Mercury Villager II (1998-2002) blu/org Wiring diagrams

5 1 14 16 LOCK ANTI-THEFT RELAY ANTI-THEFT ``ON" INDICATOR BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPT) BATTERY JUNCTION BOX JOINT CONNECTOR BLK WIRE BLK/PNK WIRE BLU WIRE BLU/ORG WIRE BLU/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) CIRCUIT BREAKER 1 (BEHIND LEFT SIDE OF DASH) ENGINE COMPARTMENT SWITCH (1999, 2000) FULL POWER WINDOWS FUSE 35 FUSE 4 FUSE 49 FUSE 52 GRN/ORG WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE GRY WIRE GRY/YEL WIRE HORNS SYSTEM HOT AT ALL TIMES HOT IN RUN OR ACCY HOT IN RUN OR START IGNITION KEY SWITCH LEFT FRONT DOOR AJAR SWITCH LEFT LIFTGATE AJAR SWITCH LEFT SLIDING DOOR AJAR SWITCH RIGHT SLIDING DOOR AJAR SWITCH LOCK LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE PASSENGER WINDOW/ DOOR LOCK/ UNLOCK SWITCH PNK WIRE RED WIRE RED/BLK WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT LIFTGATE AJAR SWITCH SMART ENTRY CONTROL (SEC)/ TIMER MODULE (BEHIND TOP CENTER OF DASH) STARTING/ CHARGING SYSTEM UNLK VIO WIRE WHT/GRN WIRE WHT/RED WIRE YEL WIRE

2000 VILLAGER 2001 VILLAGER A/C CLUTCH SOLENOID (ON RIGHT FRONT SIDE OF ENGINE COMPARTMENT) A/C COMPRESSOR CLUTCH DIODE (ON RIGHT FRONT OF ENGINE COMPARTMENT) A/C RELAY BATTERY JUNCTION BOX (BJB) JOINT CONNECTOR BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) BLK WIRE BLK/RED WIRE BLU WIRE BLU/BLK WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE DUAL PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) ENGINE COMPARTMENT RELAY BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) ENGINE COOLING FAN MOTOR (BEHIND RADIATOR) FUSE 21 FUSE 25 FUSE 5 GRN WIRE GRN/YEL WIRE GRY WIRE GRY/RED (OR WIRE HIGH SPEED FAN CONTROL RELAY 1 HIGH SPEED FAN CONTROL RELAY 2 HOT AT ALL TIMES IDLE SPEED CONTROL (ON TOP REAR CENTER OF ENGINE) LOW SPEED FAN CONTROL RELAY LT BLU WIRE LT GRN WIRE LT GRN/RED WIRE LT LT MODE ACTUATOR (BEHIND CENTER OF DASH) NORMAL ORG/ WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) RED WIRE SOLID STATE TOP OF ENGINE) WHT WIRE WHT/BLU WIRE WHT/ORG WIRE WHT/RED WIRE YEL WIRE

BATTERY JUNCTION BOX (BJB) (ON LEFT FRONT OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (BJB) JOINT CONNECTOR BLK WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT REAR OF ENGINE) ENGINE COOLING FAN MOTOR (BEHIND RADIATOR) FUSE 21 FUSE 25 FUSE 37 FUSE 5 HIGH SPEED FAN CONTROL RELAY 1 HIGH SPEED FAN CONTROL RELAY 2 HOT AT ALL TIMES HOT IN RUN OR START LOW SPEED FAN CONTROL RELAY LT GRN/RED WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) RED WIRE TOP OF ENGINE) WHT WIRE WHT/BLU WIRE

BATTERY JUNCTION BOX JOINT CONNECTOR (IN BATTERY JUNCTION BOX) BLK WIRE BLU/ORG WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX FUSE COURTESY LAMP CONTROL COURTESY LAMPS CONTROL DOOR SWITCH INPUT FRONT READING LAMP GLOVE BOX LAMP) HOT AT ALL TIMES IGNITION KEY SWITCH IGNITION KEY SWITCH INPUT J/C 3 (BEHIND TOP CENTER OF DASH) LEFT FRONT DOOR AJAR SWITCH LEFT FRONT DOOR ENTRY LAMP LEFT FRONT FOOTWELL LAMP LEFT LIFTGATE AJAR SWITCH LEFT SLIDING DOOR AJAR SWITCH LEFT SLIDING DOOR ENTRY LAMP LEFT VANITY MIRROR LAMP LIFTGATE LAMP LIFTGATE SWITCH INPUT MAP READING LAMP ORG/ WIRE REAR READING LAMP RED WIRE RED/GRN WIRE RED/WHT WIRE RIGHT FRONT DOOR AJAR SWITCH RIGHT FRONT DOOR ENTRY LAMP RIGHT FRONT FOOTWELL LAMP RIGHT LIFTGATE AJAR SWITCH RIGHT SLIDING DOOR AJAR SWITCH RIGHT SLIDING DOOR ENTRY LAMP RIGHT VANITY MIRROR LAMP SMART ENTRY CONTROL/TIMER MODULE) (BEHIND TOP CENTER OF DASH) UNIVERSAL GARAGE DOOR OPENER WHT WIRE

2 POLE SPEED SENSOR 6 7 8 PNK WIRE AIR BAG AIR BAG DIAGNOSTIC MONITOR (BEHIND CENTER OF DASH) ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX CHARGE WARNING IND COOLANT TEMP COOLANT TEMPERATURE SENSOR 2 CRUISE IND DOOR AJAR IND ENGINE COOLANT TEMP. GAUGE ENGINE SPEED EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH, COMBINATION SWITCH) FUEL GAUGE FUEL GAUGE SENDER FUEL LEVEL ANTI- SLOSH MODULE FUEL PUMP MODULE FUSE 37 GRN WIRE GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE HEADLIGHTS SYSTEM (COMBINATION SWITCH) HI BEAM HOT IN START OR RUN IGN ILLUM POWER ILLUM. DIM ILLUM. LAMPS IND IND. 56 OHMS INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL WARNING IND LOW OIL PRESS. IND. LOW WASHER FLUID IND MALFUNCTION IND O/D OFF IND OIL PRESSURE SWITCH ORG/ WIRE ORG/BLU WIRE PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SMART ENTRY CONTROL (SEC)/TIMER MODULE (BEHIND TOP CENTER OF DASH) SPEEDOMETER TACHOMETER TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT CLUSTER) V REF VEHICLE SPEED IN VEHICLE SPEED OUT VEHICLE SPEED SENSOR VIO WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLU WIRE YEL/VIO WIRE

15 16 PNK WIRE 19 14 (1999-00) (2001) 1999-00 AIR BAG DIAGNOSTIC MONITOR (BEHIND CENTER OF DASH) (BEHIND TOP CENTER OF DASH) AIR BAG IND ANTI-LOCK WARNING IND BLK WIRE BLK/RED WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRAKE WARNING IND BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX CHARGE WARNING IND COMBINATION SWITCH COOLANT TEMPERATURE SENSOR 2 (ON RIGHT REAR SIDE OF ENGINE) DIGITAL DISPLAY DOOR AJAR IND ELECTRONIC AUTOMATIC TEMPERATURE CONTROL (EATC) MODULE (BEHIND CENTER OF DASH) EXTERIOR LIGHTS SYSTEM (HAZARD SWITCH) FUEL GAUGE SENDER FUEL PUMP FUSE 37 FUSE 58 GRN WIRE GRN/BLK WIRE GRN/RED WIRE GRN/WHT WIRE GRN/YEL WIRE HEADLIGHTS SYSTEM HI-BEAM IND HOT AT ALL TIMES HOT IN START OR RUN IGN INSTRUMENT CLUSTER LEFT TURN IND LOW FUEL WARNING IND LOW OIL LEVEL IND LOW OIL PRESS. IND. LOW WASHER FLUID IND LT GRN/RED WIRE MALFUNCTION IND MODULE (AT FUEL TANK) O/D OFF IND OIL PRESSURE SWITCH (ON RIGHT FRONT SIDE OF ENGINE) ORG/ WIRE ORG/BLK WIRE ORG/BLU WIRE OUTSIDE AIR TEMPERATURE SENSOR PNK WIRE PNK/BLK WIRE PNK/BLU WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) PRNDL ILLUM. DIM PRNDL ILLUM. LAMP PRNDL ILLUM. PWR RED WIRE RED/BLU WIRE RED/GRN WIRE RED/WHT WIRE RED/YEL WIRE RIGHT TURN IND SEAT BELT WARNING IND SPEED CONTROL ACTUATOR MODULE (BEHIND CENTER OF DASH) TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT PANEL) VEHICLE SPEED SENSOR VIO WIRE VIO/WHT WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLU WIRE YEL/GRN WIRE YEL/VIO WIRE

0.33 OHMS 1 2 3 4 5 6 7 8 9 10 11 12 ILLUM 1.67 OHMS 0.62 OHMS BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) FUSE 26 BLK WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN WIRE BRN/WHT WIRE CENTRAL JUNCTION BOX (BEHIND LEFT SIDE OF DASH) DUAL PRESSURE SWITCH (IN RIGHT FRONT OF ENGINE COMPARTMENT) FRESH/RECIRCULATION DOOR ACTUATOR (BEHIND RIGHT SIDE OF DASH, ON A/C HEATER FRONT BLEND DOOR ACTUATOR (BEHIND RIGHT CENTER OF DASH, ON A/C-HEATER PLENUM) FRONT BLOWER MOTOR (BEHIND RIGHT SIDE OF DASH, ON A/C-HEATER PLENUM) FRONT BLOWER MOTOR RELAY FRONT BLOWER MOTOR SWITCH FRONT CLIMATE CONTROL PANEL FUSE 33 FUSE 36 FUSE 37 FUSE 39 GRN WIRE GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGNITION SWITCH LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE LT GRN/RED WIRE MED HIGH MED LOW MODE ACTUATOR (BEHIND CENTER OF DASH) NORMAL OFF ORG/ WIRE PLENUM) PNK ILLUM WIRE PNK INTERIOR LIGHTS SYSTEM WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) REAR A/C CIRCUIT RED WIRE RED/GRN WIRE RED/WHT WIRE RUN WIRE SOLID STATE TEMPERATURE DOOR VARIABLE RESISTOR (BEHIND CENTER OF DASH) TOP OF ENGINE) WHT WIRE WHT/BLU WIRE WHT/RED WIRE YEL WIRE YEL/BLK WIRE YEL/RED WIRE

2000 VILLAGER 2001 VILLAGER A/C CLUTCH SOLENOID (ON RIGHT FRONT OF ENGINE COMPARTMENT) A/C COMPRESSOR CLUTCH DIODE (ON RIGHT FRONT OF ENGINE COMPARTMENT) A/C RELAY BATTERY JUNCTION BOX (BJB) JOINT CONNECTOR BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) FUSE 5 BLK WIRE BLU WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BRN/WHT WIRE ENGINE COMPARTMENT RELAY BOX (ON LEFT FRONT OF ENGINE COMPARTMENT) ENGINE COOLING FAN MOTOR (BEHIND RADIATOR) FUSE 21 FUSE 25 GRY WIRE GRY/RED (OR WIRE GRY/RED WIRE HIGH SPEED FAN CONTROL RELAY 1 HIGH SPEED FAN CONTROL RELAY 2 HOT AT ALL TIMES IDLE SPEED CONTROL (ON TOP REAR CENTER OF ENGINE) LOW SPEED FAN CONTROL RELAY LT GRN WIRE ORG/ WIRE RED WIRE WHT WIRE WHT/BLU WIRE WHT/ORG WIRE

14 15 16 17 PNK WIRE 16 7 17 6 5 15 14 TP SWITCH PCM WOT IN PCM PCM PCM PCM 17 15 18 8 TP IN TACH PSG TP REF AIR CONDITIONING SYSTEM BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU WIRE BLU/BLK WIRE BLU/ORG WIRE BLU/RED WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE BRN/WHT WIRE BRN/YEL WIRE CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) CKP COOLING FANS SYSTEM CRUISE SONTROL SYSTEM DIAG CONN MIL GND ST SIG A/C HIGH PRESS TCM EGR TEMPERATURE SENSOR (ON UNDERSIDE OF THROTTLE BODY) ENGINE COOLANT TEMPERATURE (ECT) SENSOR (ON LEFT REAR OF ENGINE) EVAP CANISTER PURGE VALVE (ON RIGHT SIDE OF ENGINE) FUEL SIGNAL FLOW TACH OUTPUT FUSE 38 FUSE 54 GND CMP SENSOR CMP SENSOR GRN/BLK WIRE GRN/WHT WIRE GRN/YEL WIRE GRY/RED WIRE HI FAN RLY LO FAN RLY TCM HI FAN RLY TCM (TP) LO FAN RLY HOT AT ALL TIMES BATTERY JUNCTION BOX (LEFT FRONT OF ENG COMPT) FUSE 6 HOT IN START HOT IN START OR RUN IGN GND CMP SENSOR MAP/BARO INSTRUMENT CLUSTER SPEED LT GRN WIRE LT GRN/RED WIRE NCA WIRE OF DASH) ORG/ WIRE ORG/BLK WIRE PCM POWER RELAY (BEHIND RIGHT SIDE PNK 18 19 20 21 22 23 WIRE PNK PSP WIRE PNK WIRE PNK/BLK WIRE POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH) RED WIRE RED/GRN WIRE RED/WHT WIRE TCM FUEL PUMP/GAGE A/C HIGH PRESS GND FUEL PUMP RLY A/C RELAY THROTTLE POSITION (TP) SENSOR (ON THROTTLE BODY ASSEMBLY) THROTTLE POSITION SWITCH (ON THROTTLE BODY) TOP OF ENGINE) TP TCM TCM TP SWITCH VSS TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT PANEL) TRANSMISSION SYSTEM VIO WIRE WHT WIRE WHT/GRN WIRE WHT/RED WIRE WHT/VIO WIRE WITH DRL YEL WIRE

BATTERY JUNCTION BOX (ON LEFT FRONT OF ENGINE COMPT) BLK WIRE BLK/RED WIRE BLK/WHT WIRE BLK/YEL WIRE BLU/GRN WIRE BLU/ORG WIRE BLU/WHT WIRE BLU/YEL WIRE BRN WIRE CALIFORNIA ONLY DATA LINK CONNECTOR (BEHIND LEFT SIDE OF DASH) DIAG CONN DIAG CONN EGR TEMP EVAP BYPASS EVAP VENT INJ 2 FEDERAL FUEL FUSE 3 FUSE 43 GND PCMR IN MAP/BARO GRN WIRE GRN/ORG WIRE GRN/RED WIRE GRY WIRE GRY/BLU WIRE GRY/RED WIRE HEATED OXYGEN HOT AT ALL TIMES HOT IN RUN CENTRAL JUNCTION BOX (CJB) (BEHIND LEFT SIDE OF DASH) FUSE 36 HOT IN START OR RUN IDLE SPEED CONTROL (TOP REAR CENTER OF ENG) INJ 4 INJ 5 INJ 6 INJECTORS ISC ISC INJ 1 EGRV INJ 3 ISO BUS LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/RED WIRE MASS AIRFLOW (MAF) SENSOR (ON LEFT SIDE OF ENGINE COMPT) NCA WIRE PCMR IN POWERTRAIN CONTROL MODULE (PCM) (BEHIND RIGHT SIDE OF DASH, BEHIND GLOVE BOX) RED WIRE RED/YEL WIRE TOP OF ENGINE) TP SIG RTN ECT FUEL TEMP IAT EVAP KS TRANSAXLE CONTROL MODULE (TCM) (BEHIND INSTRUMENT CLUSTER) VIO WIRE WHT WIRE WHT/BLU WIRE WHT/VIO WIRE YEL WIRE YEL/BLK WIRE YEL/GRN WIRE YEL/RED WIRE YEL/VIO WIRE