Suzuki X-90 I (1995-2000) fuse 16 Wiring diagrams

1.6L 1.8L 1.8L EXCEPT 1.8L 1995 VFTC A/C A/C AMPLIFIER (BEHIND RIGHT SIDE OF DASH) A/C COMPRESSOR A/C SWITCH ALL OTHERS BI/LEVEL BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLOWER MOTOR BLOWER SWITCH BLU WIRE BLU/RED WIRE CONDENSER FAN MOTOR CONDENSER FAN MOTOR RELAY DEF DEF/HEAT FUSE 16 FUSE 33 FUSE PANEL GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRY/BLK WIRE GRY/BLU WIRE GRY/RED WIRE HEAT (+) HOT AT ALL TIMES HOT IN ON AND START HOT IN ON FUSE 20 HOT IN ON OR START LT GRN WIRE LT GRN/RED WIRE MAIN FUSE BOX FUSE 18 MODE ACTUATOR (CENTER OF DASH) OFF PNK 4 5 HI WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE PNK/GRN WIRE RED WIRE RED/BLU (OR BLU/BLK) WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RESISTOR (RIGHT SIDE OF DASH) THERMISTOR (RIGHT SIDE OF DASH) VENT WHT/BLK WIRE WHT/RED (OR BLK/WHT) WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE

ABS ACTIVE IND. ABS ACTUATOR (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) ABS CHECK RELAY (ON LEFT INNER FENDER PANEL, BEHIND HEADLIGHT) ABS CONTROL MODULE (SIDEKICK: BEHIND DASH, RIGHT OF STEERING COLUMN) ABS ENABLE RELAY (ON LEFT INNER FENDER PANEL, BEHIND HEADLIGHT) ABS G SENSOR ABS IND. ABS RESISTOR (BEHIND RIGHT SIDE OF DASH) BLK (OR WHT) WIRE BLK (OR WIRE BLK WIRE BLK/ WHT WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/WHT WIRE BRAKE DIFFERENTIAL SWITCH (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) BRAKE IND BRAKELIGHT SWITCH (ABOVE BRAKE PEDAL) BRN WIRE BRN/BLK WIRE COMBINATION METER DATA LINK CONNECTOR (DLC) (PARTIAL) (UNDER LEFT CENTER OF DASH) DIODE ENGINE COMPARTMENT FUSE BLOCK FUSE 11 FUSE 12 FUSE 16 FUSE 19 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH UNDER STEERING COLUMN) FUSE 17 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) GRN WIRE GRN/BLK WIRE GRN/WHT WIRE HOT AT ALL TIMES HOT IN ON HOT IN ON OR START LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MAIN FUSE (SIDEKICK: ON ENGINE ROOM FUSE BLOCK, IN FRONT OF BATTERY) FUSE NCA WIRE ORG (OR YEL/GRN) WIRE ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK ENGINE CONTROLS SYSTEM WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/WHT WIRE RIGHT ABS SOLENOID LEFT ABS SOLENOID RIGHT FRONT SPEED SENSOR REAR SPEED SENSOR SIDE- KICK SIDE- KICK X-90 SIDEKICK VIO/GRN (OR VIO/WHT) WIRE VIO/GRN WIRE VIO/WHT WIRE WHT (OR BLK) WIRE WHT WIRE WHT/ BLK WIRE WHT/BLU WIRE X-90 YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE

A/T SHIFT SOLENOID VALVES (ON TRANSMISSION HOUSING) BLK WIRE BLK/BLU (OR BLK/ORG) WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/GRN WIRE BLU/WHT WIRE BRAKE LIGHT SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRN/RED WIRE CRUISE CONTROL SYSTEM ENGINE COOLANT TEMPERATURE SENSOR (REAR OF INTAKE MANIFOLD, NEAR THROTTLE BODY) FUSE 11 FUSE 12 FUSE 16 FUSE 17 FUSE BOX GRN WIRE GRN/BLU WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/RED WIRE GRY/YEL (OR BRN) WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION SWITCH IND INSTRUMENT CLUSTER J/C LOCK LOW SWITCH NCA WIRE O/D OFF IND ORG/ WIRE ORG/BLK WIRE ORG/GRN WIRE ORG/WHT WIRE OVERDRIVE OFF SWITCH P/N IN P/N SWITCH PNK 7 6 2 3 WIRE PNK WIRE PNK/BLU WIRE PNK/GRN WIRE POWERTRAIN CONTROL MODULE (BEHIND DASH, ON STEERING COLUMN) RED WIRE RED/YEL WIRE RUN WIRE SHIFT INTERLOCK RELAY STARTING/ CHARGING SYSTEM SWITCH THROTTLE POSITION SENSOR (ON THROTTLE BODY ASSEMBLY) TRANSMISSION RANGE SWITCH (RIGHT SIDE OF TRANSAXLE) VEHICLE SPEED SENSOR (LEFT REAR OF TRANSAXLE) WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE

1.6L 1.6L 1.8L 1.8L BATTERY BLK WIRE BLK/BLU WIRE BLK/WHT WIRE CHARGE IND COMBINATION METER FUSE 1 FUSE 16 FUSE 3 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) GENERATOR HEADLIGHTS SYSTEM (DRL CONTROLLER) IGNITION SWITCH J/C (LOWER LEFT END OF DASH) J/C OR W/S (LOWER LEFT SIDE OF STEERING COLUMN) LOCK NCA WIRE STARTER WHT (OR BLK) WIRE WHT WIRE WHT/GRN WIRE WHT/RED WIRE

15 16 G-09 3 4 G-10 BLK WIRE BLK/ WHT (OR NCA) WIRE BLK/ WHT WIRE BLK/ YEL WIRE BLK/WHT WIRE BRAKE DIFFERENTIAL SWITCH (ON LEFT REAR CORNER OF ENGINE COMPARTMENT) BRAKE FLUID LEVEL SWITCH (ON BOTTOM OF BRAKE FLUID RESERVOIR) BRAKE INDICATOR CHARGE INDICATOR COMBINATION METER COMBINATION SWITCH DIMMER, PASSING SWITCH DIODE (BEHIND RIGHT SIDE OF DASH) DRL INDICATOR FUSE 11 FUSE 16 FUSE 23 FUSE 24 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) G-11 GRN VIO/ WIRE HEAD HEADLIGHT RELAY 1 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HEADLIGHT RELAY 2 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HIGH BEAM INDICATOR HOT AT ALL TIMES HOT IN ON OR START LEFT HEADLIGHT LIGHT SWITCH OFF MAIN FUSE (ON ENGINE COMPARTMENT FUSE BLOCK) NCA WIRE NCA) (OR WHT BLK/ WIRE OFF ORG/WHT WIRE PARKING BRAKE SWITCH (ON REAR OF PARKING BRAKE LEVER) PASS PNK/ WHT WIRE PNK/BLU WIRE PNK/WHT WIRE RED WIRE RED/ BLK WIRE RED/BLK (OR NCA) WIRE RED/BLK WIRE RED/BLU WIRE RED/WHT (OR NCA) WIRE RED/WHT WIRE RED/YEL WIRE RIGHT HEADLIGHT STARTING/CHARGING SYSTEM (GENERATOR) TAIL VIO WIRE WARNING SYSTEMS WHT RED/ WIRE WHT WIRE WHT/ BLK WIRE WHT/ BLU WIRE WHT/BLU (OR NCA) WIRE WHT/BLU WIRE WHT/RED WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 DATA LINE 1 4 DIAGNOSIS CONNECTOR (ON RIGHT FENDER INNER PANEL, BEHIND HEADLIGHT) AIRBAG INDICATOR BLK WIRE BLK/WHT WIRE BLU WIRE BLU/RED WIRE COMBINATION METER CONTACT COIL DATA LINK CONNECTOR (UNDER LEFT CENTER OF DASH) DRIVER INFLATOR SEAT BELT SWITCH (IN BUCKLE) FUSE 16 FUSE 32 FUSE BOX (LEFT SIDE OF DASH) GRN WIRE GRN/RED WIRE GRY/RED WIRE HOT IN ON OR START J/C (LEFT SIDE OF DASH) NCA WIRE PASSENGER INFLATOR RED/BLK WIRE SEAT BELT INDICATOR SENSING, DIAGNOSTIC MODULE (SDM) (BELOW CENTER OF DASH) VIO/WHT WIRE WHT WIRE X-90 SIDEKICK X-90, SIDEKICK: 1.8L SIDEKICK: 1.6L YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

1 2 (1.6L/4D-A, SIDEKICK 2WD) (X-90, 1.6L/4D-B) 2 4 (1.6L/4D-A, SIDEKICK 2WD) (X-90, 1.6L/4D-B) BLK/RED WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF GLOVE BOX) TCC RELAY CONTROL FUSE 16 FUSE 7 FUSE BOX HOT AT ALL TIMES HOT IN ON, START MAIN FUSE MAIN RELAY (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) MAIN RELAY CONTROL TORQUE CONVERTER CLUTCH (TCC) SOLENOID (ON TRANSMISSION HOUSING) WHT WIRE WHT/YEL WIRE

BLK (OR NCA) WIRE BLK WIRE BLK/BLU WIRE BLK/WHT WIRE BLU/BLK WIRE COMBINATION METER FUSE 16 FUSE BLOCK (PASSENGER COMPARTMENT) (BEHIND DASH, UNDER STEERING COLUMN) FUSE 11 GRY/RED (OR YEL/RED) WIRE HEADLIGHT RELAY 2 (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) HOT AT ALL TIMES HOT IN ON OR START J/C KEY REMINDER SWITCH (IGNITION SWITCH) LEFT FRONT DOOR SWITCH NCA WIRE RED/YEL WIRE SEAT BELT INDICATOR SEAT BELT SWITCH (ON DRIVER'S SEAT BELT BUCKLE) WARNING CONTROLLER/BUZZER (BEHIND RIGHT CENTER OF DASH) WHT WIRE YEL/RED WIRE

ABS CONTROLLER AIR CONDITIONING SYSTEM BLK WIRE BLK/BLU WIRE BLK/ORG WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRAKE LIGHT SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR COMBINATION METER CRANKSHAFT POSITION SENSOR (CKP) (ON ENG FRONT COVER) CRUISE CONTROL MODULE DISTRIBUTOR EGR SOLENOID VACUUM VALVE (ON RIGHT SIDE OF ENG) FUSE 12 FUSE 16 FUSE BOX GRN WIRE GRN/BLU WIRE GRN/RED WIRE GRN/WHT WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR ON IGNITER IGNITION COIL IND J/C LT GRN/WHT WIRE MAIN FUSE BOX FUSE 7 MAIN RELAY (BEHIND RIGHT CENTER OF DASH, IN RELAY BLOCK) MAL- FUNCTION INDICATOR LAMP P/N IND NOISE SUPPRESSOR FILTER (LEFT REAR OF ENG COMPT) O/D OFF IND ORG/ WIRE ORG/BLU WIRE PNK 1 2 3 4 WIRE PNK WIRE PNK/GRN WIRE PNK/WHT WIRE POWER STEERING PUMP PRESSURE SWITCH (ON POWER STEERING PUMP ASSEMBLY) POWERTRAIN CONTROL MODULE (BEHIND DASH, ON STEERING COLUMN) RED WIRE RED/BLK WIRE RED/BLU WIRE RED/YEL WIRE SWITCH THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TO SPARK PLUGS VEHICLE SPEED SENSOR VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

A/T ABS CONTROLLER AIR CONDITIONING SYSTEM BLK WIRE BLK/BLU WIRE BLK/ORG WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/RED WIRE BRN/WHT WIRE BRN/YEL WIRE CAMSHAFT POSITION (CMP) SENSOR COMBINATION METER DISTRIBUTOR EGR SOLENOID VACUUM VALVE (ON RIGHT SIDE OF ENG) FUSE 11 FUSE 16 FUSE BOX GRN/RED WIRE GRY WIRE GRY/BLK WIRE GRY/RED WIRE GRY/YEL WIRE HOT AT ALL TIMES HOT IN START OR ON IGNITER IGNITION COIL J/C J/C 6 7 (NEAR LEFT KICK PANEL) LT GRN/WHT WIRE M/T MAIN FUSE BOX FUSE 7 MALFUNCTION INDICATOR LAMP NOISE SUPPRESSOR FILTER (LEFT REAR OF ENG COMPT) ORG/ WIRE PNK 19 20 21 WIRE PNK WIRE PNK/WHT WIRE POWER STEERING PUMP PRESSURE SWITCH (ON POWER STEERING PUMP ASSEMBLY) RED/BLK WIRE RED/BLU WIRE RED/YEL WIRE THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY) TO SPARK PLUGS VIO WIRE VIO/YEL WIRE W/ TACHO W/O TACHO WHT WIRE WHT/YEL WIRE YEL (OR RED/BLU) WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE