Volkswagen Routan I (2008-2012) blk/lt blu Wiring diagrams

1 2 BLW MTR SPLY BLW MTR CTRL SPLY 1 2 FAN SNS RTN FAN SNS A/C A/C HEATER CONTROL BLK WIRE BLK/LT BLU WIRE BLK/ORG WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLW MTR BLW SPEED RLY MTR CTRL BLW ON IND BRN WIRE BRN/LT BLU WIRE BRN/ORG WIRE CAN (-) CAN (+) COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE ELECTRONICS FEED SNS FRONT BLOWER MOTOR POWER MODULE (HVAC UNIT) FUSE FUSE FUSE GND BLW MTR CTRL BLW MTR SPLY GND MTR CTRL BLW MTR SPLY GND SENS GND EVAP TEMP SENS SIG SUN SENS 1 SIG SUN SENS 2 SIG AUTO HDLP SIG HEADLAMP LOW WASHER HOT AT ALL TIMES HOT IN HOT AT ALL TIMES LT BLU WIRE LT BLU/BRN WIRE LT BLU/DK BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE MUX RTN ORG/GRY WIRE PANEL LAMP PNK/LT GRN WIRE PNK/YEL WIRE RADIATOR FAN LOW SPEED RELAY REAR A/C HEATER CONTROL REAR BLOWER CONTROL SWITCH REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR MODE RED WIRE RED/BRN WIRE RUN WIRE SENS BUS BUS (+) SNS SPLY TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

BLK WIRE BLK/LT BLU WIRE BREAKOUT) BRN/LT BLU WIRE BRN/ORG WIRE CAN C A/C CAN C BUS BUS CLUTCH SENS (-) CTRL (+) SIG GND COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) ECT ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) FAN CTRL CTRL OUT HDLP SIG INFRARED SENSOR (CENTER FRONT OF ROOF) LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN WIRE OCCUPANT RESTRAINT CONTROLLER MODULE PNK/LT GRN WIRE REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) REAR MODE DOOR ACTUATOR 3 (HVAC UNIT) RED/BRN WIRE RLY GND OUT SENS GND SENS SIG SENS SIG 1 SENS SIG 2 SUN SENSOR VIO/LT BLU WIRE VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE WHT/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 WASHER FLUID LVL SW SENSE 1 2 3 4 5 6 7 8 9 10 11 12 13 FUSED B (+) A/C CLUTCH CTRL A/C PRESS TRANSDUCER SIGNAL AIR CONDITIONING SYSTEM ASD RLY CTRL B(+) BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE BLK/ORG WIRE BRN WIRE BRN/DK BLU WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/WHT WIRE BRN/YEL WIRE CAN C BUS (-) CAN C BUS (+) A/C PRESSURE SENSOR GROUND COMPUTER DATA LINES SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM COOLING FANS SYSTEM HEADLIGHTS SYSTEM DEFOGGER SYSTEM DK BLU/DK GRN WIRE DK BLU/ORG WIRE DK BLU/YEL WIRE DK GRN/ORG WIRE DK GRN/RED WIRE DOOR LOCKS SYSTEM DOOR LOCKS SYSTEM ENGINE CONTROLS SYSTEM HEADLIGHTS SYSTEM ENGINE CONTROLS SYSTEM ENGINE CONTROLS SYSTEM AIR CONDITIONING SYSTEM EXTERIOR LIGHTS SYSTEM ANTI-LOCK BRAKES SYSTEM DOOR LOCKS SYSTEM EXTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM FRONT FOG LAMP RLY FUEL PUMP CTRL FUSED ASD OUTPUT FUSED B (+) FUSED B (+) REAR BLOWER MTR CTRL REAR WIPER MOTOR CONTROL GROUND FUSED IGN SW OUT (RUN-START) FUSED IGN SW OUTPUT FUSED IGN SW OUTPUT A/C CLUTCH OUTPUT GROUND GRY/LT BLU WIRE GRY/YEL WIRE HEADLAMP RETURN SIGNAL HEADLIGHTS SYSTEM HOOD AJAR SWITCH SENSE HORN CTRL OUTPUT FRONT WASHER PUMP MTR CTRL HORNS SYSTEM WIPER/WASHER SYSTEM IGN SW OUT (RUN-START) PASS DOOR UNLOCK DRIVER FUSED B (+) LF TURN SIGNAL CTRL LT BLU WIRE LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN/LT BLU WIRE PNK/GRY WIRE PNK/LT GRN WIRE PNK/WHT WIRE PNK/YEL WIRE POWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM AIR CONDITIONING SYSTEM WIPER/WASHER SYSTEM POWER DISTRIBUTION SYSTEM DOOR LOCKS SYSTEM POWER WINDOWS SYSTEM RAD FAN LO SPD CTRL RED WIRE RED/BRN WIRE RF TURN SIGNAL CONTROL SENSOR GROUND AAT SIGNAL FRONT FOG LAMP RLY OUTPUT STARTER RLY CTRL STARTER RLY OUTPUT FUSED B (+) STARTING/CHARGING SYSTEM STARTING/CHARGING SYSTEM ENGINE CONTROLS SYSTEM TAN/BRN WIRE TAN/RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) TRANSMISSION CTRL A/C PRESSURE 5 VOLT SPLY TRANSMISSION CTRL OUTPUT TRANSMISSIONS SYSTEM TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM VIO/BRN WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM WIPER/WASHER SYSTEM YEL/BRN WIRE YEL/GRY WIRE YEL/ORG WIRE YEL/RED WIRE

3.3L/ 3.8L 4.0L 3.8L 3.3L/ 4.0L 3.3L/ 4.0L 3.8L A/C COMPRESSOR CLUTCH ANTI-LOCK BRAKES MODULE BATTERY BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE DODGE DOOR LOCK RELAY DOOR UNLOCK 1 RELAY DOOR UNLOCK 2 RELAY EARLY PRODUCTION EGR VALVE ASSEMBLY ELECTRONICS EXCEPT DODGE DODGE FRONT WASHER PUMP RELAY HEADLAMP RADIATOR WASHER FAN MOTOR MOTOR HORN 1 LATE PRODUCTION LEFT FRONT ASSEMBLY LAMP LEFT FRONT FOG LAMP LEFT FRONT TIRE PRESSURE TRANSPONDER LEFT SIDE REPEATER LAMP OCCUPANT RESTRAINT CONTROLLER MODULE OXYGEN SENSOR 1/1 OXYGEN SENSOR 1/2 OXYGEN SENSOR 2/1 OXYGEN SENSOR 2/2 POWERTRAIN CONTROL MODULE RADIATOR COOLING FAN MODULE REAR WIPER RELAY RIGHT FRONT ASSEMBLY LAMP RIGHT FRONT FOG LAMP RIGHT FRONT TIRE PRESSURE TRANSPONDER RIGHT SIDE REPEATER HORN 2 LAMP THROTTLE VALVE SOLENOID

A/C HEATER CONTROL AIR CONDITIONING SYSTEM AUTO HEADLAMPS SIG AUTOMATIC A/C B(+) BLK WIRE BLK/LT BLU WIRE BLK/LT GRN WIRE CAN INTERIOR BUS + CAN-BUS CHRYSLER CHRYSLER W/ HID CHRYSLER W/O HID DODGE CLUSTER COMPUTER DATA LINES SYSTEM DK BLU/DK GRN WIRE DK GRN/WHT WIRE DRV/ SENS GND ELECTRONICS EVIC FRONT COMMON DR DRV/ SENS GND FRONT FOG LAMP RLY OUT FUSE FUSED B (+) GROUND HEADLAMP RTN SIG HEADLAMP SW MUX HEADLAMP SW MUX RTN HEADLAMP SW SIG HEADLAMP SWITCH HIGH BEAM OUT HIGH HDLP BEAM DRV RTN SIG OUT HIGH LOW BEAM HDLP BEAM DRV OUT RTN SIG HOT AT ALL TIMES LEFT CAN LOW INTERIOR BEAM BUS (+) LEFT FRONT ASSEMBLY LAMP LEFT FRONT FOG LAMP LEFT LOW BEAM DRV MANUAL A/C AUTOMATIC A/C ORG/BRN WIRE ORG/GRY WIRE PANEL LAMPS DIM SIG PANEL LAMPS DRV PARK BRK SW SNS PARKING BRAKE SWITCH (BEHIND LEFT RED WIRE RIGHT RIGHT FRONT ASSEMBLY LAMP RIGHT FRONT FOG LAMP RIGHT LOW BEAM DRV SIDE OF DASH) SIG SUN SENSOR TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/TAN WIRE WHT/BRN WIRE WHT/DK BLU WIRE WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/VIO WIRE WHT/YEL WIRE YEL/WHT WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 EVAP TEMP SENS SIG 1 2 3 4 5 DRV BLOWER MTR HI A/C A/C HEATER CONTROL AUTO HDLP SIG BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BLU/ BRN WIRE BLW MTR BLW RLY MTR SPEED SPLY CTRL BLW ON IND BRN/LT BLU WIRE BRN/ORG WIRE BRN/WHT WIRE BUS BUS SENS (+) (-) CAN (-) CAN (+) COMMON COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/ ORG WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRV DR ELECTRONICS FEED SNS FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY) FRT BLOWER LOW SPD GND FUSE FUSE FUSE HDLP SIG HEADLAMP WASHER LOW HI CLUTCH CLUTCH SPEED RLY RLY TRANS CTRL CTRL CTRL CTRL OUT SIG SPLY GND HOT AT ALL TIMES HOT IN HOT AT ALL TIMES INTERIOR LIGHTS SYSTEM COMPUTER DATA LINES SYSTEM LT BLU WIRE LT BLU/BRN WIRE LT BLU/DK BLU WIRE LT BLU/ORG WIRE LT BLU/YEL WIRE LT GRN WIRE MUX RTN ORG/GRY WIRE PANEL LAMP PNK/YEL WIRE RADIATOR FAN LOW SPEED RELAY REAR A/C HEATER CONTROL REAR BLOWER HI REAR BLOWER LO REAR BLOWER MEDIUM REAR BLOWER MODE SNS REAR A/C TEMP CTRL SIG HVAC MUX RTN REAR BLOWER MOTOR REAR BLOWER MOTOR RELAY REAR BLOWER MOTOR RESISTOR REAR MODE RED WIRE RED/BRN WIRE RUN WIRE SNS SPLY TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/LT BLU WIRE VIO/TAN WIRE VIO/WHT WIRE W/ SUNROOF W/O SUNROOF WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/VIO WIRE YEL WIRE

A/C BLK WIRE BLK/LT BLU WIRE BRN/LT BLU WIRE BRN/ORG WIRE CAN C CAN C CLUTCH BUS BUS SENS ECT CTRL (-) (+) GND SIG COMPUTER (4.0L) DATA LINES SYSTEM (3.3L, 3.8L) (4.0L: NEAR POWERTRAIN CTRL FAN OUT CTRL DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) LT BLU/BRN WIRE LT BLU/ORG WIRE LT BLU/PNK WIRE LT BLU/YEL WIRE LT GRN WIRE REAR BLEND DOOR ACTUATOR (LEFT SIDE OF HVAC UNIT) REAR MODE DOOR ACTUATOR 3 (HVAC UNIT) RECIRCULATION DOOR ACTUATOR (RIGHT SIDE OF HVAC ASSEMBLY) RED/BRN WIRE RLY OUT GND VIO/ORG WIRE WHT/BLK WIRE WHT/LT BLU WIRE

1 2 3 4 5 GND FRT BLOWER LOW SPD A/C CLUTCH CTRL A/C COMPRESSOR CLUTCH (4.0L: FRONT OF A/C COMPRESSOR) (3.3L, 3.8L: LEFT A/C HEATER CONTROL BLK WIRE BLK/LT BLU WIRE BLOWER MOTOR (UNDER RIGHT SIDE OF DASH) BRN/LT BLU WIRE BRN/ORG WIRE BUS SENS BUS (-) GND (+) CAN (-) CAN (+) CAN C BUS (+) CLUTCH A/C TRANS SPEED RLY CLUTCH CTRL CTRL OUT CTRL SIG SPLY COMPUTER DATA LINES SYSTEM CTRL OUT DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/VIO WIRE DK BLU/YEL WIRE DRIVER BLEND DOOR ACTUATOR (HVAC UNIT) DRV BLOWER MTR HI DRV DR RECIRCULATION DRV DR MODE DRV DR BLEND DRV DR COMMON 2 ECT SIG ELECTRONICS ENGINE CONTROLS SYSTEM EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC) EXCEPT BASE FAN CTRL FRONT BLOWER MOTOR RESISTOR (RIGHT SIDE OF HVAC ASSEMBLY) FUSE HEADLAMP LOW BLW WASHER SPEED MTR RLY CTRL SPLY HOT AT ALL TIMES HOT IN LT BLU/BRN WIRE LT BLU/ORG WIRE LT GRN WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIATOR COOLING FAN MODULE (BEHIND RADIATOR COOLING FAN) RADIATOR FAN HIGH SPEED RELAY (LEFT OF RADIATOR) RADIATOR FAN LOW SPEED RELAY RADIATOR FAN RESISTOR (TOP RIGHT SIDE OF RADIATOR) RED WIRE RED/BRN WIRE RLY OUT RUN WIRE SENS GND TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/ORG WIRE WHT/BLK WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE