Volkswagen Routan I (2008-2012) except base Wiring diagrams

AUTO DAY/ NIGHT MIRR (+) AUTO DAY/NIGHT MIRR (-) BACKUP LAMP RELAY BACKUP LAMP SW OUT BLK WIRE BLK/YEL WIRE CAN INTR BUS (+) COMPUTER DATA LINES SYSTEM DK GRN/LT BLU WIRE DK GRN/YEL WIRE DRIVER DOOR MODULE (IN DRIVER DOOR) EXCEPT BASE FUSE FUSED IGN SW OUT HANDS FREE MODULE (BEHIND LEFT END OF DASH) HOT W/ RUN/ START RELAY ENERGIZED INSIDE REARVIEW MIRROR LT BLU/WHT WIRE LT GRN/DK BLU WIRE LT GRN/DK GRN WIRE MICROPHONE 1 IN (+) MICROPHONE 2 IN (+) MICROPHONE FEED MICROPHONE IN (-) NIGHT MIRR (-) AUTO DAY/ ORG/GRY WIRE PNK/LT GRN WIRE RADIO SENS GND SENSOR GROUND TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ NAVIGATION W/ RAIN SENSE W/O NAVIGATION WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE

AUTO DAY/ NIGHT MIRROR AUTO DAY/NIGHT MIRROR (-) BACKUP LAMP RELAY BACKUP LAMP SW BLK WIRE BLK/DK BLU WIRE BLK/DK GRN WIRE BLK/YEL WIRE DRIVER DOOR MODULE (DRIVER FRONT DOOR) EXCEPT BASE FUSE FUSED IGN SW OUT HOT W/ RUN/START RELAY ENERGIZED INSIDE REARVIEW MIRROR LT GRN WIRE PNK WIRE PNK/LT GRN WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/LT GRN WIRE

1 2 COURTESY LAMPS DRV GND 2 3 1 COURTESY LAMPS DRV COURTESY LAMPS DRV GND 3 1 FUSED IGN SW OUT (RUN) GND 3 2 1 COURTESY LAMPS DRV COURTESY LAMPS DRV GND 3 2 1 FUSED IGN SW OUT (RUN) DRV DR COURTESY LAMP GND 3 2 1 FUSED IGN SW OUT (RUN) PASS DR COURTESY LAMP GND 3 2 COURTESY LAMPS DRV GND B(+) BASE BLK WIRE BLK/WHT WIRE COURTESY LAMPS DRV GND DOME LAMP DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRV DR COURTESY LAMP ELECTRONICS EXCEPT 3 ZONE EXCEPT BASE FLASHLIGHT LAMP FRONT READING LAMP FUSE FUSED B(+) UGDO ENABLE CTRL GRY WIRE HOT AT ALL TIMES LEFT COURTESY LAMP LEFT VANITY LAMP (W/ HOMELINK) LEFT VANITY LAMP (W/O HOMELINK) LIFTGATE LAMP MAP 2 LAMP ORG/DK BLU WIRE ORG/LT BLU WIRE OVERHEAD RAIL LAMP PASS DR COURTESY LAMP PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PNK/YEL WIRE RED WIRE RELAY RIGHT COURTESY LAMP RIGHT VANITY LAMP RUN RLY CTRL RUN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) YEL/LT BLU WIRE YEL/VIO WIRE

1 2 LH TURN SIG GND 1 2 RH TURN SIG GND 1 3 GND LIN BUS 1 4 HAZARD SW SNS GND 1 5 PARK LAMP CTRL OUT GND 11 9 SW MUX RTN SW MUX 19 15 16 LIN BUS CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 3 2 1 FUSED B(+) LIN BUS GND B(+) BANK 1 SWITCH BLK WIRE BLK/YEL WIRE BRAKE LAMP SW OUT BRAKE SIG 1 BRAKE SIG 2 BRK LP SW OUT BUS (+) CAN INTERIOR CAN INTERIOR BUS + CENTER HIGH MOUNTED STOP LAMP CLUSTER COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE DODGE EXCEPT DODGE ENGINE COMPT) EXCEPT BASE FUSE FUSE FUSE FUSE FUSED B (+) FUSED IGN SW OUT (RUN-START) HDLP SW SIG HEADLAMP SW SIG HEADLAMP SWITCH HOT AT ALL TIMES HOT W/ RUN/ START RELAY ENERGIZED IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) LEFT 3-WAY TRAILER TOW WIRING LEFT TAIL LAMP ASSEMBLY LF TURN SIG CTRL LF TURN SIG CTRL LH TURN SIG GND 1 2 3 3 2 1 LH TURN SIG LICENSE LAMP LICENSE PLATE LAMP/ REAR CAMERA ASSEMBLY LR TURN SIG CTRL LT BLU WIRE LT BLU/DK GRN WIRE LT GRN/RED WIRE NCA WIRE PARK LAMP CTRL OUT PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED WIRE RF TURN SIG CTRL RF TURN SIG CTRL RH TURN SIG GND RIGHT 3-WAY TRAILER TOW WIRING RIGHT TAIL LAMP ASSEMBLY RR TURN SIG CTRL SIG RH TURN STEERING CONTROL MODULE (BEHIND LEFT SIDE OF DASH) STOP LAMP SWITCH (TOP OF BRAKE PEDAL) SW MUX SW MUX RTN SW SNS HAZARD TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ELECTRONICS TURN SIGNAL SWITCHES W/O TRAILER TOW W/O W/ REAR REAR CAMERA CAMERA WHT WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/WHT WIRE

1 2 3 4 5 GND FRT BLOWER LOW SPD A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (4.0L: FRONT OF A/C COMPRESSOR) (3.3L, 3.8L: LEFT A/C HEATER CONTROL BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BRN/LT BLU WIRE BRN/ORG WIRE BUS SENS BUS (-) GND (+) CAN (-) CAN (+) CAN C BUS (+) CLUTCH A/C TRANS SPEED RLY CLUTCH CTRL CTRL OUT CTRL SIG SPLY COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) DRV BLOWER MTR HI DRV DR RECIRCULATION DRV DR MODE DRV DR BLEND DRV DR COMMON 2 ECT SIG ELECTRONICS ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FAN CTRL FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY) FUSE HEADLAMP LOW BLW WASHER SPEED MTR RLY CTRL SPLY HOT AT ALL TIMES HOT IN LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIATOR COOLING FAN MODULE (BEHIND RADIATOR COOLING FAN) RADIATOR FAN HIGH SPEED RELAY (LEFT OF RADIATOR) RADIATOR FAN LOW SPEED RELAY RADIATOR FAN RESISTOR (TOP RIGHT SIDE OF RADIATOR) RED WIRE RED/BRN WIRE RLY OUT RUN WIRE SENS GND TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/ORG WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 FUSED B+ STATUS IND 3 1 5 4 6 ENABLE SW SIG STATUS IND DRV GND PANEL LAMPS SW SIG AC POWER OUTLET AUTO SHUT DOWN RELAY BACKUP LAMP RELAY BASE BLK WIRE BLK/ORG WIRE BRK LP SW OUT BRN/YEL WIRE CENTER HIGH MOUNTED STOP LAMP CLUSTER DK GRN/RED WIRE DRIVER WINDOW/DOOR LOCK SWITCH ELECTRONICS IGN SW OUTPUT (RUN- START) ELECTRONICS TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) EXCEPT BASE FROM FRONT WASHER PUMP RELAY FRONT WIPER HIGH/LOW RELAY FRONT WIPER ON RELAY FUSE FUSE FUSE GND ENABLE SW SIG HORN RELAY IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) INVERTER MODULE (ABOVE LEFT REAR WHEELWELL) INVERTER SWITCH LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) LT BLU/RED WIRE LT GRN WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/RED WIRE LT GRN/WHT WIRE OCCUPANT RESTRAINT CONTROLLER MODULE ORG/GRY WIRE PCM RELAY PNK/WHT WIRE RADIATOR FAN HIGH SPEED RELAY RADIATOR FAN LOW SPEED RELAY REAR BLOWER MOTOR RELAY REAR WASHER PUMP RELAY REAR WINDOW DEFOGGER RELAY REAR WIPER RELAY RED WIRE RED/BRN WIRE RED/LT BLU WIRE RIGHT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) SHIFTER LEVER ASSEMBLY STARTER RELAY STEERING CONTROL MODULE STOP LAMP SWITCH SW SIG TO RUN RELAY (DIAGRAM 3 OF 4) TRS PARK SIG W/ COMPASS WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE YEL/DK BLU WIRE

3 ZONE MANUAL A/C ALL POWER WINDOW ANTI-LOCK BRAKES MODULE AUTOMATIC A/C BASE BLIND SPOT MODULE BLK WIRE BLK/YEL WIRE BLU PNK WIRE CIGAR LIGHTER CLUSTER COMPASS INFRARED MODULE SENSOR CONSOLE POWER OUTLET DK BLU WIRE DK BLU/PNK WIRE ELECTRONICS RUN/ EXCEPT 3 ZONE MANUAL A/C EXCEPT BASE EXCEPT BASE BASE FLASH LIGHT LAMP FREE FROM FRONT POWER WINDOW FUEL PUMP RELAY FUSE FUSE FUSE HANDS FREE EXCEPT HANDS HEATED SEATS MODULE INSIDE STEERING REARVIEW CONTROL MIRROR MODULE INSTRUMENT PANEL POWER LEFT COURTESY LAMP LEFT FRONT TIRE PRESSURE A/C HEATER TRANSPONDER CONTROL LEFT REAR RIGHT REAR BLEND SPOT BLEND SPOT SENSOR SENSOR LEFT REAR TIRE PRESSURE TRANSPONDER LT BLU/PNK WIRE LT GRN PNK/ WIRE LT GRN WIRE LT GRN/WHT WIRE OCCUPANT RESTRAINT CONTROLLER MODULE ORG PNK/ WIRE OUTLET PARK HEADLAMP ASSIST LEVELING MODULE MODULE PNK WIRE PNK/ LT GRN WIRE PNK/ YEL WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/ORG WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE RAIN PASSENGER SENSOR WINDOW/DOOR LOCK SWITCH REAR POWER OUTLET RED WIRE RED/BLK WIRE RED/LT GRN WIRE RELAY RELAY RLY CTRL CTRL RIGHT COURTESY LAMP RIGHT FRONT TIRE PRESSURE TRANSPONDER RLY CTRL RUN WIRE RUN/ RUN/ ACCESSORY RELAY SHIFTER LEVER ASSEMBLY STEERING ANGLE SENSOR STOP LAMP SWITCH SUNROOF MOTOR/ MODULE (NEAR MANIFOLD ABSOLUTE PRESSURE SENSOR) TO CIRCUIT BREAKER 1 (DIAGRAM 4 OF 4) TO FUSE