Volkswagen Routan I (2008-2012) electronics Wiring diagrams

1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RH SLIDING DR AJAR SW SNS GND 1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RR DR LCK SNS RH PWR SLIDING DR MUX RTN 1 2 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 1 2 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV 1 4 LH SLIDING DR PILLAR SW MUX SW RTN 1 4 RH SLIDING DR PILLAR SW MUX SW RTN 2 1 RH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 7 3 16 RH PWR SLIDING DR MUX RTN RH DR IN/OUT HANDLE SW SNS RH DR SECTOR SW SNS 7 4 PASS SW RTN PASS DR LCK SW MUX 7 6 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV B(+) BASE BASE EXCEPT BASE BLK WIRE BRAKE FLUID LEVEL SENSOR (BRAKE FLUID RESERVOIR) BRAKE LP SW BRAKE SIG 1 BRN/YEL WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH DRV DR LCK SW MUX DRV DR LCK SW MUX LIN BUS ELECTRONICS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) HOT AT ALL TIMES IGN SW, RUN/ START LEFT B-PILLAR SWITCH (LEFT "B" PILLAR) LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT FRONT OF ENGINE COMPT) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT REAR WHEELWELL) LF TURN SIG CTRL LH SLIDING DR LIN BUS LR TURN SIG CTRL LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE MONITOR LAN OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/DK GRN WIRE ORG/GRY WIRE ORG/YEL WIRE PASS DR LCK SW MUX PASS SW RTN PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/ DOOR LOCK SWITCH PILLAR SW MUX PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED/ORG WIRE RF TURN SIG CTRL RH SLIDING DR RIGHT B-PILLAR SWITCH (RIGHT "B" PILLAR) RIGHT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH (W/O POWER SLIDING DOOR) RIGHT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (RIGHT REAR DOORS) RIGHT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) RR SLIDING DR AJ SW RR TURN SIG CTRL SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) SOL UNLOCK TRS PRK SIG STOP LAMP SWITCH (AT TOP OF BRAKE PEDAL) SW RTN SW RTN PASS DR LCK SW MUX TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/DK GRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/DK BLU WIRE

1 2 BLW MTR SPLY BLW MTR CTRL SPLY 1 2 FAN SNS RTN FAN SNS A/C A/C HEATER CONTROL BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLW MTR BLW SPEED RLY MTR CTRL BLW ON IND BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE CAN (-) CAN (+) COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE ELECTRONICS FEED SNS FRONT BLOWER MOTOR POWER MODULE (HVAC UNIT) FUSE FUSE FUSE GND BLW MTR CTRL BLW MTR SPLY GND MTR CTRL BLW MTR SPLY GND SENS GND EVAP TEMP SENS SIG SUN SENS 1 SIG SUN SENS 2 SIG AUTO HDLP SIG HEADLAMP LOW WASHER HOT AT ALL TIMES HOT IN HOT AT ALL TIMES LT BLU WIRE LT BLU/BRN WIRE LT BLU/DK BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE MUX RTN ORG/GRY WIRE PANEL LAMP PNK/LT GRN WIRE PNK/YEL WIRE RADIATOR FAN LOW SPEED RELAY REAR A/C HEATER CONTROL REAR BLOWER CONTROL SWITCH REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR MODE RED WIRE RED/BRN WIRE RUN WIRE SENS BUS BUS (+) SNS SPLY TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

BLK WIRE BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE CAN (-) CAN (+) CAN C BUS (+) COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/VIO WIRE DK GRN WIRE ECT SIG ELECTRONICS ENGINE CONTROLS SYSTEM FUSE HOT AT ALL TIMES LT BLU WIRE ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIATOR FAN HIGH SPEED RELAY (LEFT OF RADIATOR) RADIATOR FAN LOW SPEED RELAY RADIATOR FAN RESISTOR (TOP RIGHT SIDE OF RADIATOR) RED/BRN WIRE SENS GND TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/ORG WIRE WASHER HI SPEED SPEED RLY BUS BUS CTRL CTRL CTRL (-) (+) WHT WIRE WHT/BLK WIRE WHT/LT BLU WIRE

2 19 8 16 6 5 CAN INT BUS (+) CAN INT BUS (-) A/C HEATER CONTROL AUTOMATIC A/C MANUAL A/C BLK WIRE CAN INT BUS (-) (+) COMPUTER DATA LINES SYSTEM DEFOGGER RELAY CONTROL DK BLU WIRE DRIVER OUTSIDE REARVIEW MIRROR (DRIVER DOOR MIRROR) ELECTRIC HEATED BACKLITE ELECTRONICS FUSE GRY WIRE HOT AT ALL TIMES ORG/ WIRE PASSENGER OUTSIDE REARVIEW MIRROR (PASSENGER DOOR MIRROR) PNK WIRE REAR WINDOW DEFOGGER RELAY REAR WINDOW DEFOGGER SW TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ 3-ZONE MANUAL A/C WHT WIRE WHT/GRY WIRE WHT/ORG WIRE YEL WIRE

3.3L/ 3.8L 4.0L 3.8L 3.3L/ 4.0L 3.3L/ 4.0L 3.8L A/C COMPRESSOR CLUTCH ANTI-LOCK BRAKES MODULE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE DODGE DOOR LOCK RELAY DOOR UNLOCK 1 RELAY DOOR UNLOCK 2 RELAY EARLY PRODUCTION EGR VALVE ASSEMBLY ELECTRONICS EXCEPT DODGE DODGE FRONT WASHER PUMP RELAY HEADLAMP RADIATOR WASHER FAN MOTOR MOTOR HORN 1 LATE PRODUCTION LEFT FRONT ASSEMBLY LAMP LEFT FRONT FOG LAMP LEFT FRONT TIRE PRESSURE TRANSPONDER LEFT SIDE REPEATER LAMP OCCUPANT RESTRAINT CONTROLLER MODULE OXYGEN SENSOR 1/1 OXYGEN SENSOR 1/2 OXYGEN SENSOR 2/1 OXYGEN SENSOR 2/2 POWERTRAIN CONTROL MODULE RADIATOR COOLING FAN MODULE REAR WIPER RELAY RIGHT FRONT ASSEMBLY LAMP RIGHT FRONT FOG LAMP RIGHT FRONT TIRE PRESSURE TRANSPONDER RIGHT SIDE REPEATER HORN 2 LAMP THROTTLE VALVE SOLENOID

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 EVAP TEMP SENS SIG 1 2 3 4 5 DRV BLOWER MTR HI A/C A/C HEATER CONTROL AUTO HDLP SIG BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLU/ BRN WIRE BLW MTR BLW RLY MTR SPEED SPLY CTRL BLW ON IND BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BUS BUS SENS (+) (-) CAN (-) CAN (+) COMMON COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/ ORG WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRV DR ELECTRONICS FEED SNS FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY) FRT BLOWER LOW SPD GND FUSE FUSE FUSE HDLP SIG HEADLAMP WASHER LOW HI CLUTCH CLUTCH SPEED RLY RLY TRANS CTRL CTRL CTRL CTRL OUT SIG SPLY GND HOT AT ALL TIMES HOT IN HOT AT ALL TIMES INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM LT BLU WIRE LT BLU/BRN WIRE LT BLU/DK BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE MUX RTN ORG/GRY WIRE PANEL LAMP PNK/YEL WIRE RADIATOR FAN LOW SPEED RELAY REAR A/C HEATER CONTROL REAR BLOWER HI REAR BLOWER LO REAR BLOWER MEDIUM REAR BLOWER MODE SNS REAR A/C TEMP CTRL SIG HVAC MUX RTN REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR BLOWER MOTOR RESISTOR REAR MODE RED WIRE RED/BRN WIRE RUN WIRE SNS SPLY TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/LT BLU WIRE VIO/TAN WIRE VIO/WHT WIRE W/ SUNROOF W/O SUNROOF WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

1 2 3 4 5 GND FRT BLOWER LOW SPD A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (4.0L: FRONT OF A/C COMPRESSOR) (3.3L, 3.8L: LEFT A/C HEATER CONTROL BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BRN/LT BLU WIRE BRN/ORG WIRE BUS SENS BUS (-) GND (+) CAN (-) CAN (+) CAN C BUS (+) CLUTCH A/C TRANS SPEED RLY CLUTCH CTRL CTRL OUT CTRL SIG SPLY COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) DRV BLOWER MTR HI DRV DR RECIRCULATION DRV DR MODE DRV DR BLEND DRV DR COMMON 2 ECT SIG ELECTRONICS ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FAN CTRL FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY) FUSE HEADLAMP LOW BLW WASHER SPEED MTR RLY CTRL SPLY HOT AT ALL TIMES HOT IN LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIATOR COOLING FAN MODULE (BEHIND RADIATOR COOLING FAN) RADIATOR FAN HIGH SPEED RELAY (LEFT OF RADIATOR) RADIATOR FAN LOW SPEED RELAY RADIATOR FAN RESISTOR (TOP RIGHT SIDE OF RADIATOR) RED WIRE RED/BRN WIRE RLY OUT RUN WIRE SENS GND TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/ORG WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM ELECTRONICS EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE FUSED IGN SW OUT (RUN- SENS START) RTN SIG HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LINE PRESSURE SENSOR/ VARIABLE FORCE SOLENOID ASSEMBLY LP VFS CTRL LT BLU/DK GRN WIRE LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) PRESS SENS SIG S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND STARTING/ CHARGING SYSTEM TAN WIRE TEMP SENS SIG TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION RANGE SENSOR TRANSMISSION SOLENOID/PRESSURE SWITCH ASSEMBLY UP CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE WHT/DK GRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DC CTRL DC PRESS SIG DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOOR LOCKS SYSTEM ELECTRONICS EMC SOLENOID CTRL EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LC CTRL LC PRESS SIG LC PRESS SIG OD PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND SENS RTN SIG STARTING/ CHARGING SYSTEM TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE

1 2 3 4 GND SENS RTN FUEL LEVEL SENS SIG FUEL PUMP CTRL OUT 1 2 GND ESM SIG 2/4 CTRL 2/4 PRESS SIG B(+) BLK WIRE BLK/LT GRN WIRE BLK/RED WIRE BRN WIRE CRUISE CONTROL SYSTEM DC CTRL DC PRESS SIG DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/GRY WIRE DK GRN/LT BLU WIRE DK GRN/LT GRN WIRE DK GRN/ORG WIRE DK GRN/PNK WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE DOOR LOCKS SYSTEM ELECTRONICS EMC SOLENOID CTRL EVAP SYSTEM MONITOR SWITCH (UNDER LEFT REAR OF VEHICLE) FUEL LEVEL SENS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUEL PUMP RELAY FUSE HOT AT ALL TIMES HOT W/ RUN/START RELAY ENERGIZED L/R CTRL L/R CTRL LP VFS CTRL GND GND GND L/R PRESS SIG LC CTRL LC PRESS SIG LC PRESS SIG OD PRESS SIG LINE PRESS SENS SIG LP VFS CTRL LT GRN PNK/ WIRE LT GRN/TAN WIRE O/D CTRL OD PRESS SIG PCM RELAY PNK/LT GRN WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) S/C SIG 1 ESM SIG APP SIG 2 FUEL PUMP CTRL STARTER RELAY CTRL SENS GND SENS SIG RTN STARTING/ CHARGING SYSTEM TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRAN CTRL OUT TRAN CTRL TRAN CTRL OUT TRAN TEMP SENS SIG TRANSFER SPEED SENSOR (RIGHT REAR OF TRANSAXLE) TRANSFER SPEED SIG TRANSMISSION SOLENOID/ TRS ASSEMBLY (LEFT SIDE OF TRANSMISSION) UD CTRL VIO WIRE VIO/WHT WIRE WHT/BRN WIRE YEL/BRN WIRE YEL/DK BLU WIRE YEL/DK GRN WIRE YEL/GRY WIRE YEL/LT BLU WIRE YEL/ORG WIRE YEL/PNK WIRE YEL/TAN WIRE