Suzuki X-90 I (1995-2000) nca Wiring diagrams

ABS ACTIVE IND. ABS ACTUATOR (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) ABS CHECK RELAY (ON LEFT INNER FENDER PANEL, BEHIND HEADLIGHT) ABS CONTROL MODULE (SIDEKICK: BEHIND DASH, RIGHT OF STEERING COLUMN) ABS ENABLE RELAY (ON LEFT INNER FENDER PANEL, BEHIND HEADLIGHT) ABS G SENSOR ABS IND. ABS RESISTOR (BEHIND RIGHT SIDE OF DASH) BLK (OR WHT) WIRE BLK (OR WIRE BLK WIRE BLK/ WHT WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/WHT WIRE BRAKE DIFFERENTIAL SWITCH (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) BRAKE IND BRAKELIGHT SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/BLK WIRE COMBINATION METER DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER LEFT CENTER OF DASH) DIODE ENGINE COMPARTMENT FUSE BLOCK FUSE 11 FUSE 12 FUSE 16 FUSE 19 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH UNDER STEERING COLUMN) FUSE 17 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) GRN WIRE GRN/BLK WIRE GRN/WHT WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAIN FUSE (SIDEKICK: ON ENGINE ROOM FUSE BLOCK, IN FRONT OF BATTERY) FUSE NCA WIRE ORG (OR YEL/GRN) WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK ENGINE CONTROLS SYSTEM WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/WHT WIRE RIGHT ABS SOLENOID LEFT ABS SOLENOID RIGHT FRONT SPEED SENSOR REAR SPEED SENSOR SIDE- KICK SIDE- KICK X-90 SIDEKICK VIO/GRN (OR VIO/WHT) WIRE VIO/GRN WIRE VIO/WHT WIRE WHT (OR BLK) WIRE WHT WIRE WHT/ BLK WIRE WHT/BLU WIRE X-90 YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE

4 A/T TRANSMISSION RANGE SWITCH (ON TRANSMISSION ASSEMBLY) 5 SPEED: M/T BLK WIRE BLK/ORG WIRE BLK/RED (OR BLU) WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK (OR NCA) WIRE BLU/BLK WIRE BRAKELIGHT SWITCH (ABOVE BRAKE PEDAL) CLUTCH PEDAL POSITION (CPP) SWITCH (ABOVE CLUTCH PEDAL) COAST SET COMBINATION METER COMBINATION SWITCH (CRUISE SWITCH) CRUISE INDICATOR LAMP CRUISE MAIN SWITCH FUSE 12 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) FUSE 16 GRN WIRE GRN/WHT WIRE GRY WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION SWITCH J/C LOCK LT GRN WIRE LT GRN/WHT WIRE M/T A/T MAIN FUSE (ON ENGINE COMPARTMENT FUSE BLOCK) FUSE 7 MAIN RELAY (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) NCA WIRE PNK/BLK WIRE PNK/BLU WIRE PNK/GRN WIRE RED WIRE RESUME/ ACCEL STARTER VSS WHT WIRE YEL (OR NCA) WIRE YEL WIRE YEL/GRN WIRE

1.6L MODELS 1.8L BLK WIRE BLK/BLU WIRE GRN WIRE ILLUMINATION J/C J/C OR NCA WIRE OFF ON ON INDICATOR REAR DEFOGGER REAR DEFOGGER SWITCH RED WIRE RED/WHT WIRE WHT WIRE YEL WIRE

BLK WIRE BLK/YEL WIRE BLU WIRE BRAKELIGHT SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) COMBINATION METER COMBINATION SWITCH CRUISE CONTROL SYSTEM ENGINE CONTROLS SYSTEM FUSE 11 FUSE 12 FUSE 13 FUSE 17 FUSE BLOCK (PASSENGER COMPARMENT) (BEHIND DASH, UNDER STEERING COLUMN) FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) GRN WIRE GRN/RED WIRE GRN/YEL WIRE HAZARD WARNING SWITCH HEAD HEADLIGHT RELAY 2 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HIGH MOUNTED STOP LIGHT HOT AT ALL TIMES HOT IN ON OR START IF EQUIPPED (OR J/C J/C (LEFT KICK PANEL) LEFT FRONT COMBINATION LIGHT LEFT FRONT SIDE MARKER LIGHT LEFT LICENSE PLATE LIGHT LEFT REAR COMBINATION LIGHT LEFT TURN INDICATOR NCA WIRE OFF ON OFF OFF ON RED WIRE RED/GRN WIRE RED/YEL WIRE RIGHT FRONT COMBI- NATION LIGHT RIGHT FRONT SIDE MARKER LIGHT RIGHT LICENSE PLATE LIGHT RIGHT REAR COMBINATION LIGHT RIGHT TURN INDICATOR TAIL TAIL/ STOP LIGHT TURN LIGHT TURN SIGNAL SWITCH TURN SIGNAL, HAZARD WARNING RELAY (BEHIND RIGHT SIDE OUTER CORNER OF DASH) WHT WIRE YEL WIRE

ABS ACTUATOR MOTOR (1.8L), CONDENSER FAN MOTOR (1.8L), FRONT WASHER MOTOR, ABS CHECK RELAY (1.6L) (X90), AIR BAG DIAGNOSIS CONNECTOR, AIR BAG CONTROLLER, PASSENGER INFLATOR BATTERY BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/YEL WIRE BLU/ORG WIRE CLUTCH PEDAL POSITION CRUISE CONTROL ACTUATOR ASSEMBLY W/CONTROL MODULE, HORN (HI), DOOR MOTOR, SWITCH HEADLIGHT RELAY 1 (1.8L) (X90), J/C J/C (LEFT KICK PANEL) LEFT FRONT COMBINATION LIGHT, LEFT SIDE MARKER LIGHT, REAR WASHER MOTOR (1.8L) NCA WIRE RIGHT LICENSE PLATE LIGHT (1.8L), RIGHT REAR COMBINATION LIGHT YEL WIRE

15 16 G-09 3 4 G-10 BLK WIRE BLK/ WHT (OR NCA) WIRE BLK/ WHT WIRE BLK/ YEL WIRE BLK/WHT WIRE BRAKE DIFFERENTIAL SWITCH (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) BRAKE FLUID LEVEL SWITCH (ON BOTTOM OF BRAKE FLUID RESERVOIR) BRAKE INDICATOR CHARGE INDICATOR COMBINATION METER COMBINATION SWITCH DIMMER, PASSING SWITCH DIODE (BEHIND RIGHT SIDE OF DASH) DRL INDICATOR FUSE 11 FUSE 16 FUSE 23 FUSE 24 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) G-11 GRN VIO/ WIRE HEAD HEADLIGHT RELAY 1 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HEADLIGHT RELAY 2 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN ON OR START LEFT HEADLIGHT LIGHT SWITCH OFF MAIN FUSE (ON ENGINE COMPARTMENT FUSE BLOCK) NCA WIRE NCA) (OR WHT BLK/ WIRE OFF ORG/WHT WIRE PARKING BRAKE SWITCH (ON REAR OF PARKING BRAKE LEVER) PASS PNK/ WHT WIRE PNK/BLU WIRE PNK/WHT WIRE RED WIRE RED/ BLK WIRE RED/BLK (OR NCA) WIRE RED/BLK WIRE RED/BLU WIRE RED/WHT (OR NCA) WIRE RED/WHT WIRE RED/YEL WIRE RIGHT HEADLIGHT STARTING/CHARGING SYSTEM (GENERATOR) TAIL VIO WIRE WARNING SYSTEMS WHT RED/ WIRE WHT WIRE WHT/ BLK WIRE WHT/ BLU WIRE WHT/BLU (OR NCA) WIRE WHT/BLU WIRE WHT/RED WIRE YEL/RED WIRE

1.6L 4 DOOR A, SIDEKICK 2 DOOR 1.8L 1.8L ALL MODELS EXCEPT 1.8L 1.8L, 1.6L 4 DOOR B, X90 ALL MODELS EXCEPT 1.8L ALL MODELS EXCEPT 1.8L 1.8L BLK WIRE BLU WIRE FUSE 12 GRN WIRE GRN/BLK WIRE HORN (HI) HORN (LO) (IF EQUIPPED) HORN SWITCH HOT AT ALL TIMES NCA WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 G-09 1 2 3 4 5 6 7 8 9 10 11 12 13 G-11 TRANSMISSIONS SYSTEM 1 2 3 4 5 6 7 8 9 10 G-10 EXTERIOR LIGHTS SYSTEM 1.6L 1.6L 1.8L, X90 1.6L 4 D00R A MODEL, 2 DOOR 1.6L SIDE- KICK 1.8L, 1.6L SIDEKICK 1.6L SIDEKICK 2 DOOR 1.6L SIDEKICK 1.8L 1.8L 1.6L 1.8L SIDEKICK 1.8L, 1.6L 4 DOOR B MODEL 1.8L, X90 1.8L, X90 1.6L ABS ACTIVE INDIC (1.6L) ABS INDIC AIR BAG INDIC ANTI-LOCK BRAKES SYSTEM AUTO CRUISE INDIC BELT INDIC BLK (OR BLK/GRN) WIRE BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BRAKE FLUID LEVEL SWITCH (ON BRAKE FLUID RESERVOIR) BRAKE INDIC BRN/WHT WIRE CHARGE INDIC COMBINATION METER CRUISE CONTROL SYSTEM DRL INDIC ENGINE CONTROLS SYSTEM FUEL GAUGE FUEL LEVEL GAUGE SENDER (IN FUEL TANK) GRN WIRE GRN/RED WIRE GRY WIRE GRY/RED WIRE HEADLIGHTS SYSTEM HEADLIGHTS SYSTEM EXTERIOR LIGHTS SYSTEM HI BEAM INDIC HOT IN ON OR START FUSE BLOCK (PASSENGER COMPARTMENT) (SIDEKICK 1.6L, FUSE 16 IGNITION SWITCH ILLUMINATION J/C J/C (LOWER LEFT SIDE OF DASH) J/C OR W/S (RIGHT SIDE OF DASH) LEFT TURN INDIC LOCK LT GRN/RED WIRE NCA WIRE O/D OFF INDIC OIL INDIC OIL PRESSURE SWITCH (ON LEFT SIDE OF ENGINE) ORG/BLK WIRE ORG/WHT WIRE PARKING BRAKE SWITCH (ON REAR OF PARKING BRAKE LEVER) PNK WIRE POWER INDIC RED WIRE RED/ BLK WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/YEL WIRE RIGHT TURN INDIC SEAT BELT SWITCH (ON DRIVER'S SEAT BELT BUCKLE) SERVICE ENGINE SOON INDIC STARTING/CHARGING SYSTEM TACHOMETER TEMPERATURE GAUGE TRANSMISSIONS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM UNDER STEERING COLUMN) (SIDEKICK 1.8L: UNDER LEFT SIDE OF DASH) VEHICLE SPEED SENSOR VIO WIRE VIO/RED WIRE VIO/YEL WIRE W/ ABS W/ ABS W/ TACH W/O TACH ONLY WHT/BLK WIRE WHT/BLU WIRE WHT/RED WIRE X-90 X-90 1.8L J/C (BEHIND CENTER AIR VENTS) YEL RED/ WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE YEL/WHT WIRE

9 10 11 12 13 14 15 PNK PNK WIRE BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/RED WIRE BODY BRN/RED WIRE CRUISE CONTROL SYSTEM DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH, RIGHT OF STEERING COLUMN) EVAP CANISTER PURGE VALVE (ON RIGHT SIDE OF ENG) FUEL INJECTORS GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/RED WIRE GRN/YEL WIRE GRY/YEL WIRE HEATED OXYGEN IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE ILLUM J/C LOW SWITCH LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE NCA NCA WIRE NCA WIRE ORG/ WIRE ORG/BLU WIRE ORG/GRN WIRE ORG/WHT WIRE OVERDRIVE OFF SWITCH P/N SWITCH CONTAEUR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE PNK/WHT WIRE POWERTRAIN CONTROL MODULE (BEHIND DASH, ON STEERING COLUMN) RED WIRE RED/BLU WIRE RED/GRN WIRE RED/YEL WIRE SHIFT INTERLOCK SYSTEM STARTING/ CHARGING SYSTEM TRANSMISSION RANGE SWITCH (ON TRANSMISSION ASSEMBLY) VEHICLE SPEED SENSOR (ON TRANSMISSION ASSEMBLY) VIO WIRE VIO/GRN WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/GRN WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BODY COMBINATION METER CRANKSHAFT POSITION SENSOR (CKP) (ON ENG FRONT COVER) DATA LINK CONNECTOR (UNDER LEFT SIDE OF DASH, RIGHT OF STEERING COLUMN) ENGINE CONTROL EVAP CANISTER PURGE VALVE (RIGHT SIDE OF ENG) FUEL INJECTORS GRN/BLU WIRE GRN/WHT WIRE GRY/YEL WIRE HEATED OXYGEN IDLE AIR CONTROL (IAC) VALVE (ON THROTTLE LT GRN/BLK WIRE LT GRN/RED WIRE LT GRN/YEL WIRE NCA WIRE ORG/BLU WIRE PNK WIRE PNK/BLK WIRE RED WIRE RED/BLU WIRE SHIFT INTERLOCK SYSTEM (3 A/T ONLY) TANK PRESSURE CONTROL SOLENOID VACUUM VALVE (ON RIGHT INNER FENDER PANEL) VIO/GRN WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE WHT/GRN WIRE YEL (OR RED/BLU) WIRE YEL (OR WIRE