Subaru Baja I (2002-2006) engine controls system Wiring diagrams

A/C RELAY BLK WIRE BLK/YEL WIRE BLU/WHT WIRE BRN/WHT WIRE COMBINATION METER ENGINE CONTROL MODULE ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR, THERMOMETER (RIGHT REAR OF ENGINE) FUSE 17 FUSE 18 FUSE FUSE HOLDER (LEFT SIDE OF ENGINE COMPT) FUSE/ RELAY BOX (LEFT REAR OF ENGINE COMPT) GB-2 (AT LEFT FRONT OF ENGINE COMPT) GRN/BLK WIRE GRN/BLU WIRE GRN/RED WIRE HOT AT ALL TIMES HOT IN ON OR START MAIN FAN RELAY PNK/WHT WIRE RADIATOR MAIN FAN MOTOR RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIELD, SENSOR GROUND JOINT CONNECTOR (LOWER RIGHT END OF DASH) SUB FAN MOTOR SUB FAN RELAY W/O LOW EMISSION W/ LOW EMISSION (BEHIND RIGHT SIDE OF DASH) WHT/BLK WIRE WHT/DK GRN WIRE YEL/GRN WIRE YEL/RED WIRE

A/C PRESSURE SWITCH (ON A/C RECEIVER-DRIER) A/C RELAY HOLDER AIR CONDITIONING RELAY BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR RELAY (AT LEFT KICK PANEL) BLOWER MOTOR RESISTOR (BEHIND RIGHT SIDE OF DASH) BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BLU/YEL WIRE BRN/WHT WIRE COMBINATION METER CONNECTOR (LOWER RIGHT END OF DASH) ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR, THERMOMETER (RIGHT REAR OF ENGINE) EVAPORATOR THERMO SWITCH (BEHIND RIGHT SIDE OF DASH, ON INTAKE UNIT CASE) FUSE FUSE 17 FUSE 18 (LEFT REAR OF ENGINE COMPT) FUSE 2 FUSE 1 FUSE/ RELAY BOX GB-5 (UNDER FRONT OF CENTER CONSOLE) GB-7 (AT FRONT LEFT SIDE OF CENTER CONSOLE) GRN VIO/ WIRE GRN/BLK WIRE GRN/BLU WIRE GRN/RED WIRE HOT AT ALL TIMES HOT IN ON OR START LT GRN/RED WIRE LT GRN/WHT WIRE MAGNET CLUTCH MAIN FAN RELAY MODE ACTUATOR (BEHIND CENTER OF DASH) MODE CONTROL PANEL NCA WIRE PNK/GRN WIRE PNK/WHT WIRE RADIATOR MAIN FAN MOTOR (LEFT FRONT OF ENGINE COMPT) REAR DEFOGGER RELAY RED WIRE RED/ WHT WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIELD, SENSOR GROUND JOINT SUB FAN RELAY VIO WIRE VIO/GRN WIRE VIO/RED WIRE VIO/YEL WIRE W/O LOW EMISSION W/ LOW EMISSION WHT WIRE WHT/BLK WIRE WHT/DK GRN WIRE WHT/ORG WIRE YEL WIRE YEL/GRN WIRE YEL/RED WIRE

A/C RELAY HOLDER BLK WIRE BLK/GRN WIRE BLU/WHT WIRE BRN/WHT WIRE COMBINATION METER ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR, THERMOMETER (TOP FRONT OF ENGINE) FAN MODE RELAY FUSE FUSE (LEFT SIDE OF ENGINE COMPT) FUSE 17 FUSE 18 FUSE/ RELAY BOX (LEFT REAR OF ENGINE COMPT) GB-2 (AT LEFT FRONT OF ENGINE COMPT) GRN/BLK WIRE GRN/BLU WIRE GRN/RED WIRE HOT AT ALL TIMES HOT IN ON OR START MAIN FAN RELAY NCA WIRE PNK/WHT WIRE RADIATOR MAIN FAN MOTOR RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIELD, SENSOR GROUND JOINT CONNECTOR (LOWER RIGHT END OF DASH) SUB FAN MOTOR SUB FAN RELAY WHT/BLK WIRE WHT/GRN WIRE YEL/BLK WIRE YEL/GRN WIRE

A/T BLK WIRE BLK/BLU WIRE BLK/ORG WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/RED WIRE BLU/YEL WIRE BRN WIRE BRN/WHT WIRE CLUTCH SWITCH (ON CLUTCH PEDAL BRACKET) COMBINATION METER CRUISE CONTROL MAIN SWITCH CRUISE CONTROL SUB SWITCH CRUISE SET IND LIGHT DIMMER CIRCUIT ELECTRIC THROTTLE RELAY ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE CONTROLS SYSTEM FUSE 11 FUSE 16 FUSE 18 FUSE, RELAY BOX (LEFT END GB-3 (AT REAR OF ENGINE COMPT) GB-7 (AT FRONT LEFT SIDE OF CENTER CONSOLE) GE-1 (ON TOP LEFT OF ENGINE) GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN ON OR START IGNITION RELAY IGNITION SWITCH ILLUM LT GRN WIRE LT GRN/BLK WIRE M/T MAIN FUSE BOX (LEFT SIDE OF ENGINE COMPT) FUSE MAIN RELAY (AT RIGHT KICK PANEL) NCA WIRE OF DASH) OFF ORG/BLK WIRE RED WIRE RED/BLU WIRE RED/GRN WIRE RESUME SBF FUSE 5 SET- ST LOCK ON OFF STOPLIGHT, BRAKE SWITCH (ON BRAKE PEDAL BRACKET) TRANSMISSION CONTROL MODULE (BEHIND LEFT SIDE OF DASH) U COM VEHICLE SPEED SENSOR (ON RIGHT SIDE OF TRANSMISSION) ELECTRIC THROTTLE VIO WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/RED WIRE

A/C RELAY HOLDER (LEFT SIDE OF ENGINE COMPT) AIR CONDITIONING RELAY BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH) BLOWER MOTOR RELAY (AT LEFT KICK PANEL) BLOWER MOTOR RESISTOR (BEHIND RIGHT SIDE OF DASH) BLU WIRE BLU/ORG WIRE BLU/WHT WIRE BLU/YEL WIRE BRN/WHT WIRE COMBINATION METER CONNECTOR (LOWER RIGHT END OF DASH) ENGINE CONTROL MODULE (BEHIND RIGHT SIDE OF DASH) ENGINE CONTROLS SYSTEM ENGINE COOLANT TEMPERATURE SENSOR, THERMOMETER (TOP FRONT OF ENGINE) EVAPORATOR THERMO SWITCH (BEHIND RIGHT SIDE OF DASH, ON INTAKE UNIT CASE) FAN MODE RELAY FUSE FUSE 17 FUSE 18 (LEFT REAR OF ENGINE COMPT) FUSE 2 FUSE 1 FUSE/ RELAY BOX GB-1 (AT RIGHT FRONT OF ENGINE COMPT) GB-5 (UNDER FRONT OF CENTER CONSOLE) GB-7 (AT FRONT LEFT SIDE OF CENTER CONSOLE) GRN VIO/ WIRE GRN/BLK WIRE GRN/BLU WIRE GRN/RED WIRE HOT AT ALL TIMES HOT IN ON OR START LT GRN/RED WIRE LT GRN/WHT WIRE MAGNET CLUTCH MAIN FAN RELAY MODE ACTUATOR (BEHIND CENTER OF DASH) MODE CONTROL PANEL NCA WIRE PNK/GRN WIRE PNK/WHT WIRE PRESSURE SWITCH (ON A/C RECEIVER-DRIER) RADIATOR MAIN FAN MOTOR (LEFT FRONT OF ENGINE COMPT) REAR DEFOGGER RELAY RED WIRE RED/ WHT WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIELD, SENSOR GROUND JOINT SUB FAN MOTOR (RIGHT FRONT OF ENGINE COMPT) SUB FAN RELAY VIO WIRE VIO/GRN WIRE VIO/RED WIRE VIO/YEL WIRE WHT WIRE WHT/BLK WIRE WHT/GRN WIRE WHT/ORG WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE

2.5L 3.0L BLK WIRE BLK/BLU WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE FLUID LEVEL SWITCH (IN BRAKE MASTER CYLINDER) BRN WIRE BRN/BLK WIRE BRN/RED WIRE BRN/WHT WIRE BUMPER) AMBIENT SENSOR DIODE (SPORT LIGHT) (BEHIND RIGHT SIDE OF DASH) DK GRN/RED WIRE ENGINE CONTROLS SYSTEM EXCEPT 2.5L TURBO FUEL LEVEL SENSOR FUEL SUB LEVEL SENSOR FUSE 2 FUSE 5 GB-3 (AT REAR OF ENGINE COMPT) GB-7 (AT FRONT LEFT SIDE OF CENTER CONSOLE) GB-8 (UNDER RIGHT FRONT SEAT) GE (ON RIGHT REAR OF ENGINE) GE-1 (ON TOP LEFT OF ENGINE) GRN WIRE GRN/ORG WIRE GRN/WHT WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION RELAY (IN RELAY BLOCK) LEFT FRONT DOOR SWITCH LEFT REAR DOOR SWITCH MAIN FUSE BOX (LEFT SIDE OF ENGINE COMPT) OP CONNECTOR (BEHIND LEFT CENTER OF DASH) PNK WIRE ORG/ WIRE PARKING BRAKE SWITCH (AT BASE OF PARKING BRAKE LEVER) PICK-UP PNK 1 WIRE PNK 8 9 10 WIRE PNK WIRE RED WIRE RIGHT FRONT DOOR SWITCH RIGHT REAR DOOR SWITCH SEDAN WAGON SHIELD, SENSOR GROUND JOINT CONNECTOR (LOWER RIGHT END OF DASH) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/RED WIRE

2.5L ABS WARNING IND AIR BAG AIR BAG WARNING IND ANTI-THEFT SYSTEM BLK WIRE BLK/BLU WIRE BLK/GRN WIRE BLK/ORG WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE FLUID PARKING BRAKE/ BRN WIRE BRN/BLK WIRE BRN/BLU WIRE BRN/RED WIRE BUZZER CARGO LIGHT IND CHARGE WARNING IND CIRCUIT CLOCK/OUT TEMPERATURE LCD BACK IND COMBINATION METER DIMMER DIMMER CIRCUIT DIMMER CIRCUIT CRUISE SET IND DOOR WARNING BACK LIGHT DOOR WARNING SPORTS SHIFT (LCD) ENGINE CONTROLS SYSTEM FUEL GAUGE FUSE 12 FUSE/ RELAY BOX (LEFT REAR OF ENGINE COMPT) GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT W/ TAIL, ILLUMINATION RELAY ENERGIZED ILLUM LAMPS (4) INTERIOR LIGHTS SYSTEM ENGINE CONTROLS SYSTEM EXTERIOR LIGHTS SYSTEM LEFT TURN SIG IND LEVEL WARNING IND LOW FUEL WARNING IND LT GRN WIRE LT GRN/BLK WIRE LT GRN/YEL WIRE MALFUNCTION IND NCA WIRE ODO/TRIP LCD BACK IND ORG/ WIRE ORG/BLU WIRE ORG/WHT WIRE PNK WIRE PNK/BLK WIRE PNK/WHT WIRE POWER RED WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RIGHT TURN SIG IND SEAT BELT IND SECURITY IND SPEEDOMETER STARTING/CHARGING SYSTEM CRUISE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM SWITCH BACK GATE WARNING IND TACHOMETER ODO/TRIP CLOCK/ OUT TEMP TEMPERATURE GAUGE TRANSMISSIONS SYSTEM VIO WIRE WARNING IND A/T OIL TEMP WARNING IND OIL PRESSURE WHT/GRN WIRE WHT/RED WIRE YEL/BLU WIRE YEL/RED WIRE

2.5L 3.0L 8 9 10 11 PNK WIRE BLK WIRE BLK/BLU WIRE BLK/RED WIRE BLK/WHT WIRE BLU WIRE BLU/BLK WIRE BLU/RED WIRE BRAKE FLUID LEVEL SWITCH (IN BRAKE MASTER CYLINDER) BRN WIRE BRN/BLK WIRE BRN/RED WIRE BRN/WHT WIRE BUMPER) AMBIENT SENSOR DIODE (SPORT LIGHT) (BEHIND RIGHT SIDE OF DASH) DK GRN/RED WIRE ENGINE CONTROLS SYSTEM EXCEPT 2.5L TURBO FUEL LEVEL SENSOR FUEL SUB LEVEL SENSOR FUSE 2 FUSE 5 GB-3 (AT REAR OF ENGINE COMPT) GB-7 (AT FRONT LEFT SIDE OF CENTER CONSOLE) GB-8 (UNDER RIGHT FRONT SEAT) GE (ON RIGHT REAR OF ENGINE) GE-1 (ON TOP LEFT OF ENGINE) GRN WIRE GRN/ORG WIRE GRN/WHT WIRE HOT AT ALL TIMES HOT IN ON OR START IGNITION RELAY (IN RELAY BLOCK) LEFT FRONT DOOR SWITCH LEFT REAR DOOR SWITCH MAIN FUSE BOX (LEFT SIDE OF ENGINE COMPT) OP CONNECTOR (BEHIND LEFT CENTER OF DASH) PNK WIRE ORG/ WIRE PARKING BRAKE SWITCH (AT BASE OF PARKING BRAKE LEVER) PICK-UP PNK 1 WIRE PNK WIRE RED WIRE RIGHT FRONT DOOR SWITCH RIGHT REAR DOOR SWITCH SEDAN WAGON SHIELD, SENSOR GROUND JOINT CONNECTOR (LOWER RIGHT END OF DASH) WHT WIRE WHT/BLU WIRE WHT/GRN WIRE YEL WIRE YEL/RED WIRE

2 3 6 7 8 CHECK CONNECTOR (PARTIAL) (BEHIND CENTER OF DASH) AIR BAG CONTROL MODULE AIR BAG INDICATOR LIGHT AIR BAG CIRCUIT BLK WIRE BLK/BLU WIRE BLK/WHT WIRE BLU WIRE BRN WIRE COMBINATION METER DIAGNOSIS CONNECTOR (BEHIND CENTER OF DASH) DRIVER SIDE INFLATOR ENGINE CONTROLS SYSTEM FUSE 5 FUSE 6 FUSE 11 FUSE, RELAY BOX (F/B) GB-3 (2.5L) (AT REAR OF ENGINE COMPARTMENT) GB-6 (UNDER FRONT OF CENTER CONSOLE) GB-4 (REAR OF ENGINE COMPT) GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HOT AT ALL TIMES HOT IN ON OR START I 28 IGNITION RELAY (IN RELAY BLOCK) IGNITION SWITCH LEFT FRONT SUB SENSOR LEFT PRETENSIONER (W/ELR) LEFT SIDE AIR BAG SENSOR LEFT SIDE INFLATOR LT GRN WIRE MAIN FUSE BOX (M/B) (AT LEFT SIDE OF ENGINE COMPARTMENT, AT REAR OF BATTERY) NCA WIRE OFF ON IG PASSENGER SIDE INFLATOR PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT SUB SENSOR RIGHT PRETENSIONER (W/ELR) RIGHT SIDE AIR BAG SENSOR RIGHT SIDE INFLATOR STEERING ROLL CONNECTOR WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLK WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/PNK WIRE YEL/RED WIRE YEL/WHT WIRE