE

1995 EARLY PRODUCTION 1995 ONLY ANTI-THEFT SYSTEM BACK UP LAMP BACK-UP LAMPS CIRCUIT BLK WIRE BLU WIRE BLU/GRN WIRE BLU/GRY WIRE BLU/RED WIRE BULB MALFUNCTION INDICATOR CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) FUSE 13 FUSE 27 GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE GRY/WHT WIRE HAZARD FLASHER RELAY/ SWITCH ILLUM- INATION LAMP HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT IN RUN INSTRUMENT CLUSTER INSTRUMENT CLUSTER SYSTEM LEFT LOWER TAILLIGHT ASSEMBLY LEFT TURN INDICATOR LEFT UPPER TAILLIGHT ASSEMBLY PARK LAMP PNK WIRE POWER GROUND CONNECTOR REAR FOG/ PARK LAMP RED WIRE RED/WHT WIRE RIGHT LOWER TAILLIGHT ASSEMBLY RIGHT TURN INDICATOR RIGHT UPPER TAILLIGHT ASSEMBLY SOLID STATE STOP LAMP TRAILER INDICATOR TURN SIGNAL LAMP TURN SIGNAL/ HIGH-LOW BEAM SWITCH VIO/WHT WIRE YEL/BRN WIRE YEL/GRY WIRE

1/1 1995 EARLY PRODUCTION 1995 EARY PRODUCTION 1996, 1997 2.4L W/ MOTRONIC (4.4 MFI) ENGINE CONTROLS 1997 DIESEL (FRONT OF ENGINE) 31/11 31/15 31/32 31/33 31/4 31/44 31/47 31/50 31/51 31/52 31/55 31/65 31/7 BLK WIRE BLU WIRE BODY GROUND CONNECTOR BRN WIRE CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) CONTROL MODULE CONTROL MODULE, PTC RESISTOR PRE-HEATER (TURBO) DI IGNITION DISCHARGE MODULE/ IGNITION COIL ENGINE CONTROL MODULE ENGINE CONTROL MODULE, ON-BOARD DIAGNOSTIC (II) CONNECTOR (1995), ENGINE COOLING FAN FUEL SYSTEM MAIN RELAY, ENGINE CONTROL MODULE, PTC RESISTOR HORN SWITCH ORG BLK WIRE POWER GROUND CONNECTOR RIGHT TAILLIGHT ASSEMBLY(S), TILT SENSOR (SEDAN-1996) SECONDARY AIR PUMP SIGNAL GROUND CONNECTOR

1995 EARLY PRODUCTION 1995 LATE PRODUCTION, 1996-97 BLK WIRE CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) FUSE 34 HORN 1 HORN 2 HORN SWITCH HOT IN ACC OR RUN SLIP RING (IN STEERING COLUMN) YEL/BLK WIRE YEL/VIO WIRE

1. AVG SPEED 2. INSTANT 1995 EARLY PRODUCTION 1995 LATE PRODUCTION ABS INDICATOR ANTI-LOCK BRAKE SYSTEM BLK WIRE BLU WIRE BLU/GRN WIRE BLU/PNK WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING INDICATOR BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE BULB FAILURE WARNING INDICATOR CHARGING INDICATOR CHARGING SYSTEM CHECK ENGINE INDICATOR CLOCK MODULE COOLANT LEVEL INDICATOR EXTERIOR LIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM COMPUTER DATALINES SYSTEM FUEL CONSUMPTION 3. AVG FUEL CONSUMPTION 4. OUTSIDE TEMP 5. DISTANCE FUEL GAUGE FUSE GRN WIRE GRN/BLK WIRE GRN/BRN WIRE GRN/GRY WIRE GRN/ORG WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/WHT WIRE HAND BRAKE SWITCH (BELOW CENTER CONSOLE) HIGH BEAM INDICATOR ILLUMINATION (4 BULBS) INSTRUMENT CLUSTER KEDT KEFA LEFT TURN SIGNAL INDICATOR LOW FUEL INDICATOR SERVICE REMINDER INDICATOR LOW GEAR SELECTION INDICATOR MICROPROCESSOR N/A NCA WIRE OIL PRESSURE SENSOR (FRONT OF ENGINE) OIL PRESSURE WARNING INDICATOR OUTSIDE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF FRONT BUMPER) PARK BRAKE INDICATOR PNK WIRE REAR FOG LIGHTS INDICATOR RED/BLK WIRE RED/WHT WIRE REG REG RESET+ RIGHT TURN SIGNAL INDICATOR SINCE LAST RESET 6. DISTANCE TO EMPTY 7. DIAGNOSIS SPEEDO- METER SRS SRS INDICATOR TACHO- METER TEMPERATURE GAUGE TRACS INDICATOR TRAILER WARNING INDICATOR TRIP COMPUTER CONTROLS TRIP COMPUTER OR AMBIENT TEMPERATURE/ CLOCK MODULE VIO WIRE VIO/WHT WIRE WASHER LEVEL WARNING INDICATOR WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/RED WIRE YEL/WHT WIRE

1995 EARLY PRODUCTION 1995 LATE PRODUCTION ABS INDICATOR ANTI-LOCK BRAKE SYSTEM BLK WIRE BLU WIRE BLU/GRN WIRE BLU/PNK WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING INDICATOR BRN WIRE BRN/BLK WIRE BRN/GRY WIRE BRN/WHT WIRE BULB FAILURE WARNING INDICATOR CHARGING INDICATOR CHARGING SYSTEM CHECK ENGINE INDICATOR CLOCK MODULE COOLANT LEVEL INDICATOR EXTERIOR LIGHTS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM FUSE GRN WIRE GRN/BLK WIRE GRN/BRN WIRE GRN/GRY WIRE GRN/ORG WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HAND BRAKE SWITCH (BELOW CENTER CONSOLE) HIGH BEAM INDICATOR ILLUMINATION (5 BULBS) INSTRUMENT CLUSTER LEFT TURN SIGNAL INDICATOR LOW FUEL INDICATOR LOW GEAR SELECTION INDICATOR NCA WIRE OIL PRESSURE SENSOR (FRONT OF ENGINE) OIL PRESSURE WARNING INDICATOR OUTSIDE TEMPERATURE SENSOR (BEHIND LEFT SIDE OF FRONT BUMPER) OUTSIDE TEMPERATURE/ CLOCK MODULE PARK BRAKE INDICATOR PNK WIRE REAR FOG LIGHTS INDICATOR RED/BLK WIRE RED/WHT WIRE REG RIGHT TURN SIGNAL INDICATOR SERVICE REMINDER INDICATOR SPEEDMETER SRS SRS INDICATOR TACHOMETER TANK/ TEMPERATURE GAUGE TRACS INDICATOR TRAILER WARNING INDICATOR VIO WIRE VIO/WHT WIRE WASHER LEVEL WARNING INDICATOR WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/BRN WIRE YEL/GRY WIRE YEL/RED WIRE YEL/WHT WIRE

1995 EARLY PRODUCTION 1995 LATE PROD, 1996, 1997 1996 EARLY PRODUCTION ONLY ABS CONTROL MODULE, ABS COMBINATION RELAY ALARM RELAY, CRUISE CONTROL MODULE (W/ A/T) ALARM SIREN (W/ LATE PROD GUARD ALARM II) BLK WIRE BLU WIRE BLU/RED WIRE BODY GROUND CONNECTOR BATTERY BRN WIRE CENTRAL ELECTRICAL UNIT (LEFT REAR OF ENGINE COMPT) CENTRAL LOCKING/ ANTI-THEFT REMOTE CONTROL MODULE, RADIO CIGAR LIGHTER CIRCUIT BREAKER 37 ELECTRONIC IMMOBILIZER (1997) ENGINE CONTROL MODULE, AW 50-42 AUTOMATIC TRANSMISSION CONTROL MODULE FROM FUSE 11 (1996 LATE PRODUCTION ONLY) (HOT AT ALL TIMES) (DIAGRAM 1 OF 2) FROM FUSE 6 (POSITIVE BATTERY TERMINAL) (HOT AT ALL TIMES) (DIAGRAM 1 OF 2) FROM FUSE 7 (POSITIVE BATTERY TERMINAL) (HOT AT ALL TIMES) (DIAGRAM 1 OF 2) FROM FUSE 8 (POSITIVE BATTERY TERMINAL) (HOT AT ALL TIMES) (DIAGRAM 1 OF 2) FUSE 1 FUSE 17 FUSE 26 FUSE 27 FUSE 29 FUSE 3 FUSE 30 FUSE 31 FUSE 32 FUSE 33 FUSE 34 FUSE 35 FUSE 36 FUSE 28 FUSE 4 FUSE 2 GRN WIRE GRY WIRE IGNITION SWITCH KEY IN KEY-IN IGNITION SWITCH LIGHT SWITCH LIGHT SWITCH, POWER DOOR MIRROR SWITCHES, FRONT HEATED SEAT SWITCHES OFF ORG/ WIRE OVERLOAD RELAY #1 (X+) OVERLOAD RELAY #1 (X+), OVERLOAD RELAY #3 (X+) (DIAGRAM 2 OF 2) OVERLOAD RELAY #2 (15+) OVERLOAD RELAY #2 (X+), FUSE 1 (DIAGRAM 2 OF 2) OVERLOAD RELAY #3 (X+) POSITIVE BATTERY TERMINAL (DIAGRAM 1 OF 1) POWER GROUND CONNECTOR POWER WINDOW SWITCHES, POWER SUNROOF CONTROL MODULE RED WIRE RHEOSTAT, POWER SUNROOF SWITCH, ACCESSORIES CONNECTOR SEAT BELT REMINDER/ KEY WARNING RELAY SPEED WARNING RELAY, CENTRAL LOCKING/ DELAYED INTERIOR LIGHTING RELAY SRS SENSOR UNIT VIO WIRE YEL WIRE YEL/VIO WIRE