Volkswagen Routan I (2008-2012) breakout) Wiring diagrams

BLK WIRE BLK/LT BLU WIRE BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE CAN C A/C CAN C BUS BUS CLUTCH SENS (-) CTRL (+) SIG GND COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) ECT ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) FAN CTRL CTRL OUT HDLP SIG INFRARED SENSOR (CENTER FRONT OF ROOF) LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN WIRE OCCUPANT RESTRAINT CONTROLLER MODULE PNK/LT GRN WIRE REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) REAR MODE DOOR ACTUATOR 3 (HVAC UNIT) RED/BRN WIRE RLY GND OUT SENS GND SENS SIG SENS SIG 1 SENS SIG 2 SUN SENSOR VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/VIO WIRE

13 2 CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) 14 4 CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) 19 16 15 LIN BUS CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) 3 ZONE SUNROOF, EXCEPT 3 ZONE 34 35 CAN C BUS (+) CAN C BUS (-) 6 5 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 8 16 2 19 CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) 9 1 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) A/C HEATER CONTROL ALL POWER WINDOWS ANTI-LOCK BRAKES MODULE (LEFT FRONT OF ENGINE COMPT) AUTOMATIC A/C MANUAL A/C W/ 3 ZONE MANUAL A/C B(+) BLK WIRE BREAKOUT) BUS (+) CAN INTERIOR CAN C (-) DIAGNOSTIC CAN C BUS (+) CAN INTERIOR BUS + CLUSTER COMPASS MODULE (BEHIND LEFT SIDE OF DASH) DATA LINK CONNECTOR (BELOW LEFT SIDE OF DASH) DUAL 3 ZONE DVD EXCEPT SUNROOF EXCEPT EXPRESS EXPRESS FRONT POWER WINDOWS GRY WIRE HANDS FREE HANDS FREE MODULE (IF EQUIPPED) (BEHIND LEFT END OF DASH) HEATED SEATS MODULE (UNDER DRIVER'S SEAT) HOT AT ALL TIMES IGNITION WIRELESS NODE (BEHIND LEFT SIDE OF DASH) LIN BUS MONITOR/DVD MEDIA SYSTEM OCCUPANT RESTRAINT CONTROLLER MODULE (UNDER CENTER OF DASH) ORG/ WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIO ROW DVD SATELLITE VIDEO MODULE (3 ZONE AUTOMATIC A/C) SINGLE DVD STEERING ANGLE SENSOR (W/ ESP) (STEERING COLUMN) STEERING CONTROL MODULE (BEHIND LEFT SIDE OF DASH) TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) ELECTRONICS VIDEO SCREEN 1 MODULE VIDEO SCREEN 2 MODULE W/ HANDS FREE W/O W/O DVD W/O HANDS FREE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 10 FUSED B(+) PANEL LAMPS DRIVER 12 11 1 RH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 2 1 GND LIFTGATE AJAR SW SNS 21 17 18 LIFTGATE AJAR SW SNS CAN INT BUS - CAN INT BUS + 3 4 ESP ON/OFF SNS GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BLK WIRE BLK/ORG WIRE BREAKOUT) BUS (-) CAN C BUS - CAN C BUS (+) CAN INTERIOR CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM COURTESY LAMPS DRIVER DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR DRV DR AJAR SW SNS ELECTRONICS EOP SIG ESP ON/OFF SNS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) FUSED IGN SW OUT (RUN-START) FUSED B(+) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HEADLAMP SW MUX PANEL LAMPS DIMMER SIG HEADLAMP SW MUX RTN HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED HOT W/ RUN/ START RELAY ENERGIZED INTERIOR LAMPS DRIVER HEADLAMP SW SIG INTERIOR LIGHTS SYSTEM COMPUTER DATA INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 12 11 1 LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) LIN BUS GND SW OUT (RUN) LINES SYSTEM LT GRN/TAN WIRE MODULE (LEFT SIDE OF ENGINE COMPT) OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE ORG/VIO WIRE PANEL LAMPS DRV PARK BRAKE PARKING BRAKE SWITCH (BEHIND LEFT SIDE OF DASH) PASS DR AJAR PASS DR AJAR SW SNS PNK/LT GRN WIRE PNK/YEL WIRE POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) POWER SLIDING DOOR LOCKOUT SNS PARK BRAKE SW SNS POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIO CONTROL MUX HORN SW SNS RADIO CONTROL MUX RTN RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) RIGHT REAR DOOR MODULE (RIGHT REAR DOORS) SENS RTN SENS SIG FUEL LVL SOUND SYSTEMS SOUND SYSTEMS HORNS SYSTEM SW SNS TOTALLY INTEGRATED POWER TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM INTERIOR LIGHTS SYSTEM UGDO ENABLE CONTROL LIN BUS VIO WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ COMPASS W/O POWER LIFTGATE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE YEL/WHT WIRE

5 VOLT SPLY BLK WIRE BREAKOUT) BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE EGR CTRL EGR SIG ETC MTR IGNITION CAPACITOR (RIGHT REAR OF ENGINE) INTAKE AIR TEMPERATURE SENSOR (THROTTLE BODY) PNK/ YEL WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE SENS GND THROTTLE BODY (RIGHT FRONT OF ENGINE) TP SENS GND TP SIG 1 TP SIG 2 VIO/BRN WIRE YEL/PNK WIRE