Volkswagen Routan I (2008-2012) occupant restraint controller module Wiring diagrams

1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RH SLIDING DR AJAR SW SNS GND 1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RR DR LCK SNS RH PWR SLIDING DR MUX RTN 1 2 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 1 2 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV 1 4 LH SLIDING DR PILLAR SW MUX SW RTN 1 4 RH SLIDING DR PILLAR SW MUX SW RTN 2 1 RH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 7 3 16 RH PWR SLIDING DR MUX RTN RH DR IN/OUT HANDLE SW SNS RH DR SECTOR SW SNS 7 4 PASS SW RTN PASS DR LCK SW MUX 7 6 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV B(+) BASE BASE EXCEPT BASE BLK WIRE BRAKE FLUID LEVEL SENSOR (BRAKE FLUID RESERVOIR) BRAKE LP SW BRAKE SIG 1 BRN/YEL WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH DRV DR LCK SW MUX DRV DR LCK SW MUX LIN BUS ELECTRONICS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) HOT AT ALL TIMES IGN SW, RUN/ START LEFT B-PILLAR SWITCH (LEFT "B" PILLAR) LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT FRONT OF ENGINE COMPT) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT REAR WHEELWELL) LF TURN SIG CTRL LH SLIDING DR LIN BUS LR TURN SIG CTRL LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE MONITOR LAN OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/DK GRN WIRE ORG/GRY WIRE ORG/YEL WIRE PASS DR LCK SW MUX PASS SW RTN PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/ DOOR LOCK SWITCH PILLAR SW MUX PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED/ORG WIRE RF TURN SIG CTRL RH SLIDING DR RIGHT B-PILLAR SWITCH (RIGHT "B" PILLAR) RIGHT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH (W/O POWER SLIDING DOOR) RIGHT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (RIGHT REAR DOORS) RIGHT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) RR SLIDING DR AJ SW RR TURN SIG CTRL SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) SOL UNLOCK TRS PRK SIG STOP LAMP SWITCH (AT TOP OF BRAKE PEDAL) SW RTN SW RTN PASS DR LCK SW MUX TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/DK GRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/DK BLU WIRE

BLK WIRE BLK/LT BLU WIRE BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE CAN C A/C CAN C BUS BUS CLUTCH SENS (-) CTRL (+) SIG GND COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) ECT ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) FAN CTRL CTRL OUT HDLP SIG INFRARED SENSOR (CENTER FRONT OF ROOF) LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN WIRE OCCUPANT RESTRAINT CONTROLLER MODULE PNK/LT GRN WIRE REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) REAR MODE DOOR ACTUATOR 3 (HVAC UNIT) RED/BRN WIRE RLY GND OUT SENS GND SENS SIG SENS SIG 1 SENS SIG 2 SUN SENSOR VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/VIO WIRE

3.3L/ 3.8L 4.0L 3.8L 3.3L/ 4.0L 3.3L/ 4.0L 3.8L A/C COMPRESSOR CLUTCH ANTI-LOCK BRAKES MODULE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE DODGE DOOR LOCK RELAY DOOR UNLOCK 1 RELAY DOOR UNLOCK 2 RELAY EARLY PRODUCTION EGR VALVE ASSEMBLY ELECTRONICS EXCEPT DODGE DODGE FRONT WASHER PUMP RELAY HEADLAMP RADIATOR WASHER FAN MOTOR MOTOR HORN 1 LATE PRODUCTION LEFT FRONT ASSEMBLY LAMP LEFT FRONT FOG LAMP LEFT FRONT TIRE PRESSURE TRANSPONDER LEFT SIDE REPEATER LAMP OCCUPANT RESTRAINT CONTROLLER MODULE OXYGEN SENSOR 1/1 OXYGEN SENSOR 1/2 OXYGEN SENSOR 2/1 OXYGEN SENSOR 2/2 POWERTRAIN CONTROL MODULE RADIATOR COOLING FAN MODULE REAR WIPER RELAY RIGHT FRONT ASSEMBLY LAMP RIGHT FRONT FOG LAMP RIGHT FRONT TIRE PRESSURE TRANSPONDER RIGHT SIDE REPEATER HORN 2 LAMP THROTTLE VALVE SOLENOID

1 2 3 4 5 6 7 8 9 10 FUSED B(+) PANEL LAMPS DRIVER 12 11 1 RH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 2 1 GND LIFTGATE AJAR SW SNS 21 17 18 LIFTGATE AJAR SW SNS CAN INT BUS - CAN INT BUS + 3 4 ESP ON/OFF SNS GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BLK WIRE BLK/ORG WIRE BREAKOUT) BUS (-) CAN C BUS - CAN C BUS (+) CAN INTERIOR CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM COURTESY LAMPS DRIVER DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR DRV DR AJAR SW SNS ELECTRONICS EOP SIG ESP ON/OFF SNS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) FUSED IGN SW OUT (RUN-START) FUSED B(+) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HEADLAMP SW MUX PANEL LAMPS DIMMER SIG HEADLAMP SW MUX RTN HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED HOT W/ RUN/ START RELAY ENERGIZED INTERIOR LAMPS DRIVER HEADLAMP SW SIG INTERIOR LIGHTS SYSTEM COMPUTER DATA INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 12 11 1 LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) LIN BUS GND SW OUT (RUN) LINES SYSTEM LT GRN/TAN WIRE MODULE (LEFT SIDE OF ENGINE COMPT) OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE ORG/VIO WIRE PANEL LAMPS DRV PARK BRAKE PARKING BRAKE SWITCH (BEHIND LEFT SIDE OF DASH) PASS DR AJAR PASS DR AJAR SW SNS PNK/LT GRN WIRE PNK/YEL WIRE POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) POWER SLIDING DOOR LOCKOUT SNS PARK BRAKE SW SNS POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIO CONTROL MUX HORN SW SNS RADIO CONTROL MUX RTN RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) RIGHT REAR DOOR MODULE (RIGHT REAR DOORS) SENS RTN SENS SIG FUEL LVL SOUND SYSTEMS SOUND SYSTEMS HORNS SYSTEM SW SNS TOTALLY INTEGRATED POWER TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM INTERIOR LIGHTS SYSTEM UGDO ENABLE CONTROL LIN BUS VIO WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ COMPASS W/O POWER LIFTGATE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE YEL/WHT WIRE

1 6 2 8 FUSED B(+) FUSED B(+) PANEL LAMPS DRV GND 15 16 10 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) PANEL LAMPS DIMMER SIG 2 1 PANEL LAMPS DRV GND 2 4 5 PANEL LAMPS DIMMER SIG PANEL LAMPS DRV GND 3 2 PANEL LAMPS DRV GND 3 ZONE MANUAL A/C 4 3 PANEL LAMPS DRV GND 4 5 PANEL LAMPS DRV GND 7 4 PANEL LAMPS DRV GND 7 9 17 9 PANEL LAMPS DRV GND A/C HEATER CONTROL ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BANK 2 SWITCH BLK WIRE BUS - CAN INTERIOR CAN INTERIOR BUS + CENTER CONSOLE LAMP CLUSTER COMPASS COMPUTER DATA LINES SYSTEM ELECTRONICS FUSE HEADLAMP SWITCH HOT AT ALL TIMES INVERTER SWITCH MANUAL A/C AUTOMATIC A/C OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE PANEL LAMPS DRV REAR BLOWER CONTROL SWITCH RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ CENTER CONSOLE LAMP W/O CENTER CONSOLE LAMP WHT/GRY WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 FUSED B+ STATUS IND 3 1 5 4 6 ENABLE SW SIG STATUS IND DRV GND PANEL LAMPS SW SIG AC POWER OUTLET AUTO SHUT DOWN RELAY BACKUP LAMP RELAY BASE BLK WIRE BLK/ORG WIRE BRK LP SW OUT BRN/YEL WIRE CENTER HIGH MOUNTED STOP LAMP CLUSTER DK GRN/RED WIRE DRIVER WINDOW/DOOR LOCK SWITCH ELECTRONICS IGN SW OUTPUT (RUN- START) ELECTRONICS TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) EXCEPT BASE FROM FRONT WASHER PUMP RELAY FRONT WIPER HIGH/LOW RELAY FRONT WIPER ON RELAY FUSE FUSE FUSE GND ENABLE SW SIG HORN RELAY IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) INVERTER MODULE (ABOVE LEFT REAR WHEELWELL) INVERTER SWITCH LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) LT BLU/RED WIRE LT GRN WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE OCCUPANT RESTRAINT CONTROLLER MODULE ORG/GRY WIRE PCM RELAY PNK/WHT WIRE RADIATOR FAN HIGH SPEED RELAY RADIATOR FAN LOW SPEED RELAY REAR BLOWER MOTOR RELAY REAR WASHER PUMP RELAY REAR WINDOW DEFOGGER RELAY REAR WIPER RELAY RED WIRE RED/BRN WIRE RED/LT BLU WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) SHIFTER LEVER ASSEMBLY STARTER RELAY STEERING CONTROL MODULE STOP LAMP SWITCH SW SIG TO RUN RELAY (DIAGRAM 3 OF 4) TRS PARK SIG W/ COMPASS WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE YEL/DK BLU WIRE

3 ZONE MANUAL A/C ALL POWER WINDOW ANTI-LOCK BRAKES MODULE AUTOMATIC A/C BASE BLIND SPOT MODULE BLK WIRE BLK/YEL WIRE BLU PNK WIRE CIGAR LIGHTER CLUSTER COMPASS INFRARED MODULE SENSOR CONSOLE POWER OUTLET DK BLU WIRE DK BLU/PNK WIRE ELECTRONICS RUN/ EXCEPT 3 ZONE MANUAL A/C EXCEPT BASE EXCEPT BASE BASE FLASH LIGHT LAMP FREE FROM FRONT POWER WINDOW FUEL PUMP RELAY FUSE FUSE FUSE HANDS FREE EXCEPT HANDS HEATED SEATS MODULE INSIDE STEERING REARVIEW CONTROL MIRROR MODULE INSTRUMENT PANEL POWER LEFT COURTESY LAMP LEFT FRONT TIRE PRESSURE A/C HEATER TRANSPONDER CONTROL LEFT REAR RIGHT REAR BLEND SPOT BLEND SPOT SENSOR SENSOR LEFT REAR TIRE PRESSURE TRANSPONDER LT BLU/PNK WIRE LT GRN PNK/ WIRE LT GRN WIRE LT GRN/WHT WIRE OCCUPANT RESTRAINT CONTROLLER MODULE ORG PNK/ WIRE OUTLET PARK HEADLAMP ASSIST LEVELING MODULE MODULE PNK WIRE PNK/ LT GRN WIRE PNK/ YEL WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAIN PASSENGER SENSOR WINDOW/DOOR LOCK SWITCH REAR POWER OUTLET RED WIRE RED/BLK WIRE RED/LT GRN WIRE RELAY RELAY RLY CTRL CTRL RIGHT COURTESY LAMP RIGHT FRONT TIRE PRESSURE TRANSPONDER RLY CTRL RUN WIRE RUN/ RUN/ ACCESSORY RELAY SHIFTER LEVER ASSEMBLY STEERING ANGLE SENSOR STOP LAMP SWITCH SUNROOF MOTOR/ MODULE (NEAR MANIFOLD ABSOLUTE PRESSURE SENSOR) TO CIRCUIT BREAKER 1 (DIAGRAM 4 OF 4) TO FUSE

1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RH SLIDING DR AJAR SW SNS GND 1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RR DR LCK SNS RH PWR SLIDING DR MUX RTN 1 2 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 1 2 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV 1 4 LH SLIDING DR PILLAR SW MUX SW RTN 1 4 RH SLIDING DR PILLAR SW MUX SW RTN 2 1 RH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 7 3 16 RH PWR SLIDING DR MUX RTN RH DR IN/OUT HANDLE SW SNS RH DR SECTOR SW SNS 7 4 PASS SW RTN PASS DR LCK SW MUX 7 6 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV B(+) BASE BASE EXCEPT BASE BLK WIRE BRAKE FLUID LEVEL SENSOR (BRAKE FLUID RESERVOIR) BRAKE LP SW BRAKE SIG 1 BRN/YEL WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH DRV DR LCK SW MUX DRV DR LCK SW MUX LIN BUS ELECTRONICS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) HOT AT ALL TIMES IGN SW, RUN/ START LEFT B-PILLAR SWITCH (LEFT "B" PILLAR) LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT FRONT OF ENGINE COMPT) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT REAR WHEELWELL) LF TURN SIG CTRL LH SLIDING DR LIN BUS LR TURN SIG CTRL LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE MONITOR LAN OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/DK GRN WIRE ORG/GRY WIRE ORG/YEL WIRE PASS DR LCK SW MUX PASS SW RTN PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/ DOOR LOCK SWITCH PILLAR SW MUX PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED/ORG WIRE RF TURN SIG CTRL RH SLIDING DR RIGHT B-PILLAR SWITCH (RIGHT "B" PILLAR) RIGHT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH (W/O POWER SLIDING DOOR) RIGHT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (RIGHT REAR DOORS) RIGHT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) RR SLIDING DR AJ SW RR TURN SIG CTRL SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) SOL UNLOCK TRS PRK SIG STOP LAMP SWITCH (AT TOP OF BRAKE PEDAL) SW RTN SW RTN PASS DR LCK SW MUX TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/DK GRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/DK BLU WIRE