Volkswagen Routan I (2008-2012) electronics Wiring diagrams

ADJUSTABLE PEDALS MOTOR (UNDER LEFT SIDE OF DASH) ADJUSTABLE PEDALS SWITCH BLK WIRE CAN C BUS (+) COMPUTER DATA LINES SYSTEM ELECTRONICS FRWD MTR FUSED B (+) GROUND HOT AT ALL TIMES LT GRN/LT BLU WIRE LT GRN/WHT WIRE RED/ORG WIRE RRWD MTR TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT/BRN WIRE WHT/LT BLU WIRE

1 8 FUSED B(+) GND 2 1 GND LIFTGATE AJAR SW SNS 3 4 DRV DR AJAR SW SNS GND 3 4 PASS DR AJAR SW SEN GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS B(+) BLK WIRE BLK/ORG WIRE BUS - CAN INTERIOR CLUSTER COMPASS COMPUTER DATA LINES SYSTEM DRIVER 1 OVERHEAD HALO LAMP DRIVER 2 OVERHEAD HALO LAMP DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR ELECTRONICS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUSE GRY WIRE HEADLAMP SWITCH HOT AT ALL TIMES INTERIOR LAMPS DRV LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) ORG/BRN WIRE PANEL LAMPS DIMMER SIGNAL PASS DR AJAR PASSENGER 1 OVERHEAD HALO LAMP PASSENGER 2 OVERHEAD HALO LAMP POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH RIGHT REAR DOOR MODULE (RIGHT REAR DOOR) SW SNS TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ SUNROOF W/O POWER LIFTGATE W/O SUNROOF WHT/GRY WIRE WHT/ORG WIRE YEL/BLU WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE

1 2 COURTESY LAMPS DRV GND 2 3 1 COURTESY LAMPS DRV COURTESY LAMPS DRV GND 3 1 FUSED IGN SW OUT (RUN) GND 3 2 1 COURTESY LAMPS DRV COURTESY LAMPS DRV GND 3 2 1 FUSED IGN SW OUT (RUN) DRV DR COURTESY LAMP GND 3 2 1 FUSED IGN SW OUT (RUN) PASS DR COURTESY LAMP GND 3 2 COURTESY LAMPS DRV GND B(+) BASE BLK WIRE BLK/WHT WIRE COURTESY LAMPS DRV GND DOME LAMP DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRV DR COURTESY LAMP ELECTRONICS EXCEPT 3 ZONE EXCEPT BASE FLASHLIGHT LAMP FRONT READING LAMP FUSE FUSED B(+) UGDO ENABLE CTRL GRY WIRE HOT AT ALL TIMES LEFT COURTESY LAMP LEFT VANITY LAMP (W/ HOMELINK) LEFT VANITY LAMP (W/O HOMELINK) LIFTGATE LAMP MAP 2 LAMP ORG/DK BLU WIRE ORG/LT BLU WIRE OVERHEAD RAIL LAMP PASS DR COURTESY LAMP PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PNK/YEL WIRE RED WIRE RELAY RIGHT COURTESY LAMP RIGHT VANITY LAMP RUN RLY CTRL RUN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) YEL/LT BLU WIRE YEL/VIO WIRE

A/C HEATER CONTROL AIR CONDITIONING SYSTEM AUTO HEADLAMPS SIG AUTOMATIC A/C B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE CAN INTERIOR BUS + CAN-BUS CHRYSLER CHRYSLER W/ HID CHRYSLER W/O HID DODGE CLUSTER COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK GRN/WHT WIRE DRV/ SENS GND ELECTRONICS EVIC FRONT COMMON DR DRV/ SENS GND FRONT FOG LAMP RLY OUT FUSE FUSED B (+) GROUND HEADLAMP RTN SIG HEADLAMP SW MUX HEADLAMP SW MUX RTN HEADLAMP SW SIG HEADLAMP SWITCH HIGH BEAM OUT HIGH HDLP BEAM DRV RTN SIG OUT HIGH LOW BEAM HDLP BEAM DRV OUT RTN SIG HOT AT ALL TIMES LEFT CAN LOW INTERIOR BEAM BUS (+) LEFT FRONT ASSEMBLY LAMP LEFT FRONT FOG LAMP LEFT LOW BEAM DRV MANUAL A/C AUTOMATIC A/C ORG/BRN WIRE ORG/GRY WIRE PANEL LAMPS DIM SIG PANEL LAMPS DRV PARK BRK SW SNS PARKING BRAKE SWITCH (BEHIND LEFT RED WIRE RIGHT RIGHT FRONT ASSEMBLY LAMP RIGHT FRONT FOG LAMP RIGHT LOW BEAM DRV SIDE OF DASH) SIG SUN SENSOR TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/TAN WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/WHT WIRE

BLK WIRE CAN INTERIOR BUS + CLUSTER COMPUTER DATA LINES SYSTEM DK GRN/VIO WIRE ELECTRONICS FUSE GRN WIRE GRY WIRE GRY/ORG WIRE HORN 1 (RIGHT FRONT FRAME RAIL) HORN 2 (LEFT FRONT FRAME RAIL) HORN CAN RELAY INTERIOR CTRL BUS (-) HORN RELAY HORN SW SENSE HORN SWITCH HORN SW SENSE HOT AT ALL TIMES INTERIOR BUS (+) LIN BUS LT BLU WIRE ORG/ WIRE POWER MODULE (LEFT SIDE OF ENGINE COMPT) FUSE RADIO CTRL MUX RADIO CTRL MUX RTN RIGHT STEERING WHEEL SWITCH SOUND SYSTEMS STEERING CONTROL MODULE (BEHIND LEFT SIDE OF DASH) TOTALLY INTEGRATED VIO WIRE WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/ORG WIRE YEL WIRE

1 2 3 4 5 6 7 8 9 10 FUSED B(+) PANEL LAMPS DRIVER 12 11 1 RH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 2 1 GND LIFTGATE AJAR SW SNS 21 17 18 LIFTGATE AJAR SW SNS CAN INT BUS - CAN INT BUS + 3 4 ESP ON/OFF SNS GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BLK WIRE BLK/ORG WIRE BREAKOUT) BUS (-) CAN C BUS - CAN C BUS (+) CAN INTERIOR CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM COURTESY LAMPS DRIVER DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR DRV DR AJAR SW SNS ELECTRONICS EOP SIG ESP ON/OFF SNS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) FUSED IGN SW OUT (RUN-START) FUSED B(+) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HEADLAMP SW MUX PANEL LAMPS DIMMER SIG HEADLAMP SW MUX RTN HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED HOT W/ RUN/ START RELAY ENERGIZED INTERIOR LAMPS DRIVER HEADLAMP SW SIG INTERIOR LIGHTS SYSTEM COMPUTER DATA INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 12 11 1 LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) LIN BUS GND SW OUT (RUN) LINES SYSTEM LT GRN/TAN WIRE MODULE (LEFT SIDE OF ENGINE COMPT) OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE ORG/VIO WIRE PANEL LAMPS DRV PARK BRAKE PARKING BRAKE SWITCH (BEHIND LEFT SIDE OF DASH) PASS DR AJAR PASS DR AJAR SW SNS PNK/LT GRN WIRE PNK/YEL WIRE POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) POWER SLIDING DOOR LOCKOUT SNS PARK BRAKE SW SNS POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIO CONTROL MUX HORN SW SNS RADIO CONTROL MUX RTN RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) RIGHT REAR DOOR MODULE (RIGHT REAR DOORS) SENS RTN SENS SIG FUEL LVL SOUND SYSTEMS SOUND SYSTEMS HORNS SYSTEM SW SNS TOTALLY INTEGRATED POWER TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM INTERIOR LIGHTS SYSTEM UGDO ENABLE CONTROL LIN BUS VIO WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ COMPASS W/O POWER LIFTGATE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE YEL/WHT WIRE

1 6 2 8 FUSED B(+) FUSED B(+) PANEL LAMPS DRV GND 15 16 10 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) PANEL LAMPS DIMMER SIG 2 1 PANEL LAMPS DRV GND 2 4 5 PANEL LAMPS DIMMER SIG PANEL LAMPS DRV GND 3 2 PANEL LAMPS DRV GND 3 ZONE MANUAL A/C 4 3 PANEL LAMPS DRV GND 4 5 PANEL LAMPS DRV GND 7 4 PANEL LAMPS DRV GND 7 9 17 9 PANEL LAMPS DRV GND A/C HEATER CONTROL ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BANK 2 SWITCH BLK WIRE BUS - CAN INTERIOR CAN INTERIOR BUS + CENTER CONSOLE LAMP CLUSTER COMPASS COMPUTER DATA LINES SYSTEM ELECTRONICS FUSE HEADLAMP SWITCH HOT AT ALL TIMES INVERTER SWITCH MANUAL A/C AUTOMATIC A/C OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE PANEL LAMPS DRV REAR BLOWER CONTROL SWITCH RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ CENTER CONSOLE LAMP W/O CENTER CONSOLE LAMP WHT/GRY WIRE WHT/ORG WIRE

A/C HEATER CONTROL ADJUSTABLE PEDALS SWITCH ANALOG CLUSTER CLOCK MODULE ANTI-LOCK BRAKES MODULE AUTOMATIC A/C B+ FUSED B(+) BATTERY BRN/ORG WIRE CIRCUIT BREAKER DK GRN/RED WIRE DRIVER DOOR MODULE DRIVER SEAT SWITCH ELECTRONICS EXCEPT DVD EXCEPT MEMORY EXCEPT PREMIUM AUDIO FUSE FUSE FUSE FUSE FUSE FUSED IGN SW FUSED B(+) IOD SENSE HEADLAMP WASHER RELAY LEFT REAR DOOR MODULE LEFT SIDE POWER SLIDING DOOR MODULE MANUAL A/C MEMORY MEMORY SEAT MODULE MONITOR/ DVD MEDIA LEFT HANDS SYSTEM VANITY FREE LAMP MODULE ORG RED/ WIRE PASSENGER DOOR MODULE PASSENGER SEAT SWITCH PNK/ YEL WIRE PNK/WHT WIRE POWER LIFTGATE MODULE POWER STARTER REAR FOLDING SEAT MODULE POWERTRAIN CONTROL MODULE PREMIUM AUDIO RADIO RADIO, AMPLIFIER RED ORG/ WIRE RED WIRE RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RIGHT POWER SLIDING DOOR MODULE RIGHT REAR DOOR MODULE SATELLITE VIDEO MODULE SCREEN SCREEN SCREEN (INSTRUMENT PANEL HARNESS) STEERING CONTROL MODULE TAN/RED WIRE TO SPLICE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) FUSE VIDEO SCREEN 2 MODULE W/ ANTI- THEFT WHT/RED WIRE YEL/RED WIRE

1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RH SLIDING DR AJAR SW SNS GND 1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RR DR LCK SNS RH PWR SLIDING DR MUX RTN 1 2 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 1 2 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV 1 4 LH SLIDING DR PILLAR SW MUX SW RTN 1 4 RH SLIDING DR PILLAR SW MUX SW RTN 2 1 RH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 7 3 16 RH PWR SLIDING DR MUX RTN RH DR IN/OUT HANDLE SW SNS RH DR SECTOR SW SNS 7 4 PASS SW RTN PASS DR LCK SW MUX 7 6 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV B(+) BASE BASE EXCEPT BASE BLK WIRE BRAKE FLUID LEVEL SENSOR (BRAKE FLUID RESERVOIR) BRAKE LP SW BRAKE SIG 1 BRN/YEL WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH DRV DR LCK SW MUX DRV DR LCK SW MUX LIN BUS ELECTRONICS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) HOT AT ALL TIMES IGN SW, RUN/ START LEFT B-PILLAR SWITCH (LEFT "B" PILLAR) LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT FRONT OF ENGINE COMPT) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT REAR WHEELWELL) LF TURN SIG CTRL LH SLIDING DR LIN BUS LR TURN SIG CTRL LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE MONITOR LAN OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/DK GRN WIRE ORG/GRY WIRE ORG/YEL WIRE PASS DR LCK SW MUX PASS SW RTN PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/ DOOR LOCK SWITCH PILLAR SW MUX PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED/ORG WIRE RF TURN SIG CTRL RH SLIDING DR RIGHT B-PILLAR SWITCH (RIGHT "B" PILLAR) RIGHT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH (W/O POWER SLIDING DOOR) RIGHT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (RIGHT REAR DOORS) RIGHT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) RR SLIDING DR AJ SW RR TURN SIG CTRL SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) SOL UNLOCK TRS PRK SIG STOP LAMP SWITCH (AT TOP OF BRAKE PEDAL) SW RTN SW RTN PASS DR LCK SW MUX TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/DK GRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/DK BLU WIRE

1 2 CAN BUS(-) CAN BUS(+) 1 4 5 6 2 GND FUSED B (+) FUSED B (+) REAR VENT WIND CLOSE REAR VENT WIND OPEN 14 12 1 8 RF MASTER WIND SW (DN) RF MASTER WIND SW (UP) FUSED B(+) FUSED B(+) 4 3 9 6 DOOR LOCK SW MUX DOOR LOCK SW MUX FUSED B(+) DRIVER FRONT DOOR LIN B(+) BLK WIRE BREAKOUT) DOOR LOCKS SYSTEM CIRCUIT BREAKER 1 COMPUTER DATA LINES SYSTEM DK BLU/PNK WIRE DK GRN/RED WIRE DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRIVER FRONT DOOR LIN DRIVER RIGHT REAR WINDOW MOTOR VENT MOTOR (LEFT (RIGHT "D" PILLAR) FRONT DOOR) DRIVER WINDOW/DOOR LOCK SWITCH DRV DOOR SW LOCK SW MUX RETURN ELECTRONICS EXCEPT REAR WINDOW VENT FRONT PASSENGER WINDOW MOTOR (FRONT PASSENGER'S DOOR) FUSE HOT AT ALL TIMES LEFT REAR POWER WINDOW SWITCH (MEMORY W/O POWER SLIDING DOORS) LEFT REAR VENT MOTOR (LEFT "D" PILLAR) LEFT REAR WINDOW MOTOR (LEFT REAR DOOR) LT GRN/LT BLU WIRE LT GRN/TAN WIRE ORG/BRN WIRE ORG/DK BLU WIRE ORG/GRY WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/TAN WIRE ORG/VIO WIRE ORG/WHT WIRE PASSENGER WINDOW/DOOR LOCK SWITCH PNK/YEL WIRE REAR WINDOW VENT REAR WINDOW VENT SWITCH RIGHT DOOR LOCK SW MUX RIGHT REAR POWER WINDOW SWITCH (MEMORY W/O POWER SLIDING DOORS) RIGHT REAR WINDOW MOTOR (RIGHT REAR DOOR) RUN/ ACCESSORY RELAY RUN/ ACCESSORY RELAY CTRL TAN/LT BLU WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/DK GRN WIRE VIO/LT GRN WIRE WHT/GRY WIRE WHT/ORG WIRE