Mercury Villager II (1998-2002) pnk/blu Wiring diagrams

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 EPC DR TCC 24 25 31 22 7 26 TCM TCM TCM TCM TCM TPS 33 58 57 23 TCM RETURN TPS TPS ABS CONTROL MODULE, SMART ENTRY CONTROL/ TIMER MODULE BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/RED WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (BEHIND DASH, LEFT OF STEERING COLUMN) ELEC ANALOG ELECTRONIC TEMP CONTROL MODULE ENGINE CONTROLS FUSE 35 FUSE 37 FUSE 54 FUSE 58 GRN WIRE GRN/BLK WIRE GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HOT AT ALL TIMES HOT IN RUN OR START IGN INSTRUMENT CLUSTER JOINT CONNECTOR LIGHTING CONTROL MODULE LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE MODULE (PCM) COMPUTER DATA LINES NCA WIRE O/D OFF LAMP VSS OUT TACH OUT VSS IN OD OFF PCM PCM TPS TPS SPD CTL IGN CCS ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE P/N PCM PCM PCM PCM, EVAP SOLENOIDS, IDLE SPEED CONTROL, EGR SOLENOID, MAP/BARO SOLENOID PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL PULSE SIGNAL GENERATOR (BEHIND LEFT SIDE OF DASH) REAR WIPER MOTOR RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE SHIFT SOLENOID 2 SPD CTL SPEED CONTROL ACTUATOR MODULE STARTING/ CHARGING BACK-UP LIGHTS TACH VSS PCM RETURN TCS TFT GRD THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY ASSEMBLY) THROTTLE POSITION (TP) SWITCH (ON THROTTLE BODY) TORQUE CONVERTER CLUTCH SOLENOID SHIFT SOLENOID 1 TRANSAXLE CONTROL MODULE (TCM) (BEHIND INST PANEL) TRANSAXLE FLUID TEMPERATURE SENSOR COASTING CLUTCH SOLENOID TRANSAXLE SOLENOID ASSEMBLY/ TRANSAXLE FLUID TEMPERATURE TRANSMISSION TRANSMISSION CONTROL SWITCH (PART OF GEAR SHIFT SELECTOR) TRANSMISSION RANGE (TR) SENSOR (TOP FRONT OF TRANSAXLE) VIO WIRE WHT WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE

0.33 OHMS 0.62 OHMS 1.67 OHMS BLK WIRE BLK/YEL WIRE BLU WIRE BLU/YEL WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) ELECTRONIC AUTOMATIC TEMPERATURE CONTROL MODULE (BEHIND CENTER OF DASH) FUSE 37 FUSE 45 GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN/BLK WIRE OFF PNK WIRE PNK/BLK WIRE PNK/BLU WIRE REAR BLOWER MOTOR (BEHIND PANEL, RIGHT REAR SIDE OF LUGGAGE COMPARTMENT) REAR BLOWER MOTOR RELAY (BEHIND CENTER OF DASH) REAR BLOWER MOTOR SWITCH (FRONT) REAR BLOWER MOTOR SWITCH (REAR) REAR OFF RED WIRE RED/BLK WIRE SOLID STATE YEL/BLK (OR BLK/YEL) WIRE YEL/BLK WIRE

AIR BAG SLIDING BATTERY JUNCTION BOX BATTERY JUNCTION BOX J/C (IN BAT JUNCTION BOX) BLK WIRE BLK/RED WIRE BLU WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE PEDAL POSITION (BPP) SWITCH (ON BRACKET, ABOVE BRAKE PEDAL) BRAKE SHIFT INTERLOCK BRN WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CONTACT CRUISE INDICATOR DEACTIVATOR SWITCH (TOP OF BRAKE PEDAL SUPPORT) ENGINE COMPARTMENT RELAY BOX ENGINE COMPT. RELAY BOX FUSE 13 FUSE 37 FUSE 51 GRN WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HORN RELAY (IN ENGINE COMPT RELAY BOX) HORN SWITCH HOT AT ALL TIMES HOT IN START OR RUN INHIBIT RELAY INSTRU- MENT CLUSTER SPEED CONTROL ACTUATOR SWITCH INSTRUMENT CLUSTER LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE OHMS ON INDICATOR ON ON OFF OFF ORG/ WIRE PNK WIRE PNK/BLU WIRE PPL/ORG WIRE RED WIRE RED/YEL WIRE RESUME/ ACCEL SET/ COAST SPEED CONTROL ACTUATOR (ON RIGHT REAR OF ENGINE COMPARTMENT) SPEED CONTROL ACTUATOR MODULE (MOUNTED ON CENTER DASH SUPPORT BRACKET) SPEED CONTROL ACTUATOR SWITCH (STEERING WHEEL) SPEED CONTROL HOLD RELAY SPEED SIGNAL INPUT (ANALOG) 3 3 (ELECTRONIC) STEERING COLUMN GROUND TRANSAXLE CONTROL MODULE (TCM) (BEHIND DASH) VACUUM PUMP MOTOR VACUUM SOLENOID VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSAXLE) VENT SOLENOID WHT WIRE WHT/BLU WIRE YEL WIRE YEL/BLU WIRE

1999 ONLY 6 3 19 8 2 1 LFT TURN RT TURN GROUND ANALOG AUTO AUTOLAMP SENSOR BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX JOINT CONNECTOR (IN BATTERY JUNCTION BOX) BLK WIRE BLK/WHT WIRE BLU/ WHT WIRE BLU/WHT WIRE BRAKE PEDAL POSITION SWITCH (ON BRACKET ABOVE BRAKE PEDAL) DIGITAL ELECTRONIC FLASHER MODULE (BEHIND LEFT SIDE OF DASH) EXTERIOR LIGHTS SYSTEM (TRAILER ADAPTER) FUSE 29 FUSE 41 FUSE 49 FUSE 51 FUSE 61 FUSE 57 FUSE JUNCTION PANEL (BEHIND DASH, LEFT OF STEERING COLUMN) GRN WIRE GRN/ WHT WIRE GRN/ YEL WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HAZARD FLASHER SWITCH HEAD HEADLAMP SWITCH HIGH MOUNTED STOPLAMP HOT AT ALL TIMES HOT IN INSTRUMENT CLUSTER INSTRUMENT ILLUMINATION LEFT FRONT PARK/TURN LAMP LEFT FRONT SIDE LAMP LEFT FRONT TURN LAMP LEFT LICENSE LAMP LEFT REAR PARK/STOP LAMP LEFT REAR TURN LAMP LIGHTING CONTROL MODULE (BEHIND CENTER OF DASH) MULTIFUNCTION SWITCH NCA WIRE OFF ORG/ WIRE PARK PNK/ WHT WIRE PNK/BLU WIRE PNK/WHT WIRE RED WIRE RED/ GRY WIRE RED/ WHT WIRE RED/GRN WIRE RED/WHT WIRE RIGHT FRONT PARK/TURN LAMP RIGHT FRONT SIDE LAMP RIGHT FRONT TURN LAMP RIGHT REAR PARK/STOP LAMP RIGHT LICENSE LAMP RIGHT REAR TURN LAMP RUN/ TAIL LAMP RELAY VIO WIRE W/ AUTO- LAMP WHT WIRE WHT/ BLU WIRE YEL GRN/ WIRE YEL WIRE YEL/BLK WIRE

BATTERY JUNCTION BOX (LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/WHT WIRE BLU/ORG WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FRONT WASHER PUMP MOTOR (IN WASHER RESERVOIR) FRONT WIPER MOTOR ASSEMBLY (LEFT SIDE OF FIREWALL) FRONT WIPER/WASHER AMPLIFIER ASSEMBLY FUSE 46 GRN WIRE HI OFF SLOW LO FAST HOT IN ACC OR RUN JOINT CONNECTOR MULTIFUNCTION SWITCH OFF SLOW LO FAST PARK PNK/BLU WIRE RED WIRE RUN WIRE WASHER SWITCH WHT WIRE WIPER MOTOR YEL/RED WIRE

2 POLE SPEED SENSOR 6 7 8 PNK WIRE AIR BAG AIR BAG DIAGNOSTIC MONITOR (BEHIND CENTER OF DASH) ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX CHARGE WARNING IND COOLANT TEMP COOLANT TEMPERATURE SENSOR 2 CRUISE IND DOOR AJAR IND ENGINE COOLANT TEMP. GAUGE ENGINE SPEED EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH, COMBINATION SWITCH) FUEL GAUGE FUEL GAUGE SENDER FUEL LEVEL ANTI- SLOSH MODULE FUEL PUMP MODULE FUSE 37 GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE HEADLIGHTS SYSTEM (COMBINATION SWITCH) HI BEAM HOT IN START OR RUN IGN ILLUM POWER ILLUM. DIM ILLUM. LAMPS IND IND. 56 OHMS INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL WARNING IND LOW OIL PRESS. IND. LOW WASHER FLUID IND MALFUNCTION IND O/D OFF IND OIL PRESSURE SWITCH ORG/ WIRE ORG/BLU WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SMART ENTRY CONTROL (SEC)/TIMER MODULE (BEHIND TOP CENTER OF DASH) SPEEDOMETER TACHOMETER TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT CLUSTER) V REF VEHICLE SPEED IN VEHICLE SPEED OUT VEHICLE SPEED SENSOR VIO WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLU WIRE YEL/VIO WIRE

15 16 PNK WIRE 19 14 (1999-00) (2001) 1999-00 AIR BAG DIAGNOSTIC MONITOR (BEHIND CENTER OF DASH) (BEHIND TOP CENTER OF DASH) AIR BAG IND ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX CHARGE WARNING IND COMBINATION SWITCH COOLANT TEMPERATURE SENSOR 2 (ON RIGHT REAR SIDE OF ENGINE) DIGITAL DISPLAY DOOR AJAR IND ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH) FUEL GAUGE SENDER FUEL PUMP FUSE 37 FUSE 58 GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT AT ALL TIMES HOT IN START OR RUN IGN INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL WARNING IND LOW OIL LEVEL IND LOW OIL PRESS. IND. LOW WASHER FLUID IND LT GRN/RED WIRE MALFUNCTION IND MODULE (AT FUEL TANK) O/D OFF IND OIL PRESSURE SWITCH (ON RIGHT FRONT SIDE OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE OUTSIDE AIR TEMPERATURE SENSOR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SPEED CONTROL ACTUATOR MODULE (BEHIND CENTER OF DASH) TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT PANEL) VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

0.33 OHMS 0.62 OHMS 1.67 OHMS BLK WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BRN WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) FRONT CLIMATE CONTROL PANEL FUSE 37 FUSE 45 GRN WIRE HOT AT ALL TIMES HOT IN RUN OR START LT GRN WIRE OFF OFF REAR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE REAR BLOWER MOTOR (BEHIND PANEL, RIGHT REAR OF LUGGAGE COMPARTMENT) REAR BLOWER MOTOR RELAY (BEHIND CENTER OF DASH) REAR BLOWER MOTOR SWITCH (FRONT) REAR BLOWER MOTOR SWITCH (REAR) RED WIRE RED/BLK WIRE SOLID STATE YEL WIRE YEL/BLK (OR BLK/YEL) WIRE YEL/BLK WIRE YEL/RED WIRE