Automatic a/c circuit for Toyota 4Runner IV (2002-2005)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 PNK WIRE 1 2 3 4 5 6 7 8 9 10 11 12 IG +B BLW 1 2 LIMITED A/C CONTROL ASSEMBLY (BEHIND LOWER CENTER OF DASH) A/C ROOM TEMPERATURE SENSOR (BEHIND LOWER LEFT CENTER OF DASH) AIR INLET CONTROL SERVO MOTOR (BEHIND UPPER RIGHT END OF DASH, ON HVAC ASSEMBLY) AIR MIX CONTROL SERVO MOTOR AMCDR OR AMC AMCPA AMHDR OR AMH AMHPA ACS AOF AOD AIR AIF THE BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLOWER MOTOR (BEHIND LOWER RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN/BLK WIRE DMOT DMIN DOME FUSE EB (ON LEFT FRONT INNER FENDER) ECU-B FUSE ENGINE ROOM R/B (ON LEFT SIDE OF ENGINE COMPARTMENT) GND SG TWI SPD GRN WIRE GRN/YEL WIRE GRY WIRE GRY/GRN WIRE HEATER 2 FUSE HEATER FUSE HEATER RELAY HOT AT ALL TIMES HR TAM TPPA TE TPDR OR TP TSPA JUNCTION CONNECTOR 1 (ON LEFT FRONT OF ENGINE COMPARTMENT, NEAR BATTERY) JUNCTION CONNECTOR 2, 3 (ON LEFT FRONT OF ENGINE COMPARTMENT, NEAR BATTERY) JUNCTION CONNECTOR 7 (BEHIND LEFT END OF DASH) LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE OF DASH) ORG/ WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE PNK/GRN WIRE PSW RED WIRE TR TPI TPO ACLD TSDR OR TS VIO WIRE VIO/GRN WIRE VIO/RED WIRE VIO/WHT WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE

A/C AMBIENT TEMPERATURE SENSOR (BEHIND CENTER OF FRONT GRILLE) A/C SOLAR SENSOR (LIMITED) (ON UPPER LEFT SIDE OF DASH) AIR VENT MODE CONTROL SERVO MOTOR (BEHIND RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) BB BB BB BB BB BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLOWER MOTOR CONTROLLER (BEHIND LOWER RIGHT SIDE OF DASH) BLU WIRE BLU/BLK WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN/BLK WIRE DRIVER SIDE J/B (BEHIND LOWER LEFT END OF DASH) FB DB DB BB FUSE GRN WIRE GRN/YEL WIRE GRY WIRE GRY/GRN WIRE HOT IN ACC OR ON HOT IN ON OR START IGN FUSE JUNCTION CONNECTOR 20 (BEHIND INSTRUMENT CLUSTER) JUNCTION CONNECTOR 25 (BEHIND RIGHT CENTER OF DASH) JUNCTION CONNECTOR 31, 32 (BEHIND RIGHT END OF DASH) JUNCTION CONNECTOR 6 (BEHIND LEFT END OF DASH) JUNCTION CONNECTOR 7 (BEHIND LEFT END OF DASH) JUNCTION CONNECTOR 8, 9 (BEHIND INSTRUMENT CLUSTER) LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE LT PNK LT WIRE ORG/ WIRE PNK 5 6 7 8 WIRE PNK PNK PNK PNK PNK PNK PNK WIRE PNK WIRE RED WIRE VIO WIRE VIO/GRN WIRE VIO/RED WIRE VM +B SI GND WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE

14 13 12 11 10 9 8 7 6 5 4 3 2 1 LIN-B 33 2 1 14 31 32 ACLD ACMG HP THWD A/CS THE 4.0L A/C EVAPORATOR TEMPERATURE SENSOR (BEHIND RIGHT SIDE OF DASH, ON HVAC ASSEMBLY) A/C LOCK SENSOR, MAGNETIC CLUTCH (ON A/C COMPRESSOR ASSEMBLY) A/C SOLAR SENSOR AB CA ANTI-THEFT SYSTEM DEFOGGER SYSTEM INTERIOR LIGHTS SYSTEM BLK WIRE BLK/ORG WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BRN WIRE BRN/BLK WIRE CENTER J/B (BEHIND RIGHT CENTER OF DASH) COMBINATION METER DEFOGGER SYSTEM WARNING SYSTEMS DFSW PBEW IG+ EE (ON REAR OF RIGHT CYLINDER HEAD) EF (ON REAR OF LEFT CYLINDER HEAD) ENGINE CONTROL MODULE (BEHIND RIGHT END OF DASH) ENGINE ROOM R/B (ON LEFT SIDE OF ENGINE COMPARTMENT) GRN WIRE GRN/RED WIRE GRY WIRE GRY/GRN WIRE HEATER CONTROL PANEL JUNCTION CONNECTOR 10, 11 (BEHIND INSTRUMENT CLUSTER) JUNCTION CONNECTOR 26 (BEHIND RIGHT 4.7L JUNCTION CONNECTOR 33, 34 (BEHIND RIGHT END OF DASH) JUNCTION CONNECTOR 8, 9 (BEHIND INSTRUMENT CLUSTER) LT GRN WIRE MG CLT RELAY ORG/ WIRE PNK 5 6 7 8 WIRE PNK WIRE RED WIRE RED/YEL WIRE SIDE OF DASH, NEAR FIREWALL GROMMET) SIND DIND ILL- ILL+ SPEEDO- METER TEMP VIO WIRE VIO/GRN WIRE VIO/RED WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE