2.4l, manual a/c circuit for Toyota Highlander I facelift (2003-2007)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 ILL- ILL- GND SG TEST 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 SG MPX+ 4 5 6 1 HI A/C CONTROL ASSEMBLY (BEHIND CENTER OF DASH) AIR BAG SENSOR ASSEMBLY (BELOW FRONT OF CENTER CONSOLE) AIR INLET CONTROL SERVO MOTOR (BEHIND UPPER CENTER OF DASH) AIR MIX CONTROL SERVO MOTOR (BEHIND CENTER OF DASH) AIR VENT MODE CONTROL SERVO MOTOR (BEHIND LEFT CENTER OF DASH) BLK WIRE BLK/YEL WIRE BLOWER CONTROL SWITCH BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER RESISTOR (BEHIND RIGHT SIDE OF DASH) BLU WIRE BRN WIRE CENTER J/B (BEHIND UPPER CENTER OF DASH) CONTROL PANEL DIM ILL+ INTERIOR LIGHTS SYSTEM ECU-B FUSE ENGINE ROOM J/B (ON LEFT SIDE OF ENGINE COMPARTMENT) EVAPORATOR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF DASH) FUSIBLE LINK BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) GND B+ GRN WIRE GRN/YEL WIRE GRY WIRE HEATER FUSE HEATER RELAY (RIGHT OF INSTRUMENT PANEL J/B) HOT AT ALL TIMES HOT IN ON OR ACC HOT IN ON OR START IA (AT LEFT KICK PANEL) IB (AT RIGHT DASH BRACE) IC (AT RIGHT KICK PANEL) ILL+ ILL+ IG INSTRUMENT PANEL J/B (BEHIND LEFT SIDE OF DASH) INSTRUMENT PANEL J/B (BEHIND LEFT SIDE OF DASH) HEATER FUSE INTERIOR LIGHTS SYSTEM ILL + JUNCTION CONNECTOR 5 (LEFT SIDE OF DASH, BEHIND INSTRUMENT CLUSTER) LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE MPX MR/F AIR AIF HR ORG/ WIRE PASSENGER SIDE J/B (BEHIND RIGHT SIDE OF DASH) PNK SG-1 AMC AMH WIRE PNK/BLU WIRE RADIO 2 FUSE RED WIRE SHORT CONNECTOR (BEHIND LEFT SIDE OF DASH) STX CLK DPD SWD TE TPO AOD AOF SS-4 TP TELLTALE LIGHT ASSEMBLY VIO WIRE W/ NAVIGATION GATEWAY ECU (BEHIND RIGHT SIDE OF DASH) W/O NAVIGATION WHT WIRE WHT/BLK WIRE YEL WIRE YEL/GRN WIRE

A/C MAGNETIC CLUTCH, LOCK SENSOR (ON A/C COMP- RESISTOR) A/C TRIPLE PRESSURE SWITCH (ON RIGHT FRONT OF ENGINE COMPARTMENT) ACMG BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BODY ECU (BEHIND RIGHT SIDE OF DASH) BRN WIRE CDS FUSE CENTER J/B (BEHIND UPPER CENTER OF DASH) COMBINATION METER CONDENSER FAN MOTOR (BEHIND RADIATOR) DUAL EE (AT INTAKE SIDE OF CYLINDER BLOCK) ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE ROOM J/B (ON LEFT SIDE OF ENGINE COMPARTMENT) ENGINE ROOM R/B (ON LEFT SIDE OF ENGINE COMPARTMENT) FAN FAN 1 RELAY FAN 2 RELAY FAN 3 RELAY FUSIBLE LINK BLOCK (ON LEFT SIDE OF ENGINE COMPARTMENT) GRN WIRE GRN/BLK WIRE GRY WIRE HOT AT ALL TIMES J/C 2 (BEHIND LEFT HEADLIGHT) JUNCTION CONNECTOR 2 (BEHIND LEFT HEADLIGHT) JUNCTION CONNECTOR 7 (BEHIND RIGHT SIDE OF DASH) LT BLU WIRE MG CLT RELAY MPX ORG/ WIRE PASSENGER SIDE J/B (BEHIND RIGHT SIDE OF DASH) POWER WINDOW MASTER SWITCH WITH ECU (IN DRIVER'S DOOR) PRE RADIATOR FAN MOTOR (BEHIND RADIATOR) RDI FUSE RED WIRE RED/BLU WIRE RED/WHT WIRE RED/YEL WIRE SINGLE VIO WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE YEL WIRE