Volkswagen Routan I (2008-2012) lp vfs ctrl Wiring diagrams

18 19 22 RLY TRAN CTRL OUT OD PRESS SIG 2/4 CTRL 2/4 PRESS SIG 24 27 28 29 30 31 32 33 34 35 37 38 TRANSFER SPEED SIG 26 27 DOWNSHIFT SIG UPSHIFT SIG 5 6 7 12 BUS (+) BUS (-) SOL UNLCK TRS PARK SIG 6 2 1 3 4 5 GND TRS PARK SIG SOL UNLCK (RUN-START) UPSHIFT SIG DOWNSHIFT SIG B(+) BLK WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE ENGINE CONTROLS SYSTEM FUSE ELECTRONICS FUSED IGN SW OUT (RUN-START) HOT AT ALL TIMES IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) L/R CTRL L/R PRESS SIG LINE PRESS SIG LINE PRESSURE SENSOR/VARIABLE FORCE SOLENOID ASSEMBLY LP VFS CTRL LT BLU/DK GRN WIRE LT GRN PNK/ WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) SENS GND SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) TAN WIRE TEMP SENS SIG TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSMISSION RANGE SENSOR TRANSMISSION SOLENOID/PRESSURE SWITCH ASSEMBLY UD CTRL WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

2/4 CTRL 2/4 PRESS SIG 26 27 DOWNSHIFT SIG UPSHIFT SIG 4.0L 5 6 7 12 BUS (+) BUS (-) SOL UNLCK TRS PARK SIG 6 2 1 3 4 5 GND TRS PARK SIG SOL UNLCK (RUN-START) UPSHIFT SIG DOWNSHIFT SIG B(+) BLK WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DC CTRL DC PRESS SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EMC SOLENOID CTRL ENGINE CONTROLS SYSTEM FUSE ELECTRONICS FUSED IGN SW OUT (RUN-START) HOT AT ALL TIMES IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) L/R CTRL L/R PRESS SIG LC CTRL LC PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) SENS GND SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

2/4 CTRL 2/4 PRESS SIG 26 27 DOWNSHIFT SIG UPSHIFT SIG 4.0L 5 6 7 12 BUS (+) BUS (-) SOL UNLCK TRS PARK SIG 6 2 1 3 4 5 GND TRS PARK SIG SOL UNLCK (RUN-START) UPSHIFT SIG DOWNSHIFT SIG B(+) BLK WIRE BRN/YEL WIRE COMPUTER DATA LINES SYSTEM DC CTRL DC PRESS SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EMC SOLENOID CTRL ENGINE CONTROLS SYSTEM FUSE ELECTRONICS FUSED IGN SW OUT (RUN-START) HOT AT ALL TIMES IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) L/R CTRL L/R PRESS SIG LC CTRL LC PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) SENS GND SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT BLU WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM ELECTRONICS EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE FUSED IGN SW OUT (RUN- SENS START) RTN SIG HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LINE PRESSURE SENSOR/ VARIABLE FORCE SOLENOID ASSEMBLY LP VFS CTRL LT BLU/DK GRN WIRE LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) PRESS SENS SIG S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND STARTING/ CHARGING SYSTEM TAN WIRE TEMP SENS SIG TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION RANGE SENSOR TRANSMISSION SOLENOID/PRESSURE SWITCH ASSEMBLY UP CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/DK GRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DC CTRL DC PRESS SIG DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOOR LOCKS SYSTEM ELECTRONICS EMC SOLENOID CTRL EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LC CTRL LC PRESS SIG LC PRESS SIG OD PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND SENS RTN SIG STARTING/ CHARGING SYSTEM TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DC CTRL DC PRESS SIG DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOOR LOCKS SYSTEM ELECTRONICS EMC SOLENOID CTRL EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LC CTRL LC PRESS SIG LC PRESS SIG OD PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND SENS SIG RTN STARTING/ CHARGING SYSTEM TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE