Manual a/c circuit for Saturn Outlook I (2006-2010)

1382 300 1551 4540 5060 INTERIOR LIGHTS SYSTEM 193 735 1450 DEFOGGER SYSTEM 3 4 5 PNK WIRE 54 53 HI SPD CLG FAN A/C CLUTCH A/C GND A/C PRESSURE A/C REFRIGERANT PRESSURE SENSOR (NEAR REAR OF A/C COMPRESSOR) AMBIENT AIR TEMP SIG AUTOMATIC TRANSMISSION AUXILIARY DOOR CTRL AUX BLOWER SPEED BLK WIRE BLK/WHT WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) (LEFT FRONT CORNER OF ENGINE COMPT) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (LEFT SIDE OF ENGINE) GRN WIRE GRY WIRE HOT AT ALL TIMES HVAC CONTROL MODULE HVAC FUSE I/P FUSE BLOCK (BEHIND RIGHT END OF DASH) INDICATOR LOGIC LOW REF LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE OUTPUT SPEED (+) PNK WIRE POWER MODE POWER MODE GND B+ LOW SPEED GMLAN PPL/WHT WIRE REAR DEFOG RECIRCULATE GND RED/WHT WIRE RH AIR TEMP SW SIG AUX MODE AUX MODE DOOR CTRL SENSOR TAN WIRE TAN/BLK WIRE TEMPERATURE GND TRANSMISSION CONTROL MODULE WHT WIRE WIPER/ WASHER SYSTEM YEL WIRE

3 4 5 PNK WIRE A/C CMPRSR CLTCH RELAY A/C COMPRESSOR CLUTCH (LOWER LEFT FRONT OF ENGINE) AC CLTCH FUSE BLK WIRE DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE EMISSION 2 FUSE FAN 1 FUSE FAN 1 RELAY FAN 2 RELAY FAN 3 RELAY FAN-2 FUSE FRONT WHEELWELL) GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY ENERGIZED LEFT COOLING FAN (MOUNTED TO REAR LEFT SIDE OF RADIATOR) LT BLU WIRE LT GRN WIRE ORG/ WIRE PNK 4 5 WIRE PPL/WHT WIRE RED WIRE RIGHT COOLING FAN (MOUNTED TO REAR RIGHT SIDE OF RADIATOR) UNDERHOOD FUSE BLOCK (ABOVE RIGHT WHT WIRE YEL WIRE

1 2 B+ BLOWER SPEED 1 2 PPL BLOWER VOLT LOW REF 6 5 4 3 2 1 B+ GND AUX BLOWER SPEED AUX BLOWER SPEED AUX TEMPERATURE AUX MODE AUX TEMP AUXILIARY AIR TEMPERATURE ACTUATOR (ON REAR HVAC MODULE) AUXILIARY BLOWER MOTOR (ON REAR HVAC MODULE) AUXILIARY BLOWER MOTOR CONTROL MODULE (ON REAR HVAC MODULE) AUXILIARY HVAC CONTROL ASSEMBLY (W/O REAR SEAT, EARPHONE JACKS RADIO CONTROL) AUXILIARY MODE ACTUATOR (ON REAR HVAC MODULE) AUXILIARY RADIO/HVAC CONTROL (W/ REAR SEAT, EARPHONE JACKS RADIO CONTROL) BLK WIRE BLOWER MOTOR (PART OF HVAC MODULE, BEHIND GLOVE BOX) BLOWER MOTOR CONTROL MODULE (BEHIND GLOVE BOX, IN FRONT OF BLOWER MOTOR) BLOWER SPEED BLOWER SPEED DOWN BLOWER SPEED UP BRN WIRE CHANGE MODE COMPUTER DATA LINES SYSTEM DK GRN WIRE FLOOR MODE FLOOR/VENT GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HVAC BLWR FUSE LO SPD GMLAN LOGIC LOW REF LT GRN/WHT WIRE ORG/ WIRE PNK 4 5 WIRE PNK WIRE PPL PPL/WHT WIRE RED/BLK WIRE RED/WHT WIRE RR HVAC FUSE TEMPERATURE DOWN TEMPERATURE UP UNDERHOOD FUSE BLOCK (ABOVE RIGHT FRONT WHEELWELL) VENT MODE VOLT GND WHT WIRE YEL WIRE

AIR TEMPERATURE ACTUATOR BLOWER SPEED BLOWER SPEED MODE DOOR CTRL TEMPERATURE DOOR CTRL BRN WIRE COMPUTER DATA LINES SYSTEM DEFROST MODE DEFROST/FLOOR MODE FLOOR MODE FLOOR/VENT MODE VENT MODE DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY EVAPORATOR TEMPERATURE SENSOR (RIGHT SIDE OF HVAC MODULE) GRY WIRE GRY/BLK WIRE HVAC CONTROL MODULE INSTRUMENT PANEL CLUSTER (IPC) LOGIC LT GRN WIRE LT GRN/WHT WIRE MODE MOTOR SPLY VOLT TEMPERATURE SPLY VOLT LOW REF MODE POS RECIRCULATION POS BLOWER SPEED MODE DOOR CTRL ORG/ WIRE PPL RECIRCULATION DOOR A TEMPERATURE A LOW REF LOW REF RECIRCULATION DOOR CTRL AIR TEMPERATURE DOOR TAN WIRE TAN/BLK WIRE TEMPERATURE POS TEMPERATURE SENS SIG MODE DOOR CTRL WHT WIRE WHT/BLK WIRE YEL WIRE