RAM Pickup 2500 (2011-2012) asd ctrl Wiring diagrams

5 VOLT ENG SNSR SEC FD ALTR FLD FD ECT SIG TP 1 SIG ALTR SNS ASD CTRL B(+) BATT FD BLK WIRE BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE CAN-BUS CAN-BUS CMP SIG CRK SPD SNR KNOCK SENS 2 SIG KNOCK SENS 2 RETURN ETC MOTOR (-) COIL CTRL 7 INJECTOR CTRL 8 INJECTOR CTRL 7 COMPUTER DATA LINES SYSTEM CTRL SIG DK BLU WIRE DK BLU/DK GRN WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/ORG WIRE DK BLU/PNK WIRE DK BLU/RED WIRE DK BLU/TAN WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DK GRN WIRE FUSE GROUND BATT FD IGN ENG CTRL (RUN-START) IGN (ULK-RUN-START) GROUND GROUND OIL PRESSURE SIG SRV SEN OUT PRESS SENS SIG HOT AT ALL TIMES KNOCK SENS 1 (-) KNOCK SENS 1 RETURN KNOCK SENS 2 (-) KNOCK SENS 2 RETURN LEFT KNOCK SENSOR 1 (LEFT SIDE OF ENGINE) MAP SIG KNOCK SENS 1 RETURN KNOCK SENS 1 SIG PNK/GRY WIRE PNK/WHT WIRE PNK/YEL WIRE POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RED WIRE RED/GRY WIRE RIGHT KNOCK SENSOR 2 (TOP CENTER FRONT OF ENGINE) RUN-START) IGN (ULK- SENS RTN SIG SENS RTN TP 2 SIG 5 VOLT ENG SNSR IAT SIG SHORT RUNNER VALVE SOLENOID SIG SRV ACTR SRV ACTR CTRL SIG SRV SEN OUT STARTING/ CHARGING SYSTEM TAN/ORG WIRE TAN/YEL WIRE TOTALLY INTEGRATED CIRCUIT BOARD POWER MODULE (LEFT FRONT OF ENGINE COMPT) VIO/BRN WIRE VIO/GRY WIRE VIO/ORG WIRE WHT/BRN WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE YEL/DK BLU WIRE YEL/PNK WIRE

ASD CTRL BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE COM SNSR RTN 4 CRANKCASE SENSOR (TOP LEFT SIDE OF ENGINE) CRKCSE PRESS SIG CTRL COM DK BLU WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR MTR EGR MTR POS SIG 2 EGR TEMPERATURE SENSOR EGR VALVE ASSEMBLY ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FD 3 FUEL INJ 1 RTN FUEL INJ 1 SIG FUEL INJ 2 RTN FUEL INJ 2 SIG FUEL INJ 3 RTN FUEL INJ 3 SIG FUEL INJECTOR 1 FUEL INJECTOR 2 (TOP OF ENGINE, OVER 1, 2, 3 CYLINDERS) FUEL INJECTOR 3 FUEL PRESS SNSR FUEL PRESSURE SENSOR (TOP LEFT REAR OF ENGINE) GRY/BRN WIRE INLT AIR PRESS SNSR INLT AIR TEMP SNSR MAF ALFW MAP TEMPERATURE/ PRESSURE SENSOR MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE) ORG/BRN WIRE OUT OUT 2 + OUT 3 POS SIG POS SIG 3 SIG SNSR RTN 4 SNSR SIG SSR IGN FD TURBO SPEED SENSOR (ON TURBO) VAR IN VIO/LT GRN WIRE VIO/ORG WIRE VLV PWM WATER IN FUEL SENSOR (LEFT SIDE OF ENGINE) WHT/BRN WIRE YEL/BRN WIRE

AIR INTKE THRTL MTR (+) AIR INTKE THRTL MTR (-) ALTR FLD FD ASD CTRL BLK WIRE BOOST PRESSURE SENSOR BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BST PRESS SIG CAM POSTN CAMSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE BLOCK) COM SNSR COM SNSR RTN 4 COMPUTER DATA LINES SYSTEM CTRL COM SNSR RTN 4 DIFF PRESS SNSE DK BLU WIRE DK BLU/BRN WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DSEL INLT AIR PRESS SNSR DSEL INLT AIR TEMP SNSR FUEL INJ 6 RTN FUEL INJ 5 RTN DSL HIGH SIDE DRVR RTN EGR MTR OUT EGR MTR POS SIG 2 TURBO SPD SNSR SIG CAM POSTN SNSR SIG ELECTRONIC TURBO ACTUATOR ENG CTRL COM SNSR RTN 4 AIR THRTL STAT FDBK SIG 2 ENG FAN SPD OUT EXHAUST DIFFERENTIAL PRESSURE SENSOR (TOP RIGHT FRONT OF ENGINE) FD 3 FUEL INJ 3 RTN FUEL INJ 2 RTN FUEL INJ 1 RTN FUEL INJ 4 RTN FUEL INJ 4 SIG FUEL INJ 5 RTN FUEL INJ 5 SIG FUEL INJ 6 RTN FUEL INJ 6 SIG FUEL INJECTOR 4 FUEL INJECTOR 5 FUEL INJECTOR 6 FUEL PUMP MOTOR GRY/BRN WIRE HI SIDE DRVR RTN INLET AIR PRESSURE SENSOR (RIGHT FRONT OF ENGINE) INTKE TEMP SENS SIG INTKE THRTL MTR (+) LT BLU/BRN WIRE LT GRN/BRN WIRE MAF AFLW SIG OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PMP POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RAD FAN MTR SPD RAD FAN MTR SPD SIG OIL PRESS SNSE/SW SIG RADIATOR FAN DRIVE RED/VIO WIRE RTN 4 SNSR SIG SSR IGN FD STARTING/CHARGING SYSTEM THRTL STAT FDBK SIG 2 VIO/GRY WIRE VIO/ORG WIRE VLTG FD WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE

1 RTN 1 SIG 2 RTN (-) 2 SIG 3 RTN 3 SIG ASD CTRL BLK WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/ORG WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE COM SNSR RTN 4 CRANKCASE SENSOR (TOP LEFT SIDE OF ENGINE) CRKCSE PRESS SIG CTRL COM SNSR RTN 4 DK BLU WIRE DK BLU/DK BLU WIRE DK BLU/GRY WIRE DK BLU/LT BLU WIRE DK BLU/LT GRN WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE EGR MTR EGR TEMPERATURE SENSOR EGR VALVE ASSEMBLY (TOP REAR OF ENGINE) ENGINE COOLANT TEMPERATURE SENSOR (TOP FRONT OF ENGINE) FD 3 FUEL INJ + FUEL INJECTOR 1 (TOP OF ENGINE, OVER CYLINDER 1) FUEL INJECTOR 2 (TOP OF ENGINE, OVER CYLINDER 2) FUEL INJECTOR 3 (TOP OF ENGINE, OVER CYLINDER 3) FUEL PRESS SNSR FUEL RAIL PRESSURE SENSOR (TOP LEFT REAR OF ENGINE) GRY/BRN WIRE INLT AIR PRESS SNSR INLT AIR TEMP SNSR MAF ALFW MAP TEMPERATURE/ PRESSURE SENSOR MASS AIR FLOW SENSOR (RIGHT FRONT OF ENGINE) ORG/BRN WIRE OUT OUT 2 + OUT 3 POS SIG POS SIG 2 POS SIG 3 SIG SNSR SIG SSR IGN FD TURBO SPEED SENSOR (ON TURBO) VAR IN VIO/LT GRN WIRE VIO/ORG WIRE VLV PWM WATER IN FUEL SENSOR (LEFT SIDE OF ENGINE) WHT/BRN WIRE YEL/BRN WIRE

4 RTN 4 SIG 5 RTN 5 SIG 6 RTN 6 SIG AIR INTKE THRTL MTR (+) AIR INTKE THRTL MTR (-) ALTR FLD FD ASD CTRL BLK WIRE BOOST PRESSURE SENSOR BRN WIRE BRN/DK BLU WIRE BRN/DK GRN WIRE BRN/GRY WIRE BRN/LT BLU WIRE BRN/LT GRN WIRE BRN/ORG WIRE BRN/PNK WIRE BRN/TAN WIRE BRN/VIO WIRE BRN/WHT WIRE BRN/YEL WIRE BST PRESS SIG CAM POSTN CAMSHAFT POSITION SENSOR (LOWER LEFT FRONT OF ENGINE BLOCK) COM SNSR COM SNSR RTN 4 COMPUTER DATA LINES SYSTEM CTRL COM SNSR RTN 4 DIFF PRESS SNSE DK BLU WIRE DK BLU/BRN WIRE DK BLU/DK BLU WIRE DK BLU/GRY WIRE DK BLU/LT GRN WIRE DK BLU/PNK WIRE DK BLU/WHT WIRE DK BLU/YEL WIRE DSEL INLT AIR PRESS SNSR DSEL INLT AIR TEMP SNSR FUEL INJ 6 RTN FUEL INJ 5 RTN DSL HIGH SIDE DRVR RTN EGR MTR OUT EGR MTR POS SIG 2 TURBO SPD SNSR SIG CAM POSTN SNSR SIG ELECTRONIC TURBO ACTUATOR ENG CTRL COM SNSR RTN 4 AIR THRTL STAT FDBK SIG 2 ENG FAN SPD OUT EXHAUST DIFFERENTIAL PRESSURE SENSOR (TOP RIGHT FRONT OF ENGINE) FD 3 FUEL INJ + FUEL INJ 3 RTN FUEL INJ 2 RTN FUEL INJ 1 RTN FUEL INJECTOR 4 (TOP OF ENGINE, OVER CYLINDER 4) FUEL INJECTOR 5 (TOP OF ENGINE, OVER CYLINDER 5) FUEL INJECTOR 6 (TOP OF ENGINE, OVER CYLINDER 6) FUEL PUMP MOTOR GRY/BRN WIRE HI SIDE DRVR RTN INLET AIR PRESSURE SENSOR (RIGHT FRONT OF ENGINE) INTKE TEMP SNSR SIG INTKE THRTL MTR (+) LT BLU/BRN WIRE LT GRN/BRN WIRE MAF AFLW SIG OIL PRESSURE SWITCH (LEFT SIDE OF ENGINE) ORG/BRN WIRE PMP POWERTRAIN CONTROL MODULE (RIGHT REAR OF ENGINE COMPT) RAD FAN MTR SPD RAD FAN MTR SPD SIG OIL PRESS SNSE/SW SIG RADIATOR FAN DRIVE RED/VIO WIRE RTN 4 SNSR SIG SSR IGN FD STARTING/ CHARGING SYSTEM THRTL STAT FDBK SIG 2 VIO/GRY WIRE VIO/ORG WIRE VLTG FD WHT/BRN WIRE WHT/DK GRN WIRE WHT/LT GRN WIRE YEL/BRN WIRE