Volkswagen Routan I (2008-2012) driver blend door actuator (hvac unit) Wiring diagrams
This page contains all the electrical diagrams for the component. driver blend door actuator (hvac unit), in which he is found in the car Volkswagen Routan I (2008-2012). You can view various wiring diagrams where this component is used, as well as go to more detailed diagrams to see the complete connection and interaction in the system. All diagrams have links to quickly jump to the corresponding section with the component for easy viewing..
driver blend door actuator (hvac unit) wiring diagram (1 of 3)
BLK WIRE
BLK/LT BLU WIRE
BREAKOUT)
BRN/LT BLU WIRE
BRN/ORG WIRE
CAN C A/C CAN C BUS BUS CLUTCH SENS (-) CTRL (+) SIG GND
COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN
DK BLU/BRN WIRE
DK BLU/DK GRN WIRE
DK BLU/LT BLU WIRE
DK BLU/LT GRN WIRE
DK BLU/VIO WIRE
DK BLU/YEL WIRE
DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
ECT
ENGINE CONTROLS SYSTEM
EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC)
FAN CTRL CTRL OUT
HDLP SIG
INFRARED SENSOR (CENTER FRONT OF ROOF)
LT BLU/BRN WIRE
LT BLU/ORG WIRE
LT BLU/PNK WIRE
LT BLU/YEL WIRE
LT GRN WIRE
OCCUPANT RESTRAINT CONTROLLER MODULE
PNK/LT GRN WIRE
REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT)
REAR MODE DOOR ACTUATOR 3 (HVAC UNIT)
RED/BRN WIRE
RLY GND OUT
SENS GND
SENS SIG
SENS SIG 1
SENS SIG 2
SUN SENSOR
VIO/LT BLU WIRE
VIO/ORG WIRE
WHT/BLK WIRE
WHT/LT BLU WIRE
WHT/VIO WIRE
Go to component -> Automatic a/c circuit (2 of 2) -> DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
driver blend door actuator (hvac unit) wiring diagram (2 of 3)
A/C
BLK WIRE
BLK/LT BLU WIRE
BRN/LT BLU WIRE
BRN/ORG WIRE
CAN C CAN C CLUTCH BUS BUS SENS ECT CTRL (-) (+) GND SIG
COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN
CTRL FAN OUT CTRL
DK BLU/BRN WIRE
DK BLU/DK GRN WIRE
DK BLU/LT BLU WIRE
DK BLU/LT GRN WIRE
DK BLU/RED WIRE
DK BLU/TAN WIRE
DK BLU/VIO WIRE
DK BLU/YEL WIRE
DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
ENGINE CONTROLS SYSTEM
EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC)
LT BLU/BRN WIRE
LT BLU/ORG WIRE
LT BLU/PNK WIRE
LT BLU/YEL WIRE
LT GRN WIRE
REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT)
REAR MODE DOOR ACTUATOR 3 (HVAC UNIT)
RECIRCULATION DOOR ACTUATOR (RIGHT SIDE OF HVAC ASSEMBLY)
RED/BRN WIRE
RLY OUT GND
VIO/ORG WIRE
WHT/BLK WIRE
WHT/LT BLU WIRE
Go to component -> Manual a/c circuit, with 3 zone (2 of 2) -> DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
driver blend door actuator (hvac unit) wiring diagram (3 of 3)
1 2 3 4 5 GND FRT BLOWER LOW SPD
A/C CLUTCH CTRL
A/C COMPRESSOR CLUTCH (4.0L: FRONT OF A/C COMPRESSOR) (3.3L, 3.8L: LEFT
A/C HEATER CONTROL
BLK WIRE
BLK/LT BLU WIRE
BLOWER MOTOR (UNDER RIGHT SIDE OF DASH)
BRN/LT BLU WIRE
BRN/ORG WIRE
BUS SENS BUS (-) GND (+)
CAN (-) CAN (+)
CAN C BUS (+)
CLUTCH A/C TRANS SPEED RLY CLUTCH CTRL CTRL OUT CTRL SIG SPLY
COMPUTER DATA LINES SYSTEM
CTRL OUT
DK BLU WIRE
DK BLU/BRN WIRE
DK BLU/DK GRN WIRE
DK BLU/GRY WIRE
DK BLU/LT GRN WIRE
DK BLU/ORG WIRE
DK BLU/RED WIRE
DK BLU/TAN WIRE
DK BLU/VIO WIRE
DK BLU/YEL WIRE
DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
DRV BLOWER MTR HI
DRV DR RECIRCULATION DRV DR MODE DRV DR BLEND DRV DR COMMON 2
ECT SIG
ELECTRONICS
ENGINE CONTROLS SYSTEM
EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC)
EXCEPT BASE
FAN CTRL
FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY)
FUSE
HEADLAMP LOW BLW WASHER SPEED MTR RLY CTRL SPLY
HOT AT ALL TIMES
HOT IN
LT BLU/BRN WIRE
LT BLU/ORG WIRE
LT GRN WIRE
PNK/YEL WIRE
POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT)
RADIATOR COOLING FAN MODULE (BEHIND RADIATOR COOLING FAN)
RADIATOR FAN HIGH SPEED RELAY (LEFT OF RADIATOR)
RADIATOR FAN LOW SPEED RELAY
RADIATOR FAN RESISTOR (TOP RIGHT SIDE OF RADIATOR)
RED WIRE
RED/BRN WIRE
RLY OUT
RUN WIRE
SENS GND
TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT)
VIO/ORG WIRE
WHT/BLK WIRE
WHT/GRY WIRE
WHT/LT BLU WIRE
WHT/ORG WIRE
Go to component -> Manual a/c circuit, without 3 zone -> DRIVER BLEND DOOR ACTUATOR (HVAC UNIT)
